Ford F-250 Complaints (2001)

508 consumer complaints on file.

#11651526March 29, 2025
POWER TRAIN
When im in traffic, starting out driving or merging between intersections my truck decides to either hard shift or not shift at all. Several times ive had to lay on my horn in an attempt to warn oncoming vehicles that i have no power and cannot accelerate and several times it has nearly caused an accident. I purchased the truck used and have yet to take it into the dealership to have them inspect the issue though from what i’ve read thus far is that ford calls this problem “normal operation” and has been less than understanding when people attempt to have this obvious defect resolved. There are no warning lights that come on when this happens. I can have my truck inspected by whomever, whenever need be. I will also be returning to the dealer to use my warranty to help deal with this issue. The date this most recently happened causing a near miss was today, though there has been an occasional but recurring situation almost weekly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461209April 18, 2022
TIRES:TREAD/BELT
The contact owns a 2001 Ford F-250 equipped with Toyo tires, Tire Line: HT Open Country, Tire Size: LT265/75/R16, DOT Number: CXLTCAK4815. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and felt like the front tires were bouncing. The contact veered to the side of the road, where he noticed that the tires were deformed. The contact continued to drive. The vehicle was taken to the local dealer where it was diagnosed that the tread belt was separating. The front tires were replaced; however, the failure reoccurred with the rear tires. The vehicle was taken to an independent tire mechanic where the rear tires were replaced under an unknown recall. The contact stated that the failure reoccurred on the front tires. The dealer was notified of the failure. The manufacturer was notified of the failure but did not provide any assistance. The tires were not replaced. The tires were replacement equipment. The tire failure mileage was 30,000. The vehicle failure mileage was approximately 230,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448721January 24, 2022
AIR BAGS
Was T-Boned in the passenger side of the truck which changed my direction of travel resulting in hitting a tree head on. Neither frontal air bags deployed. The frontal impact was hard enough to push the tree 18 to 20 inches into the engine compartment bending the frame where the front bumper was attached. The accident resulted in a fatality. I'm just confused why neither air bag deployed. I have had this truck since it was new so I know it's history. There was not any warnings lights on, No air bag warning lights, No modifications were ever done to the truck. All stock. There was never any indication that the air bags were not operating normal. So Why did they malfunction?
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
1
#11364408October 14, 2020
WHEELS, UNKNOWN OR OTHER
TAILPIPE IS CLOSE ENOUGH TO SPARE TIRE TO MELT TIRE. TIRE IS UNUSABLE. LATER VEHICLES HAVE A HEAT SHIELD IN PLACE TO PREVENT THIS. FORD SHOULD HAVE RECALLED EARLIER UNITS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11340813July 22, 2020
ELECTRICAL SYSTEM
WHILE SHOPPING MY F250 TRYED TO BURN DOWN IN PARKING LOT 2ND TIME AT A SCHOOL SOCCER GAME AND 4 THE THIRD TIME RIGHT IN FRONT OF MY HOUSE AND STILL AFTER THOUSANDS IN REPAIRS STILL SAME ISSUE FORD NEEDS TO MAN UP AN ADDRESS THIS SITUATION..... [XXXX] KEY NEVER IN TRUCK ALL THREE TIMES THIS HAS OCCURED REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11320910April 12, 2020
SERVICE BRAKES, ENGINE, STEERING
SPARK PLUGS KEEP BLOWING OUT OF THE ENGINE, WHILE ACCELERATING, HAS DONE FIVE TIMES,, WHEN IT DOES VEHICLE STALLED POSSIBLY CARE CAUSE AN ACCIDENT, ALMOST GOT HIT BY A TRUCK TRYING TO TURN,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11311334February 25, 2020
SERVICE BRAKES, VEHICLE SPEED CONTROL
LOCATION MASTER CYLINDER CRUISE CONTROL DEACTIVATION SENSOR LEAKING BRAKE FLUID NON FUNCTIONAL BRAKES AND CRUISE CONTROL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11265985October 3, 2019
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS STATIONARY IN A PARKING LOT, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. THE CONTACT EXITED THE VEHICLE, OPENED THE HOOD, AND NOTICED FLAMES. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH WATER AND NOTICED THAT AN UNKNOWN PLUG RELATED TO THE CRUISE CONTROL WAS MELTED. NO POLICE OR FIRE REPORTS WERE FILED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO BE DRIVEN. THE CONTACT'S VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO EL CAJON FORD (LOCATED AT 1595 E MAIN ST, EL CAJON, CA 92021, (619) 312-4107) WHERE IT WAS DIAGNOSED THAT THE UNKNOWN PLUG RELATED TO THE CRUISE CONTROL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11256896September 20, 2019
ELECTRICAL SYSTEM, ENGINE
TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). WHILE THE VEHICLE WAS PARKED, SMOKE SPONTANEOUSLY EMERGED FROM UNDER THE HOOD AND THE VEHICLE CAUGHT FIRE WITHOUT WARNING. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS TAKEN TO BATTLEFIELD FORD COMMERCIAL TRUCK CENTER (8980 MATHIS AVE, MANASSAS, VA 20110, (703) 368-3231) WHO STATED THAT THEY WERE WAITING ON AUTHORIZATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A FIRE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 144,840.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11220340June 15, 2019
STRUCTURE:BODY
REAR PASSENGER DOORS OF EXTENDED CAB(BOTH) WILL NOT RELEASE TO OPEN. CAUSING DANGER IN DIFFICULTY OF PASSENGERS TO EXIT THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203550April 26, 2019
ENGINE
2001 FORD F250. CONSUMER WRITES IN REGARDS TO ISSUES WITH THE MOTOR. *LD THE CONSUMER STATED THE MOTOR WOULD BACK FIRE AND BLOW OUT. THE CONSUMER STATED THERE WAS A RECALL ON THE MOTOR, BUT THE MANUFACTURER WOULD NOT HONOR THE RECALL. *JS THE CONSUMER STATED THE VEHICLE BLEW IT'S LAST SPARK PLUG. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11195915April 12, 2019
SEAT BELTS
FRONT PASSENGER SEAT BELT WILL DISENGAGE WITH OUT TOUCHING THE RELEASE BUTTON. I HAVE TRIED USING HIGH PRESSURE AIR THINKING IT WOULD DISLODGE SOMETHING. EVEN TRIED A LITTLE WD-40 TO NO AVAIL. REALLY FRUSTRATING TO HEAR ITS NOT ON THE RECALL LIST FOR THIS MODEL YEAR. DEALERSHIPS SURE DON'T ACT LIKE THEY WANT TO FIX IT. HAS HAPPENED NUMEROUS TIMES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11166236January 10, 2019
STEERING
TWICE IN THE LAST 5 YEARS I HAVE EXPERIENCED TOTAL STEERING LOSS WHILE DRIVING FORD F-250 V10 TRITON PICKUP TRUCK, I AM FORTUNATE TO BE ALIVE, BOTH TIMES THE CONNECTION TO THE STEERING BOX BROKE. THERE HAVE BEEN NO AFTERMARKET MODIFICATIONS DONE TO THIS TRUCK. VERY SERIOUS ISSUE! TRUCK IS IN THE SHOP NOW FOLLOWING MOST RECENT FAILURE. I FEAR THINKING ABOUT THE CONSEQUENCES HAD EITHER OF THESE TWO FAILURES OCCURRED AT HIGH SPEED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11153339November 23, 2018
ENGINE, STEERING
TL* THE CONTACT OWNS A 2001 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE LOST POWER AND THE STEERING WHEEL SEIZED. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE DEALER (TOMBALL FORD, 22702 TOMBALL PKWY, TOMBALL, TX 77375, (281) 378-3160) WAS CONTACTED, BUT DID NOT RECEIVE AUTHORIZATION FROM THE CONTACT TO DIAGNOSE THE VEHICLE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HIGH VOLUME OIL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 157,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11120091August 15, 2018
ENGINE, VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A FIRE WAS DETECTED COMING FROM UNDERNEATH THE DRIVER'S SIDE WHEEL. THE CONTACT ALSO MENTIONED THAT THE DRIVER SIDE OF THE VEHICLE EXPLODED. A POLICE REPORT WAS FILED. THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT TAKEN OR TOWED TO A DEALER OR INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST OR REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V170000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11097017May 21, 2018
POWER TRAIN
PARKED VEHICLE AT MAIN POST OFFICE , REMOVED KEYS, I KNOW THIS BECAUSE IT HAS MY POBOX KEY ON KEY RING. I HOPPED OUT AND STATED TO WALK OFF, THEN I GLANCED A VIEW TO THE RIGHT, AND NOTICED OR THOUGHT I NOTICED, MY TRUCK ROLLING BACKWARDS. IT WAS !!! I CHASED MY TRUCK AND CAUGHT UP TO IT, AND ATTEMPTED HOP IN AND ENGAGE FOOT BRAKE. I AM TO FAT AND SLOW TO DO THAT, SO I THOUGHT QUICKLY, , AH HA, THE EMERGENCY BRAKE . I REACHED DOWN AND LET THE TRUCK ROLL THE ER BRAKE TO MY HAND, AND ENGAGE IT I CALLED THE FORD DEALER, NO KNOW ISSUES LIKE THIS HAS HAPPENED, SO I WAS TOLD. SO MAYBE THIS WAS AN 1 OFF EVENT,,,, RIGHT WRONG SEVERAL MONTH LATER, SAME THING HAPPEN, DIFFERENT LOCATION. ALTHOUGH I CATCH BEFORE I GOT OUT. THIS TIME I TOOK A VIDEO OF THE ROLL BACK, AND THE SNIFTER IN PARK, AND THE KEYS OUT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11091426May 2, 2018
ELECTRICAL SYSTEM
DRIVING AT NIGHT, TRIED TO USE CRUISE CONTROL (DIDN'T COME ON) THEN OVERDRIVE "ON" BUTTON STARTED FLASHING, THEN SPEEDOMETER BEGAN BOUNCING. LATER TRUCK WOULD NOT GO OFF WHEN KEY WAS TURNED TO OFF POSITION. NEXT DAY A LOW BEEP WAS NOTED. REPAIR SHOP WITH SCANNER SAID IT WAS AN AIRBAG WARNING BEEP. THE FOLLOWING DAY THE HEADLIGHTS CAME ON AT NIGHT ALTHOUGH THE KEY WAS TO THE OFF POSITION AND OUT OF THE TRUCK. SUBSEQUENTLY ALL SYMPTOMS STOPPED AND NORMAL OPERATION RETURNED UNTIL A RAINY DAY. SAME SYMPTOMS. DAY FOLLOWING THAT, NORMAL OPERATION. MECHANIC STATES THAT SYMPTOMS NEED TO BE OCCURRING TO MAKE PROPER DIAGNOSIS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11083636April 6, 2018
ENGINE
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS IDLING AT A STOP SIGN, THE CONTACT HEARD A LOUD ABNORMAL POPPING NOISE COMING FROM THE ENGINE COMPARTMENT. THE CONTACT DROVE THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THEY REPLACED THE SPARK PLUG TAPS AND DIAGNOSED THAT THE INTAKE MANIFOLD NEEDED TO BE REPLACED. THE MANIFOLD WAS NOT REPLACED. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11046199November 15, 2017
ENGINE
5 TH EJECTED SPARK PLUG GOING DOWN ROAD AT 45 MPH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11034491October 19, 2017
SERVICE BRAKES, POWER TRAIN
PARKED MY TRUCK AT THE POST OFFICE TO RETRIEVE MAIL, GOT OUT AND SHUT DOOR, AND OUT OF THE CORNER OF MY EYE I SAW WHAT I THOUGHT AS MOVEMENT OF MY TRUCK, SO I TURNED AROUND TO SEE MY TRUCK STARTING TO ROLL BACKWARDS , I YELLED WTF, AND STARTED TO CHASE MY TRUCK THROUGH THE PARKING AREA, TRIED TO JUMP IN WHEN I OPENED THE DOOR AND I WAS TO OLD AND FAT TO DO THAT, TRIED PUSH BACK , BUT TRUCK WAS TO HEAVY TO DO THAT, SO I WENT FOR THE PARKING BRAKE PRESSED IT HARD AND FAST AS I COULD, AND THAT WORKED MY TRUCK WAS IN PARK, AS I HAD MY KEYS IN MY HAND. THE PARK LOCK ON THE TRANSMISSION FAILED IN SOME WAY ,ALLOWING TO ROLL LIKE IT WAS IN NEUTRAL
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250