CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.
ON CERTAIN PASSENGER VEHICLES, THE INTEGRATED AIR BAG MONITOR (IABM) CAN BE CONTAMINATED WITH WATER OR OTHER LIQUIDS AND COULD EXPERIENCE INTERNAL ELECTRICAL SHORTING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE S/R OPTION. THE S/R OPTION INCLUDES, AMONG OTHER FEATURES, A 5-SPEED MANUAL TRANSMISSION. ON THESE VEHICLES, THE TRANSMISSION SHIFT PATTERN IS NOT DISPLAYED IN THE OCCUPANT COMPARTMENT IN VIEW OF THE DRIVER. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT."
The rubber fuel filler neck hose that connects the metal fuel filler neck to the gas tank failed for the first time in 2013. During fueling, a large pool of gasoline leaked onto the pavement under the vehicle, presenting an environmental and fire hazard. The filler neck hose was replaced with a Ford OEM hose purchased from a local Ford dealer in Sacramento, CA. The replacement hose failed in a similar manner the original hose in less than two years time - thus requiring replacement in 2015. A genuine Ford OEM replacement was obtained from a dealer in the Sacramento area and installed. This hose failed in less than 2 years time, in 2017. Again a replacement hose was obtained from a Sacramento area Ford dealer ind installed. This hose then failed in 2019 and was replaced with another Ford dealer-obtained part... which failed in 2021 and was replaced with another Ford dealer-obtained part. The hose has failed again in less than 2 years time. It is apparent that the replacement parts that Ford has been selling through their dealers are made of a material that is not suitable for the application. Since the original part lasted 16 years, it should be possible to make a replacement part last a similar period of time. The vehicle has been a 'one family' ownership since purchased new in 1997, so the service history is well known by the present owners. The (lack of quality) of this part presents a safety and environmental hazard. Similar quality issues have been reported by other owners of the same vehicle. It is likely that other vehicle models are experiencing similar issues if the supplier of this part is also supplying other similar parts. See Ford Escort Owners Association online forum (with search feature) to read about other's experiences with these parts - here's a few: https://www.feoa.net/threads/gas-filler-neck-hose-cracking.112610/post-1076796 https://www.feoa.net/threads/fuel-hose-tank-to-filler-neck-how-long-should-it-last.105585/post-995753
No injuries · No fire · No crash
I have a very bad gas leak and have Always smelt fuel since I have owned the car, the front suspension is also affected and my rear lights are faulty
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1998 FORD ESCORT. WHILE DRIVING 20 MPH, THE VEHICLE CAUGHT FIRE UNDER THE HOOD WITHOUT WARNING. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THERE WERE NO INJURIES. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 144,998. *AS
TL* THE CONTACT OWNS A 1999 FORD ESCORT. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND NO OCCUPANT INSIDE, THE VEHICLE ROLLED BACKWARDS AND CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE CONTACT STATED THAT THE GEAR SHIFT LEVER WAS IN THE PARK POSITION AT THE TIME. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. THE VIN WAS NOT AVAILABLE.
I AM CONCERNED REGARDING REAR BUMPER COVER. THIS VERY IMPORTANT PAFT ON TBIS VEHICLE IS MADE TOTALLY OF FIBERGLASS OR A SIMILAR PRODUCT WHICH BECOMES MORE CRACKED WITH TIME AND THE MAIN ISSUE IS THAT IT HAS NO HARD METAL BAR FOR PROTECTION IN THE EVENT OF A REAR IMPACT . THIS BUMPER WHICH I HAD REMOVED TO RPLACED WHAT WAS LEFT OF IT HAS SOMETHING THAT APPEARS TO BE A BAR ATTACHED OR PART OF IT YET IT IS NOT ANY TYPE OF METAL THAT WOULD IN ANY WAY HELP ENDURE THE REAR OF THE VEHICLE IN THE EVENT OF A REAR IMPACT. IN FACT I AM CONCERNED THAT IT CAN EASILY SERIOUSLY CAUSE SERIOUS INJURY TO REAR PASSENGERS IF NOT DEATH BECAUSE THERE IS NO PROTECTION WITH THIS BUMPER. BESIDES THIS AND MAKING IT MORE DANGEROUS , THE GAS TANK IS RIGHT NEXT TO THIS SAID BUMPER AND THIS MAKES IT MUCH MORE DANGEROUS . I DON'T KNOW IF THERE WAS A RECALL FOR THIS ITEM , I JUST WANT TO LET NHTSA KNOW THE SAFETY HAZARD THIS IS AND THE DANGER IT POSES TO THE REAR PASSENGERS AND REALLY ALL PEOPLE IN THIS VEHICLE IN THE EVENT OF A REAR IMPACT.
No injuries · No fire · No crash