Ram 3500 Complaints (2022)

187 consumer complaints on file.

#11623124November 1, 2024
UNKNOWN OR OTHER
The UCONNECT digital center display occasionally goes completely dark or shuts off. Sometimes displays an error message like "uconnect box requires service". This display is essential for managing everything from air conditioning to music and navigation. When the windshield fogs up and you need to adjust airflow while driving for visibility, this malfunction can be distracting and pose a safety hazard. Additionally, the rear backup camera fails to function when the screen is blank, which is particularly concerning in this long-bed truck when reversing in parking lots. This issue has been presented to the dealer, and the vehicle has been dropped off for service. Initially, the problems were minor, such as difficulties with CarPlay connectivity and the screen rebooting, but I could not replicate the issue. However, it has since escalated, occurring with every trip, and the dealer is now able to observe the problem firsthand.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618321October 6, 2024
POWER TRAIN
Transmission failed in heavy interstate traffic while towing 35 ft 15,000 lbs RV. My RAM 3500 only has 19,000 miles and is still under new vehicle warranty. The event: While travelling on Washington DC beltway in lane 3 of 4 without warning my transmission starting slipping. No abnormal noise, no dash lamps warning of an issue. As I pressed on accelerator my speed continued to decrease. I quickly signaled to right lane in an attempt to get off the road. I was slowing at a rate I was concerned I may be stopped on highway with vehicles traveling 55 mph approaching. I did make the shoulder in between an exit and entrance ramp with barely enough room for a tow truck to be in front. I had 3 ft on my left with 55mph traffic passing constantly. The vehicle was towed to a local RAM dealer as my wife and I waited on the highway with RV for second tow service. This all could have been avoided. Why was a TSB or recall already in place? RAM has many transmission failures on the 2022 Aisin transmission noted on RAM truck forums. I had read about it but considered myself lucky as I was almost 2 years driving truck without any problems. My safety, my wife and tow truck drivers safety were put at considerable risk due to Stellantis not alerting RAM dealers of a potential transmission failure. Research Noah Leotta Police Officer Montgomery County Maryland. The circumstances we experienced were exactly how he lost his life. I have not received work ticket from dealership, I will follow up with documentation when requested.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617318September 30, 2024
SUSPENSION
The contact owns a 2022 Ram 3500. The contact stated that the vehicle experienced the death wobble while driving. There were no warning lights illuminated. The vehicle was taken to the dealer, but the vehicle was not diagnosed. The vehicle was not repaired because the VIN was not under recall. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 34,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614891September 16, 2024
POWER TRAIN, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: ASSIST
While driving around 20 mph, suddenly heard a clunk, then several dashboard warning lights came on. Truck suddenly had no torque- would only move forward if the engine was revved at much more than normal amount. Nearly complete loss of ability to accelerate from a stop/low speeds. Took to an independent service center who ran the ODB codes, showing the now well-known issue of "transmission failure gears 1-4" Warning lamps include the lane sense and check engine lights, and a message on the dash that reads ACC not available, Automatic high beams not available. Prior to this, no problems with the truck at all. I am trying to arrange getting it towed to a dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614795September 16, 2024
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2022 Ram 3500. The contact received notifications of NHTSA Campaign Numbers: 22V835000 (Power Train) and 23V060000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613650September 9, 2024
POWER TRAIN
22 Ram 3500 Cummins diesel with Aisin transmission. Transmission output shaft seal leaking in between transmission and transfer case.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609700August 20, 2024
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
The engine stopped while driving with no warning and provided no opportunity to exit the travel lane of the road. No warning lights were illuminated on the dashboard and all gauges appeared normal leading up to the event. This event is extremely frustrating, but I am thankful that it didn't happen on the interstate as there is no telling what the outcome may have been......... Leading up to the event, I had been driving on the interstate around 70mph for about 180 miles since the last restart. I exited the interstate and made it about 3/4 miles on a secondary road and the engine died without warning and the truck came to a quick stop in the lane of travel. No abnormal sounds were observed, just a sudden unwelcome deacceleration that did not provide enough time to exit the lane of travel. It was like stepping on the brakes. I attempted to restart the truck and the starter would not crank the engine and briefly pulled enough voltage to kill all the electronics. I attempted starting it again with a jump box attached and met the same result. The computers freaking out from the low voltage during the starting attempts wouldn't allow me to put the truck in neutral to move it out of the lane of travel. A police officer called for the tow truck on rotation since I was stuck in a live travel lane. The truck was towed to the Dealer on 8/19/2024 after the service department had closed and still would not turn over when removed from the tow truck. There were no signs of any fluids leaking from the truck after the event........ The next day the Service Advisor called and advised there were only 3 codes stored related to low voltage. Truck is waiting for a tech to become available to further investigate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609383August 19, 2024
STRUCTURE:BODY:HOOD, LATCHES/LOCKS/LINKAGES
The contact owns a 2022 Ram 3500. The contact stated while driving 70 MPH, the hood was raising up and down. The vehicle was taken to the dealer; however, the contact was informed that it was a design flaw by the manufacturer. The contact was informed that there was no fix for the issue. The contact stated that the vehicle was not driven often; however, when the vehicle was driven it was normally a 600-mile trip. The contact was concerned that the hood would unlatch while driving. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 27,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607616August 9, 2024
POWER TRAIN
My truck experienced a total transmission failure while at Highway Speed towing a 5th wheel camper on Interstate I95. This transmission failure is a known issue and has a TSB 21-002-23. A k1 clutch clip becomes dislodged and the transmission will not function. Being stranded and unable to move on a busy highway is unsafe and terrifying. Aisin Transmission and RAM are well aware of this failure however I was never notified about the potential failure nor has a recall been issued. The failure occurred instantly with no warning in a vehicle with 16,000 miles and less than 2 years old. My vehicle has been repaired and the failure was confirmed as the K1 clutch clip failure. There should be an immediate recall for this known failure to be repaired prior to being stranded on the side of the highway, 400 miles from home with my wife and kids. It's shameful RAM has ignored this problem!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606866August 6, 2024
POWER TRAIN
The transmission wont shift gears. We were stranded at a campsite. The problem has been confirmed by Santa Rosa Ram. Inspection by RAM directly is unknown. Loud clanking noises were heard many days before the final failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605128July 29, 2024
POWER TRAIN
While towing a camper 5 hours from home. Traveling approx 5-10 MPH in slow moving traffic the 2022 Ram 3500 HO with Aisin Transmission made a loud and sudden pop. It lost all forward power as if it went into neutral. Barely using momentum to limp the truck off the side of a busy highway during rush hour with my family on board.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601315July 11, 2024
POWER TRAIN
Transmission had 2 loud clunk, while stopped, and shifting into drive, lost all forward gears. Reverse works. Truck has 17000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596982June 26, 2024
POWER TRAIN
On June 5th, 2024 while pulling a travel trailer on vacation, we stopped for a short break and left the truck running. When we went to get back on the highway, I put the truck in gear and nothing happened. Truck would only shift into reverse with a violent bang. Would not go forward. Unhooked my trailer and shifted into REVERSE a few times and finally got the truck to inch forward at HIGH RPM. Towed to a Ram dealer and they confirmed a snap ring failure caused the forward clutches to go out. Truck is still awaiting repairs 445 miles from home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595715June 21, 2024
FUEL/PROPULSION SYSTEM
The Deisel Exhaust Fluid (DEF), SUPPLY LINE (part #57008975AA) has been replaced on my truck 4 times in 113 k miles. It now needs replaced again. The last 2 times were less than 5000 miles each. It is a plastic line that runs from the DEF tank and passes nearby the exhaust filter which is very hot. A RAM dealer in Georgia told me they have sold/replaced many of these lines. When cracked, they leak DEF in large volumes on the ground which then becomes contaminated.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593680June 11, 2024
POWER TRAIN, ENGINE
I was driving coming to a stop for a red light and it turns green. As I go to press on the gas my dashboard lights up with error codes stating a 4WD System error of some kind. As I go to press on the gas the truck loses power and acceleration and starts making a horrible clunking noise. I took it to the dealer because it seems like a transmission issue. This is a 2022 Ram 3500 with 9300 miles at time of failure. I would hate to see what happens if I was towing a large load to lose power all of a sudden risking my life and others around me. Based on what I have researched it seems like a K1 Snap Ring issue to the T. Waiting on the "official" diagnosis from the dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592505June 4, 2024
POWER TRAIN
When pulling onto the interstate on ramp (45 mph) the truck attempted to shift up when all transmission power failed. The engine ran fine, just no power. I was able to safely pull to the shoulder and park . s Shifting from drive to neutral to park and back to drive still did not resolve the issue. I put the truck in park and shut off the engine . The transmission fluid temp, color and level was ok. I restarted the truck and shifted to reverse with no problem then to neutral and drive. It felt that the transmission engaged and I slowly crept forward. I slowly accelerated and was able to resume speed. No subsequent loss of power has been encountered, BUT the truck now has slippage from 1st to 2nd gear and occasionally 3rd. Had I been on the interstate this has a potential for serious accident incident. This is the first time this has happened. I had bought the truck used and certified from the dealer in Pennsylvania. There is currently 28k miles on the truck. There were and still no warning or codes to indicate a problem This occurred [XXX] 2024. No dealer, tech or shop has looked at this issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11588599May 14, 2024
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
My truck experienced the K1 snap ring failure at 3,600 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11587819May 9, 2024
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
This vehicle left me stranded due to Aisen transmission failure with only 2000 miles on the vehicle. Has been at dealer for 3 months awaiting rebuild due to faulty clip. Why is nothing being done? Why am I not getting a new transmission? or better yet forced buy back
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586654May 2, 2024
SEAT BELTS
Discovered that the passenger side seat belt warning chime does not operate when someone is sitting in the passenger side front seat. I contacted the manufacturer just now who told me no one will be in contact with me, they just take the information. I asked the value of their customer care and they responded I don’t know. A case number was assigned but again, I was informed no one will make contact. I would think this is a safety law violation especially since we live in California. I need help here please.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586349May 1, 2024
POWER TRAIN
Transmission went out. Lost 1-4th gear. It was the K1 snap ring in the transmission. Lost power going up a mountain in a National Park exhaust brake either to slow vehicle. Check engine light came on
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500