Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo) is recalling certain 2021 XC40 BEV vehicles. A bolt that secures the cross-member bracket for the electrical motor in the engine compartment may be loose or missing.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2022 XC40 Recharge vehicles. The Battery Energy Control Module (BECM) microprocessor may reset and cause the high voltage system to disconnect.
Vehicle is starting up in the middle of the night. Not plugged in. Not updating! Has occurred at least twice that I know of. Checking the app shows no remote start. No activity! I am concerned about fire danger! Checking the app the vehicle software has not been updated since June/26.
No injuries · No fire · No crash
I own a 2021 Volvo XC40 Recharge (pure electric). At 49,030 miles, while slowly driving in a parking lot, the vehicle suddenly began shuddering and jerking as if driving over rumble strips. A warning message appeared stating “Propulsion System Failure” and indicated the vehicle would reduce speed. The vehicle lost propulsion and came to a stop. After stopping, the vehicle would not re-enter Drive or Reverse and could not be driven. It was stuck in position in the parking lot but not in a parking space. The instrument cluster and infotainment systems still powered on, but the vehicle repeatedly displayed messages such as “Vehicle system check. Wait” and would not enter a ready-to-drive state. The vehicle had to be towed to the dealership with a dolly. It took 4 hours to move it because the first tow truck could not safely move it with the wheels stuck in place. This failure occurred without prior mechanical warning or other preceding symptoms. Dealer diagnosis identified an internal failure of the front axle inverter high-voltage assembly (IHFA). Service records document a 400A fuse failure, welded battery disconnect unit (BDU) contactor relays (R1 and R2), and overheating/damage to high-voltage battery disconnect components. Repair required replacement of the IHFA, BDU contactors, and high-voltage fuse. The dealership stated this was not a normal wear-and-tear issue. I have since found reports from other Volvo Recharge owners describing similar propulsion failures involving inverter and high-voltage battery disconnect components. My safety concern is the sudden loss of propulsion while the vehicle was in motion, with no warning and complete vehicle immobilization. Had this occurred at highway speed or in traffic, it could have created a serious collision hazard. The dealership service person agreed that my only chance to get the vehicle to a safe location was to coast. After that, it'd be stuck. I was unaware of this, which is itself an issue of concern.
No injuries · No fire · No crash
The contact owns a 2021 Volvo XC40. The contact stated that the liftgate was consistently making loud sounds while opening or closing. There was no warning light illuminated. The local dealer was contacted. No further information was available. The manufacturer was not notified of the failure. The failure mileage was approximately 23,000.
No injuries · No fire · No crash
I was sitting in the car with my daughter with the car in park, but the engine was on. Suddenly the engine started revving, and I thought her foot hit the peddle but it wasn't the case, and she had to turn the car off. I then got into the driver's seat and started the car again, and it did the same thing. I turned the car off and had to Uber home.
No injuries · No fire · No crash
The contact owns a 2021 Volvo XC40. The contact stated that while driving approximately 30 MPH, the vehicle unintendedly decelerated. The contact was able to pull into a nearby parking lot where the vehicle stalled. The vehicle was towed to the dealer, who diagnosed the cause of the failure and repaired the vehicle. The contact believed that the battery and drive train were repaired. Approximately 2 to 3 years later, while driving approximately 20 MPH, the vehicle started shaking, lost motive power, and stalled. Law Enforcement arrived on the scene, and while assisting with moving the vehicle from the middle of the road became aware that coolant was leaking underneath the vehicle. The vehicle was towed to the dealer, who diagnosed the vehicle with coolant intrusion into the engine. The contact was informed that the inverter drive system and wiring harness had caused a catastrophic drive failure. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 10,000.
No injuries · No fire · No crash