Tesla Model S Complaints

470 consumer complaints on file.

#11697026November 2, 2025
TIRES
Certified pre-owned 2021 Tesla Model S delivered on October 21, 2025 with worn Michelin Pilot Sport 4S summer tires (255/35ZR21 front, 295/30ZR21 rear). Tread depth measured approximately 2/32" on the outer tread shoulders of all four tires, below Tesla’s published 5/32" delivery standard. Within the first week of ownership, the vehicle hydroplaned multiple times in wet conditions at normal speeds. Tesla service declined to replace the tires, stating measurements were “taken in the wrong location” and that only the inner grooves count, despite Tesla’s public documentation and national tire safety standards defining tread depth across the full width of the tire. Vehicle was returned in same condition without correction, leaving a continued safety risk from inadequate tread and summer tires unsuited for Ohio’s cold and wet seasonal conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696712October 31, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Car will just brake on the highway with out warning. Cruise control will just randomly change speeds. I was traveling on an overpass and speed dropped to 35 then jumped to 60mph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696322October 29, 2025
SEAT BELTS
VIN: [XXX] 2022 Tesla Model S Delivery: 10/27/2025 Passenger seatbelt was cut/frayed — FMVSS 209 + 208 violation. Tesla replaced belt but **ignored 8 other defects** (paint, body, sand, maintenance). Closed ticket early, **refused FSD goodwill**. Car still unsafe — **airbag system not recalibrated**. Loaner required. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694520October 20, 2025
WHEELS, SUSPENSION
Since purchase, I have experienced nine tire-related failures, including four separate blowouts at highway speed, leaving the vehicle disabled on major roads multiple times. The most recent occurred on [Insert Date], when the car suffered another blowout and is now disabled at my residence. This pattern of failure has occurred despite tire replacements and service visits by Tesla. The issue began on the day of delivery, when a tire failed within 70 miles, and service staff admitted the car had not been safety inspected prior to delivery. Tesla has replaced nearly all tires, reimbursed a third-party shop once, and confirmed on a recorded call that the level of tire failure is abnormal. Still, no root cause has been identified. The failures have occurred under normal driving conditions and pose a serious safety hazard to me, my family (including children), and others on the road. My family now refuses to ride in the car. This issue is ongoing, unresolved, and I believe there is a systemic defect involving the vehicle’s suspension, alignment, or structural components that is contributing to abnormal tire wear and catastrophic blowouts. I am requesting that NHTSA investigate this vehicle and Tesla’s CPO inspection process, and that appropriate safety action be taken before someone is seriously injured or killed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694506October 20, 2025
STEERING, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL
On October 17, 2025, while using Full Self-Driving (FSD) mode on my 2021 Tesla Model S Plaid, the car failed to stop at two red lights within a three-hour period. In each case, the car attempted to drive through the intersection even though the signal was solid red. I intervened manually and applied the brakes to prevent a potential collision. There were no prior warnings or alerts, and I have not modified the vehicle. This behavior endangers my safety and the safety of others. I am willing to provide the vehicle and any available data logs for inspection if requested.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694322October 18, 2025
TIRES
Vehicle: 2022 Tesla Model S Tire: Goodyear ElectricDrive 2 255/45R19 104W XL Date of incident: October 15, 2025 Location: Chambers Rd., approximately 1.7 miles from Cosmopolitan Rd., Colorado Speed: Approximately 35 mph (speed limit 40 mph) Mileage on tire: Installed October 31, 2024 — approximately 10,000 miles of light local driving Description of the Problem At approximately 1:30 PM on October 15, 2025, while driving my Tesla Model S southbound on Chambers Road at around 35 mph, the driver-side front tire suddenly exploded and detached completely from the vehicle. I heard a loud thump, then saw a tire rolling ahead of me on the road. The car’s display immediately showed “tire pressure 0.” When I stopped and exited the vehicle, I found that the tire had either blown apart or peeled off the rim and separated entirely from the car. Weather was clear and around 70°F, road conditions were normal, and traffic was light. My tire pressures had been checked earlier that day and were all around 42 PSI. I was unable to retrieve the tire because I have limited mobility and use a scooter. My daughter arrived soon after but could not locate the missing tire either. The vehicle was towed by AAA to a tire shop. The technician stated that the tire appeared to have peeled off the wheel, but could not explain why. The tire was less than one year old and had very low mileage. I drive short local trips daily (around 10–15 miles) and had only taken one 700-mile trip earlier this year. Goodyear was contacted, but they declined to investigate because the tire could not be recovered. This incident could have caused a serious crash had it occurred minutes later on I-25, where I planned to drive at 75 mph. I am reporting this because I believe the tire may have suffered a manufacturing defect, and I am concerned other drivers could experience the same failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694180October 17, 2025
UNKNOWN OR OTHER
needed to honk the horn to alert another driver of impending collision but the small button, now located to the right of the center of the steering wheels, is too hard to locate in a quick emergency situation. you look away , miss the button and set off wipers instead.,... shd be put back as pushable center
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693133October 13, 2025
UNKNOWN OR OTHER
I was using Full Self-Driving (FSD) Supervised capability. We were turning left and the car took us into an oncoming turn lane. I had to take over to get us out of the lane.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692785October 11, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
Tesla Model S 2021 Long Range: Upon closing the rear trunk close button from the app or close button on the hatch, the hatch goes down but won’t lock. It gives 3 beeps. Upon pressing open, it won’t go up and gives 3 beeps.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691415October 5, 2025
EXTERIOR LIGHTING
The reverse lights are incredibly insufficient and pose a safety risk when backing up. The lights are so dim, they are virtually ineffective to the point that they illuminate nothing that may be behind the car. This is not a bulb issue as they came from the factory, new, in this condition and the service center said there is nothing they can do. Other owners I have spoken with report the same issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691293October 3, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH:EMERGENCY MECHANICAL RELEASE
The design of the emergency opening (No power to normal opening system) of the rear passenger doors is flawed, unsafe and should never have been approved for production. This rear door emergency opening requires an occupant to reach below the seat, remove carpet and pull a manual release cable. During a fire with smoke in the passenger compartment, an occupant may not be able to visually locate the release cable, and has a much higher chance of becoming incapacitated and dying from smoke inhalation, as demonstrated in a Tesla Cybertruck accident with multiple smoke inhalation deaths in California Thanksgiving 2024. Another potential scenario is a frontal impact causing a front seat to move rearward, reducing the floorboard space between the front seat and access to the carpet and release cable. This system needs to be redesigned for this vehicle. If I had known about this system prior to purchase, it would have negatively impacted my buying decision.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689981September 26, 2025
SUSPENSION
TIRES WEAR EXCESSIVLY DUE TO INCORECT FACTORY AND NON-ADJUSTABLE CAMBER SETTINGS CAUSING EXTREME SAFTEY CONCERNS/BLOWOUTS, WHICH ARE NOT VISIBLE WITHOUT REMOVAL OF TIRE OR LIFTING OF VEHICLE BY AVERAGE MOTORIST. MY VEHICLE EXPERIENCED THIS WITHIN FIRST 10,000 MILES ON NEW CAR WITH NEW TIRES. FOURTUNEATLY A FLAT LED TO FURTHER INSPECTION AND REPLACEMENT BEFORE INCCURING TRAGIC OR ADVERSE CONSEQUENCES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689558September 24, 2025
UNKNOWN OR OTHER
Car vents emit moldy smell when started , reported this to Tesla , they changed the filters but the smell still comes back, it seems other models besides S are facing it too, the technician from Tesla tells me to run high heat to kill any mold that might accumulate as condensation water from air conditioning is getting accumulated somewhere and not draining properly. This seems to me like a recall that should be done to fix it .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687621September 16, 2025
STEERING, LANE DEPARTURE: WARNING
Sometimes while making ordinary and safe traffic maneuvers the Lane Departure Warning system sometimes emits a very loud, distracting, and startling emergency chime. In particular it does this while turning into parking garages or driveways, which are already high-workload moments with high likelihood of nearby pedestrians and other vulnerable road users.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687249September 15, 2025
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: WARNING
Without prior incident or warning all ADAS systems stopped working, including adaptive cruise control, AP, FSD, automatic emergency breaking, blind spot warning, forward collision warning, lane departure warning, lane keeping assistance, parking collision warning. There were no alerts displayed on either driver’s display (other than ‘park assist unavailable’). Also there was no visualization of surrounding traffic, roads etc that is normally visible. The cameras were clean. Rebooting the MCU did not resolve the issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687128September 13, 2025
EXTERIOR LIGHTING
Tonight, shortly after dusk, on a lightly traveled road near my home, the high-beams failed to function as described in the manual, or according to any alternative way to activate them. Traffic is 30 MPH with a single lanes divided by a double yellow center line with cat-eyes. This area frequently has deer and other wildlife. Accordingly, whenever possible, high beams should be activated. Conditions were dry, and clear, without oncoming traffic -- while driving at or near the posted limit. Pushing and persistently holding the high-beam light maintained high-beam only while pressing the high-beam marked part of the steering wheel. Typical operation, in the past, operated the high beam if the button (capacitative sensitive surface on the steering wheel) was held in for about a full second and then released. This is no longer how it operated tonight. Driver pushed the high-beam for a full second. Upon release the high beams reverted to normal low beams. Driver repeated this 2 more times. After doing this twice, the driver is already distracted from wildlife and starting to focus on the car -- looking for error messages of some kind. After three times, its clear that it is Tesla software that is broken. Although the car is in good repair, no messages were presented. Again, conditions were clear and dry. Failure to operate visibility mechanisms is highly contrary to safe driving. Some features which should always work: 1. Wind shield wipers; 2. Defogger 3. Defroster 4. head lights 5. high beams Hopefully, Tesla has not abandoned functional high-beams like they have with Full Self Driving. On the other hand, if FSD is no longer among the executive compensation goals, perhaps providing a visible landscape to the all-camera FSD algorithm is also superfluous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684245September 1, 2025
STEERING
The steering wheels on these Tesla Model S vehicles have a horn button instead of depressing the center of the wheel. This button is difficult to find when turning the wheel or when an incident is happening.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681648August 19, 2025
BACK OVER PREVENTION
The contact owns a 2023 Tesla Model S. The contact stated that while attempting to reverse the vehicle, the Collision Avoidance Assist system failed to operate as designed while reversing from the garage. A dealer was contacted. The vehicle was not diagnosed or repaired by a dealer or independent mechanic. The manufacturer was notified of the failure and stated that a representative would be sent to the residence to inspect the vehicle. The failure mileage was 16,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681016August 15, 2025
SUSPENSION
Michelin Pilot Sport 4S T2 295/30R/21 102Y. These tires are engineered by Michelin specifically for a Tesla Model S 2022+ hence the T2 mark. These are a second generation as the previous ones were a T1. Everything is supposed to be factored in by Michelin to cater to the vehicles specifications and needs. I bought a set of 4 of these mentioned tires brand new from Discount Tire. In less 10000 miles and 7 months the sidewalls have completely decoupled from the tread section/rest of the tire. The treadwear itself shows and even smooth normal wear pattern. Discount tire and Michelin are trying to claim this is an alignment issue citing too much camber. This is a false claim. The area of separation is not in the contact patch with the surface of the road. This is a defect in engineering and construction in the tire itself. This calls for a mass recall. I put the trust of my pregnant wife into these tires and she complained to me about a wallowing car ride with a decrease in handling, especially over bumps and on the highway. I could not see an issue. A few days later she informed me of a tire pressure indicator on the dashboard. It indicated tow low rear tires. Upon inspecting the tires I found both sides with a decoupled sidewall. Driver side being far worse than passenger. I immediately drove to Discount tire and the tire pressure sank from 26psi to 8psi in less than 4 miles. This could have proved fatal for my wife and unborn child on the highway. The tire company and the stores dont want to accept accountability. The stores just want to sell more tires. I am having them replaced at a cost of $610 per tire. Thats equaling to almost $3000 spent on tires in 7-8 months. Please investigate this matter. This is a defect. Not wear. The vehicle previously had Falken tires that lasted 24000 miles with smooth and even treadwear. No issues, no defects.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680711August 14, 2025
SUSPENSION, WHEELS
Premature tire wear. Inside edges of rear tires wore out in 10k miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Tesla Model S