Ford Maverick Complaints

323 consumer complaints on file.

#11654059April 11, 2025
STEERING
The contact owns a 2024 Ford Maverick. The contact stated that while driving approximately 50 MPH and making a left turn, the steering wheel became difficult to turn a causing the driver to crash into a field fence with barbed wire at a 90-degree angle, where it came to a stop. No injuries were reported, and no police report was filed. The vehicle was driven to the local dealer, who was unable to diagnose the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 10,500.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11654046April 11, 2025
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
2022 Ford Maverick had water build up under the front passenger seat floor. I'm at 3.5 years of ownership and the dealer is telling me it will cost $1100 to fix because of an improperly installed windshield and cowl issue which ruined the internal filter and air circulation motor. Now i have to pay out of pocket because of a crappy manufacturer defect. I have seen in Maverick forums that this is a common issue and yet we are the ones having to fork out the cash.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653448April 8, 2025
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
On [XXX] brought Maverick 24 2.0L gas AWD on Electronic Control Unit ( ECU) to Ford Dealer#3 PJ Ford. Was advised Hybrid trucks have ECU on inside bulkhead rear cab wall behind flip down seat. However on later 2.0 L options gas are mounted behind driver side front bumper near and behind front driver side plastic/ fabric wheel well parallel to shot axel ( CVJ) approximately 12 high from ground. Upon first truck was engine started to stall due to water spay entering uncovered rear of plastic axel. Having other Broncos and Range Rover Sport filed complaint with FMC today after requesting to have ECU relocated to where Hybrid are mounted : PJ FORD service mgr. refused and FMC stated bring to another Ford dealer Bayville Ford 14 miles to south on Thursday 4/10/25 for second warrantee claim. I am afraid that in heavy rain with road flooding over 12" the engine will die and cause a rear end collision. I have waited 90 days on recall 24S59 real view camera freezing now have to get out to measure one foot of road water or waves from other trucks assembled properly. I will keep Maverick for sunny days until FMC correct " mis Assembly " of ECU in Mexico Assembly factory. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652687April 3, 2025
POWER TRAIN, SUSPENSION
Bad CV axles causing vibration while accelerating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651414March 28, 2025
POWER TRAIN
At 61,000 miles on the odometer and the Cv shafts have to be replaced. Ford has no supply on hand and is on a global back order until the end of April. Part adviser said that this is a consistent issue with mavericks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651287March 28, 2025
ELECTRICAL SYSTEM, BACK OVER PREVENTION
The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for NHTSA Campaign Number: 25V019000 (Electrical System); and Parts distribution disconnect for NHTSA Campaign Number: 24V684000 (Back Over Prevention).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647811March 12, 2025
ELECTRICAL SYSTEM, ENGINE
The contact owns a 2022 Ford Maverick. The contact stated while her husband was driving at approximately 35 MPH approaching a light with the Auto STOP/START feature engaged, the vehicle shut off. There were no warning lights illuminated. The contact replaced the battery. The contact received notification of NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was taken to the local dealer; where it was determined that the battery was not acknowledging the software. The vehicle was repaired, but the failure recurred. The dealer indicated that there was a loosened bearing and missing screws. The contact stated that the vehicle failed to start 60 percent of the time. While the contact was driving at 35 MPH, the vehicle stalled approaching a stop. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 36,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647462March 10, 2025
SERVICE BRAKES
The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 40 MPH, the brake warning light illuminated. The contact attempted to depress the brake pedal; however, the brakes failed to stop the vehicle. The contact shifted into neutral and coasted to a patch of grass where the vehicle came to a stop. The vehicle was turned off and after a while and shifted into park and restarted. The contact stated that several unknown warning lights were illuminated. The contact turned off and restarted the vehicle and became aware that the lights were no longer illuminated and continued driving. The dealer was contacted, and it was confirmed there were no recalls on the VIN. The contact stated that approximately 3 months after the first failure, the failure reoccurred while driving approximately 45 MPH, causing the contact to coast onto the off-ramp and a curb while in neutral to stop the vehicle. Several unknown warning lights were illuminated. The contact was able to restart and drive the vehicle to the dealer with the hazard lights activated. The dealer was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647410March 10, 2025
POWER TRAIN
CV axles failed at around 28k. Replacement parts not available nationwide. Ford has recognized an engineering flaw in the axles, but have not issued a recall. I was informed it was dafe to drive while waiting for new cv axles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647390March 10, 2025
POWER TRAIN
My truck's CV axles broke around 20,000 miles. Replacement parts weren't available. This was a safety issue because I expected a new truck with low mileage to be reliable. If I wasn't technically inclined, I might not have understood the danger. The dealership replaced them under warranty, but they didn't inspect the broken parts. The truck shook badly when accelerating, which was the warning sign.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646975March 7, 2025
UNKNOWN OR OTHER
Vehicle CV Axels going bad repeatedly. Replaced them 3 times. Luckily we've discovered the CV axel failures in low speeds. If it fails at the wrong time like during a turn on the highway, it could cause a serious accident. Plus the cost and inconvenience of repeated repairs continue to be an issue on such a new truck. Most owners report the same issue happening on Maverick forums. It seems lie this program is too common to be ignored. When we contact Ford dealerships parts are never available (back ordered) and it takes weeks to get this replaced adding more complexity to this situation. Formally requesting this issue to be reviewed at the NHTSA level.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646813March 6, 2025
BACK OVER PREVENTION
The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646748March 6, 2025
ELECTRICAL SYSTEM
At a intersection turning lane as I got a green arrow, ( as I pushed down on accelerator)a loud pop sounded and all vehicle operations stopped immediately. The battery had popped in the top front side, with battery liquid all over battery. No hazard lights, no putting into gear, only driver door operational at a very busy intersection. Flagging traffic and trying to call for new battery, very tough. Plant city Florida police arrived 20 minutes later. They waited with me until 40 minutes a battery arrived. I cleaned up acid with towel I had in front and tech changed battery. [THIS INCIDENT [XXX]- intersection [XXX] ] I can't express th [XXX] ot changing every battery thats compromised is beyond crazy. I paid $385 for the battery and spent $10 thousand of my life in that intersection. Fords are a lifetime of Dad's/my Family vehicle purchase history and I wish I had some of Ford Brass in the intersection with me. If they think they have a problem, I can guarantee it. Bartow Ford can't do anything because ( its Ford problem/remedy. I was discouraged they didn't say bring it in, but my buying any future product may be my remedy. Their were no warning lights, no smells from engine, no signs of any whisps of smoke coming up from hood. All I can finish with is when it happens, your out of business completely, where ever your at. The tech took the battery and I didn't take a picture because getting out of traffic was No.1. You can't sit inside and read your manual, with no emergency hazards at a busy intersection. You won't get this adrenaline rush/anxiety on a Universal thrill ride. You have a good chance of being hit by one or more vehicles on the inside or outside. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646623March 5, 2025
POWER TRAIN, SUSPENSION
I recently reported my Ford maverick for the failure of the front right CV joint/axle at 22k miles. Well when I picked it up from Ford. They notified me that the front left is also bad. And I'm at 23k miles. These are clearly an issue that's happening everywhere.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646408March 5, 2025
POWER TRAIN
Cv axles bad went out at 29000 miles could break and your truck could roll
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646334March 4, 2025
BACK OVER PREVENTION
The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while reversing out of the driveway, the back-over prevention camera failed to display an image behind the vehicle. The passenger had to verbally inform the driver of what was behind the vehicle. The dealer was not contacted. The manufacturer was made aware of the issue. The failure mileage was 12,377. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646313March 4, 2025
UNKNOWN OR OTHER
The manufacturer has not corrected the recall in a timely manner. The recall 24V684 was started in September 2024. It is six month later March 2025 and no fix has been identified.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646093March 3, 2025
SUSPENSION
Front Left CV Axle replaced at 5000 miles. Same CV axle needs to replaced now at 10287 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645630February 28, 2025
POWER TRAIN
CV Axel = vibration under acceleration I will be taking it in. soon for the inspection The vibration is getting worse and has me concerned Not yet ill be taking it in shortly but this is a known problem among the community no warning lamps.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645552February 28, 2025
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
My backup camera freezes while in reverse, which makes it difficult to gauge my surroundings accurately and has almost caused an accident a number of times now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick