Chevrolet · Model Report
Showing safety data for the 1991 model year only.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL VETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
I HAVE A SET OF HANKOOK OPTIMO 727 TIRES ON MY FAMILY SUBURBAN, AND ONE OF THEM BLEW OUT SUDDENLY, AND UNEXPECTEDLY. THE TIRE THAT BLEW OUT ONLY HAD 14,596 MILES ON IT. THE SIZE IS P235-75-15. ALL FOUR OF THESE TIRES WERE INSTALLED IN FEBRUARY 2016, AND THE VEHICLE WAS ALWAYS KEPT IN MY GARAGE. THE TIRE THAT BLEW OUT SHOWED NO SIGNS OF SUN OZONE DEPLETION, AND AGAIN, IT NEVER SAT OUTSIDE IN THE SUN. ADDITIONALLY, THE TIRE THAT BLEW OUT HAD ALOT OF TREAD DEPTH LEFT. THE VEHICLE WAS NOT OVERLOADED, AS I WAS THE ONLY PERSON IN IT AT THE TIME OF THE BLOWOUT. I WAS SIMPLY DRIVING ABOUT 72 MPH DOWN INTERSTATE 65, JUST SOUTH OF LOUISVILLE, KY, I FELT SOME VIBRATION FOR ABOUT ONE MINUTE, THEN BOOM!, THE TIRE LET GO. I'M DISAPPOINTED IN HANKOOK TIRES, AND WILL NEVER BUY ANOTHER.
No injuries · No fire · No crash
FRAME WHERE STEERING BOX IS ATTACHED FAILED. FLEXING FROM NORMAL USE CAUSED THE AREA AROUND THE MOUNTING BOLTS TO CRACK AND WOULD ULTIMATELY SEPARATE THE STEERING BOX FROM THE FRAME IF LEFT UNREPAIRED. REPORTS OF FRAME FAILURES ON 4X4 VERSIONS HAVE BEEN CIRCULATING FOR SOME YEARS DUE TO THE HIGHER STRESS CAUSED BY THE FRONT AXLE AND THE USE OF OVERSIZED TIRES. IN THIS CASE THE SUBURBAN IS A 1/2 TON 2WD UNIT AND HAS ALWAYS RUN ON FACTORY SIZED TIRES. CRACKS WERE FIRST NOTICED JANUARY 2005 WITH 106744 MI DURING A REPAIR JOB FOR A LOOSE FRAME RIVET. CURRENTLY, DECEMBER 2010 AND 206000 MI., CRACKS HAVE FORMED ON ALL MOUNTING LOCATIONS AND REQUIRES A FRAME REPAIR KIT. REPAIR INCLUDES GRINDING AND WELDING OF CRACKS; AND WELDING ADDITIONAL REENFORCING PLATES TO STRENGTHEN THE AREA.
No injuries · No fire · No crash
TREAD SEPARATION AROUND 9/10 OF TIRE STEEL BELTS SHOWING. RUBBER SEPARATING FROM SAME. *TR
No injuries · No fire · No crash
PEP BOYS FUTURA SCRAMBLER A/P TRUCK TIRE BLOWOUT DUE TO BELT SEPARATION. *TR
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 1991 CHEVROLET SUBURBAN. WHILE DRIVING 60 MPH, THE CONTACT EXPERIENCED VALVE STEM FAILURE, WHICH CAUSED IT TO CRACK. THE TIRE FLATTENED AND WAS RUINED AS A RESULT. THE DEALER STATED THAT THEY NEVER HEARD OF THE VALVE STEM FAILURE. THROUGH ONLINE RESEARCH, THE CONTACT EXPERIENCED VARIOUS RECALLS PERTAINING TO VALVE STEM FAILURES AND CRACKS. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 51,000. THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 12,000.
No injuries · No fire · No crash