Ford Mustang Complaints (2005)

868 consumer complaints on file.

#11678583August 5, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Ford Mustang. The contact stated that while her husband was attempting to fuel the vehicle, the fuel tank was unable to be fully fueled. The contact stated that either the nozzle would shut off prematurely or gasoline would be prevented from flowing into the fuel tank. There was no warning light illuminated. The contact stated that the failure was intermittent, but by late 2024, the fuel tank could no longer be filled, and the vehicle was placed in storage. The vehicle was taken to a local dealer prior to being placed in storage, and the contact was informed that the fuel tank needed to be replaced. The contact was made aware of Technical Service Bulletin Number: 05-15012; however, the vehicle was not covered under warranty. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 32,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650264March 24, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2005 Ford Mustang. The contact stated that the check engine warning light was illuminated. While driving at approximately 25-35 MPH for approximately two miles, the engine started overheating. The oil pan gasket was leaking. The contact stated that the failure was related to NHTSA Campaign Number: 16V779000 (Engine and Engine Cooling). There were several hoses that were split. The vehicle was taken to an independent mechanic who determined that the radiator and engine were cracked, and the pistons were loose. There was air in the oil. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643850February 20, 2025
ENGINE
I have experienced two engine failures in my 2005 Ford Mustang due to timing chain issues, specifically the failure of the timing chain cassette, guides, and tensioners in the 4.0L SOHC V6 engine. The first failure happened suddenly with no warning, resulting in severe bottom-end damage, including rod knock. The timing chain cassette ends tend to snap off, sending debris through the engine and damaging lifters, camshafts, and other critical components. The second failure was preceded by an audible “death rattle,” a known symptom of timing chain guide and tensioner failure. Despite this, my vehicle never displayed a check engine light or oil pressure warning before either failure. Unlike later Mustangs with an oil pressure gauge, mine only has a warning light, which never activated.This issue poses a major safety risk, especially at highway speeds. My first engine failure occurred with no prior symptoms, which could have led to an accident had I been merging or overtaking. A failing timing chain can cause misfires, loss of power, or sudden engine shutdown, endangering the driver and others on the road. Independent mechanics have confirmed this issue, and Ford service centers recognize it as a common problem with the 4.0L SOHC V6 engine. Ford has quoted $3,000–$4,000 for timing chain service, making repairs nearly as expensive as engine replacement. These engines rely on multiple chains and hydraulic tensioners that wear out over time, causing slack in the timing chain, jumped timing, and catastrophic damage, typically after 100,000 miles. Despite this, there are no clear warning systems to alert drivers before failure occurs. While timing chains are considered serviceable components, the high failure rate of the timing chain guides and tensioners in these engines, combined with excessive repair costs, indicates a design flaw. I have spent around $4,500 addressing this issue, yet the risk of recurrence remains.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643908February 20, 2025
STRUCTURE, AIR BAGS, ELECTRICAL SYSTEM
The contact owns a 2005 Ford Mustang. The contact stated that during inclement weather, water was entering the cabin of the vehicle through the passenger’s side glove box. The contact stated that due to the failure, mold had developed throughout the vehicle on the carpet, doors, and interior seats. The contact's husband also discovered that water had entered the computer module after inspecting the vehicle and the module was removed. The contact stated that the vehicle was inoperable after several repairs and several battery replacements. The vehicle was not repaired. The contact called the dealer and was referred to the manufacturer for assistance. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 87,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638493January 25, 2025
FUEL/PROPULSION SYSTEM, POWER TRAIN, STRUCTURE:BODY
Ford did issue a recall for several issues for my car, including but not limited to, problems when filling gas tank with evaporative purge system as well as cavitation of the fuel pump in high heat conditions, the doors not closing all the way or handles remaining open( not flush with rest of door) when door is shut, driver's side door trim/bezel around power window switch making buzzing sounds when stereo is in use, as well as ticking sounds coming from motor during operation and various creaks and sounds from front suspension when cornering and going over uneven terrain, and the transmission, the 5r55s, has the known hard shift into gear caused by bad servo. I have reached out to the dealers in my area regarding these issues and even though my car is the correct model and year for the service recall bulletins and has the exact issues described there in, I am told that the vin on my car is not covered even though it is clearly suffering from equipment that exhibits all the same problems listed in the recall. I feel the responsibility to perform and pay for these repairs should fall on the manufacturer, not i, the customer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626876November 22, 2024
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
The contact owns a 2005 Ford Mustang. The contact stated while driving 65 MPH on a rainy night, the headlights started flickering. The contact stated that upon exiting the freeway, while driving 30 MPH, the headlights completely turned off and the hazard lights were inoperable. The contact drove to the nearest gas station and turned off the vehicle. The contact stated that upon attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to the residence. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 170,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619958October 15, 2024
UNKNOWN OR OTHER
I purchased this car from Trent Family Auto on May 2, 2024. On September 11, 2024 the engine failed. While working on replacing the engine I found an open recall. This is safety related and was never mentioned to me by the dealership. So aside from selling me a bad "as is" they sold me an unsafe vehicle. A vehicle my family has ridden in several times since the purchase. In regard to the recall when I reached out to them about the engine replacement cost they stated recalls can only be taken care of by manufacturing dealerships. Shouldn't they have some ownership to inform customer buying an unsafe vehicle there is an open recall? Thank your for checking into this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608307August 13, 2024
AIR BAGS
Took the 2005 Mustang GT in several years ago to have one airbag replaced. Dealer (Autonation Torrance, California) stated parts were not available for the other side. One of the airbags has never been replaced. I now read there is a "Do Not Drive" recall for vehicles of this year and model in "Zone A".
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574183February 27, 2024
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES, SEAT BELTS:FRONT:BUCKLE ASSEMBLY
The contact owns a 2005 Ford Mustang GT. The contact stated the front passenger’s side seat belt was difficult to latch and detach. The contact stated that several times the seat belt failed to detach. The seat belt warning light was illuminated stating that the seat belt was not engaged when it was engaged. The vehicle was taken to a local mechanic who stated that the pin was not attached to the clip causing the seat belt malfunction. The mechanic fractured the seat belt so the contact could drive the vehicle. The seat belt was not repaired. The contact took the vehicle to the dealer, but the vehicle was not repaired due to the warranty being expired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 8,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11561978December 27, 2023
FUEL/PROPULSION SYSTEM
Filling gas tank is a nightmare, the first batch of the newly remodeled vehicle. When filling it it'll pump for 3 seconds and then click off and shoot gas out because it thinks it's full so you have to click it on the lowest possible setting. It's a 16 gallon tank and if it's completely empty the first eight gallons will pump fine anything over that because of the way the tank is shaped is where the airlock is and that's when you can barely touch the gas lever before it clicks off and shoots gas up It takes me 20 minutes to fill up so anything before the half a tank mark will fill normally but once it's over half a tank is when the problem arises. From all of the forums that I've looked at for this new remodeled 2005 year this was a common problem and the mustangs built for the first 6 months and judging by the belt date mine was in March so far well within the first 6 months. When I pulled out the extra gas that dripped onto the ground caught on fire so I had to jump out and luckily I had a fire extinguisher in my trunk but that was terrifying because I'm at a gas station and the whole thing could have went up in flames.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11553700November 5, 2023
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, UNKNOWN OR OTHER
Body control module. It gets wet when it rains because of an engineering mess up. It shorts out my lights. Sometimes it can't get out of car because it messes with the locks and windows. Can't use my electric mirrors anymore. Instead of being a much needed recall they decided to not even make replacement bcm. It is a problem everything it gets wet that should have been recalled and fixed. At least a thousand other incidents of this happening to others.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531903July 12, 2023
ELECTRICAL SYSTEM
I've own a 2005 Mustang GT since the year 2012. Throughout the years I've encountered problems where the cooling fan would abruptly shut off and cause the engine to overheat. The first time this happened I had to pull over to the side of the road countless of times just to let my car get cool enough to get back home. I brought the Mustang GT in to a mechanic who suggested to replace the radiator fan. After replacing it, the fan would work for a few weeks only for it to randomly shut off, but turn back on. Just recently I found oil in my spark plugs and found the following OBD II error codes: P0480 Fan 1 Control Circuit & P0481 Fan 2 Control Circuit. I am convinced the valve seals and maybe the piston rings were worn out due to excessive heat caused by the Mustang's electrical issues with the radiator fan. After searching online, I found countless amounts of threads and videos of other Mustang owners experiencing the same issue. Most of them are caused by a faulty relay connection inside the Mustang's fuse box that is causing the radiator fan to fail. The faulty relay would get burnt and cause a short thus not providing power to the radiator fan which left many owners stranded on the road and caused over thousands of dollars in damages to their engine. The part that gets burnt is not easily available and would require owners to pay an additional thousands of dollars to reconnect the relays. Some owners had no choice but to create a makeshift wired connection from their radiator fan to the dashboard so that their vehicle's engine can remain under normal operating temperatures while driving. I've attached a video of someone explaining this issue at the 8:00 Minute mark. https://www.youtube.com/watch?v=WAs6uf3VV68
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529389June 28, 2023
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2005 Ford Mustang. The contact stated that while driving at an undisclosed speed, the speedometer and several unknown gauges on the instrument cluster became inoperable. The vehicle was taken to the dealer, where it was diagnosed that the instrument cluster needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 56,981.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503549January 25, 2023
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2005 Ford Mustang. The contact stated that after parking and turning the vehicle off for extended periods of time, the vehicle would not restart, and the battery needed to be recharged. The vehicle was taken to the local service center who was unable to determine the cause of the failure. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was approximately 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498703December 23, 2022
UNKNOWN OR OTHER
I just bought this the floor board is totally soaked I have read this soaking wet I have read this is a serious issue for long time to eye the wiring shorts out as been why is this not on a renal list to bed serious issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11493048November 10, 2022
AIR BAGS, SERVICE BRAKES
I have done all my airbag recalls and the light came on a few months ago and is steady flashing. Called Cresent Ford in High Pint and they looked up my VIN and my car replacement history. They told me it had been replaced but it was still under warranty and to make an appointment to have it looked at. Made an appointment, which I may add I had to take the day off and drive 40 mins one way, I was told by [XXX] that I had to pay for a diagnostic test because it may not be the airbag and they refused to look at the car until I paid for a diagnostic test. I continue to receive airbag notices and if I was told on the phone this was under warranty. If there are problems in the past with airbags and in the future, we have problems why should this not be covered and looked at by Ford at cost to them to run a diagnostic test. This is absurd. Had this happened to me 3 months ago I NEVER would not have purchased a 2010 Mustang if this is how you do your customers for your defective parts. Also went to pull the parking brake up, which was passed inspection SEVERAL times, and the brake does not work. This is a BIG safety hazard. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467057June 1, 2022
AIR BAGS
Allen , our son had accident Friday May 20th in our 2005 Ford Mustang gt. He swerved to miss something in the road and lost control of the vehicle. It actually rolled over but also damaged the front end enough to bend the frame rails. The ai bags did not set off. There was a recall on them and we had them replaced by Ford in 2020 . My wife and I felt like they should have deployed . Thanks
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11462987May 2, 2022
FUEL/PROPULSION SYSTEM
while driving home just as I was switching lanes, the car sputtered badly and a wrench light appeared on dash. Since then, the car did not exceed 20 miles per hour. as I conducted research, a lot of mustangs have this issue and it is theorized to be the throttle body.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11436811October 14, 2021
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2005 Ford Mustang. The contact stated that one day after a rainstorm she noticed several unknown warning lights were illuminated. The contact stated that the headlights were inoperable due to the water leaking into the interior of the vehicle. Additionally, there was water leaking into the interior of the dashboard. There was also water coming out of the driver’s side front air vent and the interior lighting in the vehicle from the interior module and center console. The lights were flickering on and off. The contact took the vehicle to a local dealer however, the dealer was not able to determine the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422210June 24, 2021
AIR BAGS
Brought the vehicle in for airbag replacement. Made an appointment ahead of time. Left the car over night. Contacted the service dept the next day and they told me the repair was done. I went in and was handed the keys and paperwork and told it was done. I kept getting recall notices from Ford, so I contacted them to let them know the airbags had been replaced. They insisted I never brought the car in, but I have the paperwork. Upon going over the details with Ford during the first phone call. Only one airbag had been replaced, and they gave the car back to me under the impression it was safe to drive. Last week was the third time I've contacted. Each time they say they will investigate the matter and never call back. I've lost confidence in this dealership and Ford for being unwilling to admit they dropped the ball and fix the problem. Their letters say they will come to you, but that's not happening either. I would like to watch this being done, sorry I just don't trust them anymore. (I have the paperwork)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Mustang