Ford F-250 Complaints (2001)

508 consumer complaints on file.

#10725127June 13, 2015
STEERING
WE HAD TRAVELED APROXIMATELY 450 MILES AND ON THE LAST LEG OF A TRIP IN THE MOUNTAINS. THE DRIVER NOTICED ON THE LAST 150 MILES OF THE TRIP THE STEERING WHEEL HAD CHANGED POSITION WHERE THE CENTER OF THE WHEEL NORMALLY WAS HORIZONTAL, WAS NOW 45 DEGREES OFF AND VERTICAL. THE VEHICLE WAS PARKED ON ARRIVAL TO DESTINATION. THE NEXT DAY THE VEHICLE NEEDED TO BE MOVED AND UNLOADED WHEN THIS WAS ATTEMPTED THE STEERING WHEEL JUST TURNED WITH NOT CONTROL OF THE WHEELS. SO WE WERE UNABLE TO MOVE THE VEHICLE. AFTER AN INITIAL INSPECTION OF THE VEHICLE AND IT WAS PLACED ON A FLOOR JACK TO RAISE THE FRONT END TO LOOK FOR PROBLEMS UNDER THE VEHICLE. AFTER TURNING THE WHEELS MANUALLY IT WAS NOTICED THE ARM THAT COMES FROM THE STEERING BOX WAS LOOSE AT THE ELBOW. AFTER CLOSER INSPECTION IT WAS FOUND THAT THE ENTIRE SHAFT WAS SHEERED OFF AT THE STEERING BOX. WE WERE LUCK IT FAILED WHEN WE WERE NOT ON THE ROAD. IT MUST DID THE FINAL FAILURE WHEN WE DROVE INTO OUR DRIVE WAY AND PARKED. THIS MIGHT HAVE BEEN A DISASTEROUS ACCIDENT IF THIS HAD FAILED WHILE WE WERE DRIVING ON THE MOUNTAIN ROADS WE HAD JUST DRIVEN ON OUR TRIP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10721763May 27, 2015
SEAT BELTS
FOR ABOUT 7 MONTHS, MY SON HAS BEEN DRIVING THE 2001 F250 SD UNDER NORMAL DRIVING CONDITIONS. THERE HAVE BEEN MANY INSTANCES WHERE THE DRIVER'S SIDE FRONT SEAT BELT HAS UNLATCHED ON ITS OWN. IT HAS ALSO HAPPENED TO ME WHILE DRIVING. THE TRUCK WAS TAKEN BACK TO FORD DEALERSHIP ON 3/7/03 UNDER RECALL 01S21 SEATBELT. "BUCKLES WERE INSPECTED, OK AS PER 01S21, NO REPAIRS NEEDED." WE WERE CHARGED $27.16 FOR THE INSPECTION. TOOK THE TRUCK BACK TO DEALERSHIP TODAY (5.27.15). THEY HAVE NO ADVICE FOR US. THERE ARE MANY OPEN COMPLAINTS FOR THIS PROBLEM. PLEASE DO SOMETHING ABOUT THIS BEFORE SOMEONE GETS KILLED. I'VE SEEN THE REPORTS OF MANY INJURIES ALREADY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10715035May 6, 2015
SEAT BELTS
REAR SEAT BELT BUCKLE HAS BROKEN LATCHING MECHANISM WITHIN FEMALE BUCKLE. THIS ITEM IS NOT AVAILABLE FROM THE MANUFACTURER. SEAT BELT NOT AVAILABLE FROM THE MANUFACTURER ON A 14 YEAR OLD VEHICLE ? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10715033May 6, 2015
SEAT BELTS
DRIVER SEAT BELT COMES UNLATCHED FOR NO APPARENT REASON. THERE WAS A RECALL ON THESE SEAT BELTS, BUT MY VIN WAS NOT COVERED BY THE RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10701967March 26, 2015
FUEL/PROPULSION SYSTEM
I WAS IN FLORIDA HAVING COFFEE AT THE PICNIC TABLE WHEN I NOTICED THE FUEL TANK WAS HANGING LOW. I WAS LUCKY TO CATCH IT BEFORE IT FELL OFF ON THE FREEWAY. I CAN SEND YOU A PICTURE. I UNDERSTAND THERE IS A RECALL ON OTHER FORD PICKUPS 150'S AND 250'S BUT NOT MY MODEL YEAR, MY YEAR TRUCK SHOULD BE INCLUDED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10706743March 2, 2015
WHEELS
WITHOUT WARNING, OUTER TIRE TREAD SEPARATED FROM TIRE WHILE DRIVING AT 65 MPH. UNIROYAL LIBERATOR, TIRE CODE BFOR C62U 2610, PURCHASED NEW ON 08/02/2010 WITH APPROXIMATELY 40,000 MILES. THIS HAPPENED ABOUT 0800, WEATHER WAS CLEAR, SUNNY AND ABOUT 50F DEGREES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671247January 9, 2015
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
THE 2001 F250 I OWN HAS ALWAYS STALLED AT ANY GIVEN TIME. FORD RECALLED THE CAM POSITION SENSOR, I HAD ALREADY CHANGED IT JUST BEFORE RECALL THEN THEY DID AGAIN. THAT NEVER STOPPED IT FROM STALLING, IT ALSO DOESN'T READ WHEN YOU SOMETIMES GO TO TAKE OFF. I'VE CHANGED (THROTTLE SWITCH) THAT DID NOTHING. ALL OF ITS MISHAPS HAS CASED THOUSANDS OF DOLLARS IN REPAIR. ALWAYS BROKE DOWN AND CAN'T MAKE MONEY WHEN IT'S IMPOSSIBLE TO DRIVE TRUCK TIME AFTER TIME. I HAVE BEEN IN SEVERAL CLOSE CALL ACCIDENTS, WHEN I LOSE POWERSTEERING AND ALMOST HAVE CRASHED INTO CARS. I FIGURED OUT THE FUEL TANK FLAKING OFF INSIDE THE TANK COULD BE THE CAUSE. THE TRUCK GETS TERRIBLE FUEL MILEAGE WHEN THIS HAPPENS COSTING A FORTUNE IN WASTED DIESEL FUMES. THAT HAVE BEEN KNOW TO CAUSE BRAIN CANCER, ALSO THE AMOUNT OF POLLUTION FROM NOT RUNNING PROPER. I AM NO FAN OF FORD'S REPAIR SHOP WHEN THEY TELL YOU IN 1983 TO MY FATHER THAT HIS ALMOST BRAND NEW DIESEL NEEDS NEW (SPARK PLUGS) WHEN DIESEL DO NOT EVEN HAVE THEM. I OWN THIS 2001 DIESEL FOR A LONG TIME NOW FOR A LANDSCAPING AND SNOWPLOWING THAT IS OUT OF BUSINESS. IT IS EMBARRASSING FOR IT TO STALL, REV UP SLIPPING TRANSMISSION, HARMING WHOLE DRIVE TRAIN. NEVER KNOWING WHEN I'M COULD BE STRANDED IN NORTHERN MICHIGAN. I HAVE HAD ONE THING AFTER ANOTHER WITH THE FORD I OWN. I HAVE SEEN A LOT OF SAME PROBLEMS PEOPLE ARE COMPLAINING ABOUT. SOUNDS LIKE FORD HAS DONE GOOD AT COVERING UP PROBLEM BY NOT TELLING US IF THEY KNEW. I THOUGHT THE FUEL PROBLEM CAME FROM GAS STATIONS. ONLY THING HELPED ME WAS MOSTLY SAME NEWER STATION, AND TRIED TO KEEP IT FULL HELPED. CAN ANYONE HELP, THESE ARE DANGEROUS SITUATIONS WHEN LIVES DEPEND ON THEM. I'M NOT SURE WHAT TO DO WITH THE TRUCK, I'D LIKE TO SEE IT GO TO SCRAP AT THIS TIME. WITH 277,000 NOT EVEN RUSTED OUT MUCH. IT NEEDS WHOLE DRIVE TRAIN AGAIN, I DON'T WANT THE OILY LEAKING, POLLUTING JUNK ON THE ROAD. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10667964December 29, 2014
STEERING
LETTER FROM CONGRESSMAN WOLF ON BEHALF OF CONSTITUENT RE 2001 FORD F250 SUPER DUTY TRUCK BECAUSE OF STEERING MALFUNCTION (ATTN: JOHN CZERWINSKI). *SMD THE CONSUMER STATED WHEN THE BRAKE WAS APPLIED, THE STEERING WHEEL WAS HARD TO TURN, EVEN WITH BOTH HANDS. WHEN SOME OF THE PRESSURE WAS RELEASED FROM THE BRAKE, THE STEERING WHEEL WOULD TURN FREELY. THE CONSUMER WAS INFORMED, THE STEERING PUMP WAS BAD. HOWEVER, THE STEERING PUMP WAS REPLACED FIVE TIMES. HOWEVER, THE PROBLEM CONTINUED. *JB UPDATED 03/25/15. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10661149November 27, 2014
STEERING
I WAS MAKING A SHARP LEFT TURN, FROM A STOP, WHEN I HEARD A SNAPPING NOISE, THEN I NOTICED MY STEERING WHEEL TURNING FREELY, I JUST CONTINUED FORWARD WITH NO STEERING SINCE I WAS KIND OF CROSSED ON THE MIDDLE OF THE ROAD, AND HAD CARS COMING AT ME AT A HIGH RATE OF SPEED, I WAS ABLE TO GO OVER ONTO THE SIDE WALK CROSSED, I STOPPED THE TRUCK AND WHEN I LOOKED SAW THE SHAFT AT THE STEERING BOX HAD SHEERED IN HALF. I AM A RETIRED LAW ENFORCEMENT OFFICER AND CONSIDER THIS A VERY DELICATE MATTER, HAVE I BEING TRAVELING AT A HIGH SPEED THIS COULD HAVE BEING A SITUATION WITH VERY TRAGIC RESULTS. PLEASE DO NOT IGNORE THANKS *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10618357August 2, 2014
SEAT BELTS
DRIVER SIDE SEAT BELT UNLATCHES AT RANDOM. I'VE SEEN COMPLAINTS ABOUT THIS ON THIS WEBSITE, SO I'M NOT THE ONLY ONE HAVING THIS PROBLEM. PROBLEM HAS BEEN GOING ON FOR A FEW YEARS AND I DON'T KNOW THE DATE OR MILEAGE WHEN IT STARTED HAPPENING. THE DEALER JUST TRIED TO SELL ME A NEW LATCH FOR AROUND A HUNDRED BUCKS. SEAT BELT LATCHES DON'T JUST WEAR OUT THAT EASY, MY '73 MUSTANG HAS LATCHES THAT STILL WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10617009July 28, 2014
ENGINE, SERVICE BRAKES, STEERING, ELECTRICAL SYSTEM
WHILE I WAS DRIVING ALONG A HILLY, WINDING ROAD THE ENGINE OF MY 2001 F-250 DIESEL 4X4 TRUCK UNEXPECTEDLY SHUT OFF. I LOST STEERING AND BRAKING. THERE WERE NO LIGHTS ON THE DASH. THERE WAS NO PRIOR INDICATION OF ANY PROBLEM WITH THE ENGINE OR ELECTRICAL SYSTEM. I'VE HAD THE TRUCK FOR 12 YEARS AT THE TIME AND NEVER EXPERIENCED ANY PROBLEM LIKE THIS. I WAS VERY FORTUNATE TO HAVE BEEN ABLE TO GET THE TRUCK TO THE ROAD'S SHOULDER. AFTER THE TRUCK STOPPED I PUT THE SHIFT INTO PARK. THE KEY WAS STILL IN THE RUN POSITION. I SIMPLY TURNED IT TO THE START POSITION AND THE ENGINE STARTED RIGHT UP. I TOOK IT IMMEDIATELY TO THE LOCAL FORD DEALER WHO RAN DIAGNOSTICS ON THE TRUCK. THEY FOUND NO INDICATION OF A PROBLEM OTHER THAN ONE BATTERY'S VOLTAGE WAS SLIGHTLY LOW, BUT NOT OUT OF ACCEPTABLE RANGE. I REPLACED BOTH BATTERIES AS THEY WERE ALMOST 3 YEARS OLD. SO FAR, I'VE NOT EXPERIENCED THIS PROBLEM AGAIN. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10597784June 11, 2014
TIRES, TIRES:TREAD/BELT
TIRE BLOWOUT WITH COMPLETE TREAD SEPARATION WHILE TRAVELING ON INTERSTATE PULLING A HORSE TRAILER. WAS ABLE TO SAFELY PULL TO SHOULDER & CHANGE TIRE FOR SPARE. TREAD DAMAGED TRUCK PANEL, TAILPIPE & BENT FRONT AXLE OF TRAILER. TIRES WERE WELL MAINTAINED AND HAD BEEN CHECKED BEFORE DEPARTURE. TIRES WERE NITTO TERRA GRAPPLER LT 285/75R16 126/123Q LOAD RANGE E. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10563095February 5, 2014
SERVICE BRAKES
HITTING BRAKE TO SHIFT OUT OF PARK THE PEDAL WENT TO FLOOR. STEEL LINE COMING OUT ABS RUPTURED WHERE THE FLEX SECTION ENDS RIGHT ABOVE FRAME RAIL. WHERE I LIVE, STEEP HILLS AND SHARP TURNS, THIS WAS VERY LIFE THREATENING IF OCCURRED WHILE DRIVING! I'M NOT A HAPPY CAMPER! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10557079December 23, 2013
SEAT BELTS
DRIVER SEATBELT UNLATCHES UNEXPECTEDLY. THERE DOESN'T SEEM TO BE ANY PARTICULAR CAUSE FOR THE LATCHING FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10554214November 30, 2013
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
THE TWO VENTS BEHIND THE REAR SEAT OF THE CAB LEAK AND CAUSE CARPET/FLOOR DAMAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10553105November 20, 2013
ENGINE
TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 17 MPH, HE HEARD AN ABNORMAL WHINING SOUND. THE CONTACT STOPPED THE VEHICLE AND UPON INSPECTION, NOTICED THAT THE SPARK PLUGS HAD BLOWN FROM THE CYLINDER HEAD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 207,885.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544025September 17, 2013
ELECTRICAL SYSTEM, VISIBILITY/WIPER
TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT AS HE STARTED THE ENGINE, EVERY LIGHT REMAINED ILLUMINATED OF THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT STATED THAT THERE WAS A BROKEN SEAM IN THE WINDSHIELD THAT WOULD CAUSE WATER TO LEAK INTO THE VEHICLE AND ONTO THE ELECTRONIC CONTROL MODULE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,007.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10536502August 21, 2013
ENGINE
TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, HE HEARD A LOUD NOISE AS THE VEHICLE BEGAN TO LOSE POWER. UPON FURTHER INVESTIGATION HE NOTICED THAT A SPARK PLUG HAD BEEN EXPELLED FROM THE ENGINE AT A HIGH RATE OF SPEED. HE COULD ALSO SMELL GASOLINE ON THE ENGINE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THERE WAS NOT ENOUGH THREAD IN THE ALUMINUM HEAD TO HOLD THE SPARK PLUG. A HELI COIL WAS NEEDED IN ORDER TO ADD MORE THREADS. THE CONTACT STATED THAT IT WAS THE SECOND RECURRENCE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 110,000. UPDATED 10/17/13*LJ THE CONSUMER HAS SINCE SOLD THE VEHICLE. UPDATED 10/22/13
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10526325July 23, 2013
FUEL SYSTEM, DIESEL
TURNED CORNER, HEARD A SUDDEN DRAGGING NOISE. CHECKED UNDER TRUCK. FUEL TANK STRAP HAD BROKEN AND FUEL TANK WAS DRAGGING. QUICKLY PULLED INTO DRIVEWAY. HAVING VEHICLE TOWED TO REPAIR SHOP. CALLED DEALER AND FOUND OUT THAT THERE WAS A RECALL ON THE SAME YEAR FORD TRUCK FOR F15 NOT F250. OBVIOUSLY APPEARS TO BE A PROBLEM IN OTHER MODELS.VERY LUCKY NO INJURIES, EXPLOSIONS, LEAKAGE, ETC...COULD HAVE BEEN BAD. FRUSTRATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10520763June 19, 2013
ENGINE
WAS DRIVING TRUCK ALL OF SUDDEN I HEARD A LOUD POP THEN LOUD SOUND COMING FROM UNDER THE HOOD. CALLED HUSBAND AND TOOK TRUCK BACK HOME (APPROXIMATELY 2 MILES). HUSBAND STARTED RESEARCHING PROBLEM AND FOUND ONLINE THAT SEVERAL PEOPLE HAVE HAD SPARK PLUGS EXPLODE AND HEARD SIMILAR SOUND, THIS CAUSED HIM TO REMOVE WIRES AND INSPECT SPARK PLUGS. ONE OF THE SPARK PLUG HAD POPPED OUT AND NOW THE THREADS CAN'T BE USED. I BELIEVE THIS IS A KNOWN PROBLEM AND FORD SHOULD BE RESPONSIBLE FOR THE DAMAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250