Volvo XC90 Complaints

1,540 consumer complaints on file.

#11732913April 22, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS
While driving, I experienced a sudden loss of braking assist with no warning. The brake pedal became extremely hard to press, accompanied by a hissing/air sound. Despite applying full pressure, the vehicle did not slow as expected and continued moving. At one point, after stopping, the vehicle began to move forward again while my foot remained firmly on the brake. The issue occurred immediately upon or shortly after starting the vehicle, with no prior warning indicators. This created a serious safety hazard.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732842April 21, 2026
ENGINE, FUEL/PROPULSION SYSTEM
Since moving here to Nevada in 2023, I’ve had several oil changes. After about 1200 I have to add mother oil to the car. I’ve gone back three times to 5 min oil change to get free refills since they offer free top offs after your initial oil change. I than took a deep dive on the internet and discovered that the Volvo XC90, 2016 had issues with oil consumption, but never informed me of this issue. I’ve been to the dealership several times and not once did the inform me either. I mentioned to Bailey Anderson at Findlay Volvo in Las Vegas that this car consumes a lot of oil. He said no it didn’t without even checking for facts. I read that Volvo knew about this issue and we’re fixing the issue, however when I inquired they wanted me to pay for their mistake. How is that so when they knew there is and was an oil consumption matter and did not inform me of the matter. I’m furious with Volvo for hiding or concealing this issue. How can I get them to correct the matter, at this point?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732429April 20, 2026
ENGINE
About a month ago I received an Engine Coolant Low warning from the vehicle so the fluid was topped off. This past Friday, April 17th as I was driving home around midnight, I received an Engine Temperature is High, please pull over notice so I stopped the vehicle and had it towed home. Saturday evening, as the car was sitting in my driveway, the vehicle caught fire. The entire engine bay ignited and basically melted.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11731985April 17, 2026
SERVICE BRAKES
My Volvo's XC90 brakes have failed twice. At around 95,000 miles, my brakes stopped working, and then I had them repair it. They charged me close to $3,500, which they said they were able to cover under warranty, and I only had to pay the deductible, which I don't remember. In less than nine months, at about 104,000 miles, the same problem persists. Both times I was driving the car, by God's grace and luckily, I was under 10 mph. I literally parked and started driving after that, and I realized the brakes weren't working again. I'm just thankful to the Almighty that I was not at 55 or 60 mph on a freeway when the brake stopped working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731827April 17, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
A software update (version 5.0.5) was complete on my 2024 Volvo XC90 at the end of March. The software was marketed in emails to have an enhanced infotainment display to support a safer experience. Since the upgrade, I have experienced the opposite of enhanced safety. My infotainment screen and dash displays randomly go black and it restarts itself several times a day while driving. In addition to that, the blinkers malfunction when this happens. The most important safety issue is navigation outage on the displays. The inability to rely on the Google maps navigation within Volvo, or within CarPlay, results in my having to use my phone to input and view directions, taking my eyes off the road. It also disables to cameras when I need them. On 3/31 I emailed my sales rep asking if he'd heard of others having this complaint, he did not appear to be aware and asked me to make an appt with service center. I brought the car to Volvo on 4/2 where the service check-in employees did mention they were seeing many cars coming in with the same concerns. The technician was not able to confirm the issue but said they would contact Corporate and let me know of a response, which was 15 days ago. According to online searches, multiple other Volvo drivers are experiencing the same. Since we have become so dependent on the driver assistance features, and this issue is now occurring, I have become a nervous driver in a brand of car that is marketed as one of the safest vehicles in the world. I get worried that my BLISS or lane assistance or other driver assisted features will malfunction as well. No notifications from Volvo have been received thus far. I have not contacted the Corporate offices of Volvo yet. Please take this safety issue seriously.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731647April 16, 2026
ENGINE
Hey I purchased a Volvo xc90 2016 seven months ago and I currently still have this car. Also others with the same model, are having problems with oil consumption who is the problem that I’m sadly dealing with, My car burns so much oil and I’m only 19 I got this hoping for a reliable car but in stead in burns oil just has much as I burn fuel every 500 miles, if that probably less miles. it tells me to had a liter of oil because it says I’m out of oil. I just need some one to help me it hasn’t had anything done to it it’s all original with only 127,000 miles on it and this probably has been happening since I purchased it with only 118,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730933April 13, 2026
ENGINE
The contact owns a 2019 Volvo XC90. The contact stated that while driving at various speeds, the vehicle lurched forward while switching back and forth between electric and gasoline mode. The vehicle was taken to the dealer, where an unknown repair was performed; however, the failure recurred while driving three years later. Additionally, the turtle warning light was illuminated with the message "Engine System Reduced Performance". The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730540April 11, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
2018 Volvo XC90, VIN [XXX] , 54,618 miles. Original owner. All service performed exclusively at Volvo Cars West Houston (same dealer, all three failures). Volvo Technical Journal TJ 34648.1.2, titled "Prior Approval - Lack of airflow causing poor cabin cooling," is classified as a Product Fix and explicitly lists the 2018 XC90 as an affected vehicle. This TJ required the dealer to submit a Prior Approval report to Volvo Corporate when installing the resistor fix. At 12,017 miles (August 2020), the dealer installed the evaporator resistor per TJ 34648.1.2, Part No. 32241228, under VST Operation 98734-2 — meaning Volvo Corporate has documentation of this vehicle's evaporator vulnerability on file since 2020. At 15,930 miles (March 2021), the AC compressor failed and was replaced under warranty, consistent with refrigerant starvation from the same underlying evaporator leak. The evaporator has now failed completely at 54,618 miles despite Volvo's own corrective measure being applied at 12,017 miles. The current failure (April 2026) includes a confirmed front evaporator refrigerant leak and AC discharge hose leak, documented by dealer borescope inspection showing corrosion on the evaporator fins and visual evidence of refrigerant oil residue at the discharge hose fitting. Dealer repair estimate is $4,406. This is a documented pattern failure across 2016-2018 Volvo XC90 models. Volvo Cars USA was contacted for goodwill assistance and denied the request within 24 hours without meaningful review. Case number [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729350April 6, 2026
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
VCM and Rearview camera glitching not working, can cause crashes. Everything was checked for voltage and works properly. It seems like it is a system infotainment issue for 2017 Volvo xc90
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729554April 6, 2026
TIRES
The original OEM tires on a 2025 Volvo XC90 (purchased new in March 2025) failed prematurely due to what appears to be a manufacturing defect. Tire size: [e.g. 275/45R20]. Brand: [e.g. Pirelli Scorpion]. DOT: 193 7B594P 1924 (manufactured week 19 of 2024). The vehicle's original tires were removed in November 2025 for winter tire installation, at which point the odometer showed 6,808 miles. The tires were stored indoors in bags and never used again until April 2026, when a professional tire shop (Discount Tire) refused to remount them on the vehicle citing unsafe condition. The tires exhibit severe sidewall bulging, starburst cracking indicating internal structural failure, and at least one tire shows a deep gash with internal steel cords exposed. Three of the four original tires are affected. The fourth original tire was replaced in June 2025 after it failed during normal highway driving - the cause was attributed to a road hazard at the time but is now believed to be the same underlying defect. The replacement tire (a different unit purchased separately) shows no defects whatsoever. The safety risk is significant: three tires with structural sidewall failure were on an active vehicle for the first 6,808 miles of its life, including at highway speeds. One tire experienced an in-service failure. The remaining three deteriorated to the point a professional installer deemed them unsafe to mount. The failed tires are available for inspection. The problem has been confirmed by an independent tire service center (Discount Tire) who refused to install due to safety concerns. The manufacturer has not yet inspected the tires. There were no warning lamps or prior symptoms before the June 2025 in-service failure, and no visible signs of the sidewall damage were observed until the tires were removed from storage in April 2026.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728812April 2, 2026
ELECTRICAL SYSTEM
The rear door on the driver side will not open. The child lock will not deactivate. No accident. I took my son to school and when I returned to open the door for my [XXX] old the door would not open. No warnings. A regular maintenance appeared days later. I do not understand why this is not being recalled based on online research showing the same thing happening with other Volvos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728623April 1, 2026
VEHICLE SPEED CONTROL, ENGINE, FUEL/PROPULSION SYSTEM
Unintentional acceleration.First, I was in line at car wash proceeding slowly ahead as directed in line. Foot on accelerator lightly moving, when car surged rapidly hitting back end of Tesla about 6-8 ft ahead (2/26/26 12:30pm) Impact strong enough to push Tesla into truck hitch damaging it front of it as well. Applied brake, but impact was too rapid. Second incident with my Volvo was a month later(3/22/26 about 10:30 am) and my husband was driving. . Made right turn on green light and started to accelerate when it revived and surged forward until applied brake. Dealer could not replicate. No codes but repair shop had to recalibrate after 1st incident and may have lost code on 1st incident(wreck). Now that insurance knows what happened, I don't know if they will intervene. hopefully. No warnings went off or messages. Airbag did not deploy. I believe that this is an unintentional acceleration, especially occurring twice now. Dealership says car is safe and they will monitor. I guess it means when we have another incident. Hopefully not fatal to us or anyone else. Dealer says it is a transition from hybrid electric to gas. But I have had this car 4yrs10months and this never happened until now. And the transition never has thrown me back in my seat or had the engine rev. The battery was replaced last August because of bad cell and recall on it for fire hazard. Maybe this could have an affect. On first incident I was in shock so thought maybe in hit accelerator instead of break, but when second incident occurred and it was exactly like first except no collision. Thatshow I originally reported to insurance and police as my fault. But that's not true. Now I called insurance to report dual incidents, two different drivers with unintentional acceleration. SR-1 filed
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11728493April 1, 2026
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
The car recently received a 5.05 update of the infotainment system. Since then, the infotainment system would be shut off and auto-restarts itself during driving every 10 or 15 minutes. The car would lose all the functions related to the infotainment system, such as the camera, navigation, sound and air conditioning for a few minutes during driving. It is dangerous that this would happen randomly and so frequently. This incident has been reported by many Volvo car owners in the past few days since the update, and the dealer didn't fix the problem. We are going to a dealer two days later but don't have much hope for the fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728212March 31, 2026
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2017 Volvo XC90. The contact stated that while driving 70 MPH, the rear passenger’s side door suddenly unlocked and opened. The vehicle was pulled over to the side of the road, and the door was forcefully closed. The failure had occurred more than once while diving at various speeds. There were no warning lights illuminated. The contact stated that the failure had occurred while there was a passenger seated in the rear passenger’s side seat. The door was only securely closed by force. The vehicle was taken to the dealer, but the dealer had not inspected or diagnosed the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728383March 31, 2026
UNKNOWN OR OTHER
ON CALL SERVICE/ VCM MODULE STOPPED WORKING PREVIOUS RECALLS ON THESE TYPES OF VEHICLES
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727942March 30, 2026
ELECTRICAL SYSTEM, POWER TRAIN
The contact owns a 2020 Volvo XC90. The contact stated that while driving 35-40 MPH, the message "Vehicle Not in Park" was displayed intermittently, and the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle was restarted after several attempts and was driven to the residence. The vehicle was then taken to the dealer, where the contact was informed that no failure was found. The vehicle was not diagnosed or repaired. While investigating the failure online, the contact became aware that it was a common failure, and that the dealers were unable to duplicate the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726307March 23, 2026
ELECTRICAL SYSTEM
Had to replace emission coil plugs.My mechanics said it has wiring issues
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726315March 23, 2026
FUEL/PROPULSION SYSTEM
I am reporting a failure of the fuel pump system in my Volvo vehicle, which currently has approximately 60,000 miles. The failed component is available for inspection upon request. The issue was confirmed by an authorized Volvo dealership, which diagnosed the fuel pump as defective and requiring replacement. This appears to be a premature failure given the mileage and proper maintenance of the vehicle. This failure presents a serious safety risk. A faulty fuel pump can cause the vehicle to stall unexpectedly while driving, increasing the risk of a crash, especially at highway speeds or in traffic. Loss of engine power without warning places not only the driver and passengers at risk, but also other motorists on the road. Prior to the failure, the vehicle experienced symptoms consistent with fuel system issues, including difficulty starting and intermittent performance irregularities. These symptoms escalated until the vehicle became unreliable to operate. The problem has been confirmed by the manufacturer’s authorized service center, and the vehicle has been inspected accordingly. No external factors or misuse contributed to this failure. It is my understanding that Volvo has issued recalls and/or acknowledged similar fuel pump defects in other vehicles of comparable models and years. Based on the nature of this failure and its alignment with known issues, I believe this vehicle should be evaluated for inclusion under an existing recall or be subject to further investigation. Given the safety implications of fuel system failures, I respectfully request that this issue be formally reviewed to determine whether a broader defect trend exists that could impact other vehicles. The failure occurred at relatively low mileage and under normal operating conditions, raising concern of a systemic defect rather than normal wear and tear.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725903March 20, 2026
ELECTRICAL SYSTEM, VISIBILITY/WIPER, EXTERIOR LIGHTING
The vehicle experienced a major electrical system malfunction involving multiple critical components. The issue began with the Volvo On Call system light remaining illuminated continuously, which suggested a possible communication or battery-related fault. Shortly after, additional systems failed, including the turn signal system, windshield wipers, and high beam headlights. These components are currently non-functional and can be made available for inspection upon request. The failure significantly impacted vehicle safety. The loss of turn signals made it impossible to properly indicate lane changes or turns to other drivers, increasing the risk of collisions. The failure of the windshield wipers created a serious hazard in adverse weather conditions, reducing visibility. Additionally, the loss of high beam headlights limited nighttime driving visibility. While daytime running lights and hazard lights remain functional, they are not sufficient substitutes for the failed systems. The problem has been consistent and reproducible. Each time the vehicle is operated, the same warning messages appear, including “Turn Indicator System Malfunction” and “Wiper Failure – Service Required,” and the affected systems do not respond. At this time, the issue has not yet been formally confirmed by a dealer or independent service center, but diagnostics codes (including communication-related fault codes) have been observed. The vehicle has not yet been inspected by the manufacturer, law enforcement, or insurance representatives. However, based on the symptoms, the issue appears to involve a failure in the vehicle’s central electronic or communication control systems. Prior to the complete failure, warning signs were present. The Volvo On Call light remained on persistently, indicating a potential underlying electrical or module communication issue. This warning appeared before the loss of the turn signals, wipers, and high beams, suggesting a progressive system failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725921March 20, 2026
ELECTRICAL SYSTEM
The failure involves the instrument cluster (driver information display) on my 2017 Volvo XC90. This component is responsible for displaying speed, warning indicators, and all critical driving information. The failed component remains installed and is available for inspection. The issue began while driving on public roads. The display intermittently showed distorted, “barcode-like” patterns that would appear suddenly, disappear, and then return. The condition progressively worsened over time. The failure is now consistent and reproducible. When starting the vehicle, the cluster may appear normal for a few seconds before becoming severely distorted or completely unreadable. Now it is nonfunctional from the moment of ignition. This creates a significant safety hazard because I cannot view speed, warning lights, gear position, or any system alerts. The initial failures occurred while the vehicle was in motion, which increased the risk at the time of occurrence. The vehicle is not safely operable in this condition. The vehicle has approximately 24,000 miles, has never been in an accident, and has been properly maintained. There were no external factors that could explain the failure. The only prior symptoms were the intermittent display distortions described above. An authorized Volvo retailer inspected the vehicle and diagnosed the instrument cluster as failed, recommending replacement. No repair has been completed. Volvo Car USA declined goodwill assistance despite the extremely low mileage and safety‑critical nature of the failure. I am aware of similar instrument cluster failures reported by other 2016–2017 Volvo XC90 owners, suggesting this may be part of a broader pattern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC90