BMW 535i Complaints

536 consumer complaints on file.

#10983462May 4, 2017
UNKNOWN OR OTHER
THIS COMPLAINT HAS TO DO WITH BMW MODEL 535I AIR CONDITIONER FOR VEHICLES WITH A PRODUCTION DATE PRIOR TO 2013. THE AC CONDENSER IS KNOWN FOR PREMATURE FAILURE DUE TO CORROSION, AS IDENTIFIED IN BMW SERVICE BULLETIN SI B64 10 15 (ATTACHED). I CONTACTED BMW ALEXANDRIA VIRGINIA, PASSPORT BMW MARYLAND AND BMW NORTH AMERICAN, ALL TOLD ME MY VEHICLE WAS OUT OF WARRANTY AND I NEEDED TO PAY FOR THE REPAIRS. I BELIEVE THIS IS A DEFECTIVE PART THAT SHOULD FALL UNDER A RECALL FOR REPLACEMENT BY BMW. FOR THE BMW OWNERS WHO ARE UNABLE TO PAY FOR THE REPAIR, THIS BECOMES A SAFETY ISSUE DUE TO THE EXTREME HEAT DURING THE SUMMER MONTHS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10983487May 4, 2017
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2011 BMW 535I. THE CONTACT RECEIVED NOTIFICATION OF A RECALL FOR THE IN-TANK FUEL PUMP. HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT REFUSED TO CONTACT THE MANUFACTURER AND STATED THAT IT WAS NOT HER RESPONSIBILITY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. ..UPDATED 06/27/17 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10981683May 1, 2017
AIR BAGS
TAKATA INFLATORS- BMW HAS FAILED ON SOLVED THIS RECALL IN A TIMELY MANNER EVEN THOUGH THERE IS A POTENTIALLY SAFETY RISK RESULTING IN SERIOUS INJURY OR DEATH. ITS BEEN A YEAR AND NO FIX HAS BEEN AVAILABLE EVEN THOUGH I LIVE IN ZONE A (PUERTO RIO), ZONE ASSOCIATED WITH THE MOST AT RISK VEHICLE PER NHTSA WEBSITE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10981198April 28, 2017
FUEL/PROPULSION SYSTEM
WHILE DRIVING AND THEN ACCELERATING , CAR GIVES ME A DRIVE TRAIN MALFUNCTION LIGHT AND THEN INSTANTLY LOSSES ALL POWER AND CANNOT ACCELERATE ANYMORE. DANGEROUS FOR ME AND EVERYONE ELSE ON THE ROAD AT HIGHWAY SPEEDS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10979001April 18, 2017
ELECTRICAL SYSTEM
DRIVER'S DOOR LOCK ACTUATOR FAILURE AT 33000 MILES. UNABLE TO UNLOCK AND OPEN DOOR BY INSIDE HANDLE. THEREFORE, MAY NOT BE ABLE TO GET OUT OF VEHICLE IN AN EMERGENCY IF DOOR WILL NOT UNLOCK. THIS IS A KNOWN PROBLEM WITH BMW BUT HAS NOT BEEN A RECALL, WHICH I HIGHLY RECOMMEND AS A SAFETY PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10978784April 17, 2017
FUEL/PROPULSION SYSTEM
I WAS DRIVING ON THE HIGHWAYS, AMIDST OTHER VEHICLES WHEN THE ENGINE COMPLETELY LOST POWER AND STOPPED RUNNING. I WAS VERY LUCKY THAT I DID NOT CREATE AN ACCIDENT. THE VEHICLE JUST SHUT ITSELF OFF WHILE GOING 60!! I LOST POWER STEERING BUT MANAGED TO PULL OFF TO THE SIDE OF THE ROAD. THE VEHICLE WOULD THEN NOT START AND ON THE IDRIVE IT GAVE ME A FUEL PUMP WARNING . ABOUT AN HOUR LATER AFTER CALLING FOR ASSISTANCE, I STARTED THE VEHICLE AND IT WAS AS IF NOTHING HAD OCCURED. THE WARNING DISSAPPEARING AND IT DROVE NORMALLY. IT HAS SINCE THEN DONE THIS SAME THING 4 OTHER TIMES. I HAVE READ MANY OTHER COMPLAINTS SIMILAR TO MINE AND WANT TO KNOW IF THIS VEHICLE IS RECALLED AND IF NOT THEN WHY IS IT NOT RECALLED?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10972081April 12, 2017
EXTERIOR LIGHTING
WIRE INSULATION INSIDE THE HEADLIGHT HOUSING IS FALLING AWAY LEAVING BARE WIRES. CURRENTLY ONLY AFFECTING THE DRL. SEARCHING BMW FORUMS - THIS IS NOT AN UNCOMMON PROBLEM. THIS IS A DANGEROUS CONDITION BEING THAT THE HEADLIGHTS COULD FAIL AT ANY TIME. REPLACEMENT IS PROHIBITIVELY EXPENSIVE AT MORE THAN $700 PER UNIT. WITH THE NUMBER OF COMPLAINTS THAT I HAVE SEEN IN ON-LINE FORUMS, I FEEL THIS SHOULD WARRANT A SAFETY RELATED RE-CALL. THANK YOU IN ADVANCE FOR YOUR TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10971418April 8, 2017
POWER TRAIN
WHILE TRAVELING AT APPROXIMATELY 30-40 MPH, AND ACCELERATING TO ENTER THE INTERSTATE, THE TRANSMISSION WARNING LIGHT ILLUMINATED AND THE TRANSMISSION ENTERED FAILSAFE MODE. THE VEHICLE WOULD NOT ACCERLERATE. ATTEMPTS TO USE THE SHIFTER TO CHANGE GEARS WERE INEFFECTIVE. ONCE IN A SAFE POSITION, I PULLED OVER AND TURNED THE CAR OFF. UPON RESTART, THE TRANSMISSION ENGAGED NORMALLY. THIS HAS OCCURED ABOUT SIX (6) TIMES SINCE SEPTEMBER 2016 AND PRIOR TO TAKING IT TO THE DEALER FOR SERVICE, ON MARCH 25, 2017. I TOOK THE VEHICLE TO THE DEALER ON APRIL 5, 2017, AND THE SERVICE TECHNICIAN REPORTED THE FOLLOWING: PERFORMED SHORT TEST AND FOUND CLUTCH E FAULTS IS STORED IN THE DME. PERFORMED TEST PLAN AND FOUND NO CURRENT FAULTS WITH TRANSMISSION. CLEARED FAULTS AND ADVISE CUSTOMER TO CONTINUE DRIVING VEHICLE UNTIL FAULTS COME BACK ON. THE NEXT DAY, APRIL 6, 2017 A SIMILAR INCIDENT OCCURED TWICE WHILE ENTERING TRAFFIC. ISSUE SIMILAR TO NHTSA ID NUMBER 10035010.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10968994March 28, 2017
FUEL/PROPULSION SYSTEM
TAKATA RECALL. THE VEHICLE JUST SHUTS RIGHT OFF WITHOUT ANY WARNING SIGN OR CHECK ENGINE LIGHT. THE VEHICLE LOSES POWER ON THE HIGHWAY WITHOUT ANY WARNING SIGN AND IT'S ABSOLUTELY DANGEROUS AND IT CAN CAUSES A SERIOUS ACCIDENT. BMW HAS ISSUED A RECALL ON LATER MODELS BUT NOT THIS MODEL. ONCE THE VEHICLE TURNS COMPLETELY OFF A MESSAGE ON THE VEHICLES IDRIVE DISPLAYS "FUEL PUMP FAILURE." AFTER THE VEHICLE COOLS DOWN FOR 20-30 MINUTES IT STARTS BACK UP AND IT HAPPENS AGAIN WITHOUT NOTICE MAYBE DAYS LATER OR WEEKS LATER. IT'S A DANGEROUS ISSUE AND THERE'S NO WAY TO DETECT IT SO WARRANTY COMPANIES ARE GIVING A HARD TIME TO COVER THE COSTS AND IT'S LISTED AS COVERED UNDER EXTENDED WARRANTY. VERY DANGEROUS ISSUE AND IT'S SOMETHING BMW SHOULD LOOK INTO WITH THE OLDER MODEL AS WELL. CURRENTLY THERE'S A RECALL ON THE 2010-2011 MODELS FOR DOING THE SAME EXACT THING WITH THE HIGH PRESSURE FUEL PUMP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10967149March 20, 2017
AIR BAGS, SEAT BELTS
TAKATA INFLATORS- SHOWS ON MY SCREEN THAT THERE IS A PROBLEM WITH MY RESTRAINT SAFETY SYSTEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10967340March 20, 2017
STRUCTURE:BODY
DRIVERS SIDE DOOR LATCH WILL NOT UNLOCK FROM INSIDE UNLESS CENTRAL DOOR UNLOCK BUTTON IS PUSHED OR KEYFOB UNLOCK BUTTON IS PUSHED. PLUNGER MOVES UP AND DOWN WITH DOOR HANDLE BUT DOES NOT OPEN DOOR. BECAUSE THIS CAR DISCONNECTS THE BATTERY IN AN ACCIDENT I AM AFRAID THAT I MAY NOT BE ABLE TO GET OUT OF THE CAR IN AN EMERGENCY. REPAIR IS EXPENSIVE AND NOT COVERED UNDER WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10958015March 2, 2017
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
VEHICLE HAS ISSUES IN LINE WITH THE RECALL THAT HAS BEEN EXTENDED FOR SOME VIN NUMBERS UNDER RECALL NUMBER #16V746000. VEHICLE HAS EXPERIENCED SHAKING UNDER ACCELERATION, SPUTTERING, FLASHING CHECK ENGINE LIGHT AND, MULTIPLE TRIPS TO THE DEALERSHIP. THE VEHICLE HAS HAD ITEMS NOTED UNDER THE RECALL FIXED AT THE EXPENSE OF THE VEHICLE OWNER. CURRENTLY THE HIGH PRESSURE FUEL PUMP HAS BEEN REPLACED, AS HAS THE BATTERY WITHOUT MAKING ANY CHANGE ON THE VEHICLES PERFORMANCE. IT IS CURRENTLY IN THE DEALERS HANDS (FOR THE LAST MONTH) WITH BMWNA CURRENTLY REVIEWING THE SERVICE RECORDS TO SEE IF THEY WILL COVER THE ISSUE. THE VEHICLE HAS EXPERIENCED ISSUES WHILE MERGING INTO TRAFFIC, ACCELERATING, AND DAILY DDRIVING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10957583February 28, 2017
FUEL/PROPULSION SYSTEM
MY 2009 BMW 535I X DRIVE CONTINUES TO HAVE STALLING ISSUES. I'M TIRED OF TAKING IT IN TO BMW TO HAVE THEM CHARGE ME AND SAY NOTHING IS WRONG JUST TO HAVE MY CAR CONSTANTLY SHUTTING DOWN OVER AND OVER. MY CAR HAS PRETTY MUCH BEEN REBUILT BECAUSE OF THIS ISSUE AND IT CONTINUES TO HAPPEN. I DO NOT FEEL THAT I SHOULD HAVE TO KEEP PAYING FOR A PROBLEM THAT IS NOT RESOLVED. MY HIGH PRESSURE FUEL PUMP, FUEL PUMP, BATTERY, HIGH AND LOW PRESSURE SENORS HAVE BEEN REPLACED. I'VE HAD MY OIL CHANGED AND FUEL LINE FLUSHED AND THE PROBLEM IS STILL OCCURRING. I TRULY ENJOY THE VEHICLE WHEN ITS WORKING BUT I'M JUST AT THE POINT OF TRADING IT IN FOR ANOTHER VEHICLE OTHER THEN BMW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10956532February 23, 2017
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2011 BMW 535I. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V746000 (FUEL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10954920February 15, 2017
STRUCTURE:BODY, UNKNOWN OR OTHER
THE DRIVER'S SIDE DOOR WILL NOT OPEN WITH THE DOOR HANDLE. THE DOOR LOCK WAS JAMMED INTO THE LOCKED POSITION AND WOULD NOT UNLOCK WITHOUT ACTUATING THE ELECTRIC DOOR UNLOCK SYSTEM. THE DOOR COULD NOT BE UNLOCKED MANUALLY. THIS HAS HAPPENED SEVERAL TIMES INTERMITTENTLY. THIS WAS REPORTED TO THE DEALER AND THEY INFORMED ME THIS INSTANCE HAS OCCURRED SEVERAL TIMES TO OTHER BMW VEHICLES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10953675February 9, 2017
ENGINE
TL* THE CONTACT OWNS A 2009 BMW 535I. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED ON SEVERAL OCCASIONS WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10953772February 9, 2017
SERVICE BRAKES, STEERING
THE BRAKES ON MY BMW 535XI 2014, WERE REPAIRED AND THE BMW SHOP ON A SATURDAY AND BY TUESDAY, WHILE TURNING THE BRAKES AND STEERING WHEEL LOCKED AND FAILED, CAUSING ME TO HIT ANOTHER VICHICLE.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10948770January 31, 2017
FUEL SYSTEM, GASOLINE, ENGINE
WHILE DRIVING FROM WORK ON A BUSY FRIDAY AFTERNOON THE VEHICLE'S CHECK ENGINE LIGHT COMES ON AND THE COMPUTER SCREEN STATES "ENGINE MALFUNCTION! REDUCING POWER" "HIGH PRESSURE FUEL PUMP MALFUNCTION" LESS THAN A MINUTE THE ENGINE STALLED. LEAVING ME STRANDED ON THE BRIDGE FOR HOURS, TRY TO START THE CAR BUT IT WON'T START. THE HIGH PRESSURE FUEL SYSTEM HAS BEEN REPLACED WITH A NEW REVISION BUT STILL DIDN'T SOLVE THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10948194January 29, 2017
EXTERIOR LIGHTING
I HAVE A 2008 535I (E60) W/55K MILES, IN OTHERWISE PERFECT CONDITION WITH NO AFTERMARKET ALTERATIONS. WHILE DRIVING CAR IN THE HIGHWAY, I HAD A PARKING LIGHT ALERT/ERROR THAT MY PARKING LIGHT WAS OUT. AFTER ARRIVING TO MY HOME I INSPECTED MY HEADLIGHT ASSEMBLY. THE ANGEL EYES ON BOTH LEFT AND RIGHT HEADLIGHT SHOWED COMPLETELY BARE WIRES ON BOTH SIDES OF THE BULB CONNECTORS, ON BOTH SIDES OF THE CAR. I FOUND FLAKING INSULATION AND BARE WIRES EVERYWHERE THE INNER SEALED HEADLAMP ASSEMBLY!!!. THE MORE I TOUCHED THE WIRES, THE MORE INSULATION FLAKED OFF, ALMOST LIKE A POWDER. I'VE NEVER SEEN ANYTHING LIKE IT. DEFINITELY A FIRE HAZARD!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10947293January 24, 2017
POWER TRAIN
AS SOON AS I HIT THE START BUTTON, A SECOND LATER, - JOLT OR CLUNK - IT'S NOT HAPPENED ALL STARTS. SOME STARTS WITH NOISE SOME DOESN'T. IT SOUNDS LIKE ITS FROM THE GEARBOX BUT WHEN OUTSIDE SOUNDS LIKE ITS FROM THE DIFF AREA. OCCASIONALLY THE CAR EVEN ROCKS. THE INTENSITY OF THE CLUNK VARIES EVERY START. SOME VERY LIGHT, SOME HEARD VERY LOUD HARD. IT HAPPEN WHEN IT'S IN PARKED. SHIFT GEAR AND DRIVE IS NORMAL NO NOISE OR ANYTHING...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW 535i