Ford F-250 Complaints (2025)

17 consumer complaints on file.

#11768612October 2, 2026
SEATS
During collision seat did not retain its upright position and collapsed/reclined backwards fully.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11766040September 22, 2026
UNKNOWN OR OTHER
Driving for 10 minutes when I started smelling a burnt smell. 30 to 45 seconds later I noticed smoke coming out the vents. A few seconds later (while at a stop sign at this point) I see smokecoming out of the hood. Vehicle would not go into park. After several attempts I finally was able to get the vehicle in park and get it to shut off. Opened the hood, saw a small 1 inch flame behind the motor near the firewall on the driversside and immediately called the fire department or emergency responders. Within 3 mins my vehicle was up in flames for a catastrophic vehicle loss.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11746408June 25, 2026
EXTERIOR LIGHTING
For years FORD vehicles, especially pickup trucks, have blinded drivers with their improperly adjusted headlights; because FORD gives incorrect instructions to adjust them. I refer to page 474 of the 2025 Superduty owners manual as evidence. The instructions FORD gives are to set the low-beam LEVEL, shinning the beam onto a vertical surface 25 feet from the vehicle with the beam at the same height as the headlight on the truck. This is incorrect. There should be at least a 3 inch drop of the low-beam at 25 feet. If there is no drop of the tall truck's headlight (the F-250 stock ride height of the headlight is 44 inches above the ground) it will always blind other drivers of cars/sedans--especially via the outside mirrors. This problem has become acute now that the extra bright LED headlights are becoming the norm; making two-lane roads on a rainy night a truly blinding experience. Please require FORD to correct their dangerous mistake.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743654June 12, 2026
STEERING, SUSPENSION
The contact owns a 2025 Ford F-250. The contact stated that while driving at various speeds, the steering wheel inadvertently turned to the right, then pulled to the opposite direction. The contact stated the steering wheel was cocked to the left or right even though the vehicle was driving straight down the road. There was no warning light illuminated. The contact stated the failure was due to the steering angle sensor. The vehicle was taken to the local dealer, where it was diagnosed that an alignment was needed. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, and a complaint was filed. The failure mileage was approximately 13.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725656March 19, 2026
SUSPENSION, STEERING
The contact was an insurance company that called on behalf of the previous owner. The contact's Insurance Company took possession of a 2025 Ford F-250. The contact stated that while driving at an undisclosed speed, a loud popping noise was heard coming from the vehicle with no warning lights illuminated. The contact stated that following the failure, the driver lost control of the vehicle, which resulted in a collision with another vehicle. The contact also stated that a tire unexpectedly detached from the vehicle during the incident. The vehicle then veered off the roadway and collided with a tree, where it came to a stop. No injuries were sustained, and no medical attention was required. A police report was filed. The contact confirmed that the air bags deployed during the crash. The vehicle was towed from the scene and deemed a total loss by the insurance company. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The contact mentioned that there was an unknown Ford recall regarding the suspension but was unable to reach Ford to confirm if the VIN was associated. The failure mileage was not available.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11718907February 18, 2026
SERVICE BRAKES
I have about 6,000 miles on the vehicle which was purchased new. There were 2 incidents prior to 2/15/26 (the 3rd incident), but it was only this 3rd incident whereby I could identify the problem. The 2 early incidents I only experienced the smell of burning rubber when driving and exiting the vehicle. Which, i couldn't fathom where it was coming from. And, there was probably a month between incidents. This latest 2/15/26 incident, I was driving and started smelling rubber again, but now I happened to have my fuel mileage indicator on and saw my fuel indicator drop from it's normal average of 17mpg to about 6 mpg. I immediately suspected the parking brake had independently engaged but there was no light or any indication of that on my dashboard screen. I pulled over, turned the engine off, got out and smelt strong scent of rubber burning. While standing next to the vehicle (the engine is off mind you) and making a note of this event on my phone, I heard hydraulics start and stop underneath the truck . That made me suspect the parking brakes even more. I got in, started up, and drove. All was back to normal, no more burning rubber or bad mileage. There's a software glitch PROBLEM here and I have to believe I'm not the only one! After this, I'll be reaching out to Ford to see what they're going to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714988February 2, 2026
UNKNOWN OR OTHER
I was driving down HWY 79 in South Dakota. It was 3:00 pm on Saturday Jan. 31st. Out of know where, with not a single vehicle within eyesight, my sunroof exploded. It sounded like a gun shot went off right above my head, and there was glass flying everywhere. This 100% was not due to another vehicle throwing an object up in the air. There was not another vehicle anywhere. After researching this on the internet, it seems this is a reoccurring issue with these Fords that Ford is not taking accountability for. I called the local dealer and was told it would not be covered under warrantee.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712085January 20, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS
The pre collision system on this truck is not working, dealer tried twice to fix it and says it is working, but they can’t test it and make it work in real word conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712143January 20, 2026
ELECTRICAL SYSTEM
The info system (Bluetooth) is not working and makes a high piercing noise. The vehicle is available for inspection upon request. The safety of others is at risk due to the fact that you can only use your phone in your hand in this vehicle. The state of South Carolina where this vehicle was purchased and used passed a law on September 1, 2025 (Hands-Free and Distracted Driving Act) banning handheld cell phone use. The vehicle has been to two different Ford dealerships and has been at the most recent since December 3, 20025 until present. The vehicle has been inspected with several attempts to repair without success.The problems started the first week of ownership with no prior warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709192January 6, 2026
SERVICE BRAKES
When backing up the brakes will lockup
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706147December 19, 2025
SERVICE BRAKES, STEERING
When I was pulling out of the gas station parking lot on Dec 15th, 2025, I pressed the gas and heard a noise that sounded like high RPMs. I then approached the intersection and attempted to press the brake and the brake would not press in, it was hard. My truck then continued to move forward. I attempted to turn the steering wheel as a truck was coming at me. The steering wheel would not turn or move at all. I was stuck in the middle of an intersection after it rolled to a stop. I turned on my flashers and looked at the dashboard to make sure my truck was in drive, which it was. A message was also displayed on the dashboard. It said accessory mode. I could hear my truck running. I cleared the message by pressing the ok button on the steering wheel. I put it in park and then into drive and the same message displayed again on the dashboard. I decided to turn off my truck and pressed the push button to turn it off (my foot was off the brake as I don’t need to press the brake to turn my truck off) and the starter engaged and I put the truck in drive and was able to press the brake and turn the steering wheel. I slowly drove the short distance home and called my husband which he instructed me to call Evansville Ford in Evansville, WI and had my truck towed there. Obviously, not having steering or brakes is a HUGE safety issue. Less than 24 hours earlier I had my entire family in that truck driving on the interstate. I can’t image that we would be alive if I had lost brakes and steering on the interstate. As of Dec 19th 2025, Evansville Ford has stated that they cannot find any issues, nor replicate the problem and returned my truck. My truck is currently available for inspection at my residence.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701374November 24, 2025
ELECTRICAL SYSTEM
The rearview camera intermittently blacks out when shifting into reverse and sometimes while driving forward. This occurs randomly and creates a serious safety hazard when backing up a large vehicle, as visibility is compromised. I have also experienced repeated warning messages stating, “Parking brake not fully functioning” and “Hill Start Assist not available, see dealer” These warnings appear in a barrage without cause and then disappear once vehicle is restarted, suggesting an electrical or software fault. I have multiple videos and pictures dated and timed as proof. I have taken the truck to the Ford dealer 3–4 times. Each time, the dealer states “no issue found” and has not provided a fix. The problem continues to occur despite these repair attempts. I have videos and pictures of these incidents. The upload system does not let me upload videos! The blackout of the rearview camera and false brake system warnings substantially impair the safe operation of the vehicle. Other Ford trucks have already been recalled for similar rearview camera defects, but my VIN is not included. Brenneman/Murphy Ford said a fix was coming in Q3, but here I am still waiting. I believe this defect should be investigated and addressed under recall or warranty coverage immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699631November 16, 2025
VISIBILITY/WIPER
Rear view camera system is intermittent and the dealer has been unable to resolve the issue. This is a large vehicle and it is very dangerous to back up without this camera working.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11685024September 4, 2025
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2025 Ford F-250 SD. The contact stated that while driving approximately 70-75 MPH, there was an abnormal sound coming from the sunroof, and the contact discovered that the sunroof glass had shattered. A dealer was contacted. The vehicle was taken to the dealer, and the contact was informed that the vehicle could be repaired; however, the vehicle had to be left with the dealer for seven to ten days. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 6,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675035July 21, 2025
SERVICE BRAKES
I purchased a brand-new 2025 Ford F-250 Super Duty on April 1, 2025. The truck has an intermittent and ongoing issue where the dashboard displays “Park Brake Limited Function” or “Park Brake Service Required.” I took the vehicle to the authorized Ford dealer, but they told me the problem cannot be repaired. However, when I contacted Ford corporate customer service, they claimed the issue is known and can be repaired, and referred me to safety department complain This contradiction between Ford and the dealer is unacceptable. The issue affects the functionality and safety of the vehicle, and it remains unresolved. I request that NHTSA investigate this issue and pressure Ford to provide a consistent, repairable solution
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673845July 15, 2025
STEERING, SUSPENSION
When driven the vehicle approximately 60 miles I had to fight to keep it on the road. Hoffman found suspension was out, the vehicle is chasing the road when driving highway speeds (I upload the findings). This started from the time I purchased the vehicle until now. I purchased the truck from Mark Ficken Ford Lincoln, 7601 South Blvd., Charlotte, NC on [XXX], and left for Middletown, CT the day after. I had to drive at a low speed to keep the Truck on the road. I didn't test drive it because it was new. It is still in the shop for the 3rd time for the same problem. It is not safe to drive. It is dangerous for me and others. The shop does not seem to know how to fix the problem. Ford Motor Company has been notified but has not corrected the problem. I took it to Hoffman Ford in CT and it is there now. The Truck has been in the shop more than I use it. The first two times it was in the shop, they didn't even authorize a rental vehicle for me to drive. It's in the shop now and they did authorize a rental this time. The case # with Ford Motor Company is [XXX], Melanie Krupa, case manager, phone 866-631-3788 ext.79412 email: [email protected]. I uploaded the bill of sale, finance agreement and the repair statements from Hoffman. I greatly appreciate your help. I am paying for a vehicle that is in the shop and is not safe to drive. Thank You INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673057July 12, 2025
SERVICE BRAKES
Trailer brake controller was at first intermittently failing with message “trailer disconnected” appearing on dashboard. Now > 2,000 miles trailer brakes are not working. Vehicle was updated with SSM 53889 which did not resolve the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250