Kia Motors America (Kia) is recalling certain 2019 Optima vehicles equipped with Gamma 1.6L Turbo-GDI or Theta II 2.0L Turbo-GDI engines. A software error in the Forward Collision-Avoidance Assist (FCA) system may cause the braking assist function to not engage when a stationary vehicle is detected.
Car smelled of what seemed like motor oil while driving. Parked, saw white smoke, and confirmed an engine fire. I was clearly in life threatening danger, especially with a full tank of gas. Fire developed rapidly into a roaring blaze. Entire front of car melted. Car is currently being investigated by manufacturer and cause is unknown. No warning lamps illuminated.
VEHICLE SHUT OFF WHILE DRIVING AT 40MPH, ENGINE SEIZED ,WILL NOT CRANK .SUSPECTED CONECTING ROD BEARING FAILURE UNDER SAFETY RECALL SC200, I CALL KIA 18003334542 DENIED RECALL REPAIR AND BEARING CLEARANCE TEST STATING VEHICLE IS REBUILT TITLE. FEDERAL SAFETY RECALL CANNOT BE DENIED DUE TO REBUILT TITLE PER NHTSA .REQUESTING RECALL REMEDY.
No injuries · No fire · No crash
On XXX, Towbin Kia Service (Henderson, NV) officially diagnosed my 2019 Kia Optima (VIN: [XXX], Mileage: 118,325) with a critical component failure: "LOW PRESSURE FUEL PUMP IS LEAKING FROM TOP HAT" (Invoice #XXX). Despite documenting a severe, volatile raw fuel leak that presents an immediate fire and explosion hazard, the dealership refused to keep the vehicle. They explicitly released this active safety hazard back to me. The service department even arranged a third-party Lyft ride to transport my children and me to the dealership to pick up the leaking car and force us to drive it home. The vehicle is currently parked outside my residence, actively leaking raw fuel and filling the cabin with toxic gas fumes. It is entirely un-driveable and a public safety threat. Kia Corporate must immediately bypass standard dealership timelines, authorize a flatbed tow to retrieve this fire hazard, and directly provide an emergency corporate rental vehicle line (Enterprise/Hertz) for my family's safety today. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The vehicle experienced a sudden and severe loss of engine power while being driven on the interstate at highway speeds. The vehicle lost the ability to accelerate normally beyond approximately 60 mph, the Check Engine Light began flashing rapidly, and the vehicle entered “Limp Home Mode.” This sudden loss of power occurred in heavy traffic and created an immediate risk of a high-speed rear-end collision. The vehicle was subsequently inspected by an authorized Kia dealership service center. Diagnostic testing confirmed DTC P1326 (Knock Sensor Detection System). The dealership performed the manufacturer’s Bearing Clearance Test (BCT), and the dealership paperwork documents a “NO PASS BCT” result. The dealership paperwork also documents that Service Campaign SC340 (Theta II 2.4L GDI ECM Software Upgrade) was performed on the vehicle. Despite the documented P1326 condition and the manufacturer’s “NO PASS BCT” result, the dealership is refusing to provide the engine replacement as a covered repair and has instead quoted approximately $9,000 for the engine replacement. I am requesting that NHTSA review this matter because the vehicle experienced a sudden loss of power at highway speeds, followed by a documented “NO PASS BCT” result from the manufacturer’s diagnostic procedure. The vehicle remains an unresolved safety concern. I am also requesting review of whether Kia is properly applying the applicable P1326/BCT engine-replacement procedure and associated coverage to this vehicle. The vehicle and all diagnostic and service paperwork are available for inspection upon request.
No injuries · No fire · No crash
On December 26, 2023, this vehicle received a complete engine assembly replacement at an authorized dealership under a manufacturer warranty repair order. Following the engine overhaul, the vehicle developed a severe, raw gasoline smell entering the passenger cabin through the climate control AC vents while sitting at an idle.The vehicle was brought back to Kia Store East on September 10, 2026, specifically to report this volatile safety issue. On September 17, 2026, the dealership technician explicitly duplicated and confirmed the raw fuel odor coming from the engine area in writing. Despite confirming the gasoline smell, the dealership is refusing to perform a manual high-pressure fuel system pressure-drop test to isolate the physical vapor leak. Instead, they have listed a high-pressure Fuel Pipe Assembly (Part # 35305 2GGA0) on a customer-pay estimate paired with an unrelated $1,819.12 timing cover oil seal repair.The dealership is claiming the failure is out of warranty and is holding the vehicle while forcing daily rental car fees onto me, refusing to isolate the active fuel leak unless I authorize the out-of-pocket repair. The vehicle currently sits un-repaired at the dealership as an active cabin fire and occupant chemical exposure hazard that the manufacturer and dealer refuse to properly diagnose or cover under repair workmanship guidelines.
No injuries · No fire · No crash