MINI Cooper Complaints (2012)

173 consumer complaints on file.

#11750905July 16, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
This vin waa not included in a recall however had recall issues it obtained water in the footwell which mini has a recall issue for this and the car was caught on fire it is at the dealership in [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745835June 23, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, UNKNOWN OR OTHER
My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739897May 25, 2026
ELECTRICAL SYSTEM
ELECTRIC SHORT CIRCUIT. The electronic module in the driver side footwell area may short circuit. when I unlock the car or try to start, I hear loud electrical SHORT CIRCUIT noises coming out of the seating area. I am afraid to even unlock the car, and fear car might catch fire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715494February 4, 2026
ELECTRICAL SYSTEM
The electronic control module in the driver’s side footwell short-circuit, battery and electrical in the car are being drained and car does not work properly and completely drains battery.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710137January 10, 2026
AIR BAGS
Airbag light and seatbelt light are on continuously no matter if someone is in the seat or not.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685677September 8, 2025
ELECTRICAL SYSTEM
FRM Footwell module failed leaving car stranded Problem identified by certified mechanic. Similar models (R55 & R56) in the same age range of my vehicle have been issued a recall, but the convertible model, in the same year, (R57) is not covered. All electric switches in the vehicle failed. Symptoms began with the ABS and parking brake warning lights lighting. Other warning light was a service light.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673034July 12, 2025
ENGINE
I purchased a 2012 MINI Cooper Countryman from LA Motorsports (703 1st Ave N, Windom, MN 56101) in November 2024. Prior to purchase, I specifically asked whether any open recalls remained, and the dealership assured me all had been completed. After the vehicle failed within 60 days, a certified MINI technician inspected it and confirmed the presence of stop leak and catastrophic internal engine damage. The technician also confirmed that the auxiliary water pump—subject to NHTSA Recall 18V-248, a federal Stop-Sale recall—was still actively leaking at the time of inspection, and that the recall was still open at the time of sale. This indicates the dealer sold the vehicle without completing the required recall, which violates federal law (49 U.S.C. § 30120(i); 49 C.F.R. § 573.11). I am reporting this as a violation of federal safety standards and consumer protection. I have evidence available, including a video inspection and technician report, and I am willing to provide those upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668418June 22, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
We have had issues with every single door lock actuator assembly in this vehicle the passenger door will not latch shut at all! I'm sure how you could see this as a safety concern!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665052June 5, 2025
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2012 Mini Cooper S. The contact stated that while driving, the vehicle failed to accelerate above 40 MPH, with the check engine warning light illuminated. The vehicle was taken to a dealer and the contact was informed that the fuel pump was defective, and the fuel pump was replaced. The contact stated that approximately a year later the failure recurred, and the vehicle was taken back to the dealer and was diagnosed and determined that the fuel pump had failed again and needed to be replaced. The fuel pump was replaced under warranty; however, the failure recently returned a third time. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 87,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660554May 12, 2025
ELECTRICAL SYSTEM
I had been having trouble with my Footwell Module since the fall, but for months, I didn’t know what was going on!! The first time, October 2024, I went to Advance Auto Parts to get help bc it was raining and my windows were down, and I needed headlights, not to mention, the signals weren’t working. The second time it happened in January 2025, I didn’t go to Advance, I just disconnected the battery myself for a few hours. The third time it happened, first week of April 2025, I got home that night, cut my engine off, and noticed a light in my dash I hadn’t seen before. It was a fog lamp bulb, but the car was off, and it wasn’t like normal, it was an error light. When I walked around to the front if the car, I saw my fog lamps were still on, which was weird. All lights were off on toe column and dash. So, I restarted my Mini and cut her back off again, then the fog lamps went off. I had no park lights, or headlights then either. I didn’t check my windows. If they did go down they may not go back up! I didn’t check my turn signals either. I was just happy the fogs went off… It was after much research, that I ‘figured’ out what was going on with my Mini concerning all of the intermittent craziness, but it never occurred to me that there was a fire hazard. I actually looked into purchasing an FRM back in February, and had put it into my shopping cart, but it cost more than I could gather together at one time. I am pretty sure that is why my Mini caught fire & burned to a total loss on April 18, 2025. There is no other explanation. She ran too good. She was my dream car. She would boot, scoot & boogie! PLZ SOMEONE IN BMW FIX THIS PROBLEM!!!!! I am a sucker for this yr, make & model & just purchased the same one. Plz make a RECALL & Save Us, who are so PROUD to be Mini Owners & our sweet LiL Mini’s that we ADORE, are PROUD of & LOVE! Mini Rule #1 Always park next to another Mini Mini Rule #5 Be compassionate to SUV’s
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11645836March 2, 2025
ELECTRICAL SYSTEM
My 2012 mini cooper has a Footwell Module recall and I took it to the dealer and they refused to replace it but they said i could pay to have it replaced even though it was a recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633046December 30, 2024
ELECTRICAL SYSTEM
My vehicle has an outstanding recall (NHTSA Recall #23V337) from over a year and a half ago. There is still no update on when this will be remedied. The recall states there is potential for a "thermal event", which to me is a fancy way of saying fire. For an incident where my vehicle can catch fire, I expect a bit quicker of a response from BMW/Mini.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628890December 4, 2024
AIR BAGS
Mini BMW is fully aware of an issue with their OC3 detection mat on the passengers side and offered a extended warranty of 10 years/ 100k miles. This is insufficient coverage for a crucial saftey part and has led to a grey market production of occupancy detection mats "emulators" which are being sold online as the only way to have your airbag system "functional".
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622283October 28, 2024
VISIBILITY/WIPER
My front windshield wipers stopped working suddenly while driving in the rain
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621018October 21, 2024
SERVICE BRAKES
No warning lights have come on and the car is braking on its own. I try to push the gas and it doesn't want to go. The car has around 42k miles on it. I took it to tom bush mini last week, the said the front axle was leaking some fluid, they ordererd the axle, changed all brake pads, changed the brake fluid and said it was good to go, cost about $2300. Got the car back, doing the same thing. Now they said all calipers need to be replaced and the hydro unit dsc needs to be replaced which will cost around $6400 and they can't get the hyro unit dsc or 2 months. If this was the problem why didn't they know last week? It doesn't seem like the car has enough miles to have such a big issues and no part for 2 months. I don't know what to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610271August 22, 2024
ELECTRICAL SYSTEM
I went to have my 2012 mini coopers footwell control module replaced because it was recalled. They did not replace it because they said they found no corrosion and then marked my vehicle as the recall being fixed. When I left the dealership my blinkers or highbeans would not turn on as well as my four way flashers either. And that is dangerous. When I got home I took the cover off the footwell control module and found corrosion on the plug for it. There was also 9 codes for that when I scanned the vehicle and now is trying to charge me for a recalled part that they did not replace!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609036August 16, 2024
ELECTRICAL SYSTEM, ENGINE
The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at undisclosed speeds, the vehicle stalled. The fuel tank was a third of the way full. The trunk was locking and unlocking continuously while driving or while the vehicle was parked. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical system). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was a short in the footwell module due to water intrusion. The drain was also clogged in the sunroof. The manufacturer was contacted and opened a case. The failure mileage was approximately 161,818.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607530August 9, 2024
SERVICE BRAKES, HYDRAULIC
The contact owns a 2012 Mini Cooper S Countryman. The contact stated that on several occasions while in reverse(R) and the brake pedal was depressed, the vehicle failed to stop immediately. The vehicle was taken to an independent mechanic twice and a dealer once however, the failure could not be duplicated. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606403August 5, 2024
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper S. The contact stated that the headlights, turn signals, windows, and the radio were inoperable. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical System) however, the VIN was not included. The local dealer was contacted, and it was diagnosed that there was no water leaking into the vehicle from the roof. The vehicle was not repaired. The manufacturer was contacted and opened a claim for the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606209August 2, 2024
ENGINE, UNKNOWN OR OTHER
Oil keeps leaking back into motor and many car repair companies keep saying this is common and they won’t repair it because it’s not worth it also on another side the hood latch keeps breaking
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to MINI Cooper