Kia Telluride Service Bulletins (2022)
89 manufacturer communications on file.
- June 4, 2026•Document ID: 11033994Warranty Program/ExtensionENGINE
- Mfr Comm. #:
- WTY045_TSB
- Date Added:
- June 18, 2026
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: OIL FILTER HOUSING GASKET REPLACEMENT (WTY045) - This bulletin provides information regarding the ‘Warranty Extension Program (WTY045)’ for the inspection and, if necessary, replacement of the oil filter housing gasket on certain 2020–2025 MY Telluride (ON) vehicles produced from January 9, 2019, through June 12, 2025. Under this program, the New Vehicle Warranty coverage for this condition is extended from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever occurs first, starting from the date the vehicle was first put into service. Affected vehicles may develop an engine oil leak from the oil filter housing gasket. During the extended warranty period, inspect and, if necessary, replace the oil filter housing gasket at no cost to the customer.
Associated Products (5)Associated Documents - May 28, 2026•Document ID: 11033217Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB_ELE422
- Date Added:
- June 3, 2026
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: INFOTAINMENT SYSTEM SOFTWARE UPDATE USING UPDATE.KIA.COM - This bulletin provides information and service procedures for updating the infotainment systems on applicable Kia vehicles using the Kia Navigation Updater available at update.kia.com. The software update may improve system performance, enhance existing features, and apply the latest operating software for supported vehicles (2021-2026MY All Models).
Associated Products (67)Associated Documents - May 23, 2026•Document ID: 11032907Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB_CHA128_CLSD
- Date Added:
- May 23, 2026
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: 4WD COUPLING NOISE/VIBRATION LOGIC IMPROVEMENT) - CLOSED & SUPERSEDED BY CHA129 - This bulletin is now closed and superseded by CHA129. This bulletin provides information to upgrade the 4-Wheel Drive ‘4WD’ system software on certain 2020-2022MY Telluride (ON) vehicles produced from January 09, 2019 through September 01, 2022. The affected vehicles may exhibit a noise and/or a vibration, shudder, jerking, binding, or chattering while turning at low speeds (10MPH – 15MPH) located from the 4WD coupling caused by a decrease in the oil friction of the 4WD coupling due to continuous vehicle operation in harsh conditions (high/low ambient temperatures, long time/distance traveling).
Associated Products (2)Associated Documents - May 23, 2026•Document ID: 11032906Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB_CHA129
- Date Added:
- May 23, 2026
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: AWD COUPLER NOISE/VIBRATION LOGIC IMPROVEMENT - This bulletin provides information to upgrade the 4-Wheel Drive ‘4WD’ system software on some 2020-2025MY Telluride (ON) vehicles produced from January 08, 2019 through December 17, 2025. The affected vehicles may exhibit a noise and/or a vibration, shudder, jerking, binding, or chattering sensation while turning at low speeds (10MPH – 15MPH). This concern may be caused by decreased oil friction within AWD coupling due to continuous vehicle operation in harsh conditions (high/low ambient temperatures, extended duration / distance driving).
Associated Products (5)Associated Documents - April 30, 2026•Document ID: 11031935Warranty Program/ExtensionENGINE
- Mfr Comm. #:
- WTY045_REIMB
- Date Added:
- May 1, 2026
- Manufacturer:
- KIA
SummaryWARRANTY EXTENSION CAMPAIGN: REIMBURSEMENT FORM (WTY045) - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension campaign program launch.
Associated Products (5)Associated Documents - April 30, 2026•Document ID: 11031933Warranty Program/ExtensionENGINE
- Mfr Comm. #:
- WTY045_OWNR
- Date Added:
- May 1, 2026
- Manufacturer:
- KIA
SummaryWARRANTY EXTENSION CAMPAIGN: OWNER NOTIFICATION (WTY045) - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for certain repairs related to an engine oil leak from the oil filter housing gasket in certain 2020-2025 MY Telluride vehicles from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the oil filter housing gasket leaking condition at no cost to you during this extended warranty period.
Associated Products (5)Associated Documents - April 29, 2026•Document ID: 11031928Warranty Program/ExtensionENGINE
- Mfr Comm. #:
- WTY045_DPSM
- Date Added:
- May 1, 2026
- Manufacturer:
- KIA
SummaryWARRANTY EXTENSION CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (WTY045) - This document is the announcement to the dealer Parts and Service managers advising that Kia is extending the New Vehicle Limited Warranty coverage to all owners for certain repairs related to an engine oil leak from the oil filter housing gasket in certain 2020-2025 MY Telluride vehicles manufactured from January 9, 2019 through June 12, 2025, from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the oil filter housing gasket leaking condition.
Associated Products (5)Associated Documents - April 29, 2026•Document ID: 11031920Warranty Program/ExtensionENGINE
- Mfr Comm. #:
- WTY045_DP
- Date Added:
- May 1, 2026
- Manufacturer:
- KIA
SummaryWARRANTY EXTENSION CAMPAIGN: DEALER PRINCIPAL MEMO (WTY045) - This document is the announcement to the dealer principals advising that Kia is extending the New Vehicle Limited Warranty coverage to all owners for certain repairs related to an engine oil leak from the oil filter housing gasket in certain 2020-2025 MY Telluride vehicles manufactured from January 9, 2019 through June 12, 2025, from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the oil filter housing gasket leaking condition.
Associated Products (5)Associated Documents - April 29, 2026•Document ID: 11031915Warranty Program/ExtensionENGINE
- Mfr Comm. #:
- WTY045_QA
- Date Added:
- May 1, 2026
- Manufacturer:
- KIA
SummaryWARRANTY EXTENSION CAMPAIGN: QUESTION AND ANSWER (WTY045) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension Campaign WTY045.
Associated Products (5)Associated Documents - February 21, 2026•Document ID: 11029044EmissionsENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SC357_OWNR
- Date Added:
- February 26, 2026
- Manufacturer:
- KIA
SummaryVOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC357) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) for 2020-2025 MY Telluride vehicles to ensure compliance with emissions regulations.
Associated Products (5)Associated Documents - February 16, 2026•Document ID: 11029138Service Bulletin/Repair InstructionsENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SC357_TSB
- Date Added:
- March 2, 2026
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: ECU EMISSIONS SOFTWARE LOGIC IMPROVEMENT (SC357) - This bulletin provides information to upgrade the Engine Control Unit (ECU) system software to improve the emissions-related logic on 2020-2025MY Telluride (ON) vehicles equipped with the Lambda II 3.8L GDI engine, produced from January 9, 2019 through October 27, 2025. The subject vehicles may have engine calibrations that were not optimized for emissions standards under certain specific conditions, which may cause the vehicle to release air pollutants which exceed Federal and California standards.
Associated Products (5)Associated Documents - February 12, 2026•Document ID: 11028790EmissionsENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SC357_STKR
- Date Added:
- February 12, 2026
- Manufacturer:
- KIA
SummarySC357_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION LABEL/STICKER
Associated Products (5)Associated Documents - February 12, 2026•Document ID: 11028789EmissionsENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SC357_POC
- Date Added:
- February 12, 2026
- Manufacturer:
- KIA
SummaryVOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC357_POC: PROOF OF CORRECTION CARD
Associated Products (5)Associated Documents - February 12, 2026•Document ID: 11028788EmissionsELECTRICAL SYSTEM; ENGINE
- Mfr Comm. #:
- SC357_QA
- Date Added:
- February 12, 2026
- Manufacturer:
- KIA
SummaryVOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER (SC357) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC357.
Associated Products (5)Associated Documents - February 12, 2026•Document ID: 11028787EmissionsENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SC357_DPSM
- Date Added:
- February 12, 2026
- Manufacturer:
- KIA
SummaryVOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC357) - This document is the announcement to the dealer Parts and Service managers advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations for 2020-2025 MY Telluride vehicles manufactured from January 9, 2019 through October 27, 2025.
Associated Products (5)Associated Documents - February 12, 2026•Document ID: 11028786EmissionsENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SC357_DP
- Date Added:
- February 12, 2026
- Manufacturer:
- KIA
SummaryVOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC357) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations for 2020-2025 MY Telluride vehicles manufactured from January 9, 2019 through October 27, 2025.
Associated Products (5)Associated Documents - December 9, 2025•Document ID: 11026698OtherBACK OVER PREVENTION: WARNINGS
- Mfr Comm. #:
- PS797
- Date Added:
- December 18, 2025
- Manufacturer:
- KIA
SummaryPITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)
Associated Products (60)Associated Documents - August 1, 2025•Document ID: 11021406Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- PS793
- Date Added:
- August 5, 2025
- Manufacturer:
- KIA
SummaryThis Pitstop provides information regarding an inoperative sunroof switch on 2020–2025MY Telluride (ON) vehicles. When diagnosing a vehicle for this condition, check that connectors R02 and R03 are connected in the correct cavities. If these connectors were previously interchanged unintentionally, the sunroof switch will not operate.
Associated Products (5)Associated Documents - June 4, 2025•Document ID: 11019472Service Bulletin/Repair InstructionsSTRUCTURE:BODY
- Mfr Comm. #:
- TSB_BOD340
- Date Added:
- June 11, 2025
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: DOOR BELT OUTSIDE WEATHERSTRIP REPLACEMENT (CA2504) - This bulletin provides information to replace the door belt outside weatherstrip(s) on certain 2023-2025MY Telluride (ON) vehicles produced from August 04, 2020 through February 11, 2025. The affected vehicles maybe missing an adhesive layer, causing the outer faceplate to detach/separate from the door belt outside weatherstrip molding. If a customer has a validated complaint of a door belt outside weatherstrip detaching and/or separating, replace it and any weatherstrip(s) that have not yet been replaced under warranty (including SA535 or SA578) according to the VIN list and procedure in this TSB.
Associated Products (5)Associated Documents - April 30, 2025•Document ID: 11017416Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB_CHA128
- Date Added:
- May 1, 2025
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: 4WD COUPLING NOISE/VIBRATION LOGIC IMPROVEMENT - This bulletin provides information to upgrade the 4-Wheel Drive “4WD” system software on certain 2020-2022MY Telluride (ON) vehicles produced from January 9, 2019, through September 1, 2022. The affected vehicles may exhibit a noise, vibration, shudder, and/or chattering from the 4WD coupling assembly while turning at low speeds (10-15 mph) due to continuous vehicle operation in harsh conditions (e.g., very high or low ambient temperatures).
Associated Products (2)Associated Documents