Volvo S60 Complaints

1,272 consumer complaints on file.

#11471414June 28, 2022
WHEELS
Lug bolts 19 MM are rusted into the 330 MM Brembo Disk brakes, They take over 220 ft lb of force to break lose, and you can not do that safety on the side of the road to change a flat tire
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11470504June 22, 2022
SUSPENSION, STEERING, POWER TRAIN
It is unknown what caused this issue but ever since I bought my vehicle on April 5, 2021, I have been experiencing vibration issues when driving between 65-75 MPH. I have had my vehicle inspected at multiple Volvo Service Centers across Texas and no one can seem to figure out what is causing the vibration issues. My front rotors have been replaced 3 TIMES, my rear rotors have been replaced once, I have had multiple tire rotations, alignments and balancing from Volvo Service Centers and even from Discount Tire. With all of these items serviced/repaired/replaced, the vibration is still present in the steering wheel traveling at highway speeds. I went on a test drive today, 6/22/22, with a Volvo Service Technician and he confirmed that the vibration is valid. He also stated that the only thing left to do is to replace all 4 tires, at my cost, to see if the vibration goes away. He advised that when new cars are on the lot parked waiting to be sold, dealerships typically inflate the tires to about 50 PSI so as to avoid any "flat spots" on the tires. He also stated that many dealers also typically do not inflate tires on their new fleet due to the rough ride it causes. I have contacted Volvo regarding this issue without any remedy or advice. Additionally, my Volvo dealer cannot say for sure that they will reimburse me for tires, if I do choose to replace my current ones, even though this issue has been present since day 1.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11470510June 22, 2022
VEHICLE SPEED CONTROL
Message board throttle body position sensor controls the speed of the car is having issues having a problem accelerating
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469425June 15, 2022
AIR BAGS
InJanuary 3, 2021, I received a recall for the front driver airbag but replacement parts were not available. OnApril 19, 2021I received a letter the parts were available were and for me to contact a Volvo dealer to replace the front driver's airbag.free of charge. I called Volvo Cars to let me know the dealers in Nashville. They recommended Volvo of Cool Springs. I finally got an appointment on November 16,, and had my car towed to this dealer. I picked it up on November 9, with a receipt the front driver airbag Module had been installed. Aftera few days I noticed my SRS was showing"airbag Service Urgent".I resetthe SRS but the message is still showing. I called Volvo Cars and they agreed to tow the car to Volvo of Coolsprings to check the airbag. I picked my car up the clerk tried to explain the problem was with a failed DIM control module/display. The charge would be over $2000. so the receipt showed "customer declined recommendations. My SRS was working fine until they supposedly replaced the airbag. My mechanic looked it over and the airbag is not connected. Volvo refused to pay another dealer to check the airbag. However, Volvo offered to tow my car to Volvo of Nashville on Murfreesboro road , not the orignal dealer. I refused unless they took care of the charges. I now have an a front driver airbag that is not connected. I would have to pay a dealer to find out if the airbag had been replaced. i have been driving without the recall airbag. I am filing this complaint in case of accident and to let you know the airbag recall has not been corrected. You can never talk to a mechanic at Volvo of Cool Springs. I called numerous times and left messages for the mechanic or manager to return my call.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468318June 8, 2022
ENGINE
2013 VOLVO S60. CONSUMER WRITES IN REGARD TO ILLUMINATED NO OIL PRESSURE LIGHT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466918June 1, 2022
AIR BAGS
2007 VOLVO S80. CONSUMER WRITES IN REGARD TO DRIVERS AIRBAG INFLATOR SAFETY RECALL. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464846May 16, 2022
ENGINE
Vehicle Odometer less than 7K Miles. vehicle was serviced with full synthetic oil in November 2022. March 2022, Vehicle had consumed all the synthetic lubricant and failed while driving. Report was made to both dealership and Volvo USA. only answer received as to why or how the lubricant evaporated was that ' it was a well known issue' and that since it's out of warrantee they could not assist any further. This incident mechanical failure incident scared me as a Father as my son found out while He was driving on the interstate and it puts his life in danger.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464524May 13, 2022
UNKNOWN OR OTHER
The "brushed aluminum" interior panels are peeling. The metallic part has separated from the plastic in multiple area. This creates curled up (perpendicular to the original) pieces that are VERY sharp. I have no less than 10 cuts in the last year. The pieces are razor blade sharp. I don't allow my son to come to the front seats anymore when the car is parked.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11464567May 13, 2022
AIR BAGS, FORWARD COLLISION AVOIDANCE: DYNAMIC BRAKE SUPPORT/BRAKE ASSIST
The contact owns a 2015 Volvo S60. The contact stated that while attempting to park in a parking garage, and applying the brake, her vehicle accelerated and crashed into a concrete wall, causing the air bag to deploy. The contact stated that she did apply the brake to avoid the crash, however, the brakes did not engage. The contact stated that no warning light had been illuminated at the time. The contact stated that she did sustain multiple injuries to her wrist, eyes. and ribs. The contact stated that medical attention was needed and a police report was made. The contact stated that the vehicle was then towed to a tow yard where it had been deemed a total loss. The contact stated that she then contacted the dealer who advised her to contact the manufacturer, who advised her to contact NHTSA. The failure mileage was 60,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11464298May 11, 2022
STRUCTURE:BODY
The driver door won't lock. The latch on the door is not locking causing the driver door to remain open presenting a safety issue. If the door swings opened because it is not closed properly a accident could occur. Other vehicles in that are the same make, model, and year is under recall. The problem first occurred on Saturday, May 7, 2022. I was driving the vehicle and there was no warning that the door latch had a problem. The door came opened while driving. The vehicle was towed to Southwest Volvo Sevice department and it is determined that the door latch needs to be repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463412May 4, 2022
AIR BAGS
The contact owns a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461725April 21, 2022
POWER TRAIN
Gear shifts into neutral randomly at low speeds after coming to a complete stop when auto-off on the engine is activated. This happens on the road when pulling out of an intersection and the gear shifter needs to be physically moved into neutral then drive to engage the transmission again. My dealership was unable to reproduce the problem. I took a video of it when it occurred. There have been no warning lights or indications on the dash when this happens.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11458708March 28, 2022
AIR BAGS
2002 VOLVO S60. CONSUMER WRITES IN REGARDS TO NHTSA SAFETY RECALL 21V-766. THE CONSUMER STATED THERE WERE NO VOLVO DEALERSHIPS WITHIN A REASONABLE DISTANCE TO PERFORM THE REPAIR. THE CONSUMER REQUESTED TO HAVE THE NECESSARY PARTS SENT TO A LOCAL AUTOMOTIVE SHOP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456112March 10, 2022
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2017 Volvo S60. The contact stated while entering her vehicle, the sunroof glass detached from the sunroof frame and the glass shattered. The contact was cut from the shattered glass but did not seek medical attention. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 42,427.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11454757March 1, 2022
ENGINE
On December 1, 2021 I was driving my 2012 Volvo S60 T5, that I purchased 3/2021 with 99,489 miles on it, on the highway and it stalled without warning after almost crashing. There were no warning alerts or check engine light that came on the dashboard and the car had 1,000 miles until the next oil change. After browsing the internet, we realized that the car had a recall because their vehicles were not warning the driver that there was low oil pressure allowing the driver to continue driving until the engine seized (Recall #R29436; National Highway Traffic Safety Administration campaign #13V592000). The recall was repaired by Prestige Auto on 1/2014. I contacted Volvo of North America who opened up a case and then had the car towed to Portland Volvo in Scarborough, Maine for an appointment on December 14, 2021. On December 15, 2021 Portland Volvo informed us that the vehicle’s engine was beyond repair because of an unfortunate mechanical failure due to lack of lubrication. Later that evening I received an email from Volvo of NA stating that they would cover $750 of the repairs. I emailed back asking to wait for a quote from Portland Volvo on how much it was going to be to repair the vehicle. On December 16, 2021 I was informed by Portland Volvo that she spoke with the district manager and that a used engine costs between $10-14,000. Volvo of North America has now decided to retract their $750 offer to help because the car is now out of warranty but it was due to a manufacturer's defect. I spoke with Prestige Auto (the dealership who fixed the repair) and was told that if the repair was actually fixed then it would have done its due diligence and alerted the driver that there wasn't any oil pressure. I have also read articles on these kinds of issues and it states that a recall is to be repaired until it fixes the issue, and obviously the issue wasn't fixed the first time. I asked for an appeal, was denied and now Volvo wont respond back to emails or calls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453320February 21, 2022
SEAT BELTS
I have a 2012 S60R. I just received the recall notice for the front seat belts last week. In September of 2021, the warning light on the dash board intermittently comes on with a warning sound stating that my rear seat belt is not in use. This happens while starting the car and driving. There are no passengers riding in the rear seats of my car when this happens. I have tried to fasten the rear seat belts, but they do not fasten. I can not have passengers in the car due to the malfunction of the rear seat belts which is a safety issue. My vehicle is available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11452418February 17, 2022
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
My wife and I were driving to BWI airport for a 10:30am flight from Virginia Beach in the Express Lane on I-95N going 75mph when all of a sudden at 8:30am the engine seized and I got a message telling me I would experience "Reduced Engine Performance" as my car puttered to a stop with white smoke pouring out of the exhaust. Prior to this message I had no warnings or messages on my dashboard. I got out of my car to check my oil and it was completely evaporated, so I called AAA. While we are 1 hour into waiting (it is now 9:30am) on the narrow shoulder of two Express Lanes for a tow truck to take our car to a shop at 11:40am and for a Lyft driver to figure out how to get to us, two VDOT employees told us we had to move our car by 11am otherwise the state police will tow us. I managed to call a local tow company who finally arrived by 10:55am, so we had been stranded in an Express Lane watching cars fly by at 85mph for almost 2 and a half hours before we were able to move. After the first shop took a look and told me the engine was damaged and that they couldn't replace it, I had it towed to a Volvo dealership. 5 days and a $375 diagnostic later, they find that the turbocharger has an internal oil leak and that this and the catalytic converter would have to be replaced for $6k. Aside from now being carless 4 hours from the dealership and missing my wife's birthday celebration without refund, I now have a $6,375 bill that I had no way of preventing due to a manufacturing design flaw in 2012 Volvo S60 T5. I SHOULD have been warned of a low oil situation so I could have at least pulled over and properly tended to it. I SHOULD NOT have to be liable for a Volvo design flaw that may involve faulty piston rings that has apparently affected countless others. This incident put both my wife and I in danger on an Express Lane on a very busy highway. Volvo needs to be accountable for this design flaw.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451489February 11, 2022
ENGINE
It looks as if my car should have been included in the 62Vin recall for engine sensor not stating low oil. Car started to knock and shutoff with no warning for low oil pressure. Diagnostic show oil was issue but even when completely drained car still does not display low oil which caused motor to blow. Contacted volvo and they would not add vehicle to recalls even though car year manufactured period and engine vin matched recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449962February 2, 2022
AIR BAGS
The contact owns a 2002 Volvo S60. The contact received a recall notification for NHTSA Campaign Number: 21V766000 (Air bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449675February 1, 2022
SERVICE BRAKES, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS
City Safety feature is triggering on intermittently with no reason to trigger. It occurs when initially accelerating. City Safety applies the brakes and stops the car violently. Occurs when light or dark. Has occurred several times within the past week. The feature can be manually turned off and now is with every ignition start. The default is for the feature be on, so turning off is required every time the car is turned on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S60