Chevrolet HHR Complaints

3,575 consumer complaints on file.

#11629426December 7, 2024
FUEL/PROPULSION SYSTEM
The fuel line is leaking due to it being metal and rusted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629295December 6, 2024
STEERING
The contact owns a 2006 Chevrolet HHR. The contact stated while driving at an undisclosed speed, the steering wheel seized, with the power steering warning light illuminated. The contact stated that the steering wheel became difficult to turn. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 240,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628096November 30, 2024
FUEL/PROPULSION SYSTEM
Car is leaking gas on left rear side. Corrosion and rust due to fuel line.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627210November 25, 2024
FUEL/PROPULSION SYSTEM
Fuel line leaking next to exhaust. This is very dangerous and could kill someone. Bad design on Chevy's part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627299November 25, 2024
FUEL/PROPULSION SYSTEM
Fuel line is leaking near left rear wheel wheel
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622868October 31, 2024
FUEL SYSTEM, GASOLINE, FUEL SYSTEM, OTHER, FUEL/PROPULSION SYSTEM
The contact owns a 2009 Chevrolet HHR. The contact stated that there was a fuel leak near the driver's side rear door. The contact stated that the TPMS, ESC, and check engine warning lights were illuminated. The contact researched online and determined that the failure was related to NHTSA Action Number: PE20011 (FUEL SYSTEM, OTHER, FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE). The contact called the local dealer and was informed there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 136,440.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621763October 24, 2024
FUEL/PROPULSION SYSTEM
last week we noticed gasoline showing up on the ground in front of the rear driver side tire. I looked underneath and found a pipe that seems to be corroded. I looked online and found that many people have the same problem, so I haven't had it checked at a dealership. The pipe continues to leak after you walk away and I'm afraid someone will discard a cigarette near the vehicle, or worse. We are generally home, and can be reached for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620091October 16, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2009 Chevrolet HHR. The contact stated that while the vehicle was parked, and while driving the vehicle, there was a strong fuel odor coming from the vehicle. Additionally, the contact noticed that the vehicle was experiencing excessive fuel consumption. The contact also noticed that fuel had leaked onto the ground. The contact stated that upon inspecting the vehicle, the contact noticed that fuel was leaking from the driver's side rear wheel well, where the fuel tank was located. The contact related the failure NHTSA Action Number: PE20011(Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618141October 4, 2024
STEERING
The contact owns a 2010 Chevrolet HHR. The contact stated while driving at an undisclosed speed, the vehicle lost power steering functionality. The power steering warning light was illuminated. In addition, the contact stated that after restarting the vehicle, the vehicle temporarily returned to normal functionality however, the failure reoccurred. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 14V153000 (Steering); however, the VIN was not included. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618144October 4, 2024
STEERING
Although this vehicle is a 2010 HHR, it has less than 23000 miles on it, has been garaged kept and maintained impeccably. The warning light blinks at random and then the power steering fails. It does not matter the speed of the vehicle and happens at random. Once turned off and restarted, the power steering works for approx 5 minutes and then fails again. There was a recall on 2009-2010 HHRs for sudden loss of power steering issued in 3/2014, recall # 14V153000. This recall is not VIN# specific. However, when I contact the dealer for repair of this vehicle, I am told that the recall does not pertain to my VIN#, so its not covered. NHTSA has more than 135 complaints about HHRs since 10/2019 with more than half of them being steering issues. This clearly is a wider recall issue than originally thought. My vehicle is inoperable due to this safety issue. I filed a complaint with GM. They told me it was not their issue and I could pay to have it diagnosed and fixed at a dealership. This is a GM issue due to the amount of complaints about this exact problem from other owners. I am hoping GM is made aware of the widespread issues and does the right thing, issuing another recall for all 2009-2010 HHRs regardless of VIN#.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614139September 12, 2024
STEERING
The (EPS) system in my 2006 Chevy HHR has experienced multiple malfunctions. The power steering suddenly cuts out without warning while driving at both low and high speeds, making it extremely difficult to steer, especially when attempting to turn or change lanes. This failure happens intermittently, and the EPS motor is suspected to be the root cause. I have replaced fuses and relays, but the issue persists. This system is available for inspection upon request. This malfunction poses a severe risk to my safety and the safety of others. When the power steering fails, it becomes nearly impossible to turn the vehicle, which is especially hazardous during routine maneuvers such as lane changes or turns at intersections. The sudden loss of steering capability, especially at higher speeds, has left me vulnerable to potential collisions. Given the unpredictability of the issue, it could easily lead to a fatal accident if it occurs while navigating tight curves or avoiding road hazards. The problem has been confirmed by a certified mechanic, who validated that the power steering system is malfunctioning and recognized the danger it poses. The mechanic advised that this issue is prevalent in vehicles of this make and model & suggested filing a formal complaint to prompt further investigation by the manufacturer. To date, the veh has been thoroughly examined by an independent service center. They confirmed the malfunction of the EPS system but were unable to fully resolve the issue through standard repairs like fuse or relay replacements. A "Power Steering" message illuminates on the dashboard. A few seconds later, the power steering system fails completely, leaving the vehicle almost impossible to control. These warnings have been intermittent, but their frequency has increased over time. The first occurrence was about a year ago, Given the ongoing danger and prevalence of this issue among other 2006 Chevy HHR owners, I am requesting that GM initiate a formal recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610617August 24, 2024
FUEL/PROPULSION SYSTEM
Fuel lines corroded just like millions of other HHR's. Gas is leaking. What does it take to have a recall on this? Does someone really have to be killed?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608559August 14, 2024
STRUCTURE:BODY
I was driving and I went to roll the sunroof down and it ejected itself and came off the whole glass and frame and broke in many pieces on the bridge if there would of been a car or person walking it would of hit them and caused a major accident its going to cosy over$2000.00 to get it replaced whicj I cant afford to do I feel like the manufacturer should replace the part it wasnt my fault
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607862August 11, 2024
FUEL/PROPULSION SYSTEM
Fuel leak coming from the Left (Drivers Side) of the vehicle in the area of the rear wheel. There was a strong odor of fuel, Fuel was observed dripping to the ground under the vehicle in front of the Left rear wheel. This condition was observed only when the vehicle was running and in park. The condition does not seem to happen when the vehicle is off and not running. No repair has been made yet , vehicle can be inspected in its current condition. This is a severe safety concern of ignition/explosion due to a fuel leak; risk of property damage or even death. This problem has not been addressed yet to a dealer or local mechanic as of yet . Failed component has not yet been inspected by GM, Police or insurance. No warning lamps or messages were illuminated on dashboard, prior to failure, vehicle did have some difficulty starting, possibly due to this problem, but it did start.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607018August 7, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that on one occasion after her friend parked the vehicle, the contact observed condensation underneath the rear of the vehicle. The vehicle was inspected by the friend's nephew, and it was determined that the fuel line had a hole and was leaking fuel. The vehicle was then taken to a dealer where it was diagnosed and determined that the fuel line needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605034July 29, 2024
FUEL/PROPULSION SYSTEM
Fuel line leak. My fuel line has cracked in multiple places and needs to be replaced entirely. The leak was consistent, with a constant stream leaking out when in operation and for several minutes after stopping the engine. The odor of gasoline was strong from inside of the vehicle when in operation and large puddles of gas were visible on the ground afterwards when I first noticed the issue. My repair quote is about $500 to get the line replaced entirely.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604907July 27, 2024
FUEL/PROPULSION SYSTEM
Gas lines rusted out after purchase.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595986June 23, 2024
STEERING
Power steering cuts off and very hard to steer until you turn off vehicle and turn back on but then will go out again while driving .This is very un safe when my wife is driving Kids to school.I have read that 2009-2011 has same issue and have been recalled why isn’t this one if it’s same problem .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11594455June 14, 2024
FUEL/PROPULSION SYSTEM
Gas line leaking, leaves puddles and can visibly be seen dripping
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11585773April 29, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that while parking the vehicle, the contact detected an abnormally strong fuel odor. Upon inspection, the contact noticed a leak coming from underneath the rear driver's side door. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE20011 (Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The failure mileage was 184,025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet HHR