Ford Fiesta Complaints

3,175 consumer complaints on file.

#11678521August 5, 2025
POWER TRAIN
I’m reporting a failure with the Transmission Control Module (TCM) in my 2014 Ford Fiesta. The vehicle has exhibited consistent issues tied to the known PowerShift DPS6 transmission defect: including gear slipping, delayed acceleration, hesitation, and sudden loss of power while driving—particularly dangerous during intersections or merging situations. Ford previously issued Customer Satisfaction Program 14M02 to address this issue, but I was told my VIN is no longer eligible due to build date. I also requested coverage under Ford’s one-time TCM replacement extension announced in 2023, which was meant to support customers outside the 10-year window through June 30, 2025—but I was denied this assistance as well. I’ve opened a formal case with Ford Customer Relationship Center under reference number CXH05170436-N7Z6Z1, after being denied support for a documented transmission control module failure. These symptoms present a clear safety risk, and the refusal to support a documented transmission failure—even under goodwill— I hope this will be reconsidered for safety investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678251August 4, 2025
BACK OVER PREVENTION
The contact owns a 2019 Ford Fiesta. The contact received notification of NHTSA Campaign Number: 24V951000 ( BACK OVER PREVENTION). The contact stated that occasionally, while reversing the back over prevention camera failed to function properly or as intended. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 25,557.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678059August 3, 2025
ELECTRICAL SYSTEM
I am having issues with the fuse box under the hood. I keep shorting out on my headlights ans AC clutch relay. I've purchased new head lights (bulbs), replaced them and they still didn't work. I checked the fuses after investigation online and they have blown. I had my AC completely fixed and it ran fine for a while, then stopped working. I had it checked and was told the AC relay clutch fuse was loose. I replaced it. Three weeks later it shorted out, again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677798August 1, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2011 Ford Fiesta. The contact stated that while driving on a main road at 30 MPH, the transmission shifted independently to neutral(N). The contact pulled over and restarted the vehicle. The contact shifted to drive(D) and drove to the residence. The vehicle was towed to the local dealer, where it was diagnosed that the transmission control module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677819August 1, 2025
POWER TRAIN
The contact owns a 2016 Ford Fiesta. The contact stated while depressing the accelerator pedal, the vehicle failed to respond as intended and hesitated to respond. Additionally, the vehicle failed to reverse as intended. Several unknown warning lights were illuminated. The vehicle was taken to a dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided, and the contact was informed that the VIN was not under recall. The failure mileage was 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677361July 30, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION, ENGINE
The contact owns a 2011 Ford Fiesta. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed but the vehicle failed to accelerate. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the failure was not duplicated. Additionally, the contact received notification of Customer Satisfaction Program 14M02; however, the dealer informed the contact that there was no indication of transmission failure. The vehicle was not diagnosed or repaired. The contact stated that the failure failure recurred. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair could not be covered under an unknown special program or recall. The contact was advised to contact the NHTSA Hotline to report the safety failure. The failure mileage was approximately 144,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675845July 24, 2025
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM), POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2014 Ford Fiesta. The contact stated that while his wife was driving at an undisclosed speed, the vehicle jerked, and an abnormal sound was coming from the engine. Several unknown warning lights were illuminated, and unknown messages were displayed. The contact's wife continued driving at slower speeds. The vehicle was towed to an independent mechanic who diagnosed that the transmission control module (TCM) and engine control module (ECM) had failed and needed to be replaced. The vehicle was not repaired. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 69,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675917July 24, 2025
POWER TRAIN, ENGINE, ELECTRICAL SYSTEM:IGNITION:COIL
The contact owns a 2016 Ford Fiesta. The contact stated while driving approximately 60 MPH, the vehicle was losing motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer to be diagnosed and it was determined that the spark plugs needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same dealer who diagnosed the vehicle and determined that the ignition coils needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the TCM needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Customer Satisfaction Program: 14M02 (Power Train); however, the VIN was not included. The manufacturer was informed of the failure and referred the contact to NHTSA Hotline to report the failure. The failure mileage was approximately 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675654July 23, 2025
POWER TRAIN
The contact owns a 2015 Ford Fiesta. The contact stated while driving 65 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the check engine warning light was illuminated. The contact drove the vehicle to the shoulder of the road and turned off the vehicle. The contact stated that the vehicle was restarted, and after several attempts, the vehicle started. The vehicle was driven to the residence. The dealer was made aware of the failure but provided no assistance. The vehicle was taken to an independent mechanic, where it was diagnosed with TCM failure. The manufacturer was made aware of the failure but provided no assistance. The contact was informed of an unknown recall for the TCM however, the recall had expired. The contact had not received a recall notification. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675540July 23, 2025
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
I am reporting a serious mechanical and safety issue involving my 2011 Ford Fiesta. After receiving a partially state-funded engine replacement in June 2025, my vehicle began experiencing serious transmission problems shortly after. Within a month, it went into limp mode multiple times, and warning lights appeared: the wrench light, incline warning, and “Transmission Malfunction – Service Now” messages. A diagnostic scan revealed multiple DTCs related to the Transmission Control Module (TCM), Input/Output Shaft Speed Sensors, and Clutch A disengagement (P286F) — which I understand are linked to known issues with this model’s transmission. These failures make the car dangerous to drive. The vehicle has lost power unexpectedly, putting me at risk of an accident. I’ve also been told by the repair shop that I may now need a new transmission and/or TCM, despite just receiving a major engine repair. I am unable to afford another large repair and this situation has severely impacted my ability to travel safely. I am requesting an investigation into the Ford Fiesta’s transmission problems and to confirm whether this should have been covered by a recall or warranty extension. I want to also add that my transmission clutch was repaired by Ford only 2 years ago. Please advise if this falls under known manufacturer defects or safety bulletins, and whether Ford Motor Company can be held responsible for the faulty transmission and associated safety risks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675560July 23, 2025
ENGINE
Ford and ford dealearship is not willing to provide or service 15B22 recalls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675245July 22, 2025
ENGINE
In 2020, Documents were subpoened proving that Ford falsified doors and used a dangerous faulty transmission in Ford Fiesta and Focus Moodels from 2011-2015. There were so many lawsuits, they settled through arbitration. The judicial system only required an extended waranty- no recall or redesign. These vehicles are dangerous, and when transmission overheats, the cars stop in the middle of the road. Many will not go in Reverse. Ford is recouping their arbitration settlement money by continuing to sell these cars on the Used Car Market with the same DPS6 Transmissions which they knew were faulty and dangerous, and falsified documents about, with Clean Car Faxes, often low mileage- because heat starts transmission failure, and that is not fair. The pledge does not say...."WitH liberty and justice for ALL WHO CAN AFFORD IT!" I HAVE AMOST BEEN REAR-ENDED TWICE, because car stops when Trans gets hot. One driver of a 4'4 truck, speeding around a blind spot, swerved into oncoming lane, rolled down his window, pointed a pistol at me, cursing because I ALMOST made HIM WRECK! although my safety flashers were on. There are no shoulders on these rural roads. This car is DANGEROUS! WHY WAS FORD ALLOWED TO GET AWAY WITH THIS? Falsification of documents about a cars safety is fraud. There are tens of thousands with Clean Car Faxes still being sold unfairly to unknowing victims with modest incomes who TRUST CAR FAX DOCUMENTATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675419July 22, 2025
ENGINE
In May, my 2015 Ford Fiesta SE went into "limp mode" before reaching the speed limit of 25mph. Immediately afterwards it was taken into a local shop, Mobile Mechanic, where no codes were active and coolant level was between min and max level. Next day, car experienced misfiring check engine light and overheating before being looked at by a mechanic. Mechanic replaced spark plugs due to code reading misfiring in cylinder 3. Car still continued to misfire and due to slight lower level of coolant, Engine overheated and cracked a cylinder block in the 1.0-liter three-cylinder EcoBoost engine. This car is used to travel with two children under [XXX] and [XXX]. The beginning of June the car overheated on a hot day traveling home with the two kids and myself. We had to sit in the heat for close to an hour before temperature gauge returned to normal, I checked the coolant and it was still between min and max levels. On the same trip, it was on the verge of overheating again due to climbing the hill before our house. After finding out the cylinder block was cracked by my mechanic we discovered there has been a recall issue with the same engine, Recall 17S09, that began in January 2018, a month before I purchased my car from Redwood Ford in Ukiah California ([XXX]). I called W. C. Sanderson Ford in Healdsburg, California on July, 15th, 2025 to see if it would be possible to see if this recall was actually fixed on my vehicle, which they responded that the recall has nothing to do with my car and they can't do anything about my car. The representative specifically said that due to my car being 10 years old it has been disqualified of the recall and is no longer attached to my VIN. I have taken this car to the same local mechanic 4 times since the ending of May, 2025 for the same issues before we discovered the cracked cylinder block, mechanic took pictures of fluid and water inside cylinder 3. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675002July 21, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2015 Ford Fiesta. The contact stated that while operating the vehicle, the check engine warning light illuminated, and the vehicle failed to properly accelerate while depressing the accelerator pedal. The vehicle was taken to the local O'Reilly's and was diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not eligible for Customer Satisfaction Program: 14M02 (Extended Warranty Coverage for TCM) related to the failure. The failure mileage was 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675124July 21, 2025
UNKNOWN OR OTHER
Request Reversal of Recall Cancellation by the Ford Dealer. RE: Safety Recall Notice 20S30/NHTSA Recall 20V-331 VIN [XXX] ***IMPORTANT SAFETY RECALL *** I have been working with the Service Manager, Forest at James Hodge Ford in Muskogee, Oklahoma, (1-918-682-1345) and Ford Customer Relationship Center at 1-866-436-7332. In March of 2025, an inspection was completed on my 2013 Ford Fiesta in regards to this safety recall. IAW service manager performed an inspection of the door latches and closed out the recall. The issue for this recall states that my vehicle was previously repaired under Safety Recall 15S15 or 16S30. Evidently this was completed by the previous owner but it states that it is possible that one or more of the door latches was not replaced or may not have been replaced correctly. This proved to be true because in April while on vacation I was driving when my door swung open. After grabbing it I was able to find a place to stop. Then, I discovered the latch would not close! I found a rope to wrap around it to keep it closed to finish out my vacation. Ford has recognized and issued a safety recall due to the risk of doors not closing or doors opening while driving. As stated in the letter I received about the recall the risk is: If a door latch is not replaced, there is still a risk that the pawl spring tab inside the door latch could break. This condition will typically prevent the door from latching. Where the door is able to be closed, the door may unlatch while driving, increasing the risk of injury. I returned the car to the Ford Dealer and was told the recall was for an inspection only and was cancelled. I began calling the Ford Customer Relationship Center at 1-866-436-7332 on May 1st. Case # [XXX] I have been unsuccessful obtaining a reversal of the cancellation of the recall that is a critical danger. I have been ignored, lied to and promised it would be fixed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675149July 21, 2025
POWER TRAIN
The contact owns a 2011 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the vehicle jerked, and failed to accelerate as intended while depressing the accelerator pedal. The vehicle stalled while driving. The contact waited for a short while and was able to restart the vehicle. The contact was able to move over to the side of the road. No warning lights were illuminated. The contact stated that on a separate occasion, while attempting to reverse out of a parking space, the vehicle failed to function while in reverse(R). The vehicle was taken to the dealer where it was diagnosed that the transmission PTU had failed. The vehicle was repaired. The contact stated that recently while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact was able to pull into a parking lot. An unknown warning light was illuminated. The contact turned off the vehicle and waited for a while and was able to restart the vehicle. The contact stated that while attempting to enter the driveway, the vehicle failed to respond while in reverse(R) and failed to move while in drive(D). The vehicle was not diagnosed or repaired. The dealer informed the contact that the vehicle warranty had expired in March 2025. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675178July 21, 2025
POWER TRAIN
The transmission control module (TCM) on my 2015 Ford Fiesta was failing at 81,000 miles. It was difficult to accelerate the car even at low speeds (25-30 mph) and my check engine light was on. I took my vehicle to the nearest Ford Dealership (Big Star Ford in Manvel, TX) who assessed my vehicle and determined the TCM needed to be replaced. They replaced the part but told me it was not under the 14M02 warranty. My check engine light did come on once back in May and the car was struggling to speed up but when I took it to a car shop the check engine light was not on and the mechanic said it was fine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674257July 17, 2025
BACK OVER PREVENTION, SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 Ford Fiesta. The contact stated that the rearview camera image was distorted or black while the vehicle was in reverse(R). The contact stated that the failure had obstructed the visibility of the roadway and had prevented the driver from safely operating the vehicle. Additionally, the contact stated that while driving at an undisclosed speed, there was an abnormal knocking and screeching coming from the front passenger's side and the driver's side. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the brake pads and calipers had failed and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact related the failure to NHTSA Campaign Numbers: 19V629000(Service Brakes, Hydraulic) and 24V951000 (Back Over Prevention); however, the VIN was not included in the recalls. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674126July 16, 2025
UNKNOWN OR OTHER
While driving along the transmission slipped into neutral and would not move forward.Could have been hit from behind.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674129July 16, 2025
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
The contact owns a 2016 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the failure persisted. The vehicle was taken to an independent mechanic; however, no cause for the failure was found. The mechanic informed the contact that it was possibly the battery and the key fob battery that had caused the issues. The contact took the vehicle to the dealer where the key fob battery was replaced. The contact replaced the battery independently. The check engine warning light was illuminated. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Fiesta