Chevrolet Corvette Complaints

5,302 consumer complaints on file.

#11676463July 27, 2025
FUEL/PROPULSION SYSTEM
Unknown. Gasoline fumes when parked with over a half tank of fuel. Fills my garage with the smell..purchased this in 2022 and I was unaware of this problem until I put it in my garage after filling the tank completely.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674701July 19, 2025
FUEL/PROPULSION SYSTEM
Fuel is leaking from the top of the driver side fuel sending unit. This is a know issue on these cars and should be fixed under a recall. This is a very dangerous issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673703July 15, 2025
STEERING
Vehicle was part of mandatory recall for problems with steering column lock. The same identified and inherent problem happened so that the steering column lock is engaged and will not disengage. GM was contacted and refuses support and stated that I would have to take care of the problem and I would have to pay for the cost of the repair. Chevrolet created the problem, is well aware of the inherent problem and yet Chevrolet and it's local dealer will profit from the forcing the customer to pay and for customers safety. The steering column can lock up while the vehicle is moving which puts the operator and others including vehicles, pedestrians and structures in harms way.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672291July 9, 2025
VISIBILITY, STRUCTURE
The contact owns a 2025 Chevrolet Corvette. The contact stated that the rear glass had a one-inch gap, allowing heat to escape the vehicle, and allowing water to enter the engine compartment and inside the vehicle. While the contact was driving at undisclosed speeds in the rain, there was water entering the vehicle. There were no warning lights illuminated. The local dealer was contacted and determined that the issue was not a service issue. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671073July 3, 2025
ELECTRICAL SYSTEM
Rear back up camera becomes unresponsive randomly, causing it to become unsafe when backing up
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670220June 30, 2025
AIR BAGS, SEAT BELTS
The contact's daughter owned a 2010 Chevrolet Corvette. The contact stated while her daughter was driving at an undisclosed speed on a rainy night, there was another unoccupied vehicle stopped side ways in the middle of the highway with no hazards lights activated. The contact stated that the front driver's side of the vehicle crashed into the other vehicle. The contact stated that the driver's side and passenger's side air bags failed to fully deploy as needed. The contact was occupying the rear passenger's side seat and was wearing a seat belt; however, the contact was propelled between the front driver's side and front passenger's side seats, causing the contact's left shoulder to hit the driver's side seat. The contact sustained a right shoulder dislocation, headache, neckache and soreness all over the body. The contact's daughter who was occupying the front driver's side seat hit her face against the steering wheel and sustained bruises and minor cuts on the face. The driver also sustained soreness on the shoulders, knees, feet, back, head and the face. The contact's niece who was occupying the front passenger's side seat hit her forehead against the windshield and the windshield was fractured. The contact 's niece sustained cuts on the forehead and severe neck pain that required her to be out of school for an extended period of time. The ambulance transported all passengers to the emergency room, where medical assistance was provided. The vehicle was towed and totaled. A police report was filed but the contact did not have the information available. The manufacturer was notified of the failure and informed the contact that the failure occurred because an object that was hanging on the driver's key holder had caused the ignition switch to turn off. No assistance was provided. The contact related the failure to an unknown recall. The failure mileage was unknown. The VIN was not available.
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11669852June 27, 2025
FUEL/PROPULSION SYSTEM
I bought a 2011 Grand Sport Corvette and if I fill the tank over half full the gas smell is unbearable. Some one needs to recall these cars. This issue is very serious. Fuel leaks out the top of the tanks, and will then drip down the back side onto the hot exhaust. If ignored this could result in a fire and possible death. If parked overnight in a garage, the vapor will fill the garage and could easily be triggered into an explosion and fire from a gas water heater or other ignition source.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669796June 27, 2025
STRUCTURE
The contact owns a 2022 Chevrolet Corvette. The contact stated that while started and running, the convertible top release button was depressed; however, a wire snapped. The vehicle was taken to the dealer where it was determined that the convertible top cable had snapped and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 9,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669384June 26, 2025
ENGINE
Engine needed to be replaced and it was but new engine misfiring and throwing knock codes and misfire codes. Contacted General Motors only to be told they can’t do anything about it and that’s unacceptable. Case number [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666853June 13, 2025
FUEL/PROPULSION SYSTEM
Gas smells when tank is over half full it’s the plastic fuel system on to of tank is starting to crack and I was reading they have been recalled before but has gone off and this is danger and might cause a fire with the saddle bags across the back and only 30,700 miles on car
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665801June 9, 2025
FUEL/PROPULSION SYSTEM
Strong smell of fuel after parking the car in the garage. Inspection by the dealership confirmed the fuel pump assembly is leaking. The car was left for replacement of the fuel pump assembly due to the strong possibility of fire. This is a known issue with the C6 model of Corvette and was addressed by a gm TSB in 2011 rather than more appropriately by a recall. Of more concern to me is the fact that my car was produced in 2013 with a known defective part affecting safety. The cost of the repair is over $5000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664838June 4, 2025
WHEELS
Noticed one wheel kept leaking down slowly. After a couple of weeks of filling the air in the tires, it was down near the warning pressure again on one rear wheel. Decided to remove the wheel to inspect the cause of the leak. Upon removal of the wheel, there were two noticeable cracks on the inner bead diameter of the wheel. I know this has been a big issue for all the C7 GS corvettes, because this is my 4th C7 GS with the same issue. All my previous C7 GS have had all the factory rear wheels to crack. I don't understand why there has not been a recall since every C7 GS I've owned had this same issue on all the rear wheels. I typically do my own repairs unless they are covered under warrant. I have worked on automobiles for over 35 years in my personal garage and it has become an expectation that any C7 GS or Z06 with a rear tire leaking is caused by a cracked wheel. Have contacted Rick Hendrick City Chevrolet in Charlotte NC about the cracked wheel before deciding repair method that will be taken.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662113May 20, 2025
FUEL/PROPULSION SYSTEM
Fuel smell - possible fuel leak - the issue had been previously addressed with replacement of fuel subassembly in both saddle tanks. I believe that it is happening again ...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661881May 19, 2025
FUEL/PROPULSION SYSTEM
There was a strong fuel smell after the last 2 times I drove it. I took it to the shop and they tell me the evap canister was saturated and the fuel pump had small cracks in it likely seeping when the car heats up. I am having the fuel pump replaced, the evap canister and several seals/hoses in hopes it won't leak again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660955May 14, 2025
WHEELS
Rear tire leaking air, took it to shop and they stated i have a one inch crack in my wheel
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661069May 14, 2025
FUEL/PROPULSION SYSTEM
My vehicle is covered by GM Special Warranty 17469 which relates to cracks and fuel leaks at the primary fuel pump module flange. It caught fire while driving at a high performance driver’s education event at Barber Motorsports Park and was denied coverage due to it having modifications. GM case number 9-15085163081. There were no warning messages displayed at any time during the incident. GM had the vehicle inspected by a “neutral” third party which turned out to be a retired GM service center instructor. None of the modifications on the vehicle affect the fuel pump module flange. This is in violation of the Magnuson Moss Warranty Act. The basic facts regarding the incident are as follows: the fire was a fuel fire, the vehicle had normal fuel pressure until I shut the engine off 2 minutes into the incident, the fuel line fittings are melted in the normal seated position, the fuel tank flange is cracked and fire damaged, the most significant fire damage is at the top of the driver’s side fuel tank (the location of the warrantied and currently cracked flange), the fire was not from any of the pressurized fuel lines. I have video from the vehicle of the incident prior to engine shutdown, pictures during and after the incident of all affected areas and components, and data logs of all vehicle parameters up to engine shutdown. These facts point strongly to the initial source of the fuel fire coming from the affected flange at the top of the driver’s side fuel tank. It is completely unacceptable that GM issued an extended warranty (and then denies coverage) for this known fire hazard vs issuing a recall. This is extremely unsafe and will lead to a loss of life if not corrected.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11660289May 11, 2025
ENGINE, ELECTRICAL SYSTEM
We were driving 55 and the car stalled. This has happened several times. Been at dealer and the codes show fine they replaced what they thought was issue and it still does this. Very scary
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658701May 3, 2025
ELECTRICAL SYSTEM
I cannot believe the Corvette does not show that the alternator does not show that the car is not charging. I have a thirty year old corvette that will show you when the alternator does not show the car has an under performing alternator. If you do not have it showing on the display it will not show you that the alternator is defective. You have to show it on the display you never know you have a problem. It is an issue that is not a problem unless you know. I bought a battery and it was the alternator. They need to do a software upgrade to show you when a system goes out. My 1992 Corvette show you when there is a problem. Pathtic support on the part of General Motors.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658490May 2, 2025
FUEL/PROPULSION SYSTEM
After filling the tank with fuel, I was immediately aware of a strong smell of gas. I am always extremely careful not to overfill causing any fuel to escape. The heavy smell/escape of fumes is such that the car simply can’t be put in my garage. The risk of igniting and fire is a risk that is unacceptable. General Motors knows about this issue as they did notify me in 2017 that my car could have this condition and that if it did, they would fix it at no charge. I didn’t have the issue at that time so didn’t take the car in. So, now that I the problem, I have taken the car to Bradley Chevrolet in my town, Lake Havasu City, AZ and am told that in order to inspect the car for this issue, I will have to pay for 10 hours of labor ($2200) and only then will they see if they can find a new tank at another dealer. You see, GM no longer makes or has the tanks (according to their parts department). I have contacted their Customer Service Department and have a Case (#[XXX]). I am told that they will not participate going forward unless I spend the $2200 and then if they can’t find a new tank, they will put the car back together and send me home with it! It’s my belief that since this is a documented safety defect resulting in an apparent fire hazard that they would/should take care of it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657319April 28, 2025
FUEL/PROPULSION SYSTEM
Fuel Filler Neck not Sealing
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Corvette