Kia K5 Service Bulletins (2022)
113 manufacturer communications on file.
- January 19, 2022•Document ID: 10206957Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; POWER TRAIN:CLUTCH ASSEMBLY; POWER TRAIN
- Mfr Comm. #:
- TSB_TRA100
- Date Added:
- February 4, 2022
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: 8 SPEED WET DUAL CLUTCH TRANSMISSION (WDCT) JUDDER EVALUATION - This bulletin provides information to inspect for judder in the 8-speed Wet Dual Clutch Transmission (WDCT) and possibly replace the Dual Clutch Assembly on some 2021MY~ K5 GT (DL3a) vehicles produced from November 16, 2020 and later and Sorento EX trim and above (MQ4a) non-hybrid vehicles, produced from October 26, 2020 and later, which may exhibit clutch judder. If the vehicle body vibrates without the steering wheel shuddering when performing the creep driving test (driving the vehicle up to 3mph), the vehicle is exhibiting clutch judder. The creep test can be conducted by driving at a speed slower than 5 mph after releasing the brake.
Associated Products (4)Associated Documents - January 6, 2022•Document ID: 10206642Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION; ENGINE
- Mfr Comm. #:
- TSB_ENG222_R5
- Date Added:
- January 20, 2022
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
Associated Products (68)Associated Documents - December 22, 2021•Document ID: 10205527Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- PS719
- Date Added:
- January 4, 2022
- Manufacturer:
- KIA
SummaryPITSTOP: POTENTIAL LOW OIL PRESSURE DUE TO FILTER DRAIN PLUG THAT WAS LEFT IN FILTER - Attention Dealership Service Managers, Service and Lube Techs, pay particular attention to this information. This Pitstop provides information regarding potential engine damage if the proper procedures are not followed during an oil change on some 2021 and later K5 (DL3a) and Sorento (MQ4a) vehicles equipped with 2.5L/2.5L-T GDI Theta III engines.
Associated Products (4)Associated Documents - December 21, 2021•Document ID: 10205426Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- TSB_ENG222_R4
- Date Added:
- December 23, 2021
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
Associated Products (69)Associated Documents - December 6, 2021•Document ID: 10205430Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- TSB_ENG231_R1
- Date Added:
- December 23, 2021
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC22) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
Associated Products (11)Associated Documents - October 1, 2021•Document ID: 10202225Service Bulletin/Repair InstructionsSTRUCTURE; EXTERIOR LIGHTING
- Mfr Comm. #:
- PS710
- Date Added:
- October 22, 2021
- Manufacturer:
- KIA
SummaryPITSTOP: APPEARANCE OF WATER LEAK AND/OR CONDENSATION IN REAR CENTER COMBINATION LAMP - This Pitstop provides clarification on what appears to be a water leak and/or condensation in the rear center combination lamp assembly on some 2021MY~ K5 (DL3a) vehicles. The top area of the rear center combination lamp assembly can have the appearance of condensation behind the lens. This is a normal condition for water and/or condensation to be present above the sonic weld line. As the weld forms a lip along the top of the rear combination lamp, water may enter the back side of the lens but does not actually enter the inside of the lamp housing. Replacement of the rear center combination lamp is not necessary.
Associated Products (2)Associated Documents - September 14, 2021•Document ID: 10201439Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- TSB_ENG231
- Date Added:
- October 2, 2021
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC22) - This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
Associated Products (10)Associated Documents - September 13, 2021•Document ID: 10201529Service Bulletin/Repair InstructionsSTRUCTURE; EXTERIOR LIGHTING
- Mfr Comm. #:
- TSB_BOD055_R1
- Date Added:
- October 2, 2021
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
Associated Products (199)2022 Kia Carnival2022 Kia K52022 Kia Sportage2022 Kia Stinger2022 Kia Telluride2021 Kia Cadenza2021 Kia Forte2021 Kia K52021 Kia K9002021 Kia Niro2021 Kia Rio2021 Kia Sedona2021 Kia Seltos2021 Kia Sorento2021 Kia Soul2021 Kia Sportage2021 Kia Stinger2021 Kia Telluride2020 Kia Cadenza2020 Kia Forte+ 179 moreAssociated Documents - September 1, 2021•Document ID: 10201158Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- TSB_ENG222_R3
- Date Added:
- September 10, 2021
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
Associated Products (65)Associated Documents - August 13, 2021•Document ID: 10200422Service Bulletin/Repair InstructionsEQUIPMENT; STEERING; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- TSB_CHA106
- Date Added:
- August 25, 2021
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF THE DUAL PINION MOTOR DRIVER POWER STEERING SYSTEM - This bulletin provides information regarding the availability of partial repair (depending on faulty components) of the Dual Pinion Motor Driven Power Steering (DP-MDPS) system on some 2016-2021MY~ Kia vehicles (refer to the table below) in order to enhance customer satisfaction by promoting a cost-effective repair/replacement of a faulty related part, instead of replacement of the complete DP-MDPS assembly.
Associated Products (12)Associated Documents - August 3, 2021•Document ID: 10200525Service Bulletin/Repair InstructionsFORWARD COLLISION AVOIDANCE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- PS704
- Date Added:
- August 25, 2021
- Manufacturer:
- KIA
SummaryPITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
Associated Products (68)2022 Kia Carnival2022 Kia K52022 Kia Stinger2022 Kia Telluride2021 Kia Cadenza2021 Kia Forte2021 Kia K52021 Kia K9002021 Kia Niro2021 Kia Rio2021 Kia Sedona2021 Kia Seltos2021 Kia Sorento2021 Kia Soul2021 Kia Sportage2021 Kia Stinger2021 Kia Telluride2020 Kia Cadenza2020 Kia Forte2020 Kia K900+ 48 moreAssociated Documents - June 24, 2021•Document ID: 10198619Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- PS703
- Date Added:
- July 2, 2021
- Manufacturer:
- KIA
SummaryPITSTOP: BLUETOOTH MEMORY AND VOICE RECOGNITION CONCERN WITH AVN 5.0/W - This Pitstop provides information for resolving a memory concern with the AVN 5.0 Wide head unit while downloading the contact list from a paired phone. The concern also affects Voice Recognition (VR) functionality.
Associated Products (11)Associated Documents - June 4, 2021•Document ID: 10195050Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- TSB_BOD210_R2
- Date Added:
- June 15, 2021
- Manufacturer:
- KIA
SummaryTECHNICAL SERVICE BULLETIN: COMBINATION TSB / SERVICE ACTION: CONSOLE SQUEAK NOISE INSPECTION AND REPAIR (SA436) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding a potential squeak noise between the Heating Ventilation Air Condition (HVAC) controller and the floor console upper garnish on some 2021-2022MY K5 (DL3a) produced from March 25, 2020 through June 8, 2021.
Associated Products (2)Associated Documents