Kia America, Inc. (Kia) is recalling certain 2021-2024 K5 vehicles. A damaged check valve can allow air to enter the fuel tank, causing it to expand and contact hot exhaust components, melting the tank.
Kia America, Inc. (Kia) is recalling certain 2021-2023 K5 vehicles. The side curtain air bags may have been installed incorrectly, causing them not to deploy properly in the event of a crash.
Kia Motors, Inc. (Kia) is recalling certain 2021-2022 Sorento and 2021-2023 K5 vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Kia Motor America (Kia) is recalling certain 2021 Sorento and 2021-2022 K5 vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
Kia Motors America (Kia) is recalling certain 2021-2022 K5 vehicles equipped with 2.5L T-GDI engines. The Rack-Mounted Motor Driven Power Steering (R-MDPS) system lacks the ability to diagnose communication faults. If a communication fault occurs while driving around a curve with Lane Following Assist (LFA) engaged, the steering assist level may not adjust properly, causing a sudden increase in the steering effort required.
The contact owns a 2022 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline). While driving 70 MPH, the contact heard a loud pop coming from the rear driver's side of the vehicle and the check engine warning light intermittently illuminated with an abnormal burning odor briefly inside the vehicle. The vehicle was taken to the dealer, and the contact was informed that a diagnostic test was needed to determine the cause of the failure.
No injuries · No fire · No crash
Verified by ASE Certified Mechanic Premature PCV valve/ Oil Separator failure. Causes codes such as P0507, P0171, P0471. This can trigger limp mode, sudden loss of speed/engine power, thus increasing the event of an accident.
No injuries · No fire · No crash
The contact owns a 2022 Kia K5. The contact stated that while driving 50-55 MPH, the vehicle lost motive power and came to a complete stop in the middle of the roadway. The contact did not attempt to restart the vehicle. The contact activated the hazard lights; however, 20–30 minutes later, another vehicle struck the front passenger side of the vehicle near the front passenger’s side wheel. The contact sustained sharp lower back, hip, and left knee pain. The contact's boyfriend sustained lower back and right knee pain. A family member transported both occupants to the hospital, where medical attention was provided. The check engine warning light illuminated after the failure. A Police report was filed. The vehicle was towed to Custom Auto-Collision. The contact associated the failure with NHTSA Campaign Number: 22V760000 (Power Train). The dealer was notified of the failure by phone. The failure mileage was approximately 57,000.
The vehicle is subject to Kia Safety Recall SC356 / NHTSA Recall 25V794 involving the fuel tank/check valve. The recall concerns potential fuel-tank swelling that can cause the tank to contact hot exhaust components, potentially melt and leak fuel and create a fire hazard. The component/system involved is the fuel tank and fuel tank check valve. The vehicle is available for inspection upon request. The safety concern is that a fuel tank that swells could contact hot exhaust components, potentially resulting in a fuel leak and vehicle fire. Because the vehicle is driven by my daughter, I am concerned about her safety and the safety of other occupants. The recall condition has been identified/communicated by Kia as an applicable safety recall for this vehicle. The Kia dealership has been contacted regarding the recall, but we were told that they cannot currently repair the vehicle. I am seeking clarification from Kia regarding the specific reason the repair cannot be completed and whether the vehicle is safe to drive. The vehicle has been presented/contacted with the Kia dealership regarding the recall. To my knowledge, there has been no crash, fire, or fuel leak involving this vehicle. There have been no warning lamps or warning messages reported prior to a failure. We became aware of the problem through the manufacturer’s safety recall. The vehicle has not experienced an actual failure or fire at this time.
No injuries · No fire · No crash
- The exact component that failed has not yet been determined. The vehicle experienced a sudden loss of acceleration while driving, followed by a popping noise, smoke, and a fire that severely damaged the vehicle. The vehicle is a 2022 Kia K5 GT-Line, VIN [XXX]. The vehicle has an open Safety Recall SC356 / NHTSA Recall 25V794 involving the purge control system check valve and fuel tank, which may result in fuel leakage and an increased risk of fire. The recall repair had not been performed prior to the incident. The vehicle is currently being preserved and is available for inspection upon request. - The vehicle caught fire while driving on XXX, in [XXX]. The vehicle suddenly stopped accelerating, a popping noise, and then smoke began coming from the vehicle shortly afterward. The vehicle subsequently caught fire and was destroyed. The incident created a serious risk of injury to me, other occupants, nearby motorists, and others in the area. Fortunately, there were no injuries. - The cause of the failure and fire has not yet been confirmed. The vehicle was severely damaged by the fire. The vehicle has an open Kia SC356 / NHTSA 25V794 safety recall, which we were unaware of, but it has not yet been determined whether the condition addressed by that recall caused or contributed to this incident. - The Killeen Fire Department responded to the vehicle fire and extinguished the fire. The incident has also been reported to my insurance company, and an insurance claim is currently pending. No inspection has yet been performed to determine the cause of the fire. The vehicle is being preserved so that it remains available for inspection by the manufacturer, insurance representatives, NHTSA, or an independent expert if necessary. -No warning lamps or warning messages prior to the incident. While driving, the vehicle suddenly stopped accelerating, then a popping noise was heard, followed by smoke, and the vehicle subsequently caught fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5