Ford F-250 Complaints

11,199 consumer complaints on file.

#10162324July 13, 2006
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
THE CLUTCH HYDRAULICS SPONTANEOUSLY FAILED WHILE DRIVING IN TRAFFIC. ONE DAY THE CLUTCH WAS PERFECTLY NORMAL. THE NEXT DAY, I WAS DRIVING TO THE STORE AND THE CLUTCH PEDAL STUCK TO THE FLOOR A COUPLE TIMES. I HAD TO MANUALLY LIFT THE PEDAL. EVEN WITH THE PEDAL DEPRESSED, THE CLUTCH BEGAN TO ENGAGE. THERE IS NO EVIDENT LEAKAGE. THE VEHICLE HAS 90K MILES, MOSTLY HIGHWAY. I BELIEVE THIS HAPPENED AT AROUND 20K-30K MILES BUT CORRECTED ITSELF. I CAN'T FIND A RECORD OF THE REPAIR BUT NOW THAT IT IS HAPPENING AGAIN, I RECALL IT HAPPENING BEFORE. VEHICLE IS NOW IN SHOP. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162320July 13, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED THAT THE BRAKE FLUID LEAKED INTO THE SPEED CONTROL MODULE, CAUSING THE CRUISE CONTROL TO FAIL. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE PROBLEM WAS DETERMINED TO BE CAUSED BY THE SAME ISSUE THAT CAUSED NHTSA RECALL #05V388000, RELATING TO THE VEHICLE SPEED CONTROL. THE VIN WAS NOT INCLUDED IN THE RECALL. UPDATED 8/16/2006 - THE VEHICLE WAS REPAIRED ON 7/14/2006. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162191July 12, 2006
SUSPENSION:FRONT
DT*: THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STARTED TO SHAKE UNCONTROLLABLY. THE SHAKING WAS CENTERED IN THE STEERING COLUMN. THE SHAKING CAUSED A LOSS OF CONTROL OF THE VEHICLE, NEARLY CAUSING A COLLISION. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE WHEEL BEARING WAS CHANGED. THE REPAIR, HOWEVER, DID NOT FIX THE PROBLEM.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162256July 12, 2006
TIRES:TREAD/BELT
WHILE DRIVING AT APPROXIMATELY 60 MPH IN MY 2001 FORD F250 SUPER DUTY PICK UP TRUCK, THE TRUCK STARTED TO VIBRATE. I SHIFTED INTO NEUTRAL, THINKING IT MIGHT BE A U-JOINT OR DRIVELINE PROBLEM AND THE VIBRATION GOT WORSE. I WENT BACK INTO DRIVE AND IT SETTLED DOWN SOMEWHAT. I STOPPED AND LOOKED OVER THE TIRES, U-JOINTS (WHAT I COULD SEE OF THEM, THE TRUCK IS 4-WHEEL DRIVE) AND OTHER SUSPENSION COMPONENTS. I DID NOT NOTICE ANY LUMPS OR BUMPS ON ANY OF THE TIRES. I DECIDED TO RETURN HOME, A DISTANCE OF ABOUT 20 MILES. APPROXIMATELY 3 MILES FORM HOME, THE TRUCK SHOOK VIOLENTLY AND THEN THERE WAS A LOUD "SLAPPING" NOISE. I PULLED OVER AND SAW THAT I HAD SEPARATED A TREAD FROM THE RIGHT REAR TIRE. I PICKED UP THE SEPARATED TREAD AND DROVE HOME AT ABOUT 25 MPH. I CHANGED THE TIRE AT HOME. THE TIRE WAS INFLATED TO 55 PSI AND IS STILL HOLDING THAT PRESSURE. THE TIRE IS A FIRESTONE STEELTEX RADIAL A/T, LR E, DOT NUMBER VDW8 TXL 4400. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162143July 11, 2006
ENGINE AND ENGINE COOLING:ENGINE, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
2000 F250 SUPER DUTY...49,000 MILES #8 SPARK PLUG BLEW OUT @ 45 MPH.. LIMPED HOME....REMOVED HEAD....CRACKED....$300.00 FOR RECONDITIONED HEAD..... GASKETS, GOOP, TOOLS,BOLTS, FIXTURES..$600.00...........ABLE TO DO WORK MYSELF..LUCKY.....HELP FROM FORD..HA HA HA.... 80,000 MILES HEAD GASKET OTHER SIDE..ALREADY HAD TOOLS AND FIXTURES.... GUESS WHO GOT STUCK OUT IN THE COLD AGAIN.. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162167July 11, 2006
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM, ELECTRICAL SYSTEM:WIRING, POWER TRAIN:AUTOMATIC TRANSMISSION
I COULD HAVE BEEN KILLED. IN SEPT. 2005 I LEASED A F250 AND SINCE IT HAS GIVEN ME NOTHING BUT TROUBLE. EXHAUST PROBLEMS (3 TIMES FOR THAT) INJECTOR FAILED, MANY LITTLE BUGS THAT THE DEALER CANT FIX. ON 6-24-06 ON I-94 DOING A 65-68 MPH, THE ENGINE HESITATES FOR A SECOND THEN SUDDENLY THE WHEELS LOCKED UP AND I LOST CONTROL, SKIDDING ALMOST HITTING 3 OTHER CARS AND THE WALL ON THE SHOULDER. FINALLY AFTER STEERING TO THE SHOULDER - STOPPED AND BASICALLY HAD A PANIC ATTACK, SAW MY LIFE FLASH BEFORE MY EYES. SAT FOR A COUPLE MINUTES THEN GOT OUT TO LOOK AT THE WHEELS AND UNDER THE TRUCK FOR ANY CLUES AS TO WHAT HAD JUST HAPPENED. I START UP AND STROLL ALONG THE SHOULDER TO THE NEAREST EXIT THE TOW / HAUL LIGHT IS FLASHING ON AND OFF. DRIVE ABOUT 30 MPH ON A CITY ROAD WITH MY FLASHERS ON.. NOT BUT A 1/8 OF A MILE IT LOCKS UP AGAIN AND THEN FREES UP, AND ROLLS. I AM NOW FREAKING OUT. AND NOW THE ENGINE LIGHT IS ON . CALLED FORD ROADSIDE I AM A WRECK! I'LL NEVER PUT MY 4 MONTH DAUGHTER IN IT. FIRST DIAGNOSIS 3 DAYS LATER AFTER THE LOCK UP HAPPENED TO THE MECHANIC TEST DRIVING THE TRUCK THEY GUESS THE RANGE SENSOR IN THE TRANSMISSION AND TWO DAYS LATER CALLED TO TELL ME IT WAS READY. 1 HOUR LATER THE SERVICE TECH CALLED ,SAID WE NEED TO KEEP IT LONGER 2 WKS LATER THEY DIAGNOSE THAT A MAIN WIRING HARNESS WAS LEANING AGAINST THE EXHAUST AND BURNED UP SHORTING THE COMPUTER & TOLD THE TRANS TO SHIFT. I TOLD THEM I DO NOT WANT THE TRUCK. I DON'T FEEL SAFE AND WON'T RISK MY LIFE OR MY FAMILY. FORD LEGAL FINALLY CONTACTED THE DEALERSHIP AFTER MANY CONTACTS TO THEM AND UPON THEIR DECISION 3 WKS AFTER THEY TOWED IT I MUST ACCEPT THIS VEHICLE, BECAUSE IT IS "SUPPOSEDLY" FIXED. I FEEL THAT FORD IS NOT TAKING THIS CASE SERIOUSLY, AND I WONT FEEL SAFE DRIVING THIS TRUCK AGAIN. MY SERVICE DIRECTOR AMONG MANY OF THE SERVICE AGENTS AT THE DEALERSHIP AS WELL AS THE FORD FACTORY REP. SAY THAT THEY WOULD NOT FEEL SAFE DRIVING IN THIS TRUCK IF IT WERE THEIR TRUCK, AND WOULD NOT DRIVE IT. *JB
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10161968July 10, 2006
SUSPENSION
DT*: THE CONTACT STATED THE VEHICLE WEAVED WHILE DRIVING AT ANY SPEED. HOWEVER IT WORSENS AT HIGHER SPEEDS. THE DEALERSHIP INSTALLED NEW TIRES AND ALIGNED THE FRONT END, BUT THE PROBLEM STILL PERSISTED. THE DEALERSHIP ALSO INFORMED THE CONTACT THE BALL JOINTS WERE STUCK AND GREASE FITTINGS MIGHT HELP SOLVE THE WEAVING, BUT THIS REMEDY COULD NOT BE GUARANTEED. UPDATED *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161426July 5, 2006
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
WHEN I TOOK MY TRUCK IN FOR SERVICE, THE AUTO TECH NOTICED A FUEL LEAK NEAR THE FUEL FILTER. AGREEING WITH THE TECH THAT THE LEAK WAS FROM THE FILTER, I TOOK THE TRUCK HOME AND REPLACED THE FUEL FILTER. ON INSPECTION OF THE FILTER AFTER INSTALLATION, THE TRUCK STILL CONTINUED TO LEAK FUEL. I DETERMINED THAT THE LEAK WAS COMING FROM A FUEL RETURN LINE, AT A POINT WHERE THE LINE IS HELD IN PLACE BY A METAL TAB. I TOOK THE TRUCK IN TO THE REPAIR SHOP, WHERE THE EMPLOYEES AGREED THAT THE LEAK OCCURRED FROM THE METAL TAB WEARING A HOLE IN THE FUEL RETURN LINE. THE REPAIR THEN INVOLVED REPLACING THE ENTIRE FUEL LINE ASSEMBLY (WHICH INCLUDES BRAKE, FUEL, AND ANY OTHER LINES THAT RUN FROM THE ENGINE TO THE REAR OF THE VEHICLE) AVAILABLE ONLY FROM A DEALER. THE OLD LINES ARE AVAILABLE IF THEY ARE NEEDED. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161314July 3, 2006
STEERING:GEAR BOX:SHAFT SECTOR
DT*: THE CONTACT STATED WHILE DRIVING 35 MPH THE SECTOR SHAFT OF THE STEERING GEAR BOX SNAPPED OFF CAUSING THE VEHICLE TO LOSE POWER STEERING RESULTING IN A CRASH INTO AN EMBANKMENT. THIS CRASH CAUSED DAMAGE TO THE FRONT AND PASSENGER SIDE OF THE VEHICLE. THE CONTACT AND PASSENGER SUFFERED MINOR INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT BODY SHOP. UPDATED 7/21/2006 - *NM
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10161237July 2, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
THE CAM POSITION SENSOR ON FORD'S POWER STROKE DIESEL TRUCKS ARE KNOWN TO GO BAD. EVERYONE I KNOW THAT HAS ONE ... HAS HAD TO REPLACE IT. SOMETIMES MORE THAN ONCE. MINE HAPPENED TO GO OUT WHILE DRIVING DOWN THE ROAD AT 70 MILES PER HOUR. THIS IS NOT GOOD. IT CAN CAUSE SERIOUS ACCIDENTS. I'M JUST CONCERNED WITH THE SAFETY OF PEOPLE HERE. NOT ONLY THAT, BUT REPLACING THEM CAN GET EXPENSIVE. I BOUGHT A NEW SENSOR FROM INTERNATIONAL AND PAID ~$100 USD. I THINK SOMEONE NEEDS TO STEP UP TO THE PLATE AND FIX THE PROBLEM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161253July 2, 2006
TIRES:TREAD/BELT
TREAD SEPARATED FROM TIRE CAUSING A BIG DENT IN FENDER AND CAUSED ME TO LEAVE THE HIGHWAY AT A HIGH SPEED. THIS SEEMS TO BE THE SAME PROBLEM THAT FIRESTONE HAD WITH THEIR TIRES. I STILL HAVE THE TIRE IF YOU WOULD LIKE TO HAVE IT FOR STUDY (GENERAL TIRE). *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161204July 1, 2006
ELECTRICAL SYSTEM
VEHICLE SEEMED TO BE RUNNING FINE. PARKED IN MY DRIVEWAY AND 70 MINUTES LATER MY WIFE CAME HOME AND FOUND THE TRUCK ON FIRE. HEAVY FIRE WAS ENSUING FROM THE DRIVER SIDE WHEEL WELL AS WELL AS OUT THE FRONT DRIVER SIDE GRILL. *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10161126June 30, 2006
STEERING
DURING HIGHWAY DRIVING SPEEDS WHEN A SEAM IN HIGHWAY OR BRIDGE STAKES RIGHT TIRE THEN LEFT, STEERING WHEEL OSCILLATION CAUSES TEMPORARY LOSS OF CONTROL OF VEHICLE. AT NORMAL HIGHWAY SPEEDS 60-70 MPH THE VEHICLE DRIFTS OUT OF LANE AND TO CORRECT APPLYING THE BRAKES TO BELOW 50 MPH IS REQUIRED. ALL OF THESE ACTIONS CAUSE SAFETY ISSUES IN HEAVY TRAFFIC. REPAIRS WERE MADE ON 5/11/06 WITH FORD TSB 5-22-1 COMPLETED. RECURRENCE OF ORIGINAL SYMPTOMS RETURNED FOLLOWING WEEK ON 8 SEPARATE OCCASIONS DURING TRIP TO NC AND RETURN TO UPSTATE NY. ALL ON INTERSTATE HIGHWAYS. VEHICLE WAS RETURNED TO DEALER 6/28/06 AND ADDITIONAL REPAIRS WERE REQUIRED. STABILIZER WAS REPLACED DUE TO LEAKING FLUID SHOWING COMPONENT HAD FAILED UNDER CONDITIONS PRESENTED TO VEHICLE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161156June 30, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
VEHICLE - 2000 FORD F-250 4X4 7.3L DIESEL. CAMSHAFT POSITION SENSOR (CPS) WENT OUT CAUSING VEHICLE TO STALL AND NOT START AGAIN UNTIL PART WAS REPLACED. ENGINE TURNED OFF EXITING FREEWAY GOING APPROX 65 MPH. THIS IS THE THIRD CPS THAT HAS GONE BAD ON THIS VEHICLE. FIRST AT 38,000 MILES, SECOND AT 95,000 MILE, AND THIRD AT 159,000 MILES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161165June 30, 2006
FUEL SYSTEM, DIESEL, EQUIPMENT:MECHANICAL
MY 2004 FORD F250 SUPER DUTY DIESEL HAD ITS TURBO REPLACED IN MAY 2005-IT HAS BEEN IN AND OUT OF THE DEALERSHIP'S GARAGE ON AND OFF FOR THE LAST YEAR, STALLING OUT AT VARIOUS SPEEDS, WE CAN NOT TOW ANYTHING WITH OUT IT BLOWING BLACK SMOKE AND CUTTING OUT. I AM 1000 MILES FROM THE INITIAL WARRANTY THE MECHANIC'S HAVE NOT FIXED THE PROBLEM I LOCATED A NHTSA RECALL WHICH DESCRIBES THE PROBLEM TO THE TEE. FORD MOTOR COMPANY REPRESENTATIVES TOLD ME THAT MY VEHICLE'S VIN WASN'T INCLUDED IN THE RECALL SO I HAVE TO PAY OUT OF MY POCKET FOR THE CORRECTION. EVEN THOUGH I AM STILL UNDER WARRANTY, AND THE CONSEQUENCES OF SUMMARY STATES: IF THE ENGINE STALLS, A CRASH COULD OCCUR. WHICH COULD ENDANGER MY FAMILY AND POSSIBLY SOMEONE ELSE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160984June 28, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ELECTRICAL SYSTEM
TRAVELING AT NORMAL SPEED. THE ENGINE WOULD SHUT OFF, AS IF IT HAD RUN OUT OF FUEL.. AFTER DOING THIS THREE TIMES, I REPLACED THE CAM SHAFT SENSOR. I HAVE HAD NO PROBLEM SINCE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160735June 26, 2006
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
DT: THE CONTACT STATED ON JUNE 24, 2006 THE VEHICLE BATTERY LIGHT ILLUMINATED. WHEN THE DEALER WAS CONTACTED, THEY RECOMMENDED THE VEHICLE TO BE TOWED TO THE DEALERSHIP. THIS IS THE FOURTH TIME VEHICLE HAS BEEN TAKEN TO THE DEALER FOR ALTERNATOR. THE FIRST THREE TIMES, THE VEHICLE WOULD NOT START AND THE ALTERNATOR WAS REPLACED BY THE DEALER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160699June 25, 2006
ELECTRICAL SYSTEM
CAM SENSOR PROBLEMS 2001 F250 POWERSTOKE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160714June 25, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
AT HIGHWAY SPEED, 1999 FORD F250 4WD 7.3 DIESEL STALLED ON TWO OCCASIONS. I AM TOLD THAT THIS IS MOST LIKELY CAUSED BY A FAULTY CAMSHAFT POSITION SENSOR AND IS A VERY COMMON FAILURE WITH THIS ENGINE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160564June 23, 2006
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
DT: THE CONTACT STATED BOLTS THAT HOLD THE EXHAUST MANIFOLD FRACTURED. THE FRACTURED BOLTS WERE DISCOVER BY THE SERVICE DEALER WHILE PERFORMING OTHER MAINTENANCE WORK. THE DEALER ALERTED THE CONTACT THAT THIS IS A REOCCURRING PROBLEM WITH THE YEAR, MAKE AND MODEL OF THE VEHICLE. IN THE PAST ON THERE VEHICLES, STAINLESS STEEL BOLTS HAVE BEEN USED TO REMEDY THIS PROBLEM BUT THE PROBLEM REOCCURED. THE DEALER PLANS TO REINSTALL THE SAME TYPE OF BOLTS ORIGINALLY USED ON THE CONTACT'S VEHICLE. THE CONTACT PREDICTED THE PROBLEM WILL REOCCUR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250