Kia Sedona Complaints

2,536 consumer complaints on file.

#11709756January 8, 2026
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
The contact owned a 2016 Kia Sedona. The contact stated that while her nephew was driving, the nephew made a left-hand turn, and the vehicle was hit on the front right quarter panel. The contact stated that her nephew had turned on the left-hand signal and was halfway through making the left turn when the accident occurred. The other vehicle drove on the opposite side and stated that the left-hand turn signal was not on. The contact's nephew was unsure if any warning lights were illuminated. The driver-side and passenger-side air bags were deployed. The contact's nephew had minor injuries and had a bruise on the right arm and chest that did not require medical attention. A police report was filed. The vehicle was towed to a towing yard. The contact then had the vehicle towed to the residence and no longer driven. The insurance company was contacted, and the results are pending. Upon further investigation, the contact discovered that the vehicle had an open recall pending: NHTSA Campaign Number: 21V725000 (EXTERIOR LIGHTING, ELECTRICAL SYSTEM). The contact stated that there was a passenger in the vehicle. The passenger was sitting on the front passenger seat and was not injured. The manufacturer was not made aware of the failure. The failure mileage was approximately 96,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11709403January 7, 2026
SEATS
The front passenger seat, occupant detection system wiring harness was never repaired by the dealer I had taken the vehicle to the dealer several years ago and he gave me a $8000 estimate to replace the electrical system!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709206January 6, 2026
STRUCTURE:BODY
Sliding doors have an issue where the car alarms like the doors aren’t shut. Took it in and paid a diagnostic for them to tell me a sensor was bad, it still beeps. Seems to beep more when turning away from that door (driver sliding door beeps more when turning right or when stopping, passenger beeps more when turning left or stopping). This was a problem with previous generation to where the warranty was extended and seems a decent amount of complaints for this model are related to the same.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708408January 2, 2026
ENGINE, POWER TRAIN
March 2024 just before hitting 100,000 miles I started having oil consumption issues. Current milage is 137,300 About 10,000 miles ago my check engine light came on. I took it to an auto parts store and it was reading bank 1 O2 sensor. I took it for an oil change and never scheduled for the sensor replacement due to life events. I took it in for another service About 5,000 miles ago. At around 2,000 miles after the service the motor started stalling and sounded horrible. I took it to the dealership and it was 4.5 quarts low on oil. Took it back at 1,200 miles after top off and it was 2.5 quarts low. Started the new motor process which wasn't covered on the extended warranty due to manufactur defect. It cost me 500.00. Before the new motor was in my van started getting me stranded places. Motor wouldn't turn over at all. Got it started went to auto parts store and it was reading 4 bad sensors in bank 1 and 2 (O2 and air intake on the motor). Finally got it to KIA for the new motor told them about they sensors they were supposed to check/replace them when they put the new crate motor in. Picked my van up 3 days ago. I asked when they called if the engine light was off. They called me back several hours later and said yes. Picked it up at 5 pm 3 days ago. By 8am the next morning the engine light was back on. It's scheduled for 9am Monday. The van has now gotten me stranded 2 times in 3 days. Auto parts store ran the computer and the same 4 sensors are still showing bad. Sensors are in bank 1 and 2. The report on the old motor showed cylinder 1 and 2 oil fouling on the spark plugs (replaced at 100,000 miles by dealer) and excessive oil leakage in cylinder 1 and 2 into the crank case due to carbon stuck piston rings. I was told before the motor replacement that the KIA cares warranty may not cover these sensors. Even though the sensors are going out because they are gunked up with 7 quarts of oil their motor used and they didn't go out until the issue started.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707879December 30, 2025
ENGINE
The contact owned a 2017 Kia Sedona. The contact stated that after parking in his driveway, there was white smoke coming from the front of the vehicle. The contact is handicapped and was assisted by his wife to exit the vehicle safely. The vehicle later caught on fire, and flames were visible in the front passenger side that spread to the rear of the vehicle. No warning lights illuminated before or after the failure. The contact stated that the front of the house was damaged, as well as the garage siding, along with an older truck parked in the driveway. The fire was extinguished by the fire department with water, and a police officer was on scene and tried to extinguish the rear with an extinguisher, but was unsuccessful. There was a fire report filed. The vehicle was towed a week after the fire to the insurance tow lot. The vehicle was deemed destroyed by the insurance company. No injuries were sustained. The manufacturer was notified of the failure. The failure mileage was 106,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11707644December 29, 2025
ENGINE, FUEL/PROPULSION SYSTEM
Kia service dealer diagnosed high oil consumption on my car with heavy sounds. They recommend to replace whole engine but it's out of warranty. It has only 106k miles on it. I am afraid the car is posing safety issue as well and it has less miles on it. I filed complain with kia consumer corporate a case has been generated on their system [XXX] but no one had contacted me yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706319December 20, 2025
ENGINE
My 2019 kia sedona showed the exact same symptoms for the oil pressure switch recall red oil light on the dash and a leaking oil pressure switch.2010 to 2018 sedona why was the 2019 model not added to the list
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706073December 19, 2025
ENGINE
2016 KIA Sedona. I was driving on the highway when the Engine started knocking and smoking. I had to cut cars off on the highway to get to the shoulder. The car was towed to a local mechanic who told us there were holes blown through the engine and it would need replaced. This was after a year and a half of driving it so we still had a loan on the car that we couldn't afford to just scrap the car. We had to get a new engine put in the car. Insurance would not help since we did not hit anything and it was a manufacturer defect. Mechanic checked oil level and viscosity and did not see any issues with it. No warning lamps indicated there was anything wrong with the vehicle before the engine ripped itself apart. Thankfully none of our 3 kids were in the vehicle at the time. This was 2 months that we did not have our family van during the winter holidays and it was a very difficult time for the family.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705212December 15, 2025
ENGINE
Excessive oil consumption
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704943December 14, 2025
ENGINE
I was at an intersection & was turning left. In the middle of the turn the car started knocking noise and vibrating and turned off in the middle of the intersection. It did not crank for several tries while I was panicking with a car full of kids in a busy intersection. When I got it to crank again it turned off again. Some good Samaritans then helped by holding traffic and pushing us out of harms way in a church parking lot. I kept trying to crank it and when it did, I tried to put it in drive and it started the violent knocking and vibrating like it was going to blow up. I had it towed later when I had gotten paid. I had it towed to Keffer Kia where they told me total engine failure at 88,000 miles. I still pay $300 monthly for the car and have 5 kids that I have to shuffle in my mother in laws 4 door car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703358December 5, 2025
ENGINE
The Sedona just stopped in traffic with out warning with my kids in the van. No type or warning lights came on. I had recently got an oil change and tune up. I almost caused an accident. It was extremely scary. I am thankful no one was hurt. I had to pay for a tow and come to find out the engine is locked . The machine started it had very low oil. Which makes no sense since it hadn’t even been 7 days since my oil was changed .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702930December 4, 2025
ENGINE
2016 Kia Sedona SX-L (VIN: [XXX]) equipped with 3.3L Lambda II GDI engine. This is the second engine failure — first engine failed due to head bolt studs separating from the block, second (mechanic sourced) engine began heavy smoking and nearly caught fire due to possible oil starvation/rod bearing failure. Vehicle is parked and unsafe to operate. Temperature gauge at time of incident was going towards above average operating temperature. This is the exact defect covered under multiple NHTSA investigations into Lambda 3.3L engine seizing/fire hazard (including PE23-019 for similar Kia Sorento models with the same engine, and defect petition DP24-002 specifically for 2016 Kia Sedona). Kia has extended the warranty on these engines to 15 years/150,000 miles for bearing damage in some cases, but no full recall exists yet. Requesting immediate investigation and inclusion in an engine fire recall similar to those for Theta engines. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702065November 30, 2025
SEAT BELTS
My [XXX] son pulled the seatbelt so tight it got wrapped around his neck. When I pulled over to unbuckle it, it was stuck. I turned the car off and on again to try and loosen it, but it didn't work. In the emergency, I had to cut the seatbelt with scissors. It's the passenger seatbelt in the second row, next to the window. I reported the incident to Kia in Puerto Rico by phone. They never called me back. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702087November 30, 2025
AIR BAGS
My 2016 Kia Sedona is affected by Safety Recall SC175 (Front Passenger Seat Occupant Detection System Wiring Harness), documented here: [XXX] . Kia and the servicing dealer, Rick Case Kia, report to NHTSA that this recall was completed in 2019. However, the defect described in SC175 is still present and easily reproducible. The dealer continues to insist the repair was completed, but the symptoms match the recall description exactly and the issue now poses a clear safety risk to the front passenger. I have repeatedly informed Rick Case Kia that the recall was not performed correctly or was never performed at all. Despite this, the dealer refuses to inspect or correct the issue and Kia Corporate refuses further action based solely on the dealer’s claim. This has made it impossible for me to obtain the required recall remedy. The vehicle was taken to the same dealer multiple times between 2019 and before the vehicle reached 10 years of age for other safety recalls. If SC175 had truly been completed, the issue should not be present. If it had NOT been completed, the dealer should have been notified in their system during those visits. This suggests that misrepresentation or incorrect reporting may have occurred. Because Kia Corporate relies entirely on the dealer’s incorrect reporting, I cannot obtain the required repair from any Kia dealer, and the safety defect remains unresolved. I am requesting NHTSA review this case as a potential recall-completion misrepresentation that is preventing me from receiving the mandated safety repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701953November 28, 2025
ENGINE
With a 140000 miles and the timing chain and component already failing my mechanic told it could die anytime soon local or on the highway
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701714November 26, 2025
POWER TRAIN
The contact owns a 2016 Kia Sedona. The contact stated that while attempting to park the vehicle, the brake pedal was depressed, and the gear shift lever was moved to Park(P) but failed to lock in place. The contact stated that the vehicle started to roll backwards. The contact used force to lock the gear shift lever in Park(P), and the vehicle came to a complete stop after several attempts. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed with a faulty automatic transmission shift lever. The vehicle was not repaired due to the cost. The vehicle remained at the dealer unrepaired. Upon investigation, the contact related the failure to NHTSA Campaign Number: 22V612000 (Power Train); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701347November 24, 2025
ENGINE, FUEL/PROPULSION SYSTEM
Check engine light came on all of a sudden. Smell of exhaust/gas coming from car. Took car to the dealership to get the cause of the check engine light coming on. Dealership said it came back 02 sensor bank 2 and exhaust gasket to header.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699341November 14, 2025
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2008 Kia Sedona. The contact stated that upon having a state safety inspection performed on the vehicle, the contact was informed by a mechanic that there was severe corrosion on the subframe of the vehicle. The inspector informed the contact that the vehicle might be under recall for the issue. The manufacturer was notified of the failure, and the contact was informed that the VIN was not under recall. The vehicle was not repaired. The failure mileage was approximately 96,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698939November 12, 2025
ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL (ESC), SERVICE BRAKES, HYDRAULIC
The contact owns a 2008 Kia Sedona. The contact stated that the ABS warning light was illuminated. The message "ESC OFF" was displayed. The contact stated that the headlights were inoperable. Additionally, the engine had overheated, causing an electrical short and battery failure. The battery was replaced several times; however, the failure persisted. The contact stated that while driving at 45 MPH, the vehicle shut off unexpectedly. The contact was able to pull into a parking lot. The vehicle was restarted and driven at 25 MPH; however, the failure recurred. The contact was able to pull to the side of the road. The vehicle failed to restart and remained on the side of the road. The contact stated that several mechanics had previously diagnosed the vehicle with electrical failures. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697189November 3, 2025
SERVICE BRAKES
Abs pump control module is defective, leaking fluid causing safety issues.This part is hard to find and very expensive, also has to be programmed to your vehicle with no guarantees that it will work.called Kia customer service and asked for help with this issue but was rejected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sedona