Mercedes-Benz Sprinter Complaints

760 consumer complaints on file.

#11321880April 22, 2020
STRUCTURE:BODY, POWER TRAIN, SUSPENSION
SINCE SEPTEMBER OF 2019 WITH AROUND 4500 MILES ON THE VEHICLE, LOOSE BOLTS WERE FOUND THAT HOLDS UP FUEL TANK. SEVERAL DRIVESHAFTS (AKA PILOT SHAFTS) FAILED AND WERE REPLACED. THE REAR DIFFERENTIAL FAILED AND WAS REPLACED. SEVERAL TIRES HAVE BEEN REPLACED. THIS VEHICLE VIBRATES AT HIGHWAY SPEEDS. MERCEDES BENZ HAS MADE SEVERAL ATTEMPTS OVER 80 DAYS TO CURE THIS VIBRATION PROBLEM. PHOTOS WERE SENT TO THE SERVICE MANAGER AT WAGNER MERCEDES BENZ ON 10/2/2019 SHOWING LOOSE BOLTS WHICH THEY SECURED FUEL TANK. THE VEHICLE CURRENTLY HAS 7400 MILES ON IT. I HAVE NOTICED RECALLS ON THE SPRINTER VANS BUILT AROUND THE SAME TIME WITH SIMILAR PROBLEMS. IT COULD BE POSSIBLE THAT THIS VEHICLE FELL THROUGH THE CRACKS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11320295April 6, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
WHILE DRIVING OUR 2015 MERCEDES SPRINTER 3500 ON I-5 SOUTH FROM OAKLAND, CA TO JOSHUA TREE NATIONAL PARK ON THURSDAY, MARCH 19 SUDDENLY OUR SPEED CONTROL QUIT FUNCTIONING AND THE ABS, ESP AND TRACTION CONTROL LIGHTS ON OUR INSTRUMENT PANEL LIGHTED UP. WE IMMEDIATELY CALLED A MERCEDES BENZ SERVICE DEPARTMENT IN BAKERSFIELD, CA AND WERE TOLD THAT AS LONG AS THE VAN SEEMED TO BE DRIVING , BRAKING AND HANDLING NORMALLY WE DID NOT NEED TO BRING IT IN FOR SERVICE BUT COULD CONTINUE DRIVING. THE VAN DID SEEM TO BE RUNNING NORMALLY SO WE DROVE ON WITHOUT SPEED CONTROL. ABOUT 400 MILES LATER AS WE WERE DRIVING INTO JOSHUA TREE NATIONAL PARK THE BRAKES STARTED TO MAKE A LOUD CLICKING NOISE WHEN THE PEDAL WAS DEPRESSED COMPLETELY AND THE TRANSMISSION WOULD NO LONGER SHIFT OUT OF 2ND GEAR MAKING IT IMPOSSIBLE TO DRIVE OVER 30 MPH. WE HAD TO HAVE THE VAN TOWED 46 MILES BACK TO PALM SPRINGS, CA AND AWAIT THE MERCEDES BENZ SERVICE DEPARTMENT THERE OPENING ON MONDAY, MARCH 23. AT THE SERVICE DEPARTMENT THEY DIAGNOSED THE REAR WHEEL SPEED SENSORS HAD FAILED WITH ONLY 48,271 MILES ON THE ODOMETER. THE FOLLOWING DAY THEY REPLACED THE REAR WHEEL SPEED SENSORS AND THE VAN WAS RUNNING NORMALLY AGAIN. I HAVE RESEARCHED THE PROBLEM WITH THE WHEEL SPEED SENSORS ON MERCEDES BENZ SPRINTER VANS. IT SEEMS TO BE A COMMON PROBLEM AT LEAST FROM THE YEAR 2013-2016. IT IS UNACCEPTABLE THAT A VAN THAT MERCEDES PROMOTES FOR ITS UTILITY HAS THIS KIND OF FAILURE COMMONLY. IT IS A SIGNIFICANT SAFETY ISSUE. WE WERE DRIVING ON DRY PAVEMENT SO NOTICED NO PROBLEM WITH PERFORMANCE UNTIL THE BRAKES BEGAN TO MALFUNCTION AND THE VAN WOULD NOT SHIFT ABOVE 2ND GEAR. IF WE HAD BEEN ON WET OR SLICK ROADS THE LACK OF ANTI-LOCK BRAKES, TRACTION CONTROL AND ELECTRONIC STABILITY CONTROL WOULD HAVE MADE THE VAN DANGEROUS TO DRIVE. MERCEDES BENZ NEEDS TO DO SOMETHING TO REMEDY THIS COMMON FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11319376March 26, 2020
ELECTRICAL SYSTEM, WHEELS
WHEEL SPEED SENSOR FAILURE. ABS, TRACTION CONTROL SIT DOWN UNTIL REPLACED SENSOR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11317553March 11, 2020
AIR BAGS, STEERING
HELLO ALL, I AM CURRENTLY DRIVING WITH A DEFECTIVE AIRBAG. I HAVE BEEN CONTACTED BY THE DAIMLER VANS RECALL RESOLUTION TEAM. THEY INSTRUCTED ME TO TAKE THE VEHICLE TO THE NEAREST SPRINTER REPAIR CENTER FOR THE BAG TO BE REPLACED FREE OF CHARGE. I EXPLAINED THAT THE NEAREST SERVICE CENTER WAS ST LOUIS MO WHICH HAPPENS TO BE OVER 100 MILES AWAY FROM MY HOME. I ASKED IF THEY COULD SEND SOMEONE TO CHANGE IT AT MY LOCATION, SINCE THIS WOULD TAKE ME AWAY FROM WORK FOR A DAY TO DO THIS. THEY RESPONDED NO I WOULD NEED TO HAVE IT TOWED AT MY EXPENSE TO THERE LOCATION FOR SERVICING. MERCEDES & SPRINTER SHARE THE SAME HOOD ORNAMENT, BUT SPRINTER SERVICE IS REQUIRE AT SPECIFIC SERVICING LOCATIONS. CAN YOU PLEASE HELP ME RESOLVE THIS MATTER ASAP . I HAVE BEEN RIDING WITH THIS AIRBAG NOT KNOWING IF IT WILL ACCIDENTALLY DISCHARGE WHILE I AM DRIVING. THANK YOU.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11317336March 10, 2020
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2013 MERCEDES-BENZ SPRINTER 3500. THE CONTACT STATED THAT WHILE MAKING A RIGHT TURN AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE LOSS MOTIVE POWER WITH SEVERAL WARNING LIGHTS ILLUMINATED INCLUDING; THE ABS, TRACTION CONTROL, AND THE CHECK ENGINE WARNING LIGHTS. THE CONTACT WAS ABLE TO DRIVE IN LIMP MODE TO MERCEDES-BENZ OF LYNNWOOD LOCATED AT (17800 HWY 99, LYNNWOOD, WA 98037) WHERE THE VEHICLE WAS DIAGNOSED WITH A DEFECTIVE SPEED SENSOR. THE CONTACT STATED THAT THE SPEED SENSOR WAS REPLACED ON THREE TIMES. THE CONTACT SPOKE WITH THE MANUFACTURER AND RECEIVED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 27,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11317084March 9, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), STEERING
NEW PURCHASE 02-29-2020; THE MERCEDES SPRINTER 2500 THAT WAS UPFITTED BY AIRSTREAM INTO THE AIRSTREAM INTERSTATE NINETEEN. I DROVE ABOUT 60 MILES AND WHEN BACKING FROM A PARKING SPOT I FELT A SUDDEN GRAB/JOLT FROM THE RIGHT FRONT UNDERCARRIAGE AS IF BACKED OVER A DOG/CHILD. THANKFULLY NOTHING. THREE MORE TIMES THIS OCCURRED OVER TWO DAYS BUT W/O FINDING A CAUSE I CHOSE TO DRIVE 800 MILES TO SEATTLE FROM CALIFORNIA VIA I-5. ABOUT 40 MILES ENROUTE I WAS GOING 70 MPH ON A STRAIGHT, SLIGHT DOWNGRADE STRETCH WHEN THE VEHICLE SUDDENLY GRABBED TO THE RIGHT WITH A SHORT/ABRUPT JERK ON THE STEERING WHEEL. THIS WAS THE SAME AS THE BACKWARD BUT NOW FORWARD AND FRIGHTENING. FORTUNATELY I HAD BOTH HANDS ON THE WHEEL WITH A FIRM GRIP DUE TO THE UNFAMILIAR DARK ROADWAY AND DOWNGRADE STRETCH. THIS OCCURRED FIVE OTHER TIMES OVER THE NEXT 70-100 MILES AT A REDUCED SPEED OF 40-50 WITH A FIRM GRIP ON THE WHEEL AND EXPECTING IT SO I STAYED IN THE FAR LEFT LANE TO AVOID GOING OFF THE ROADWAY ON THE RIGHT. THE FOLLOWING DAY I RESUMED THE DRIVE AT ABOUT 40-50 MPH AND FELT THE SAME GRAB INTERMITTENTLY. I CALLED MERCEDES ROADSIDE ASSIST THROUGH THE VEHICLES ELECTRONIC CONNECTIONS ON THE NAV/MEDIA SCREEN AND THEY PROMPTED ME THROUGH DEACTIVATING THE BRAKE ASSIST. I DEACTIVATED ALL THE OTHER SENSOR DEVICES LIKE LANE ASSIST, PARKTRONICS ETC THAT I COULD FIND TO BE AS SURE AS POSSIBLE IT WAS NOT GOING TO OCCUR AGAIN WHILE DRIVING. THESE ELECTRONIC SYSTEMS REACTIVATE EACH TIME YOU TURN THE IGNITION OFF SO I HAD TO REMEMBER TO DO THAT PRIOR TO DRIVING EACH TIME I STOPPED. I DROVE THE 800 MILES HOME W/O THE SENSORS ACTIVE AND THE PROBLEM DID NOT RECUR. AIRSTREAM'S UPFIT MAKES IT LESS STABLE AND THE WEIGHT NOW ABOUT 10,000-13-000 POUNDS VERY DANGEROUS. IF CRUISE CONTROL WAS ENGAGED MUCH MORE OF A PROBLEM OR WINDING ROADS. I'M A RETIRED COMMERCIAL PILOT AND IT SCARED ME; NEEDS INVESTIGATED SOON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11315341February 29, 2020
AIR BAGS, SEAT BELTS
SRS FRONT LEFT WARNING LIGHT ON FOR AIRBAG AND SEATBELT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11311647February 26, 2020
TRACTION CONTROL SYSTEM
TL* THE CONTACT OWNS A 2014 MERCEDES-BENZ SPRINTER 3500. CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE TRACTION CONTROL FAILED WITHOUT WARNING. THE CONTACT COASTED TO THE SHOULDER, TURNED THE VEHICLE OFF AND BACK ON WHICH FAILED TO REMEDY THE FAILURE. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF EASTON (4300 MORSE XING, COLUMBUS, OH 43219, (888) 530-5742) WHERE IT WAS DIAGNOSED HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE ABS SENSORS WERE REPLACED HOWEVER, THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT NO FURTHER ASSISTANCE WAS TAKEN. THE FAILURE MILEAGE WAS APPROXIMATELY 21,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11311159February 24, 2020
SEAT BELTS
THE SEAT BELT BUCKLE RECEIVER ON THE DRIVER SIDE BREAKS VERY FREQUENTLY. THE CABLES ARE VERY THIN WITH SMALL GAUGE STRANDS SO THE STRANDS SHEAR AT THE INTERNAL MOUNT POINT ONE BY ONE UNTIL THE ENTIRE CABLE BREAKS. THIS HAPPENS OVER THE COURSE OF SEVERAL MONTHS. THIS VEHICLE IS A DELIVERY VAN AND THE SEAT BELT IS BUCKLED ON AND OFF MANY TIMES. WE HAVE 20 OF THIS TYPE OF VEHICLE AND IT IS HAPPENING ON MANY OF THEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11310621February 21, 2020
ELECTRONIC STABILITY CONTROL (ESC)
THIS IS THE SECOND TIME THE RPM SPEED SENSORS HAVE NEEDED TO BE REPLACED ON MY 2016, 3500 MERCEDES SPRINTER
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11309180February 14, 2020
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2009 MERCEDES-BENZ ML350. THE CONTACT STATED THAT THE TAIL LIGHT AND THE PAINT AROUND IT BURNED WITHOUT WARNING. THE CONTACT OPENED THE VEHICLE AND FOUND THE INTERIOR OF THE VEHICLE COMPLETELY BURNED. THERE WAS NO POLICE OR FIRE REPORT AND NO INJURY WAS REPORTED. THE CONTACT STATED THAT THE FIRE MIGHT HAVE BURNED FOR DAYS BUT NEITHER HE NOR THE NEIGHBORS SAW SMOKE OR FLAMES. THE CONTACT STATED THAT THE VEHICLE WAS PARKED AT A BUSINESS PARKING LOT AT THE TIME. THE CONTACT CALLED THE INSURANCE COMPANY WHOSE AGENT CAME AND SIMPLY TOOK PICTURES. THE CONTACT SEARCHED THE VIN AND FOUND NHTSA CAMPAIGN NUMBER: 09V076000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND VERIFIED NHTSA CAMPAIGN NUMBER: 09V076000 (EXTERIOR LIGHTING), WAS ALREADY PERFORMED. THE CONTACT CALLED THE MERCEDES-BENZ OF STATE COLLEGE (3220 W COLLEGE AVE, STATE COLLEGE, PA 16801) AND WAS NOT OFFERED ANY ASSISTANCE. THE VEHICLE WAS TOTALED BUT WAS NOT TOWED AWAY. THE FAILURE MILEAGE WAS APPROXIMATELY 142,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11308653February 12, 2020
ELECTRONIC STABILITY CONTROL (ESC), STEERING
THE 2019 SPRINTER HAS A SERIOUS PROBLEM WITH THE ACTIVE LANE KEEPING ASSIST FEATURE ("ALKA") A FEW WEEKS AGO I DROVE THE VAN FROM SAN DIEGO TO MAMMOTH MOUNTAIN (BISHOP, CA. I DIDN'T FEEL THE CROSSWIND WAS A DANGER BUT I HAD TWO HANDS ON THE WHEEL TO BE PREPARED JUST IN CASE AS I HAD EXPERIENCE ISSUES WITH THE ACTIVE LANE KEEPING ASSIST FEATURE IN THE PAST AND IT CAN NOT BE PERMANENTLY DISABLED. A BURST OF WIND HIT ME AND IT PUSHED ME ONTO THE RIGHT SOLID WHITE LINE. I HAD A FAIR AMOUNT OF TARMAC OUTSIDE THE LINE TO MY RIGHT SO I WASN'T THAT CONCERNED WITH MY TIRES BEING ON TOP OF THE LINE BUT THE VAN HAD OTHER IDEAS FOR ME. ALKA KICKED IN SUPER HARD AND CORRECTED ME BACK TOWARDS THE MIDDLE OF THE ROAD. IT SCARED THE CRAP OUT OF ME AS THE ALKA HIT A LOT HARDER THAN I HAD EVER EXPERIENCED BEFORE PULLING ME BACK TOWARDS THE ONCOMING TRAFFIC GOING THE OTHER WAY! I RECALL MY INITIAL REACTION AS THINKING I HAD IMPACTED AN ANIMAL OR SOMETHING IT "HIT" SO HARD. I WENT INTO PANIC MODE AS I THOUGHT ALKA WAS GOING TO PUSH ME INTO A HEAD ON COLLISION WITH ONCOMING TRAFFIC SO I INSTINCTIVELY COUNTER STEERED RIGHT TO CORRECT AWAY FROM ONCOMING TRAFFIC. THE NET RESULT WAS A VIOLENT RIGHT (WIND), LEFT (ALKA), RIGHT (DRIVER) COMBO THAT HAD ME THINKING FOR A SECOND I AS ABOUT TO LOSE CONTROL OF THE VAN AND FLIP IT. AN EXPERIENCE MY PILOT FRIENDS WOULD CALL HAVING A PUCKER FACTOR. I MANAGED TO CONTROL IT BUT IF I'M BEING HONEST, JUST BARELY. I PULLED OVER AND TOOK A LITTLE BREAK FROM DRIVING BEFORE MAKING SURE ALKA WAS TOTALLY OFF AND CONTINUING ON. I HAVE SINCE LEARNED FROM THE SPRINTER SOURCE INTERNET FORUM FROM OTHER DRIVERS THAT THEY ALSO HAVE EXPERIENCED SIMILAR ISSUES AND THAT NUMEROUS OWNERS OF MY EXACT VAN AGREE THAT THIS SYSTEM HAS SERIOUS FLAWS THAT MAY CAUSE A SERIOUS CRASH AS IT CAN BE UNPREDICTABLE AND OVERREACTING. THANK YOU FOR LOOKING INTO THIS ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11308318February 10, 2020
VEHICLE SPEED CONTROL
PROBLEM WITH SPEED SENSORS . I HAVE REPLACED THE SPEED SENSOR ON MY VEHICLE ON FOUR DIFFERENT OCCASIONS. THIS SEEMS TO BE A REOCCURRING PROBLEM THAT NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS SERIOUSLY INJURED. MERCEDES BENZ SEEMS TO BE DOING NOTHINGS TO RECTIFY THIS PROBLEM. PLEASE BE CONCERNED THAT THE PUBLIC NEEDS YOUR HELP WITH THIS AS SOON AS POSSIBLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11301689January 24, 2020
ENGINE
I STARTED TO SMELL EXHAUST FUMES ON THE CAB OF MY VAN. I AM HAVING HEADACHES AND NOSEA . DOING RESEARCH ONLINE I DISCOVERED THAT THIS IS A COMMON PROBLEM WITH 2014 MERCEDES SPRINTER. THIS IS A HEALTH HAZARD AND A SAFETY ISSUE. THERE ARE NO SENSORS ON .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11300771January 21, 2020
AIR BAGS
WE GOT A NOTICE ABOUT RECALLS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11300778January 21, 2020
AIR BAGS
WE GOT A NOTICE ABOUT RECALLS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11298470January 10, 2020
POWER TRAIN
WHEN I WAS PARKED ON A CITY STREET I ACCIDENTALLY BUMPED THE GEAR SHIFT LEVER IN MY 2019 SPRINTER AFTER PRESSING THE IGNITION BUTTON THAT IS DIRECTLY IN FRONT OF THE LEVER. THIS PUT IT INTO NEUTRAL WITHOUT ME KNOWING, WITHOUT A BEEP OR ANY SIGNAL THAT IT WAS NOT IN PARK ANY LONGER. I ENDED UP ROLLING THE VEHICLE BACKWARDS INTO ANOTHER PARKED CAR WHEN I LET MY FOOT OFF THE BRAKE. THIS IS INCREDIBLY DANGEROUS AND SHOULD BE REVIEWED. BODY DAMAGE WAS CAUSED ON BOTH VEHICLES, AND SINCE THE INCIDENT I HAVE DONE RESEARCH ON THE LEVER DESIGN WHICH SEEMS TO BE UNIQUE TO MERCEDES WHICH HAS CAUSED DEATHS IN NEW YORK. JAKE FISHER, THE DIRECTOR OF AUTO TESTING AT CONSUMER REPORTS WAS CONNECTED TO THE ACCIDENT AND HAS A LOT OF INFORMATION ABOUT THE INEFFICIENCY AND SAFETY OF THE DESIGN. HTTPS://WWW.NYDAILYNEWS.COM/NEW-YORK/DONOHUE-SUV-GEARSHIFT-DESIGN-EYED-METRO-NORTH-TRAGEDY-ARTICLE-1.2125193
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11292401January 1, 2020
STRUCTURE:BODY
BODY PARTS ARE FALLING OF FOR RUNNING BOARDS, PARTS HAVE FALLEN OFF ON THE HIGHWAY AND HIT OTHER VEHICLES. DEALER UNABLE TO FIND PARTS TO RESOLVE ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11291145December 25, 2019
AIR BAGS, SERVICE BRAKES, SEAT BELTS
MERCEDES BENZ REFUSES FOR OVER A YEAR TO FIX MY AIRBAGS PASSENGER SEAT AIRBAG DEPLOYED WITH NO ACCIDENT. JUST DRIVING ABOUT 25 MILES AN HOUR IT EMPLOYED AT OF NOW NOWHERE BUT AIRBAG DIDN'T COME OUT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11290921December 23, 2019
STEERING
CLAMP ON THE POWER STEER HOSE CAME OFF. THE SPRING CLAMP DID NOT HOLD AND THE HOSE IS STRETCHED TOO TIGHT. WE LIVE IN FAIRBANKS, AK AND THE TEMPERATURE WAS -30 DEGREES. THE VEHICLE HAS LESS THAN 5000 MILES. WE WERE ABLE TO PUT ANOTHER CLAMP ON, WITH ONLY GETTING MINOR FROSTBITE ON FINGERS. WE WERE LUCKY THIS HAPPENED IN TOWN. THIS VEHICLE IS BEING PROMOTED AS A VEHICLE TO ACCESS MORE REMOTE LOCATIONS. THIS COULD LEAVE PEOPLE IN A DANGEROUS SITUATION. THIS HAS HAPPENED FREQUENTLY ON THIS VEHICLE ACCORDING TO SOCIAL MEDIA SITES. WE WERE LUCKILY PARKED IN A WALMART PARKING LOT, AND WHEN WE STARTED TO DRIVE OUT, THE STEERING WHEEL WOULD NOT TURN. AS WE HAD BEEN WARNED OF THIS HAPPENING, WE KNEW WHAT TO LOOK FOR. THERE WAS A POOL OF POWER STEERING FLUID BENEATH THE ENGINE. SHOULDNT THIS BE A RECALL ISSUE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercedes-Benz Sprinter