Volkswagen Beetle Complaints (2004)

349 consumer complaints on file.

#11415125May 4, 2021
FUEL/PROPULSION SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
DRIVING MY 2004 VOLKSWAGEN BEETLE IS DANGEROUS. THE TIPTRONIC TRANSMISSION IN THE 2004 VW BEETLE IS KNOWN BY VOLKSWAGEN TO BE DEFECTIVE. AT ANY POINT THE VALVE BODY CAN FAIL, WHICH CAUSES DELAYED SHIFTING, AND HARD JERKING BETWEEN GEARS. MY 2004 BEETLE FAILS TO SHIFT WHEN ACCELERATING BETWEEN 2ND AND 3RD GEAR. THIS CAUSES THE VEHICLE TO COAST FOR SEVERAL SECONDS, SOMETIMES REQUIRING PULLING OFF THE ROAD BECAUSE OF TRAFFIC. WHEN DOWNSHIFTING IT JERKS EXTREMELY HARD. YOU GET IN, START THE ENGINE, AND RECEIVE NO WARNINGS THAT ANYTHING IS WRONG WITH THE VEHICLE. NO CHECK-ENGINE LIGHT PROVIDES ANY INDICATION THAT THE VEHICLE IS DANGEROUS. YOU DRIVE DOWN SOME CITY STREETS AND HOP ONTO THE FREEWAY TO GO TO YOUR FAVORITE GROCERY STORE. AFTER GETTING OFF THE FREEWAY THE CAR IS FULLY WARMED UP, AND AS IT DOWNSHIFTS FROM 4TH TO 3RD GEAR IT LURCHES. IT FEELS LIKE THE ENGINE IS TRYING TO JUMP OUT OF THE CAR! NO ENGINE LIGHT COMES ON. THEN YOU STOP AT THE END OF THE OFF-RAMP, AND WAIT FOR A TRAFFIC LIGHT TO TURN. AFTER TURNING THE CAR SHIFTS FROM 1ST TO 2ND GEAR. THEN IT FAILS TO SHIFT FROM 2ND TO 3RD GEAR. THE GEAR DOESN'T ENGAGE, AND THE CAR COASTS DOWN THE ROAD WITHOUT ANY POWER. DRIVERS PASSING BY ARE STARING. THE SUV BEHIND YOU IS RIGHT ON YOUR BUTT; THEY BEGIN HONKING. THERE'S NOTHING YOU CAN DO. FINALLY, AFTER 20 SECONDS OF COASTING THE CAR ENTERS 3RD GEAR WITH A GIANT LURCH. IT FEELS LIKE IT'S GOING TO EXPLODE! YOU PULL INTO THE GROCERY STORE PARKING LOT, HEART RACING, KNOWING THAT THE CAR YOU'RE DRIVING ALMOST CAUSED AN ACCIDENT THAT COULD KILL A HALF A DOZEN PEOPLE. AND YOU KNOW TO GET HOME IT'S GOING TO HAPPEN ALL OVER AGAIN. THIS PROBLEM IS REPORTED BY HUNDREDS OF OWNERS. THIS IS AN EXTREME SAFETY HAZARD. VOLKSWAGEN NEEDS TO RECALL THE AFFECTED VEHICLES AND PAY DAMAGES FOR THOSE WHOSE TRANSMISSIONS WERE DESTROYED BY THIS DEFECTIVE VALVE BODY AND TRANSMISSION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11352371August 31, 2020
AIR BAGS
AIR BAG LIGHT NEVER GOES OFF, STARTED AT 33650 MILES, RIGHT AFTER MY MOM SIGNED OVER THE CAR TO ME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11297990January 8, 2020
AIR BAGS
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ILLUMINATED FOR TWO MONTHS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR WHICH WAS A PART OF THE DRIVER'S FRONTAL SEAT BELT SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE PART NEEDED FOR THE REPAIR WAS ON BACK ORDER. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268768October 15, 2019
AIR BAGS
AIR BAG LIGHTS ON AND SEEMS THE DEALER CANNOT GET PARTS TO FIX ??
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11231906July 15, 2019
ELECTRICAL SYSTEM, POWER TRAIN
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE BATTERY AND ABS INDICATORS ILLUMINATED AND THE VEHICLE DOWNSHIFTED INTO FIRST GEAR. THE VEHICLE SEIZED AND WAS MOVED TO THE SIDE OF THE ROAD. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRE HARNESS FAILED AND NEEDED TO BE REPLACED. THE FUSE BOX WAS REPLACED THREE TIMES, BUT THE FAILURE RECURRED. LEITH VOLKSWAGEN OF CARY (2300 AUTOPARK BLVD, CARY, NC 27511, (919) 842-5624) AND THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11230138July 8, 2019
ENGINE, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT A SLOW RATE OF SPEED, THE CONTACT SMELLED BURNING RUBBER AND THE VEHICLE'S RADIO STOPPED WORKING. AS THE CONTACT PROCEEDED DRIVING, SEVERAL UNKNOWN WARNING INDICATORS BEGAN FLASHING. THE CONTACT STATED THAT THE VEHICLE SHUT COMPLETELY OFF. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC. THE MECHANIC WAS ABLE TO DIAGNOSE THE VEHICLE AND HAD THE FUSE BOX REPLACED, YET THE FAILURE STILL PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11220226June 14, 2019
ENGINE, UNKNOWN OR OTHER
WHEN DRIVING THE CAR SHUTS OFF IN TRAFFIC IN TOWN AND ON THE HIGHWAY. 2 TIMES NO CHECK ENGINE LIGHT CAME ON. ONE TIME LIGHT CAME ON. MECHANIC IS NOT SURE WHY. I HAVE READ SEVERAL SIMILAR OCCURANCES ONLINE BY OTHER OWNERS. SOUNDS LIKE A RISK FOR FATALITY TO ME. MY DAUGHTER JUST BOUGHT THIS CAR FROM ANOTHER PARTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11164006December 29, 2018
POWER TRAIN
2004 BEETLE WITH 85,000 MILES HARD SHIFTING DOWN - IT JERKS FROM GEAR TO GEAR UNTIL IT COMES TO FULL STOP. . NOW WHILE UPSHIFTING IT COULDN'T MAKE IT OUT OF 3RD GEAR AND HAVE ALMOST BEEN REAR ENDED 3 TIMES. CAR JERKS ,SHUDDERS, LURCHES . TRANSMISSION PROBLEM IS CONSISTENT WITH LOW MILEAGE VW BEETLES
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11161757December 15, 2018
ENGINE, UNKNOWN OR OTHER
I BOUGHT MY VW BEETLE 2004 USED 3 MONTHS AGO. (EPC LIGHT ON, CHECK ENGINE LIGHT ON) SINCE THEN IVE HAD TO FIX THE TIMING BELT, COOLING, AND HOSES BECAUSE OF BACKFIRE. I GOT NOTIFIED THAT THERE IS A RECALL IN MY CAR, YET WENT TYPING THE VIN # IT SAYS IT NO RECALLS HAVE BEEN FOUND FOR MY CAR. I HAVE DOCUMENTATION TO SHOW THE REPAIRS AND COSTS. I'M WONDERING WHO DO I CONTACT TO DETERMINATE IF MY CAR DOES HAVE A REAL OR NOT.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11151369November 13, 2018
SEATS
THE PASSENGER FRONT SEAT HEATER WAS LEFT ON POWER LEVEL 3 WITH A BAG OF CLOTHES IN THE SEAT. AN ODOR WAS DETECTED AND UPON MOVING THE BAG, AN APPROXIMATELY 6' X 10' BURN WAS DISCOVERED ON LOWER PORTION OF THE SEAT BACK.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11093711May 14, 2018
POWER TRAIN
I BOUGHT THE NEW BEETLE NOT EVEN A MONTH AND I NOTICED A JERKING IN THE TRANSMISSION. I FOUND OUT USING SPECIALIZED WEBSITES FOR ENTHUSIASTS THAT VOLKSWAGEN ISSUE LETTERS TO OWNERS OF NEW BEETLES IN 2010 INFORMING THAT TONS OF OWNERS COMPLAINED ABOUT THE HARD SHIFT THEY WERE EXPERIENCING IN THE AUTOMATIC TRANSMISSION OFTHEIR NEW BEETLE. VOKSWAGEN OFFERED TO EXTEND THE WARRANTY ON THE TRANSMISSION VALVE BODY. THE MODELS AFFECTED SPANS FROM 2003 TO 2008. IN OTHER WORDS, VOLKS SOLD FAULTY CARS WITHING THIS TIME RANGE AND ONLY RECOGNIZED LATER IN 2010 ABOUT THE ISSUE. HOWEVER, THE VALVE BODY FAILURE IN THE TRANSMISSION IS ACROSS THE BOARD AND A RECALL SHOULD HAVE BEEN ISSUED FOR THE RANGE OF 2003-2008. THE COMPONENT WAS DESIGNED TO FAIL BY DESIGN. NOT EVEN THE REPLACEMENT WOULD FIX IT BECAUSE IT WOULD HAPPEN AGAIN. IMAGINE THE DANGER WHEN THERE IS A HARD-SHIFT AND THE CAR STARTS TO JERK AND CHANGING GEARS ERRATICALLY ? IMAGINE THIS HAPPENING ON I95 OR ANY OTHER HIGHWAY. VW JUST EXTENDED THE WARRANTY BUT A RECALL IS NEEDED HERE. I CALLED VW AND THEY ARE REFUSING TO FIX IT SAYING IT IS AN OLD CAR AND WARRANTY IS EXPIRED, BUT THE TRUTH IS SINCE 2003 THE HARD SHIFT CONDITION EXISTED. IT TAKES TIME FOR THE VALVE BODY TO FAIL BUT IT WILL FAIL. I HAVE OTHER CARS, BUT WHEN I NOTICED THE JERK I INVESTIGATED. I ATTACHED THE LETTER THAT I OBTAINED FROM THE NEW BEETLE.ORG SITE AND THERE THERE IS A DETAIL EXPLANATION HOW THE AUTOMATIC TRANSMISSION WILL FAIL DUE TO THE DESIGN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11083941April 9, 2018
FUEL/PROPULSION SYSTEM
FEUL LEAK, REAR PASSANGER SIDE RIGHT. SAME SIDE THAT THE FUEL FILL IS ON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11066820February 3, 2018
ELECTRICAL SYSTEM
THE FUSE BOX IS BURNING BECAUSE SOME CABLES ARE TOO SMALL AND ACCORDING TO THE MECHANICS, IT IS SOMETHING EXTREMELY COMMON BUT ACCORDING TO ME, IT IS NOT SUPPOSED TO HAPPEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11043985November 6, 2017
ELECTRICAL SYSTEM
CONTINUED HEADLAMP FAILURE RE: HEADLAMP COVER GLASS / LEXAN COMES OFF AND FLYS OFF OF CAR. SEVERAL OWNERS REPORT SAME PROBLEM. CREATES HAZERDOUS DEBRIS WHEN IT HAPPENS ON HIGHWAY AND ALSO EXPOSES HEADLAMP LIGHTS DIRECTLY TO WEATHER AND CAUSES FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11031424October 2, 2017
POWER TRAIN
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE FELT AS IF IT WERE IN NEUTRAL. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, PLACED THE GEAR SHIFTER IN PARK AND THEN BACK INTO DRIVE, AND WAS ABLE TO RESUME DRIVING. THE CONTACT STATED THAT SHE HAD TO REPEAT THE SAME PROCEDURE FIVE TIMES UNTIL SHE REACHED HER DESTINATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO PERRYSBURG AUTO MALL (26875 N DIXIE HWY, PERRYSBURG, OH 43551, PHONE NUMBER: (419) 874-4331) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11014835August 12, 2017
AIR BAGS, ELECTRICAL SYSTEM
VW CHECK ENGINE LIGHT ON, OBD SENSOR PORT NOT READING, BATTERY LIGHT CAME ON, AND ABS LIGHT CAME ON, NOW RADIO IS GOING ON AND OFF. STARTED YESTERDAY MORNING,WHILE DRIVING TO WORK THE ABS STARTED AFTER WORK ON THE WAY HOME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10986055May 16, 2017
POWER TRAIN
THE GEARBOX SLIPS, STUTTERS AND JERKS . AND WILL SLIP OUT OF GEAR AND NOT GO BACK IN GEAR UNTIL ENGINE IS RESTARTED. THIS HAPPENS WHEN STARTING TO MOVE FROM A STOP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10935569December 15, 2016
UNKNOWN OR OTHER
WINDOW REGULATORS ARE EASY TO BREAK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10926488November 16, 2016
POWER TRAIN
TRANSMISSION LOCKS UP, NOISY UPSHIFT AND DOWNSHIFTS. WHILE DRIVING UNPREDICTABLE GEAR SHIFTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10898011August 23, 2016
AIR BAGS
AIR BAG LIGHT CAME ON LAST YEAR, RESOLVED. BACK ON, I SEE OLD RECALL? WHAT TO DO?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Beetle