Volvo S80 Complaints

954 consumer complaints on file.

#10138949October 6, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM), SUSPENSION:FRONT, FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
3 INDEPENDENT ISSUES: THROTTLE MODULE - VEHICLE SUDDENLY AND UNPREDICTABLY SURGES FORWARD, PARTICULARLY DURING IDLE OR LOW SPEEDS WHILE IN FORWARD OR REVERSE EITHER STOPPED OR MOVING, CAUSING POTENTIAL SAFETY PROBLEMS. TRANSMISSION MODULE - VEHICLE SUDDENLY AND UNPREDICTABLY LOOSES POWER, PRESENTING THE DRIVING PERFORMANCE OF A "SLIPPING" TRANSMISSION, CAUSING UNPREDICTABLE RESPONSIVENESS TO CHANGING TRAFFIC CONDITIONS, AND POTENTIAL SAFETY PROBLEMS. FRONT SUSPENSION - "KNOCKING" NOISE FROM FRONT SUSPENSION COMPONENT(S), CAUSING LACK OF DRIVING CONFIDENCE AND CONCERNS OF DRIVING SAFETY AND PERFORMANCE. ALL 3 OF THESE PROBLEMS ARE WIDELY REPORTED AS CHRONIC DESIGN, PERFORMANCE, SAFETY AND RELIABILITY ISSUES FOR THE SAME MODEL YEARS BY OTHER VOLVO OWNERS. IN NEWER MODEL YEARS, VOLVO HAS MADE MANUFACTURING CHANGES TO ADDRESS THESE RECOGNIZED ISSUES, BUT HAS NOT AS YET SUCCESSFULLY ADDRESSED AND RESPONDED TO THESE SAFETY ISSUES. FURTHER, THESE ISSUES HAVE BEEN REPORTED TO NHTSA BY OTHER VOLVO OWNERS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136459October 6, 2005
VEHICLE SPEED CONTROL
DT: THE CONTACT OWNS A 2001 VOLVO S80. THE VEHICLE WILL BEGIN TO BUCK AT HIGHWAY SPEEDS. THE CRUISE CONTROL WILL DROP OFF AT RANDOM AND STOP WORKING BEFORE THE BUCKING STARTS. SOMETIMES AT START UP IT WILL IDLE REALLY ROUGH. THE CONTACT PURCHASED THE VEHICLE ON JULY 16, 2005 AND THIS PROBLEM HAS BEEN OCCURRING EVER SINCE HE PURCHASED THE VEHICLE. THE VEHICLE WILL COMPLETELY STALL AS WELL AS RUN AT LOW SPEEDS. THE VEHICLE FAILED AT LEAST 50 TIMES SINCE HE PURCHASED THE VEHICLE. THE CONSUMER WAS NOT THE ORIGINAL OWNER. THE PROBLEM HAS BEEN DIAGNOSED AS THE ELECTRONIC THROTTLE MODULE, BUT HAS NOT BEEN FIXED AT THIS POINT. *AK *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131690October 6, 2005
VEHICLE SPEED CONTROL
DT: THE CONSUMER STATED THAT THE VEHICLE STALLED / DIED AND LOST POWER. THE ENGINE WAS MISSING, AND WHEN THE GAS PEDAL WAS PRESSED THE CAR WOULDN'T ACCERLATE. THE CAR WOULD ONLY GET UP TO ABOUT 20-40 MPH. CONSUMER WAS GOING ABOUT 70 AND THE CAR LOST POWER. THE DRIVER WAS ABLE TO DRIVE THE CAR TO THE DEALERSHIP, THEY SAID THE ELECTRONIC THROTTLE BODY FAILED. THE DEALERSHIP REPLACED IT AND CHARGED THE CONSUMER $883.00 FOR THE PARTS AND LABOR. *AK *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138687October 5, 2005
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VOLVO S80 ELECTRONIC THROTTLE MODULE (ETM) PRODUCTION DEFECT NOT COVERED UNDER WARRANTY AS THE DEFECT OCCURRED JUST OUTSIDE OF WARRANTY. DEALER COST TO CORRECT IS OUTRAGEOUS GIVEN THIS IS CLEARLY A MANUFACTURER ENGINEERING DEFECT WITHIN THE THROTTLE BODY MECHANISM ITSELF. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138309October 1, 2005
ELECTRICAL SYSTEM
2000 S80 VOLVO T6, HAS STALLED IN TRAFFIC NINE TIMES, INCLUDING A SUDDEN LOSS OF SPEED AND POWER STEERING WHILE DRIVING IN HIGHWAY TRAFFIC WITHOUT WARNING. I HAVE HAD CAR TOWED TO OUR DEALER SEVERAL TIMES, THEY KEEP IT FOR A WEEK, TRYING TO SEE IF THE CAR WILL STALL FOR THEM. WE ARE FRUSTRATED WITH THE DEALER, WILL IT TAKE A DEATH BEFORE THERE IS ANY ACTION. CAN YOU PLEASE HELP US? *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138222September 30, 2005
VEHICLE SPEED CONTROL
I HAVE EXPERIENCED REPEATED PROBLEMS WITH THE ELECTRONIC THROTTLE MODULE ON MY 2000 S80 VOLVO. FOR THE LAST COUPLE YEARS I HAVE TAKEN MY VEHICLE TO THE VOLVO SERVICE DEALER FOR REPEATED PROBLEMS WITH THE CAR ENGINE SURGING WHEN COMING TO A STOP. THE VOLVO DEALER SERVICE WORKED ON THE ISSUE MULTIPLE THROUGHOUT THE WARRANTY PERIOD, STATING THEY KNEW OF A PROBLEM WITH THE ETM AND TO WATCH IT. NOW MY VEHICLE IS OUT OF WARRANTY AND THE PROBLEM WAS DEFINITELY DIAGNOSED AND I HAD TO PAY OVER $900.00 TO GET IT FIXED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138258September 30, 2005
VEHICLE SPEED CONTROL
DT: THGE CONTACT STATED THE THROTTLE CONTROLLER COMPUTER IS BAD ON 2000 VOLVO S-80. A . THE VEHICLE STALLS/DIES, AND LOSES POWER. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136317September 29, 2005
VEHICLE SPEED CONTROL
DT: ON SEPTEMBER 12, 2005 THE CONSUMER'S HUSBAND HAD HIS FOOT ON THE BRAKE AND THE VEHICLE SURGED FORWARD. THE ELECTRONIC THROTTLE MODULE FAILED AND WAS REPLACED. *AK *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132472September 29, 2005
ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL
DT: THE CONTACT STATED THE VEHICLE INTERMITTENTLY STALLED/DIED AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132993September 29, 2005
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING
DT:THE CONTACT OWNS A VOLVO S80 VEHICLE. IT INTERMITTENTLY STALLED/ DIED, AND LOST POWER. THE ELECTRONIC THROTTLE MODULE FAILED AND WAS CLEANED THREE TIMES. *AK THE LINE SEAL AND GASKET WERE REPLACED DUE TO AN OIL LEAK. THE TOP ENGINE TORQUE ARM WAS CRACKED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132057September 29, 2005
VEHICLE SPEED CONTROL
DT: 2001 VOLVO S80. VEHICLE STALLED/DIED AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK THE THROTTLE BODY AND GASKET HAVE BEEN REPLACED THREE TIMES TO ALLEVIATE THE STALLING PROBLEM. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138034September 28, 2005
ELECTRICAL SYSTEM
SURGING ENGINE RPM NOTED ON NUMEROUS OCCASIONS WHILE STOPPED. SEEMS TO BE WHEN USING AIR CONDITIONER OUR SAFETY CONCERN IS THE POSSIBILITY OF THE ENGINE OVERPOWERING THE BRAKES. DEALER SAYS IT IS THE ELECTRONIC THROTTLE MODULE AND NOTED IT IS AN ON-GOING PROBLEM WITH THIS MODEL CAR AS WELL AS A SAFETY AND RELIABILITY CONCERN. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138044September 28, 2005
ELECTRICAL SYSTEM
I OWN A VOLVO S80 AND HAVE SEEN SOME PERFORMANCE PROBLEMS SIMILAR TO THOSE DESCRIBED BY HTTP://VEXEDVOLVO.ORG/. STALLING ON A HIGHWAY IS ONE OF THE BIGGEST PROBLEMS ALTHOUGH MY STALLS USUALLY DON''T CAUSE THE CAR TO TOTALLY STOP. I RECENTLY CONTACTED VOLVO SINCE I FEEL THAT THIS TYPE OF SITUATION IS UNSAFE. THEY NEVER RESPONDED TO MY REQUEST, WHICH WAS FOR A REPLACEMENT PART, THAT I WOULD PAY FOR, THAT WOULDN'T FAIL OVER TIME. I HAVE SENT THEM TWO EMAILS SO FAR WITH NO RESULTS. I AM A 9-YEAR VOLVO OWNER AND BECAUSE OF THE PROBLEMS THEY HAVE IGNORED I FEE L VOLVO HAS GIVEN UP ON TRYING TO MAKE THEIR CARS SAFE AND RELIABLE. IF I CAN HELP WITH YOUR INVESTIGATION PLEASE LET ME KNOW. THE CAR HAS 88000 MILES ON IT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137856September 27, 2005
ENGINE AND ENGINE COOLING:ENGINE, SUSPENSION:FRONT:CONTROL ARM
1) EVENTS LEADING UP TO FAILURE: PURCHASED NEW VOLVO S80 CAR ON 9/3/2005 WITH 813 MILES, DROVE IT HOME. NO INFORMATION WAS GIVEN ON THE 813 MILES ALREADY ON THE CAR. THE NEXT DAY THERE WERE OIL PUDDLES UNDERNEATH CAR AND OIL WAS ALL OVER THE PASSENGER SIDE FRAME UNDERNEATH THE CAR. THE CAR WAS TAKEN IN FOR SERVICE TUES 9/6 MORNING FOR OIL LEAKING. THE LEAKING OIL PUMP AND SEALS WERE REPLACED. CAR WAS READY AND PICKED UP ON FRI EVENING 9/9. FROM TALKING WITH THE SERVICE PEOPLE THE OIL PUMP HAD BEEN CRACKED. THEY SAID THE CAR HAD BEEN CLEANED OF THE OIL AND THAT THERE WAS NO MORE OIL LEAKING. ON SAT MORNING 9/10 THERE WAS A NEW OIL PUDDLE AND OIL UNDERNEATH THE PASSENGER SIDE OF THE CAR ON THE FRAME. SERVICE IS CLOSED ON THE WEEKEND. ON MON I WAS NOT ABLE TO CHANGE CARS DUE TO WORK COMMITMENTS AND AFTER DRIVING HOME FROM WORK THERE WAS THE SMELL OF BURNING OIL. THE CAR WAS SERVICED ON TUES 9/13 FOR OIL LEAKING. THE SERVICE PEOPLE REPORTED THAT THERE OIL COLLECTED IN THE BOTTOM OF THE CAR FROM THE FIRST OIL LEAK. THEY REPORTED CLEANING THE CAR AGAIN AND DOING A LOT OF TEST DRIVING TO VERIFY THAT THERE WAS NO MORE OIL LEAKING. I RECEIVED THE CAR BACK TUES AFTERNOON. 2) FAILURE: SAT 9/17/2005, I LEFT HOME WITH 2 CHILDREN IN THE NEW VOLVO S80 CAR TO GO SHOPPING. ONE CHILD WAS IN THE PASSENGER FRONT SEAT AND THE OTHER IN THE PASSENGER SIDE BACK SEAT. AFTER TURNING ON ANOTHER SIDE STREET, THE CAR WENT TO THE RIGHT AND HIT A MAILBOX. THE ARM (CONTROL ARM) ON THE PASSENGER SIDE TIRE WAS SPLIT BROKE OFF. THE CAR HAD DAMAGE FROM THE MAILBOX TO THE HEADLIGHTS, HOOD, AND SIDE PANEL. THE PASSENGER SIDE WHEEL WAS NO LONGER IN THE CORRECT POSITION BUT PUSHED TOWARD THE REAR OF THE CAR. THE CAR WAS NOT DRIVABLE AND TOWED BY VOLVO SERVICE TO SAM SWOPE AUTO COLLISION CENTER. 3) MY INSURANCE COMPANY HAS INSPECTED THE DAMAGE. THE VOLVO FIELD TECH SPECIALIST (FTS) INSPECTED THE CAR ON THURS 9/22. NO INFORMATION HAS BEEN RELEASED FROM VOLVO. *NM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10137864September 27, 2005
VEHICLE SPEED CONTROL
DT: THE CALLER SAID THAT WHILE DRIVING VEHICLE SPUTTERED AND STALLED. THE CALLER SAID THAT WHEN THE PROBLEM STARTED IT WOULD HAPPEN ABOUT ONCE A WEEK, AND IT GOT PROGRESSIVELY WORSE. IT WOULD STALL APPLYING THE BRAKES. HE SAID THIS PROBLEM MADE IT VERY HARD TO DRIVE IN DAILY TRAFFIC. THE CALLER WAS ABLE TO GET VEHICLE OFF THE ROAD. THEN, IT STARTED BACK UP. HE HAD THE ELECTRONIC THROTTLE MODULE REPLACED. DEALER SAID THE PROBLEM WAS COMMON IN THIS VEHICLE, AND THEY FIXED IT. MANUFACTURER SAID TO CALL DEALER. THE CALLER HAD THE PROBLEM FIXED ABOUT SIX MONTHS AGO. HE JUST WANTED TO LET NHTSA KNOW ABOUT THIS PROBLEM.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137903September 27, 2005
ELECTRICAL SYSTEM
CAR WAS RACING AND STALLING ON HIGHWAY AND WHILE IDLING. TOOK IT IN AND DIAGNOSTIC CODES IDENTIFIED A FAULTY MASS AIR FLOW SENSOR AND ELECTRONIC THROTTLE MODULE/RELOAD AND THROTTLE BODY. CAR HAS 48,800 MILES ON IT. THESE REPAIRS COST OVER $1400. PLEASE HAVE VOLVO LOOK INTO THIS AND A RECALL IS JUSTIFIED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137929September 27, 2005
FUEL SYSTEM, OTHER
VOLVO 2000 S-80 2.9 105,000 MILES 1. STALLING, LACK OF ACCELERATION, HESITATION AT HIGHWAY SPEEDS AND AROUND TOWN 2. COMPLETE SHUT DOWN OF ENGINE AT SPEED ON ROUTE 95 DURING RUSH HOUR 3. THROTTLE MODULE REPLACED AT A COST $1200.00 TASCA VOLVO STATED I REPLACE DOZENS OF THESE. THE MANUFACTURER KNOWS ABOUT THE PROBLEM AND DOES NOTHING. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137611September 26, 2005
VEHICLE SPEED CONTROL
DT: WHILE DRIVING AT 65 MPHICLE STALLED/HESITATED, AND OPERATED AT REDUCED SPEED OF 20 MPH. THE THROTTLE MODULE MALFUNCTIONED, CAUSING THE VEHICLE TO STALL. THE THROTTLE MODULE WAS REPLACED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137671September 26, 2005
ELECTRICAL SYSTEM:IGNITION:MODULE
VEHICLE SURGES IN RPM WHILE DRIVING,VEHICLE STARTED BY NO ACCELERATION WARNING LIGHT ON ENGINE MALFUNCTION. SHUT OFF WHILE DRIVING. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137697September 26, 2005
FUEL SYSTEM, GASOLINE
I OWN A 2001 VOLVO S 80. IT DIED ON THE HIGHWAY IN THE MIDDLE OF BUSY RUSH HOUR TRAFFIC. HAD IT TOWED TO VOLVO AND REPAIRED. NEED A NEW THROTTLE BODY AND MASS AIR FLOW SENSOR. VERY EXPENSIVE REPAIR AND WAS TOLD OFF THE RECORD THAT THIS PART FAILURE HAS BEEN MUCH MORE COMMON THAN IT SHOULD BE. I AM NOTIFYING YOU SO THAT YOU WILL LOOK INTO MANNER. SEEMS THIS SHOULD BE A RECALL ITEM. THANK YOU. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S80