Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.
1. Component or system that failed/malfunctioned & availability for inspection: The Motor Driven Power Steering (MDPS) system and the steering column assembly have failed. The vehicle and the defective steering column are fully available for inspection upon request. 2. How safety was put at risk: A known, dealer-diagnosed defective steering column compromises structural steering control. Operating a vehicle with an unresolved steering column defect creates an immediate risk of catastrophic steering failure, locking, or sudden loss of control at high speeds, placing myself, my passengers, and other drivers in imminent danger. 3. Reproduction or confirmation by a dealer/independent center: The problem was explicitly confirmed by a certified Kia dealership. After a prior flex coupler repair, a severe whining noise immediately developed upon leaving the lot. I returned the car, and the dealership's secondary inspection confirmed that the entire steering column was defective and required complete replacement. They issued an official itemized cost invoice for the replacement work. 4. Inspection by manufacturer, police, insurance, or others: The component was formally inspected by the local authorized Kia dealership. However, the dealership subsequently misinformed Kia Corporate by falsely reporting that the vehicle was fully "resolved" to close the corporate case file, leaving the safety hazard unaddressed. 5. Warning lamps, messages, or prior symptoms: There were no warning lamps or dashboard messages. The primary symptom was a distinct, loud whining noise that developed immediately following the dealer's physical teardown and replacement of the steering flex coupler. The issue became persistent from that exact date forward.
No injuries · No fire · No crash
The contact's daughter owns a 2014 Kia Optima. The contact stated that while driving at 45 MPH, the engine stalled and shut off. The vehicle coasted to the shoulder of the road. The contact stated that while attempting to start the vehicle, the engine failed to restart. The vehicle was towed to the dealer, where it was diagnosed with an engine failure and it was determined that the engine required replacement. The contact was informed that the repair was not covered under NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling) due to insufficient service records. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 145,848.
No injuries · No fire · No crash
The contact owns a 2014 Kia Optima. The contact stated that after leaving the vehicle parked for approximately 4 hours, the contact returned to the vehicle and the engine running even though the vehicle was turned off. While driving approximately 30 MPH, the traction control light, ABS, and the parking brake light were illuminated. The contact stopped, parked the vehicle, and restarted the vehicle, attempting to reset the vehicle; however, the lights remained illuminated. While the vehicle was at the residence a family member disconnected the battery and used water on the body of the vehicle closest to the steering wheel underneath the hood of the vehicle. The contact was advised by the family member not to drive the vehicle because of the overheating.
No injuries · No fire · No crash
The contact owns a 2014 Kia Optima. The contact’s son stated that while driving 30 MPH, the steering wheel became inoperable. The contact stated that the steering wheel seized, and significant effort was required to control or turn the steering wheel. The contact’s son also became aware of an electrical burning odor during the failure. The manufacturer was made aware of the failure by telephone. The failure mileage was approximately 153,000.
No injuries · No fire · No crash
I was driving normally on I-76 when suddenly, I couldn’t feel the gas working. Everything was fine with the car until then, but all of a sudden, I saw all the lights on the dashboard. I could slowly smell the smell of flames, and later, it caught fire! I was terrified for my life, and seeing that happen to my first car, which I had only had for three weeks, still haunts me.