Ram 3500 Complaints (2022)

187 consumer complaints on file.

#11689660September 25, 2025
STEERING
The contact owns a 2022 Ram Promaster 3500. The contact stated that while driving approximately 60 MPH, the steering wheel malfunctioned and jerked out of his hands and became difficult to turn in either direction. The vehicle was taken to the local dealer who diagnosed that the steering rack and steering rack wiring harness was faulty and needed to be replaced. The steering rack and steering rack wiring harness were replaced, and the vehicle was repaired. The contact stated that the vehicle had previously experienced the failure, and the steering rack wiring harness was replaced, but the failure reoccurred. The manufacturer was not yet contacted. The failure mileage was 60,910.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687508September 16, 2025
POWER TRAIN
While driving on interstate leaving a construction zone started to accelerate to maybe 40mph and heard/felt a hard clang and lost all forward motion costed to side of interstate. Looked underneath truck, nothing visible broken or leaking. Restarted truck tried to move forward with no luck. Reverse worked, put back in drive loud noise again stomped on the accelerator and started moving forward very slow and difficult. Made it to an exit to look at things in a safer location than the busy interstate. Figured out that I had reverse and 5th gear so it was very hard/ slow to get moving. Check engine light on, gear ration incorrect, code P0731, Tran sensor failure, no 4x4 Transmission failure 1-4 gears not working
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680975August 15, 2025
STEERING
The contact owns a 2022 Ram 3500. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the electric power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. The contact was able to pull over to the shoulder of the roadway, where the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the wiring harness connector due to water intrusion, resulting in damages to the electric power steering control module. The contact was informed that the connector seal had failed to prevent the entrance of water leading to water damage. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672202July 9, 2025
POWER TRAIN
The transmission in my vehicle failed suddenly on May 31, 2025, entering “limp mode” and losing the ability to shift properly. The vehicle became immobile and was towed to the dealership. Initial diagnostics revealed difficulty shifting between 3rd and 4th gears. Service technicians attempted repair in June based on RAM TSB MC-10231775, which indicated snap ring failure in the Aisin transmission. Repairs prescribed in TSB were attempted but unsuccessful, as the vehicle still could not shift into 4th gear. Additional parts were ordered, and another repair was unsuccessfully attempted in late June. Ram has shipped a new transmission which we are waiting on the dealership to install.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667995June 19, 2025
FUEL/PROPULSION SYSTEM
My 2022 RAM 3500 has repeated failures of the diesel particulate filter (DPF) system. The truck enters limp mode unexpectedly, including while towing on the interstate, creating a serious safety hazard due to sudden loss of power. Since purchasing the vehicle, I have experienced ongoing issues with the emissions system, specifically related to the DPF. The check engine light comes on frequently, and diagnostic scans consistently show code P2459 (Diesel Particulate Filter Regeneration Frequency Too High). The DPF system has been replaced approximately five times by authorized RAM dealer. Despite these repairs, the same problem continues to occur. The truck will sometimes enter limp mode without warning, drastically reducing engine power. This has happened while towing a camper on the interstate, making it difficult or impossible to maintain safe highway speeds or accelerate when needed. This puts me, my passengers, and other motorists at risk of a crash, particularly when merging or changing lanes in fast-moving traffic. I have already pursued and settled a claim with Stellantis (RAM’s manufacturer) for $10k due to these issues. However, the problem persists, and the root cause has not been resolved. Accepting the settlement was recommended by legal counsel. The failure has occurred on multiple occasions (at least five separate incidents). The vehicle has undergone several service visits and emissions system replacements, but the safety issue continues. Current mileage 42,000. Dates of incidents from most recent: 6/25 (still in shop), 3/25, 9/24, 8/24,7/24,6/24,4/24,1/24,7/23,6/23,11/22. Documentation available upon request. Diesel particulate filter (DPF) system replaced approximately five times. I believe there is a defect in the design or operation of the emissions system that poses a safety risk. Loss of power while driving at highway speeds or towing creates a dangerous situation. I am reporting this in hopes that NHTSA will investigate this recurring issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666682June 13, 2025
POWER TRAIN
Transmission failure while driving not allowing to go in park after we got stopped. Truck un operable to get out of traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666415June 11, 2025
AIR BAGS
The contact owns a 2022 RAM 3500. The contact stated while her husband was driving at 65 MPH, coming to a stop the brake pedal was depressed however the vehicle failed to stop in a timely manner rear ending the vehicle in front of him. The contact stated that no air bags deployed. The contact stated that her husband sustained injuries to his shoulders and his head. The vehicle was towed to caliber consultation auto shop. Medical attention was required. The contact stated that a police report was filed. The contact mentioned the vehicle has not been deemed a total by her insurance company yet. The contact stated that the failure was not diagnosed by a dealer or independent mechanic. The manufacturer was not notified of the failure. The approximate failure mileage was 70,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11665229June 6, 2025
VISIBILITY/WIPER
The contact owns a 2022 Ram 3500. The contact stated while driving approximately 65 MPH during the rain, the windshield wipers suddenly failed to operate as needed. The vehicle was taken to the dealer who diagnosed that the park switch wiring had failed. The wiring was replaced; however, the failure remained. The dealer determined that the Variable Cylinder Management (VCM) had failed and DTC: B2303/11; was retrieved. The contact stated that the VCM was repaired; however, the failure remained. The manufacturer was not informed of the failure. The failure mileage was approximately 161,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657841April 30, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2022 Ram 3500. The contact stated while driving 40-45 MPH and hauling a 14-ft loaded trailer, the engine made an abnormally loud knocking sound. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the residence, where a mobile independent mechanic diagnosed that the grid heater nut had melted and entered cylinder #6. The vehicle was then towed to the dealer, where it was diagnosed that the grid heater nut failure had caused catastrophic failure of the pistons, turbo charger, and engine. The dealer determined that the engine assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the repair could not be covered under warranty due to the mileage on the vehicle. The failure mileage was approximately 112,700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649162March 19, 2025
SERVICE BRAKES
Trailer brake controler will report not connected when it is connected correctly. Systemm was tested and everything on the trailer is working properly. system was working corretly and suddenly stopped when on the interstate. Have had multiple shops look at the issue and no one can locate the issue. The radio/infotanment system will also disconnect radomly. Both act like a wire is lose. disconnect then reconnect and disconnect and reconnect, over and over. The radio disconnecting from the phone is an issue however not a safety concern like the trailer brake issue is. When I am pulling a 16,000 pound camper and the trailer brake stops that means I no longer have traler brakes and that can be an issue when stopping.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647720March 11, 2025
STEERING
The contact owns a 2022 Ram 3500. The contact stated that while driving on a main street at 10 MPH and attempting to make a turn, the vehicle experienced a loss of steering. The contact stated that the steering linkage had disconnected. The contact stated there was a clunking sound underneath the vehicle. There was no warning light illuminated. Upon inspection, the contact noticed that a bolt securing the steering rod to the steering linkage had detached. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the steering linkage had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 42,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645431February 27, 2025
ENGINE, FUEL/PROPULSION SYSTEM
Driving on highway 02/24/2025 approximately 07:15 pm EST at 65 mph, vehicle began Diesel DPF automatic regeneration cycle. Strong smell of "burning trash" and fuel vapor entered cabin with windows up. this happens frequently
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643701February 19, 2025
STEERING:STEERING WHEEL /HANDLE BAR:HAND HEATER/COOLER
The contact owns a 2022 Ram 3500. The contact stated that while driving at an undisclosed speed with the heated steering wheel feature activated, the steering wheel became extremely hot; making the vehicle difficult to maneuver because the contact was only able to hold the steering for several seconds while driving. The contact stated that the steering wheel was replaced a year prior due to a separate failure. No warning lights were illuminated. The vehicle was taken to the dealer, who observed that the steering wheel reached temperatures of more than 120-145 degrees. However, after consulting with the manufacturer, the dealer informed the contact that the feature was operating as intended and within specifications. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643337February 18, 2025
ENGINE, FUEL/PROPULSION SYSTEM
Emission system failure. Code P2459 Regeneration Frequency. Overheating of the DPF while stuck in regen cycle causes burning smell and diesel fumes in the cabin while driving. Suspected vehicle on fire. Date of incident 01/25/2025. Vehicle at dealership for repair 01/28/2025. Dealership repair unsuccessful following STAR approved process of elimination. Vehicle returned to dealer 02/18/2025 for same issue. Many customers with 2019-2022 diesel engines having same issue. No known fix according to dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643037February 16, 2025
SERVICE BRAKES
Intermittent fault causing ELECTRONIC STABILITY CONTROL (ESC), SERVICE BRAKES, cruise control, to disable while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11636173January 15, 2025
TIRES
Firestone trans force Ht. 275/70R18 These tires came from factory on my Dodge Ram. The truck is around two years old and only with 13,500 miles on it. All four tires are failing and cracking on the side walls. I know earlier models of the same exact tire was recalled for the same issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629425December 7, 2024
SERVICE BRAKES
Intermittent abs and traction control alarm. Very random and can come on without notice. Similar issue to the recall issued in September for the 1500 ram.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627002November 23, 2024
SERVICE BRAKES
Started getting an alarm for abs and traction control alarm with 15000 miles, it would come and go every few thousand miles. Truck now has 44000 miles and the alarm has appeared twice in the past 4000 miles. This almost caused an accident as it disables the abs at any given time. The dealer says it is the Hydraulic Control Unit.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625823November 18, 2024
SERVICE BRAKES
ABS LIGHT IS ON I HAVE A PROBLEM WHIT THE ABS MODULE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11624859November 12, 2024
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
On 9 September, while driving, I got an emergency dashboard notice that stated Throttle System Malfunction contact dealer. It went out and then another immediately flashed that stated Exhaust System Malfunction contact dealer. The vehicle lost power within seconds after the second notice. I coasted to a stop on the side of the road. Once stopped, smoke quickly started coming out of the engine compartment and then flames. I contacted 911, an engine arrived but the truck was fully engaged and completely burnt.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Ram 3500