Ford Bronco Complaints (2024)

82 consumer complaints on file.

#11701435November 25, 2025
SERVICE BRAKES
The caliber seized causing the brake pad the fall and destroy the rotator. No brake indicators like turned on to advised of an issue. Ford does not want to take full responsibility for the faulty part that could have caused a major accident. Ford case# CXH06202259-S8K4B1. The vehicle is still at Ford for the repair so I don't have the repair documents yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701105November 23, 2025
ENGINE
The failure appears to have originated in the passenger side engine compartment, but the exact component or system (fuel, electrical, or other) is unknown. The vehicle is a total loss from the fire but should be available for inspection at the tow or storage facility. Our safety and the safety of others were put at risk because the vehicle caught fire suddenly while driving with traffic on a public road; my wife was driving, I was in the passenger seat, and our dog was in the back, and if we had not noticed the smoke and pulled over, the fire could have led to loss of control, injury, or a larger fire. The problem has not been reproduced or confirmed by a dealer or independent service center because the vehicle is completely burned and not drivable. As of now, the vehicle has not yet been inspected by the manufacturer; a claim has been initiated with my insurance company, and I expect their representatives and/or a fire investigator to inspect the vehicle, and local emergency services responded to the scene. There were no warning lamps or messages on the dashboard prior to the fire; the only prior symptom was an abnormal odor from the exhaust that smelled like mothballs or ammonia, first noticed immediately after starting the vehicle at the beginning of the trip on November 23, 2025, followed later in the trip by smoke and then the fire.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11699696November 16, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, EXTERIOR LIGHTING
Tail lights sensors / control are defective in some way. To be clear the tail lights at the rear of the vechile work perfectly fine and are very bright. They light up during lock and unlock. Also if you set headlight to on when parked. Also note brake lights still work in all situations. However. When they are set to auto at times they don’t light at all even at night. Also if in auto every time when you shift into reverse or drive they also go out. Took video of this issue after two dealer visits they said they were unable to replicate. They are suppose to replace the vechile control unit next week. I have my doubts that’s the issue. I’m willing to wager it’s the body control unit that’s the issue which my vechile doesn’t have for some reason because it wasn’t equipped with the tow package.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698284November 7, 2025
AIR BAGS, STRUCTURE:BODY, ELECTRICAL SYSTEM
Vehicle sustained significant front-end impact in a collision, but none of the airbags deployed. Front bumper, hood, and frame sustained visible damage. Concern that sensors or airbag system failed to activate during qualifying crash.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11697925November 6, 2025
UNKNOWN OR OTHER
Rear window of 2024 Bronco spontaneously broke with a loud bang while driving 40 mph down 2 lane smooth asphalt road in town, 55 degrees outside. Only 8000 miles on vehicle. Nobody else was on the road, there are no sidewalks. It would be impossible for a rock or other object to hit it from the back while I was driving 40mph. There was nothing being transported inside the back area of the vehicle and no sudden braking or movements in the car. The entire window exploded into the vehicle while all supporting parts dangled. I drove directly to the Ford dealership who confirmed it, took pictures, vacuumed up the window, and filed a claim, but Ford corporate denied a warranty claim. Similar stories can be found on [XXX] , Facebook, Reddit, and [XXX] . It sounded like a gunshot and then the interior of the car was sprayed with glass. I assume other glass fell outward as well. There were no other indications or warnings, and this is a vehicle driven for pleasure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696220October 28, 2025
SUSPENSION, STEERING
The vehicle started showing excessive tire wear with only 3500 miles on it. We took it to the dealership to have this checked and discovered it the front suspension was severely out of alignment they aligned the suspension and 1500 miles later it was out of alignment again and was re aligned. Then 1500 miles later it was aligned yet again because of excessive wear and pulling hard to the left. The vehicle was returned to the dealership it was purchased from and they kept it for 27 straight days and claimed to have done 5 alignments and the 5th one worked. We drove the vehicle 1000 miles and the front tires were showing even worse wear and the front end was discovered to be out of alignment yet again. As of today the vehicle is scheduled to be returned to the dealership for a 5th time with no real remedy or answer on the issue. I uploaded 10 documents but have 11 more available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695690October 26, 2025
UNKNOWN OR OTHER
The turn signal stalk automatically switches the active turn signal to the opposite turn signal after a turn is completed, with no turn signal sound for the new opposite side signal. This is repeatable and has occurred since the purchase of the new vehicle. Example: Engaging the left turn signal using the stalk initiates the left turn signal. However, once the left turn is completed and the stalk clicks back into its neutral position, the right signal is automatically engaged, and there is no sound accompanying the flashing right turn indicator light on the dashboard. Other owners and drivers of this make and model have complained on social media about this issue, which can create havoc in certain traffic situations.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695322October 23, 2025
VISIBILITY/WIPER
Went out to start the vehicle one afternoon to notice a Crack from the outside passenger edge by the frame. Nothing hit the windshield and just a single line of Crack spread from one side of the windshield straight across took to ford to be told that while they couldn't see an impact they wouldn't cover it under warranty be cause they couldn't prove it was their fault
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690543September 30, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
The contact owns a 2024 Ford Bronco. The contact stated that while driving and coming to a stop, the Engine Auto Start-Stop system failed to engage, and the engine revved significantly, causing the vehicle to move forward unintendedly. The contact stated that the failure persisted while standing on the brake pedal, requiring the contact to shift to neutral(N) or to park(P) to stop the engine. The contact stated that the failure had occurred on two occasions. The contact stated that the vehicle nearly moved into oncoming traffic on the first occasion and the vehicle nearly crashed into the rear of another vehicle on the second occasion. The failure also required the contact to steer the vehicle away from another vehicle or to shut off the engine to avoid a crash. The vehicle was taken to the dealer, where it was determined that the failure might be related to a low battery. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 6,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685826September 8, 2025
UNKNOWN OR OTHER
Soft top cable that secures stop top became loose or broke. Only opened the top 5-10 times. There is now i rattle and the top is not secure. This is horrible. I have found this mentioned mulitple online threads trying to figure out how to fix. This is obviously a manufacture defect. I bought the bronco in feb of 2025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671831July 7, 2025
UNKNOWN OR OTHER
Subject: Unresolved Safety Recall – Ford Bronco To Whom It May Concern, I am writing to formally lodge a complaint regarding an outstanding safety recall on my Ford Bronco. I received a recall notification letter from the manufacturer in January of this year concerning a critical safety issue. However, as of today’s date, the issue has not been resolved, nor have I received a clear timeline for repair. When I first purchased the vehicle, I noticed a pronounced bouncing sensation while driving at speeds around 70 mph. I brought this to the attention of the dealership, but they assured me that the vehicle was functioning normally and that there was nothing wrong. However, the existence of this unresolved recall has made me question whether the issue I experienced is truly unrelated—or if it was early evidence of a deeper safety concern. I feel unsafe driving the car, and no receiving any information about when the necessary parts or services will be available. This delay in action leaves my vehicle potentially unsafe and creates significant inconvenience, as I rely on it for daily transportation. I urge the NHTSA to investigate the prolonged delay in remedying this recall. Consumers deserve prompt and transparent resolution when their safety is at risk. Please advise on any further steps I should take to escalate this issue and keep me informed of any actions that may be taken. Thank you for your attention to this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671358July 5, 2025
STRUCTURE:BODY
Removable top cracks and allows moister into effected panels fostering an environment for possible black mold growth.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671355July 5, 2025
STRUCTURE:BODY
Removable top cracks allowing moisture to get into effected panels fostering an environment for black mold growth.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670299June 30, 2025
POWER TRAIN, ELECTRICAL SYSTEM
While vehicle was on a boat ramp the vehicle”s gear shift was put into the park position. The vehicle’s park gear failed to engage and it continued to roll backwards. Additional attempts to then put the vehicle into drive also failed to respond. My brand new 2024 Ford Bronco that only had just over 2300 miles on it, continued to roll backwards until it was completely submerged underwater. The vehicle had to be pulled out of the water by another truck!!! With my wife and children watching I was fortunate enough to escape without drowning!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670160June 30, 2025
SUSPENSION
The contact owns a 2024 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669542June 26, 2025
UNKNOWN OR OTHER
There’s been reported weakness in the back glass due to manufacturer defect in back window parked spontaneously shattered and window shocks shot through window, ford doesn’t have any current open recall but customer service says they have several people call with this, it’s being reported on the internet but again they won’t honor recall or manufacture warranty, I just bought this car a couple weeks ago
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664021May 30, 2025
UNKNOWN OR OTHER
Roof leaking water on the hardtop bronco I own will be going to the dealer for the second time to address this issue. Order comes in next to glove box on the passenger side.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663865May 30, 2025
UNKNOWN OR OTHER
When making right turn, after completing turn the indicator automatically activates for a left turn. I have had this occur 10 times since purchasing vehicle last month.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662108May 20, 2025
STRUCTURE
The contact owns a 2024 Ford Bronco. The contact stated that after purchasing the vehicle, it was discovered that the rear trim cover did not sit flush with the soft top roof installed, making the roof unsecure. The manufacturer and local dealer was notified of the failure, but no assistance was offered. The contact was made aware of the NHTSA ID Number: 11001584 (Structure) and related the failure to the NHTSA ID number. The failure mileage was 10.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658139May 1, 2025
POWER TRAIN, SERVICE BRAKES, HYDRAULIC
The contact owns a 2024 Ford Bronco. The contact stated that while driving at an undisclosed speed, the "Pre-Collision System Fault Detected" message was displayed. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was towed to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The contact stated that later while driving at an undisclosed speed, the "Powertrain Fault Detected - Reduced Power”, “Service Engine Soon" and "Brake Fault Detected" messages were displayed. The vehicle was taken back to the dealer, who diagnosed a failure with the brake actuator. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco