Volkswagen · Model Report
Showing safety data for the 2004 model year only.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
DRIVING MY 2004 VOLKSWAGEN BEETLE IS DANGEROUS. THE TIPTRONIC TRANSMISSION IN THE 2004 VW BEETLE IS KNOWN BY VOLKSWAGEN TO BE DEFECTIVE. AT ANY POINT THE VALVE BODY CAN FAIL, WHICH CAUSES DELAYED SHIFTING, AND HARD JERKING BETWEEN GEARS. MY 2004 BEETLE FAILS TO SHIFT WHEN ACCELERATING BETWEEN 2ND AND 3RD GEAR. THIS CAUSES THE VEHICLE TO COAST FOR SEVERAL SECONDS, SOMETIMES REQUIRING PULLING OFF THE ROAD BECAUSE OF TRAFFIC. WHEN DOWNSHIFTING IT JERKS EXTREMELY HARD. YOU GET IN, START THE ENGINE, AND RECEIVE NO WARNINGS THAT ANYTHING IS WRONG WITH THE VEHICLE. NO CHECK-ENGINE LIGHT PROVIDES ANY INDICATION THAT THE VEHICLE IS DANGEROUS. YOU DRIVE DOWN SOME CITY STREETS AND HOP ONTO THE FREEWAY TO GO TO YOUR FAVORITE GROCERY STORE. AFTER GETTING OFF THE FREEWAY THE CAR IS FULLY WARMED UP, AND AS IT DOWNSHIFTS FROM 4TH TO 3RD GEAR IT LURCHES. IT FEELS LIKE THE ENGINE IS TRYING TO JUMP OUT OF THE CAR! NO ENGINE LIGHT COMES ON. THEN YOU STOP AT THE END OF THE OFF-RAMP, AND WAIT FOR A TRAFFIC LIGHT TO TURN. AFTER TURNING THE CAR SHIFTS FROM 1ST TO 2ND GEAR. THEN IT FAILS TO SHIFT FROM 2ND TO 3RD GEAR. THE GEAR DOESN'T ENGAGE, AND THE CAR COASTS DOWN THE ROAD WITHOUT ANY POWER. DRIVERS PASSING BY ARE STARING. THE SUV BEHIND YOU IS RIGHT ON YOUR BUTT; THEY BEGIN HONKING. THERE'S NOTHING YOU CAN DO. FINALLY, AFTER 20 SECONDS OF COASTING THE CAR ENTERS 3RD GEAR WITH A GIANT LURCH. IT FEELS LIKE IT'S GOING TO EXPLODE! YOU PULL INTO THE GROCERY STORE PARKING LOT, HEART RACING, KNOWING THAT THE CAR YOU'RE DRIVING ALMOST CAUSED AN ACCIDENT THAT COULD KILL A HALF A DOZEN PEOPLE. AND YOU KNOW TO GET HOME IT'S GOING TO HAPPEN ALL OVER AGAIN. THIS PROBLEM IS REPORTED BY HUNDREDS OF OWNERS. THIS IS AN EXTREME SAFETY HAZARD. VOLKSWAGEN NEEDS TO RECALL THE AFFECTED VEHICLES AND PAY DAMAGES FOR THOSE WHOSE TRANSMISSIONS WERE DESTROYED BY THIS DEFECTIVE VALVE BODY AND TRANSMISSION.
No injuries · No fire · No crash
AIR BAG LIGHT NEVER GOES OFF, STARTED AT 33650 MILES, RIGHT AFTER MY MOM SIGNED OVER THE CAR TO ME.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ILLUMINATED FOR TWO MONTHS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR WHICH WAS A PART OF THE DRIVER'S FRONTAL SEAT BELT SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE PART NEEDED FOR THE REPAIR WAS ON BACK ORDER. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.
No injuries · No fire · No crash
AIR BAG LIGHTS ON AND SEEMS THE DEALER CANNOT GET PARTS TO FIX ??
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE BATTERY AND ABS INDICATORS ILLUMINATED AND THE VEHICLE DOWNSHIFTED INTO FIRST GEAR. THE VEHICLE SEIZED AND WAS MOVED TO THE SIDE OF THE ROAD. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRE HARNESS FAILED AND NEEDED TO BE REPLACED. THE FUSE BOX WAS REPLACED THREE TIMES, BUT THE FAILURE RECURRED. LEITH VOLKSWAGEN OF CARY (2300 AUTOPARK BLVD, CARY, NC 27511, (919) 842-5624) AND THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.
No injuries · No fire · No crash