Kia Carnival Complaints

397 consumer complaints on file.

#11470164June 21, 2022
VISIBILITY/WIPER
We purchased our Carnival in November of 2021. A few months ago a rock hit our windshield. I could tell that the small rock chip was quickly making crack lines. We called a windshield repair company who suggested that we put a piece of tape over it until we could get it fixed. Luckily we followed his advice and put tape on it until we could get in a few days later for a chip repair. If we would not have followed his advice I have no doubt the cracks would have spread. Fast foward to last Saturday, June 18th. We were driving down the freeway and suddenly we notice that there is a large crack in the windshield, directly in front of the driver's view. It's maybe 8 inches long and we have no idea where it came from. We thought for sure we would have a few days to take care of it before it spread. It has already doubled in size. There have been no extreme temperatures to explain the quickly spreading crack. When we looked to see the source of the large crack, we noticed a very very small chip in the very edge of the windshield. The chip is not even visible from the inside of the car. It seems to me that the windshield is make from weak materials. I have never had this many problems with a car. And keep in mind we've only owned this car for 7 months! I believe Kia needs to address this issue. The windshield is the only thing between the face of the driver and the outside elements. It should be durable and reliable. This type of situation makes me concerned about the quality of the windshield, especially over the life of the vehicle. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469661June 16, 2022
STRUCTURE:BODY:DOOR
The power sliding doors fail to stop closing unless excessive force is used. If an arm or hand is in the way it gets hurt and the door will try to close on it. The dealership inspected it and said it's a known issue that extra force is needed. There's nothing they can do. How was your safety or the safety of others put at risk? My child's was being closed in the door and when I tried to stop it to save my daughter my arm was bruised. Yes, the dealer knows of the issue but plays it off as just a door that requires more force to stop. Yes, Kia inspected it, found you need to apply more force then normal but has no solution but to make sure to keep far away when it's closing. They However said nothing can be done, it's just how the van comes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468938June 13, 2022
STRUCTURE:BODY
The doors sensors do not work. I am 200+ lbs and have to push with force to get it to stop closing. My 2 year old last minute stuck her hand into the car while the door was closing to get a blanket and it CRUSHED her fingers. These doors are extremely unsafe. Then we took it to Kia and they said “just keep the kids away from the doors” which is INSANE when you’re talking about little kids.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11466623May 29, 2022
STRUCTURE:BODY:DOOR
The automatic doors will close even if a child or something is in the way. Kia has acknowledged that the sensor may not work, but this is a huge safety issue when dealing with small children. I was loading the car and pressed the button to close the door. Then, I realized I forgot something and placed my hand in front of the sensor to stop the doors from closing, but the sensor failed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466619May 29, 2022
UNKNOWN OR OTHER
My daughter was closing the left sliding door with her right hand using the button and her left hand was in the doorway. There is no worthwhile sensor in the car to detect her hand and thus the door crushed her hand. She now has a fractured left thumb due to the Kia Carnival. I have tried to see if the sensor would detect my entire hand and it didn’t! I am appalled that a car could be sold that has ZERO sensor
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11465687May 23, 2022
SEATS
The middle seats seem to be spring loaded, when pushing them back into position the spring back with significant force if not "clicked" in. This resulted in a significant bruise after hitting me in the head.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11461462April 20, 2022
STRUCTURE:BODY:DOOR
'Auto reopen' feature of power sliding side door FAILS TO REOPEN by not 'sensing' a SOFT item obstruction (i.e. arm, leg, hand, pet) when closing. Daughter had severe bruising to arm (i.e. sliding door significantly squeezed arm). Sensor replaced by KIA dealership, safety problem still persists. Continued talks with KIA eventually resulted in KIA stating (in written letter) that "the auto-reverse feature is supplemental feature and should never be relied upon as a primary safety feature".
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11458174March 24, 2022
ENGINE, FUEL/PROPULSION SYSTEM
Beginning of January, when I went to drive home from work my check engine light was on and my Kia Carnival wouldn't accelerate over 10 mph. I let it run longer and tried to drive again and it wouldn't go over 20 mph. Let it sit a while longer and it finally drove normally but the check engine light stayed on. I called and made an appt with Kia in Fort Wayne immediately after it happened but they couldn't get me in for almost 2 weeks. The day I took it in (Jan. 22) the vehicle/engine shook anytime I accelerated. It did this the entire drive from my home to the Kia dealership. They ran diagnostics and found there was a sensor error with the injectors. They test drove it and said everything was fine. I got it back on Jan. 25 or 26th and it was fine. Then on the 29th I went to drive my vehicle and it had the acceleration problem again. I immediately called Kia and they couldn't get my vehicle in until Feb. 7th. I didn't drive it that day after the acceleration problem, but the check engine light was on again. I've driven it all last week because I need a vehicle. The check engine light will come on sometimes and sometimes be off. On Friday Feb. 4th the shaking happened again. It would shake when I accelerate. The check engine light was on all weekend. They looked at my car on Feb. 7th and the check engine light isn't on and it's driving fine for them at Kia. They ran the diagnostic and said it was the sensor error again. They said it was fine to drive because it wasn't happening right at that moment. I drove it home and it started to have the same issues again multiple times. I called the first time it happened again after service and they couldn't get it in until March 7th. It won't do it everyday, usually just cold mornings on the first start. It wasn't having the issue when I took it in for service. They looked at it and said it was fine. I get it back and it's doing it again. After 4 service visits I'm still having problems and Kia refuses to help or do a buyback.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11458125March 24, 2022
ENGINE, STRUCTURE:BODY:DOOR
The contact owns a 2020 Kia Carnival. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The check engine warning light was illuminated. Additionally, the rear driver's side automatic sliding door sensor malfunctioned, causing injury to the contact's daughter's shoulder when it closed while she was exiting the vehicle. No medical attention was received. The vehicle was taken to the dealer where it was diagnosed with an unknown failure. The dealer informed the contact that an unknown part needed to be replaced and deactivated the rear-powered sliding doors. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 1,020.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11457083March 17, 2022
ENGINE, FUEL/PROPULSION SYSTEM
On three separate occasions when the temperature was below -20C, this brand-new vehicle stopped working due to ice in the throttle body. Vehicle had to be towed each time. The dealer service manager informed me that the new design no longer heats the throttle body, and condensation jams the mechanism. In my mind this is a safety risk because (1) the car stops working while driving in traffic and (2) it's a family vehicle, putting up to 8 passengers at severe risk of cold-related injuries when stranded. The dealer has confirmed that this has occurred for at least three other customers at this one dealership. Each time they have inspected and disassembled the assembly, cleared the ice buildup, and applied a silicone lubricant. On the first and third occasion only, the "Check Engine" light came on. On the second occasion, the car simply died while driving, and I had to roll to the highway shoulder. Note: On the "address" page, your form does not take a Canadian address, however this vehicle is also sold in America. My Correct postal code is J7V 8P4 and Province is Quebec.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456566March 14, 2022
VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
Car will not accelerate. Error code P211800. Engine control system. Throttle control. Temp outside was 19degrees F. Check engine light is on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456403March 12, 2022
AIR BAGS
I was tboned on 3/10/2022 at high speed in the back driver's side 1/3 of the car by another who ran stop sign at high speed (I am guessing 50 or 60 mph). I have some amnesia about the impact now....but with large hematoma on left side of my head & concussion, my head must have hit the left side body/frame of the vehicle without the benefit of side curtain airbags that sure would have made this accident less traumatic to my body and brain. Currently the vehicle is being moved from an impound lot to State Farm' lot. We have not seen any warning lights or had any problems with this car up til now. It has not been inspected by any mechanics yet either.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11455242March 4, 2022
ELECTRICAL SYSTEM:IGNITION
The contact owns 2022 Kia Carnival LX. The contact stated that while driving at 55 MPH, the engine misfired, and the check engine warning light was illuminated. In addition, the vehicle would shudder when warming up. The vehicle was driven to local repair and diagnosed several times with the same failure, but not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 9,000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450964February 8, 2022
STRUCTURE:BODY:DOOR, UNKNOWN OR OTHER
My passenger doors do not appear to have a sensor and do not stop when someone or something is in the way. Could be very dangerous. My arm almost got stuck in it. Had it been a child, they may not have had the reflexes to get out in time. Also. If the door is accidentally opened when pumping gas, will it stop? Likely not.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11448472January 22, 2022
ENGINE, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
The throttle body froze up and the Van went into "limp mode". I was driving on a semi-busy road and I could not go above 10mph. It would not let me shift either. Like it was not getting any gas to let me accelerate. The check engine light was on, I used a scan reader and the code came as P2118. Also when it went to the dealership the check engine light was still on. It was inspected by the dealership, but only deleted it and it was given back to us. Yes, the first symptom was the idle was rough and the exhaust was making a deep noise. *Dealership wrote that it had high rpms*, which I never said that to them, I told them( dealership) that it was low rpms with the rough idle. I had it idle for 5 minutes so it could warm up since it was 15 degrees that night. This issue is not safe because I could get hit from behind because the van can not go faster or drive at the marked speed limit on city/highway roads. Also, having issues like this is not safe for my kids or other passengers in the Carnival. The dealership said it is from condensation getting into the throttle body. But I have never had this issue with any other car/truck I have owned.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448444January 22, 2022
ELECTRICAL SYSTEM
My check engine light keeps coming on due the throttle freezing in the winter and the car won’t go over 14mph when light is on
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448414January 21, 2022
ENGINE
This morning was the coldest morning this year (7F) and I could not accelerate the vehicle after turning it on. It won't go faster than 15mph or so and the engine warning sign popped up. The code said P211800. I have heard that there were many people complaining this issue and I had felt mine was safe from this issue, but the weather hasn't been that cold to cause the issue. I had to drive with the panic button on and all the other cars passed me and I felt I was in danger while driving back home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448401January 21, 2022
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
Will not accelerate over 10 Mph in cold temp even after warming up vehicle. Will lose acceleration at a intersection and dangerous while taking a left turn. Check engine light goes on. Throttle bottle issue. Believe it is moisture/water in the throttle body causing it to freeze in colder temps. NEEDS TO BE RECALLED. Many many other Kia Carnivals having same issue. Model is brand new and should not be having these issues. FAMILY CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448290January 20, 2022
STRUCTURE:BODY:DOOR, UNKNOWN OR OTHER
The automatic doors are supposed to stop when they sense an interference but they don’t stop. My daughter got her hand smashed in ours. I thought maybe it was just where her hand ones but I used my own arm to test the door and it smashed by arm before re-opening. Left an awful bruise. I have heard many other carnival owners have had little hands smashed in their doors
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11447955January 18, 2022
STRUCTURE:BODY:DOOR
Power sliding doors are way to powerful. They take a lot of force to be stopped.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Carnival