Chevrolet · Model Report
Showing safety data for the 1994 model year only.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1992-1994 CHEVROLET AND GMC SUBURBANS EQUIPPED WITH VACUUM POWER-BRAKE ASSIST AND EBC4 ANTI-LOCK BRAKE (ABS) MODULES. THESE VEHICLES EXHIBIT POOR BRAKE SYSTEM PERFORMANCE.
VEHICLE DESCRIPTION: PICKUP TRUCKS, CREW CABS, UTILITY TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES WERE BUILT WITH THE POLARITY OF THE WIRING FOR THE ZERO ADJUST BRAKE SWITCH REVERSED FROM WHAT WAS SPECIFIED ON THE SWITCH DRAWING. WITH THE REVERSED POLARITY, THE CONTACTS IN THE BRAKE SWITCH CAN WEAR OUT PREMATURELY. THE BRAKE SWITCH WILL PERFORM NORMALLY UNTIL THE BRAKE SWITCH CONTACTS WEAR OUT, RESULTING IN LOSS OF THE BRAKE LAMPS WITHOUT ANY WARNING TO THE DRIVER.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
The contact owns a 1994 Chevrolet Suburban equipped with two Lionhart Tires, Tire Line: LHS, Tire Size: 305/30/ZR26, DOT Number: TB2ACY50. The contact stated that he had installed two Lionhart tires on the front of the vehicle. The contact stated that the vehicle was a secondary vehicle that was not driven often. The contact stated that he observed a bulge on the tire, and the tire sidewall was separating from the tread next to the bulge. The dealer was not contacted. The manufacturer was not notified of the failure. The approximate vehicle failure mileage was 4,500 on a new installed engine. The tire failure mileage was 2,000.
No injuries · No fire · No crash
The contact owns a 1994 Chevrolet Suburban. The contact stated that while driving approximately 35 mph and applying the brake pedal to stop the pedal suddenly extended to the floor causing the vehicle to crash into the rear of a second vehicle. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The manufacturer and local dealer were not yet notified. The failure mileage was 274,000.
CONSUMER WRITES IN REGARDS TO GM CUSTOMERS AND PASSENGERS THAT USE VEHICLE AIR CONDITIONING HAVE BEEN CONTAMINATED AND/OR POISONED. *SMD THE CONSUMER STATED GM DEVELOPED AN AFTER-BLOW RETROFIT KIT TO REMOVE EXCESS WATER FROM THE A/C EVAPORATOR CORE. THE CONSUMER STATED IN DECEMBER 2002, HE WAS IN THE VEHICLE WITH HIS WIFE, WHEN HE TURNED ON THE HEATER, THE AIR HAD MUSTY ODOR AND HE BEGAN HAVING TROUBLE BREATHING. HE TURNED OFF THE HEATER AND OPENED THE WINDOWS. THEY STOPPED A T A LOCAL CHEVROLET DEALER AND INQUIRED ABOUT THE ODOR, AND THEY WERE TOLD IT WAS A DESIGN DEFECT OF HVAC SYSTEM. THE AC EVAPORATOR CORE DID NOT ALLOW WATER TO DISSIPATE/EVAPORATE AND MICROBIAL GROWTH COULD OCCUR WITHIN 24 TO 48 HOURS. THE CONSUMER STATED THE DEFECT MADE HIS ENTIRE FAMILY SICK. *JB
No injuries · No fire · No crash
VEHICLE WAS PARKED WITH THE IGNITION OFF. AFTER APPROXIMATELY 10 MINUTES, A FIRE STARTED IN THE AREA OF THE BATTERY PRECEDED BY THICK WHITE SMOKE. THE FIRE SPREAD TO THE PLASTIC WHEELWELL GUARD AND RIGHT FRONT TIRE ABOUT TWO MINUTES AFTER THE SMOKE WAS NOTICED. THE FRONT OF THE VEHICLE, DASHBOARD, WINDSHIELD, AND FRONT FLOOR PAN AREA WAS DESTROYED BY FIRE. *TR
THE SEAT BELTS WILL NOT RETRACT WHEN YOU LEAN FORWARD AND THE WIPERS WILL WORK SOMETIMES BUT MOST OF THE TIME THEY WILL NOT TURN ON. THIS REDUCES VISIBILITY WHILE RAINING AND IF IT RESULTS IN A CRASH THE SEAT BELTS MAY NOT WORK PROPERLY TO PROTECT THE PASSENGERS. *TR
No injuries · No fire · No crash