MINI Cooper Complaints (2012)

173 consumer complaints on file.

#11548149October 4, 2023
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle failed to start. Additionally, the display screen was black. The contact stated that several unknown warning lights were illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 137,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11547806October 2, 2023
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper S. The contact stated while driving 70 MPH, the turn signals were engaged but failed to respond. Additionally, the contact stated that warning lights indicated that the gas cap and trunk were opened, and other unknown warning lights were illuminated. The contact also stated that the windows failed to roll down, and the headlights and the fog lights were inoperable. The contact later received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. An unknown local dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that the vehicle needed to be diagnosed to determine whether the failure was related to the recall. The failure mileage was approximately 70,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11545174September 18, 2023
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper. The contact stated that the vehicle failed to start up after several attempts. There was no warning light illuminated. Due to the failure, the vehicle was towed to a dealer where a diagnostic test was performed. The contact was informed that water had entered the vehicle from the front passenger’s side footwell, causing damages to the junction box electronics and the footwell module. The contact was also informed that the VIN was not covered under NHTSA Campaign Number: 23V337000 (Electrical System). The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 72,308.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11542960September 6, 2023
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, ENGINE
When the vehicle computer detects low voltage all turn signals, lights and instrument cluster immediately fail and do not turn back on. The Foot Well Module (FWM) or Foot Rest Module (FRM) computer becomes corrupt and deletes data from the module. This becomes a major safety hazard as a nighttime failure occurred causing several near accidents due to inability to signal to other vehicles. This is a known issue with Mini and they released an extended service bulletin knowing the factory footrest modules were manufactured incorrectly. Vehicles falling outside the initial warranty period are prone to safety risks when this occurs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11540056August 22, 2023
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537671August 10, 2023
AIR BAGS
NHTSA recall 15V-205: OC3 Seat Occupancy Mat is missing other model years. my 2012 R56 was just diagnosed by a garage as having exactly this error. Why isn't NHTSA also recalling the other model years impacted by this safety issue? As the NHTSA must know, this safety issue is impacting many Mini Cooper model years, to the extent that a secondary market for bypass devices has emerged [XXX] ). Additionally, people have reported this safety issue to NHTSA since at least 2019 [XXX] and [XXX] ). Consider this communication as a formal report to the NHTSA of this instance of a safety issue and of the NHTSA inaction in face of this board and well-documented Mini Copper safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534133July 24, 2023
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper S Countryman. The contacted stated while driving approximately 30 MPH, the headlights, turn signals, horn, window regulators, and door locks became inoperable. There were no warning lights illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 23V337000 (Electrical System). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 126,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531545July 11, 2023
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
My 2012 Mini Countryman has had failed signal lighting. My dealer has diagnosed the issue as a failed FRM module which I have been informed that NHTSA issued in conjunction with Mini USA a warranty extension to service this module's failure. While as an owner of this car for the past 9 years, I received not notice from Mini. I recently appealed for warranty coverage of this part. Mini USA has denied coverage of my failed FRM module stating the warranty was only good for 10 years from in-service date. My vehicle went in-service 8/12/2012, or ten years and ten months. Mini is adamantly denying good will to replace this part and my car is off the road do to no working turn signals.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11531633July 11, 2023
AIR BAGS, SEATS
Passenger side airbag light on with no one in seat. The repair shop stated that there is a seat sensor fault code is 93c3(passenger seat occupancy detector). If there is an accident the airbag may not deploy. I was told to by the BMW of Hawaii in Kona that it will cost $2030 for parts and labor.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526625June 12, 2023
ELECTRICAL SYSTEM, ENGINE
Mini coopers have faulty transmission problems, and well mine today it's transmission went out when I had my AC on, the car stalled in the middle of the highway in the middle of the road with oncoming traffic and refused to budge, like seriously this is highly dangerous on the interstate
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524794June 1, 2023
ELECTRICAL SYSTEM
The car just randomly caught on fire while off in my driveway. Noticed a weird sound outside looked out and noticed the windshield wipers were going even though the car was off and I hadn't driven it. Opened the door to bellows of smoke coming out. fire department was called and had to rip it apart to get to the fire which was under the steering wheel in the left side
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11514050March 27, 2023
ENGINE
Nothing has failed yet, however, the oil stick is completely illegible. On a car that fails to have an electronic dipstick and likes to burn oil, as well as has a very small oil capacity (Around 5 liters or less) this design is going to cause the engine to run out of oil without the driver knowing. It is a seriously bad design, especially combined with BMW recommending a 10,000 mile oil change, the car will burn off all the oil it has and operator will have no idea due to the faulty design of the dipstick. I generally like BMWS engineering and designs, but this one is just atrocious and I have no idea how it got approved. Running a car out of oil usually causes the engine seize unless you shut it off at the right time, which, most people will not do. Imagine if your engine seizes on the highway? No it hasn't been inspected, I can send pictures of it, if you want? Or a video? I have not had this problem yet (knock on wood) but I have read the only warning sign, is the sound of an engine without oil and the oil pressure light comes on (which at that point you have maybe 3s to pull over and shut off the engine before it toasts the engine) I have also read about the engines consuming the entire oil capacity if you follow the BMW recommended schedule. It all just seems like a huge oversight for a company that usually has few issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11489819October 18, 2022
ENGINE
Our Mini Cooper Countymen S was being towed behind our motorhome. I. saw smoke coming from the car I stopped and the car started to catch on fire. I got out motorhome disconnect just in time before the Mini was consumed by fire, it was a total loss. The Fire Investigator stated he believed the fire started in the right side of the engine compartment.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11476707July 30, 2022
SEAT BELTS
I was driving down the road when a light popped onto my dash, it was the airbag/seatbelt light after some research. From what I've read, this will prevent the airbags from activating in case of a crash, and after talking to other MINI owners it is extremely common.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476173July 27, 2022
UNKNOWN OR OTHER, ENGINE, POWER TRAIN
timing chain failure which caused engine shut down. this is a known problem with other models. It was not recalled but BMW lost a class action lawsuit for the same problem in the same car, different years. They have not updated or repaired the issue. very expensive repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465066May 17, 2022
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Footwell module is not working due to rear left blinker is not signaling only the front light does work when turning left.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461975April 24, 2022
ELECTRICAL SYSTEM
Fire observed starting in the engine compartment from a red hot glowing spot on the auxiliary water pump, an electric powered pump on the front of the engine. The purpose of the auxiliary water pump is to continue to pump coolant through the turbocharger even after the engine was shut off. The vehicle was totaled by the insurance company after the inspection by the dealer created an estimate too high for the repairs to be made. Report of this incident to the phone no of BMW/MiniCooper customer service had no favorable response. They blamed the US Government for not including this VIN in the recalls for this fire caused by the auxiliary water pump.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11458234March 24, 2022
SEATS, AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER
Passenger side airbag light on with no one in seat, had it checked, the repair shop stated that there is a seat sensor fault, the code is 93c3(passenger seat occupancy detector). I have done some research on this and it seems that this a common problem, but there hasn't been any recalls by Mini, and if there is an accident the airbag may not deploy. I was told to by the dealer that it will cost $2300 for parts and labor.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455359March 5, 2022
ELECTRICAL SYSTEM
The failed component is the "Footwell Relay Module" (FRM) which enables communication between the instrument panel in the passenger compartment and the engine control components in the engine compartment. When this component fails the following essential controls become inoperable: emergency flashers, turn signals, door locks, and windows. Most other "convenience features controlled by the car instrument panel become inoperable as well. This problem was confirmed by an independent technician, a technician at Mini of Stevens Creek in San Jose, CA, and the owner. No inspections of the part were ever done and the FRM failed without warning. This is a common failure in Minis due to a faulty design. The part is insufficiently protected from inrush current surge when a fully-charged battery is reconnected following service. It is also not sufficiently protected from induced voltage surges from EMI such as C, K or Ka band radar or electrical storms. One or more integrated circuits in the part are destroyed when exposed to current or voltage spikes rendering the part inoperable. The cost to replace the FRM (parts & labor) exceeds $1000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440756November 17, 2021
ENGINE
The contact owned a 2012 Mini Cooper S Countryman. The contact stated while she was at a standstill in traffic, she saw smoke exiting from under the hood. The contact stated no warning light was illuminated. The contact was able to park on the emergency lane and exit the vehicle before the vehicle was engulfed in flames. The contact did not sustain any injuries nor seek medical attention. A police report was filed. The insurance company deemed the vehicle a total loss. The vehicle was towed to a towing lot. The contact spoke to the local dealer and made them aware of the failure. The vehicle was not diagnosed. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V248000 (ENGINE AND ENGINE COOLING), however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 180,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to MINI Cooper