Chevrolet · Model Report
Showing safety data for the 2004 model year only.
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
The contact owns a 2004 Chevrolet Silverado 2500. The contact stated that while driving 60-65 MPH, the vehicle experienced reduced power and went into LIMP Mode. The contact pulled over to the side of the road. The contact turned off and restarted the vehicle after several minutes, as per the Owner's Manual. The transmission warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that it could take 1-2 weeks to diagnose the vehicle, and several months to repair the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a claim was filed. The failure mileage was approximately 50,000.
No injuries · No fire · No crash
Odometer Fraud. The contact was interested in purchasing a 2004 Chevrolet Silverado 1500 from a local used car dealer. The contact stated that the odometer indicated that the mileage was 187,000. The Carfax report indicated that the last reported mileage was 312,000. In addition, the contact was informed that the vehicle had only one previous owner. The Carfax report indicated that the vehicle had four previous owners. The dealer was not made aware of the issue.
No injuries · No fire · No crash
The contact owns a 2004 Chevrolet Silverado 1500. The contact stated while driving 30-35 MPH, the brake and the check engine warning lights illuminated. The contact stated that upon depressing the brake pedal, the brake pedal traveled down to the floorboard, and the vehicle hesitated to respond. The contact pulled to the side of the road, added brake fluid to the vehicle, and continued driving. The contact stated while driving approximately 55 MPH and depressing the brake pedal, the brake pedal traveled down to the floorboard and the vehicle failed to respond. Several unknown warning lights were illuminated. The contact engaged the parking brake, and the vehicle stopped. The contact was able to coast to the side of the road downhill. The contact turned on the hazard lights and drove 5 MPH to her mother's residence while being trailed by a Police Officer. The vehicle was taken to O'Reilly and to Advanced Auto Parts, where the contact was informed that the vehicle was unsafe to drive. The contact purchased an oxygen sensor, an oil sensor, the battery, the brake booster, the thermostat, and the brake lines. The contact's son and nephew attempted to replace the parts and noticed that the brake assembly was significantly damaged. The contact's son and nephew also noticed that the frame, the exhaust system assembly, and other parts were severely corroded. The Used Car dealer was notified of the failure, but no assistance was provided. The Chevrolet dealer and manufacturer were not notified of the failure. The failure mileage was approximately 162,616.
No injuries · No fire · No crash
I just replaced the battery in my 2004 chevy Silverado 1500 with only 97,000 miles on it, and i went to drive it down the road and the vehicle now loses power and cuts off making a left turn.. It did this twice and i parked it.. THIS IS A VERY SERIOUS SAFETY ISSUE in my opinion.. PLEASE investigate the issue and report back to me please..
No injuries · No fire · No crash
The contact's son owns a 2004 Chevrolet Silverado 1500. The contact stated while his son was exiting a parking lot, the brake pedal hose ruptured, and the brake pedal depressed to the floorboard. Upon inspection of the vehicle, the contact discovered that there was a hole in the brake hose. The contact used a personal trailer to tow the vehicle home where the vehicle remained. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 160,000. The VIN was not available.
No injuries · No fire · No crash