BMW F 800 R Service Bulletins
417 manufacturer communications on file.
- May 1, 2020•Document ID: 10176367Service Bulletin/Repair InstructionsLANE DEPARTURE; WHEELS
- Mfr Comm. #:
- B270220
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryJERKING OR SHUDDERING FROM THE DRIVELINE (XDRIVE TRANSFER CASE ATX13-X): There is a jerking or shuddering during either or both of the following: Cornering or accelerating from low speeds Driving with low to medium loads There are no warning lights or Check Control messages. CAUSE Unevenly worn or incorrect fitment tires are installed on the vehicle or the factory-filled transfer case oil does not meet BMW specifications.
Associated Products (66)Associated Documents - May 1, 2020•Document ID: 10176360Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- B110120
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryB58C AND B58M ENGINES ENGINE OIL FILTER INSERT IS DIFFICULT TO REMOVE - REMOVAL: On rare occasions during an engine oil service the BMW Original (Genuine) engine oil filter insert is either difficult to remove or breaks apart in the oil filter housing. The engine oil filter is broken. The paper is torn and the lower plastic section is stuck in the engine oil filter housing.
Associated Products (131)Associated Documents - May 1, 2020•Document ID: 10176380Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B660920
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummarySURROUND VIEW WRONG VEHICLE DISPLAYED AFTER PROGRAMMING: After programming the wrong vehicle model is displayed in the Central Information Display (CID) when the Surround View is activated.
Associated Products (69)Associated Documents - April 1, 2020•Document ID: 10175288Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B660720
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummarySERVICE ACTION - REPLACE LEFT REAR SHORT RANGE RADAR SENSOR (SRR): The functionality of the left rear SRR sensor could be reduced which would display the Driving Assistance Check Control Message.
Associated Products (26)Associated Documents - April 1, 2020•Document ID: 10175285Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B611420
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummaryDEACTIVATION OF THE INTERIOR MOVEMENT DETECTOR/TILT ALARM SENSOR IS NOT POSSIBLE: Customer complains that the interior movement detector and the tilt alarm sensor system cannot be deactivated by pressing the lock button on the remote control / BMW display key twice. The second button press on the radio remote control / BMW display key is not detected. Customer may have to press the button 3 times to deactivate the interior movement detector and tilt alarm sensor. CAUSE Software error in the control unit of the roof function center (FZD).
Associated Products (77)Associated Documents - April 1, 2020•Document ID: 10174319Service Bulletin/Repair InstructionsSEAT BELTS:FRONT:BUCKLE ASSEMBLY; ELECTRICAL SYSTEM
- Mfr Comm. #:
- B720417
- Date Added:
- April 27, 2020
- Manufacturer:
- BMW
SummaryFALSE WARNINGS THAT THE FRONT PASSENGER SEAT IS OCCUPIED WITHOUT THE SEAT BELT BUCKLED: This Service Information Bulletin (Revision 10) replaces SI B72 04 17 dated September 2019. Acoustic and visual warnings indicate that the front passenger seat is occupied and the safety belt is not fastened when the seat is actually unoccupied. If the situation is currently present sit in the seat and move the seat to a slightly different position. The POL (Passenger Occupancy Light) light should now function correctly. In some cases the Air bag Warning Light was illuminated.
Associated Products (56)Associated Documents - April 1, 2020•Document ID: 10174032Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- B652214
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryAUTOMATED ACTIVATION OF NAVIGATION SYSTEM DURING PDI/QC1: This Service Information Bulletin (Revision 2) replaces SI B65 22 14 dated October 2015. The INITIAL NAV enabling code no longer needs to be pre-ordered through the Parts department! When the vehicle is connected to the diagnostic system ISTA to perform PDI/QC1 the step to activate the navigation system (part of Delete Transport Mode) will automatically request the INITIAL NAV enabling code (VIN-specific) without pre-ordering the enabling code. This enabling code will be automatically delivered through ISTA and it then activates the navigation system.
Associated Products (293)Associated Documents - April 1, 2020•Document ID: 10174029Service Bulletin/Repair InstructionsFORWARD COLLISION AVOIDANCE; LANE DEPARTURE; AIR BAGS
- Mfr Comm. #:
- B650520
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryFAULT 930C1E IS FOUND IN THE ACSM: Vehicle comes into the workshop with the following illuminated: Check Engine Light DSC warning lamp Air bag warning lamps During diagnosis the following fault code is found stored in the ASCM (Advanced Crash Safety Module): 930C1E internal ECU error If the fault is cleared it returns immediately. The root cause is under investigation.
Associated Products (47)Associated Documents - April 1, 2020•Document ID: 10174027Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EXTERIOR LIGHTING; AIR BAGS
- Mfr Comm. #:
- B630418
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryDAYTIME RUNNING LIGHT IS DIM OR DISCOLORED: This Service Information Bulletin (Revision 2) replaces SI B63 04 18 dated January 2019. One or more of the LED daytime running lights are dim or discolored. The connection between the LED module and light tube inside the headlight is damaged.
Associated Products (53)Associated Documents - April 1, 2020•Document ID: 10174019Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- B610520
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryCCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER: This Service Information Bulletin (Revision 1) replaces SI B61 05 20 dated February 2020. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases this will cause the CCM 415 to be displayed when starting the vehicle. Replacing the Controller in this case will not correct this situation.
Associated Products (137)Associated Documents - April 1, 2020•Document ID: 10174018Service Bulletin/Repair InstructionsSTRUCTURE; EXTERIOR LIGHTING
- Mfr Comm. #:
- B610320
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryMIL MAY BE ILLUMINATED BY ERRONEOUS FAULT IN THE DME: The customer states that the malfunction indicator lamp (MIL) is illuminated. During diagnosis fault code 231507 "BDC RESET by watchdog" stored in the DME. CAUSE Software error in the Body Domain Control (BDC) unit.
Associated Products (43)Associated Documents - April 1, 2020•Document ID: 10174015Service Bulletin/Repair InstructionsPARKING BRAKE; AIR BAGS
- Mfr Comm. #:
- B513016
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryTAILGATE UNINTENTIONALLY OPENS: This Service Information Bulletin (Revision 4) replaces SI B51 30 16 dated March 2018. Trunk/tailgate may open when vehicle is locked Trunk/tailgate may open while the vehicle is in motion usually after stopping such as a traffic light etc. Vehicle key trunk/tailgate button may be accidentally pressed thus opening the tailgate.
Associated Products (259)Associated Documents - April 1, 2020•Document ID: 10174009Service Bulletin/Repair InstructionsBACK OVER PREVENTION; POWER TRAIN; SERVICE BRAKES, HYDRAULIC; WHEELS
- Mfr Comm. #:
- B340517
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryTICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: This Service Information Bulletin (Revision 3) replaces SI B34 05 17 dated September 2017. Ticking noise coming from front wheel while cornering without brakes applied noticeable at low speeds. The vehicle must be moving. See attached video V34 01 20 Note: For a similar noise heard when parking with the brakes applied refer to SIB 31 01 12. Microscopic movement of the contact interface between the inner brake disc and the wheel bearing flange on vehicles equipped with lightweight brake discs.
Associated Products (218)Associated Documents - April 1, 2020•Document ID: 10174007Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- B170617
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryCOOLANT LEAK FROM LOW TEMPERATURE COOLING CIRCUIT (N63R): This Service Information Bulletin (Revision 5) replaces SI B17 06 17 dated June 2019. Traces of coolant leaking from the expansion tank of the low temperature cooling system. Coolant in the low temperature cooling circuit may also have an acrid smell and discoloration (1). Aluminum corrosion in the charge air intercoolers or in the radiator for the low temperature cooling is causing an unfavorable chemical reaction to the coolant.
Associated Products (47)Associated Documents - April 1, 2020•Document ID: 10174005Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
- Mfr Comm. #:
- B121318
- Date Added:
- April 20, 2020
- Manufacturer:
- BMW
SummaryDME FC 21A02D - COMBUSTION CONTROL: VALVE LIFT AT IDLE This Service Information Bulletin (Revision 3) replaces SI B12 13 18 dated September 2019. The vehicle will run rough or hesitate when accelerating from a stationary position.
Associated Products (114)Associated Documents - February 1, 2020•Document ID: 10172497Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B610520
- Date Added:
- March 16, 2020
- Manufacturer:
- BMW
SummaryCCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER. A yellow CCM (Check Control Message) ID 415 is displayed- "Increased battery drain! // Battery. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases this will cause the CCM 415 to be displayed when starting the vehicle. Replacing the Controller in this case will not correct this situation.
Associated Products (138)Associated Documents - February 1, 2020•Document ID: 10172487Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B110120
- Date Added:
- March 16, 2020
- Manufacturer:
- BMW
SummaryENGINE OIL FILTER INSERT IS DIFFICULT TO REMOVE - REMOVAL: This Service Information Bulletin (Revision 1) replaces SI B11 01 20 dated February 2020. On rare occasions during an engine oil service the BMW Original (Genuine) engine oil filter insert is either difficult to remove or breaks apart in the oil filter housing. The engine oil filter is broken. The paper is torn and the lower plastic section is stuck in the engine oil filter housing (1).
Associated Products (131)Associated Documents - February 1, 2020•Document ID: 10172479Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- B010518
- Date Added:
- March 16, 2020
- Manufacturer:
- BMW
SummaryLIMITED WARRANTY EXTENSIONTO 10 YEARS/120000 MILES: This Service Information Bulletin replaces SI B01 05 18 dated July 2019. Engine starts poorly (hard starting) rough idle and misfires. The Service Engine Soon (MIL) lamp is on.
Associated Products (104)Associated Documents - January 1, 2020•Document ID: 10171503Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B840220
- Date Added:
- February 18, 2020
- Manufacturer:
- BMW
SummaryREMOTE 3D VIEW NOT AVAILABLE: Remote 3D View cannot be launched In the BMW ConnectedDrive App. Software error in the Advanced Telematics Module 2 (ATM2).
Associated Products (68)Associated Documents - January 1, 2020•Document ID: 10171502Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B840120
- Date Added:
- February 18, 2020
- Manufacturer:
- BMW
SummaryBMW CONNECTEDDRIVE SERVICES ARE NOT AVAILABLE: The BMW ConnectedDrive services are not available for an extended period. This may include: Calls in the BMW Assistance app (Concierge Service) Vehicle data and status in the BMW ConnectedDrive app Remote services Remote 3D View Real Time Traffic Information (RTTI) Weather News Software error in Advanced Telematics Module 2 (ATM2).
Associated Products (68)Associated Documents