Hyundai Santa Fe Complaints

864 consumer complaints on file.

#11741734June 3, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, ENGINE
I was driving down the road and came to a stop at a stop light. After accelerating again my car lost the ability to increase speed above 20 miles/hour and would not shift gears. I was heading to the turn lane to get on the interstate and quickly had to change lanes to find an area to pull over as I could not reach highway speeds. I turned the car off. I turned the car back on and the problem resolved. This is the second time this has happened. I have seen this problem mentioned dozens of time on Reddit message boards including Hyundai buybacks on some of these vehicles. It doesn't sound like Hyundai has any idea what is causing this issue. This issue should be looked into further.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741656June 2, 2026
BACK OVER PREVENTION: WARNINGS, UNKNOWN OR OTHER
I PUT MY VEHICLE IN PARK AND VEHICLE CONTINUED TO MOVE, IT MOVED OVER A CURB AND INTO A WALL. I BROUGHT VEHICLE TO DEALERSHIP NEXT DAY AND THEY STATED IT WAS A GEAR CONTROL ISSUE AND NEEDED TO BE REPLACED. I BROUGHT THE VEHICLE TO GET AN ESTIMATE FOR REPAIRS AND ESTIMATE IS NEAR $7000. DEALERSHIP SAID THE PART IS NOT UNDER WARRANTY AND NO RECALLS. THIS IS A SAFETY CONCERN. VEHICLE HAS NOT BEEN CHECKED BY MANUFACTURE, POLICE OR INSURANCE AS OF YET NO WARNING LAMPS OR MESSAGES WARNED ME OF A POSSIBLE GEAR FAILURE. I HAVE READ ONLINE OF OTHER PEOPLE HAVING THIS SAME ISSUE WITH HYUNDAI SANTA FE
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11741652June 2, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: WARNING
Hyundai - DAW - Driver Attention Warning / Forward Attention Warning System This issue warrants immediate consideration for a recall. Despite wearing glasses, sunglasses, or no glasses, the problem persists. I occasional do remove my glasses while driving, and the warning continues to sound. This occurs regardless of the time of day, weather conditions, or whether I am sitting upright or reclining. The warning randomly activates and deactivates, sometimes without any intervention. Occasionally, I simply allow the warning to sound without taking any action, and it remains active for a few seconds or until it triggers a warning that the system will be turned off, at which point it deactivates. I have attempted various troubleshooting methods, such as keeping my eyes open, adjusting my seating position, wearing and removing my glasses, and tilting them to minimize glare. None of these methods have proven effective in preventing the warning from activating or in making it deactivate. This is a persistent problem. Hyundai dealerships initially informed me that the warning might be an annoyance and their response was to simply refrain from using it. However, if a basic feature like cruise control in a 2024 & 2025 model is rendered unusable due to a design flaw (which this certainly is), it constitutes a clear violation of safety standards and should be addressed through a recall. The incessant alerts are highly disruptive and can be quite frustrating. For instance, driving with an arm in the 12 o’clock position triggers a warning, while wearing polarized sunglasses also results in an alert. The presence of a setting to disable the warning is a welcome feature, but the system’s persistent alerts can be overwhelming. The alerts continue even after taking a break. It is distracting and a safety hazard. Drivers should be able to adjust the sensitivity of the feature to turn off this feature. Currently, there is no way to disable or temporarily disable this feature.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741562June 2, 2026
FUEL/PROPULSION SYSTEM, SERVICE BRAKES
Engine light for car read codes PO 304 303 420 prior to sale of car per code read out taken when engine light went off shortly after my purchase. Not addressed prior to sale. Codes read and called to dealership. Car taken for service. Reported fuel smell, exceleration issues, short stallings. Same codes. Stated car was " fine." Drivable. Asked for brakes/ rotors to be checked. No documented brake service given. Stated they were "fine." Taken to local brake place next day that confirmed brake rotors needed repair. Car returned after began sputtering. Reported as fuel injector failure. A known issue with this makr and model that shown codes point to that were given to, and read at service center by mechanic at dealership twice. They did not mention replacing catalytic converter, that is damaged from injectors and an emissions issue at time of call regarding repair report. No brake report or inspection requested multiple times to be checked. Did not follow correct protocol to ensure engine was clear of fuel sprayed by injectors into pistons, intake valves, ect. They placed my self at risk for engine fire, sudden car failure. Consistently mislead and failed to do proper reseach and care regarding car issues and hazards it presented. Being a known issue with this make and model it was a failure to inspect for issue. An emissions failure and violation to allow a damaged catalytic converter to be on road. This issue with the car is in class actionable suit. It is not on the recall list. As it damages the whole car systemi including emissions, it should be forced to be on the recall list so dealerships cannot allow potential harm to their customers as well as violating emission laws.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741053May 30, 2026
TIRES
New vehicle purchased February 2026 with OEM Pirelli tires. Had puncture in tire, but on repair, tire found to have inside sidewall bubble. No history of any impacts or hard strikes to tires. Discount Tire said probable tire defect, unsafe to drive even a few miles, so placed spare and we took car to dealer. No extended warranty but less than 2400 miles on gently used tire. Hyundai denied coverage under Pirelli warranty for nearly new tire, stating that it was due to some kind of undetermined impact to tire (all other tires thus far okay), and we paid for a new replacement tire. But given the lack of history, I noted that their are numerous online complaints regarding this same tire on larger vehicles, including 10 complaints filed already to NHTSA. I have filed an inquiry with Pirelli, but believe, given the numerous prior complaints and the EXTREME SAFETY RISK OF A BLOW OUT on a tire that appears to be defective. based on other reports and our experience, an investigation into this tire should be undertaken with possible recall and replacement of all of these tires with a safer model, at Pirelli's expense, should a defect indeed be found.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740975May 30, 2026
ELECTRICAL SYSTEM
While driving to work, the rear driver-side window suddenly fell down into the door without warning. The power window/regulator system appears to have failed. The window would not stay up or operate normally afterward. The failed component is available for inspection upon request. This created a safety concern because the vehicle could not be secured, outside air/noise entered the vehicle while driving, and rain/debris could enter the passenger compartment. It also created a distraction while driving because the sudden window drop was unexpected. There were no warning lights, dashboard messages, or prior symptoms before the failure. The issue has not yet been confirmed by a dealer or independent repair shop. The vehicle/component has not yet been inspected by the manufacturer, police, insurance, or others. The suspected failed component is the rear driver-side power window regulator or related window mechanism. Cause is unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740926May 29, 2026
ELECTRICAL SYSTEM, SEATS
My 2024 Hyundai Santa Fe (VIN: [XXX] ) is suffering from a severe, systemic vehicle-wide electrical network failure. The main digital instrument cluster screen has suffered four separate total blackouts (XXX), completely eliminating all driver visibility of the speedometer, odometer, safety malfunction telltales, and critical warning alerts while operating the vehicle at highway speeds. The vehicle has also experienced continuous battery collapses, recurring navigation freezes, and malfunctioning proximity key fobs/electronic door locks that fail to secure or unlock the vehicle.Most severely, on XXX, a defective, short-circuiting heated seat element experienced an uncontrolled thermal spike and caused physical thermal burn injuries to the right side of my body during an out-of-state trip. Photographic evidence of the physical body burns has been preserved. The authorized dealership was presented with this defect during an extended 38-day shop visit immediately following the incident but was completely unable to diagnose, or repair this severe electrical safety hazard. The vehicle remains unsafe to occupy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11740922May 29, 2026
POWER TRAIN, SERVICE BRAKES
My 2024 Hyundai Santa Fe (VIN: [XXX] ) was manufactured on March 14, 2024, in [XXX] . The vehicle is currently experiencing dual-clutch transmission (8DCT) juddering, shuddering, and extreme hesitation when trying to accelerate from a complete stop at traffic lights and intersections. This creates a severe lag in acceleration, leaving the vehicle dangerously exposed to oncoming traffic. This component failure directly mirrors the mechanical hazards outlined in NHTSA Safety Recall 263. Because my manufacturing date falls just outside the official recall window, this vehicle has not received a formal recall remedy, yet it actively exhibits the identical, dangerous powertrain defects, suggesting the recall's production scope may be too narrow. Furthermore, in November 2024, the vehicle suffered a catastrophic safety failure where it completely lost all propulsion power for approximately 30 seconds while moving through the middle of a live intersection. Most recently, on XXX, right after being released from an extended 38-day service stay at an authorized dealership, the electronic infotainment displayed an active warning screen stating the car should be shifted to park while the vehicle shifter was physically and securely locked in Park. Time-stamped video evidence of this active transmission/braking sensor failure has been captured and preserved. The vehicle remains an active, uncorrected threat to my physical safety on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740884May 29, 2026
VEHICLE SPEED CONTROL, SEATS:CRITICAL FASTENERS, POWER TRAIN
The contact owns a 2024 Hyundai Santa Fe. The contact stated that the anchor in the third row detached. The vehicle rolled while in the drive position. The vehicle failed to accelerate. While reversing, the vehicle jerked. No warning lights The vehicle was taken to the local dealer on five occasions and was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 20,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740722May 28, 2026
STRUCTURE:BODY
Engine Hood getting so hot it is bending or causing metal to bend , like someone sat on middle of hood. Popped it out and keeps forming a bend after driving. Not instelly but keeps coming back
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740635May 28, 2026
POWER TRAIN
While running errands around town, I noticed my 2023 Sante Fe 2.5T was sluggish shifting out of first gear into second. The RPMS revved to about 3K before the transmission shifted into 2nd. I didn't notice any problem shifting into 3rd and above. I drove to a gas station for fuel and shut off my car. When I started it and began to drive, I received an immediate warning to take the car to a dealer and the check engine light came on. The car had the same problem getting out of 1st gear at each of the traffic signals I got caught at on my way to the dealership about 2 miles away. The following day, the service department contacted me and determined I needed a new transmission due to the failure of the Dual Clutch electric high pressure oil pump in the transmission. They submitted a parts request and Hyundai approved a refurbished DCT warranty replacement. The transmission only has 50200 miles on it I am second owner but the car was a CPO so I have full warranty coverage. I was given a loaner under Hyundai' warranty provisions. My main concern is that although this vehicle is a 2023 Sante Fe, it was put in service around August of 2022 and would therefore have the same transmission as the 2021 and 2022s covered under Hyundai recall 236, but this has yet to be acknowledged as far as I know. Please investigate my situation and consider further requirements of Hyundai! Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740595May 28, 2026
EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP, BACK OVER PREVENTION: SENSING SYSTEM: OTHER
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740547May 28, 2026
POWER TRAIN
Hyundai Corporate is refusing to ground or provide alternative transportation for a documented, warranty-covered engine cooling fault (Code P2181), creating a highway stalling risk. Hyundai's legal compliance team reviews these logs daily.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740391May 27, 2026
ENGINE, POWER TRAIN
The engine has 1205 miles on it and seized up. Autofair hyundia of Manchester denied us. We did get a warning light a couple days before. But to late just the dealer inspected it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740318May 27, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, STEERING, STRUCTURE:BODY:DOOR
The contact's girlfriend owns a 2024 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently swerved from side to side. The message “Consider Taking A Break” was displayed and the Driver Attention Warning (DAW) warning light was illuminated. Additionally, the Automatic Emergency Braking activated while driving near a vehicle or object, slamming the vehicle to a stop and causing the cruise control to deactivate. The message "Keep Hands On Steering Wheel" was displayed even though the contact's hands were on the steering wheel. The contact also stated that the front and rear driver's side doors were vertically bent from a manufacturing defect. The contact stated that his girlfriend feared for her safety while driving the vehicle. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case a filed. The failure mileage was approximately 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740281May 27, 2026
FUEL/PROPULSION SYSTEM, ENGINE, POWER TRAIN
My 2025 Hyundai Santa Fe Hybrid AWD was serviced under warranty on 4/22/2026 for a driveability concern after experiencing a loss of power while driving. The service history shows part HY35326-2M500 was replaced. On or about 5/25/2026, the same issue occurred again while driving at highway speed. The vehicle suddenly lost motive power and dropped from approximately 70 mph to approximately 30 to 40 mph, creating a serious safety risk because the vehicle could not maintain speed with surrounding highway traffic. No warning lamps, dashboard messages, or diagnostic codes appeared during the failure. The vehicle is currently at a Hyundai dealership for inspection and repair for the repeat issue and should be available for inspection upon request. The prior dealer record appears to describe the issue generally as a “driveability concern,” but the current repair diagnosis and full repair notes are still pending. It is unknown whether the dealer has reproduced or confirmed the failure during the current visit. I am reporting this as a sudden loss of motive power at highway speed involving the fuel/propulsion system, engine, and/or powertrain.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740276May 27, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My vehicle activates the emergency braking system while driving. It has happened several times now, almost causing a collision. I took it to the dealership, they held it for a week and gave it back to me telling me they could not find anything wrong with it. They did not fix anything at all. It has since done it once more.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740141May 26, 2026
ELECTRICAL SYSTEM, LANE DEPARTURE: BLIND SPOT DETECTION, FORWARD COLLISION AVOIDANCE: WARNINGS
I own a 2025 Hyundai Santa Fe that was purchased on 08/15/2025. The first malfunction occurred on 08/25/2025, only days after purchase, and the vehicle has experienced repeated safety-related issues since then. The vehicle has repeatedly displayed false Forward Collision Warning alerts, Blind Spot Warning failures, Park/Neutral errors, and intermittent disabling of safety features. The most serious incident occurred when the vehicle unexpectedly entered “Limit 20 MPH” mode while I was pulling into active traffic with my toddler in the vehicle, limiting acceleration and creating a safety risk. I have also experienced false collision alerts while parked and after the vehicle was shut off. The vehicle has been taken to the dealership multiple times for diagnosis and repair attempts. Some issues were duplicated by dealership personnel, while other visits were documented as “could not duplicate.” A front ultrasonic sensor was replaced, but the vehicle continued experiencing safety-related concerns afterward. During the repair process, I was informed and observed that dealership personnel appeared limited in what repair actions could be taken after consulting Hyundai through their diagnostic system. I was also informed that Hyundai influenced what could be included on service reports and that dealership personnel were instructed to “print the book” rather than fully document observed concerns. I believe this may have affected repair efforts and documentation of ongoing issues. The vehicle has been out of service for extended periods and the issues continue despite repeated repair attempts. Due to the ongoing malfunctions and inconsistent operation of the safety systems, I no longer feel safe driving the vehicle because I am concerned it may not function properly during a real emergency situation. Attached are photos of various dashboard errors and warning messages that occurred during these incidents to document the alerts and malfunctions experienced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740013May 26, 2026
POWER TRAIN
Shifter malfunction has appeared since I bought the vehicle new. Once I took it in, they said it was the software. The vehicle now skipped and hesitate in the lower gears. When in high gears ride fine. But once it stops and start driving again, lower gears won’t drive properly. Drives with hesitation and skips.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739969May 25, 2026
POWER TRAIN, SEAT BELTS
We have had several transmission issues with this vehicle for over a year. On March 5th we dropped the car off for an oil leak, a malfunctioning middle row seat belt, and an on going transmission clunk and roll. The dealer repaired the oil leak, replaced the seat belt, (damaged the interior of the vehicle while doing so, then denied it) and said they were unable to replicate the transmission problem. The car went back to the dealer again on March 26 for the transmission clunk and roll. They kept it for 8 weeks, and said they couldn’t replicate the issue. I have confirmation that they didn’t even start the vehicle for 4 weeks. We picked up the Vehicle on May 22, and the issue persists. Yesterday, when pulling out of a gas station, the vehicle accelerated on its own until I intervened stepping on the brake pedal. When I typed in the issue to Google, I was made aware that the vehicle now has a front seat belt safety recall from April 6, which the dealer didn’t even advise us on or offer to repair. I am finding out about this on an interstate family drive and we are of course terrified of driving our vehicle now, based on the unintended accessories and now faulty front seat seat belts. I have asked Hyundai serval times for a buy back which they have refused. Corporate has asked us to bring the car back to the dealer this week, and we are about to sign papers with a lemon law lawyer tomorrow. I wanted to at least file this complaint so that it is in writing should something happen to us in our travels this week. This has all been so unacceptable with Hyundai. We bought this car new and it is paid off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe