Ford F-250 Complaints

11,199 consumer complaints on file.

#10189368May 1, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
CONCERNING: 2001 FORD F-250 7.3 DIESEL. FORD HAS PATTERN CAM POSITION SENSOR FAILURE THAT CAUSES ENGINE TO SHUT OFF WHILE TRAVELING AT SPEED. THIS RESULTS IN LOSS OF BRAKES AND STEERING. THE CAM POSITION SENSOR IN MY TRUCK FAILED WITH 75,00 MILES. FORD IS AWARE OF THIS PROBLEM BUT HAS DONE NOTHING TO RECTIFY THE CAUSE OF THE FAILURE. WHEN THE ENGINE SHUTS DOWN WITHOUT WARNING. IT'S VERY UNNERVING AND UNSAFE. DRIVING ON A CROWDED ROADWAY/FREEWAY WITH SUDDEN ENGINE SHUTDOWN AND LOSS OF POWER, BRAKES, AND STEERING IS FLAT OUT SCARY AND DANGEROUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189187April 29, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
2001 7.3 POWERSTROKE INTERMITTENTLY STALLS. THIS GOING TO GET SOMEONE KILLED. I HAVE BEEN TOLD THAT THIS IS A PROBLEM WITH THE CPS. WHEN THE ENGINE STALL I HAVE NO CONTROL OVER THE F250 SD CREWCAB CAN'T TURN CAN'T STOP UNTIL I RESTART THE ENGINE. I REPLACE THE CPS AND THIS HAS STOPPED FOR NOW UNTIL THIS CPS FAILS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189190April 29, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
DRIVING DOWN THE INTERSTATE AT POSTED SPEED LIMIT (65-70 MPH) THE TRUCK SHUT-OFF WITH NO WARNING LOOSING ALL POWER INCLUDING POWER BRAKES AND POWER STEERING. PULLED OVER TO THE SIDE OF THE ROAD, ATTEMPTED TO RESTART TRUCK AND IT DID. PULLED BACK OUT ONTO THE INTERSTATE AND AFTER A FEW HUNDRED YARDS IT SHUT-OFF AGAIN. TRUCK THEN WOULD NOT START FOR 10-15 MINUTES, FINALLY STARTED AND I MADE IT ABOUT 1/2 MILE TO NEXT EXIT. TRUCK SHUT-OFF AGAIN IN PARKING LOT OF A TRUCK STOP AND WOULD NOT START. AFTER USING A HAND HELD SCANNER TO CHECK ENGINE CODES, PROBLEM WAS IDENTIFIED AS A FAILED CPS (CAM POSITION SENSOR). NEW PART WAS PURCHASED FROM PARTS HOUSE (~$150) AND I INSTALLED IN THE PARKING LOT. TRUCK STARTED BACK UP AND CONTINUED ON A SEVERAL HOUR TRIP. A WEEK OR SO LATER THAT SENSOR HAD AN INTERMITTENT FAILURE OCCURRING (ACCORDING TO CODES FROM A HAND HELD SCANNER) SO IT WAS REPLACED AGAIN WITH A FORD PART #. I HAVE NOT HAD ANY PROBLEMS SINCE BUT BECAUSE THIS CPS FAILURE IS A WELL KNOWN PROBLEM AMONGST FORD DIESEL TRUCK OWNERS I HAVE PURCHASED A SECOND FORD SENSOR AND KEEP IN THE TRUCK AS A SPARE TO KEEP FROM STRANDING MYSELF ON THE ROAD. THE FIRST FAILURE OCCURRED WITH ~125,000 MILES ON THE TRUCK. I FEEL ~125,000 MILES IS AN ACCEPTABLE LIFE SPAN FOR THE SENSOR, BUT THE IMMEDIATE FAILURE WITHOUT WARNING CAN LEAVE THE DRIVER AND OCCUPANTS IN A DANGEROUS SITUATION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189204April 29, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, EQUIPMENT:ELECTRICAL
MY FORD F250 DIESEL DIED THREE TIMES WHILE DRIVING DOWN THE HIGHWAY PULLING A BOAT AND TRAILER. ALL POWER STEERING AND BRAKING WAS LOST WHEN THE MOTOR DIED. THERE WAS NO SHOULDER TO MOVE OVER TO. CARS BEHIND ME BECAME UPSET AND WOULD TRY TO PASS ME UNDER UNSAFE CONDITIONS AS I TRIED TO COAST THE TRUCK TO THE NEAREST PLACE TO GET OFF OF THE ROAD. IT WAS THE CAM POSITION SENSOR THAT HAD FAILED. THIS IS THE SECOND TIME THE SAME FAILURE HAS OCCURRED. BOTH TIMES LEAVING ME IN A VERY BAD SITUATION WITH A SEVEN THOUSAND POUND TRUCK WITH NO POWER STEERING OR BRAKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189154April 28, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TRUCK STARTED CUTTING OFF RANDOMLY. TRUCK FINALLY QUIT RUNNING ON MAJOR STREET WAS ABLE TO GET IT OFF THE ROAD COASTING. CPS WAS REPLACED AND PROBLEM WAS CORRECTED. OLD PART MAY STILL BE AVAILABLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189163April 28, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
I OWN A 99 F250 PSD. WITHIN THE FIRST 3 WEEKS OF OWNERSHIP THE TRUCK BROKE DOWN AND LEFT ME SITTING ON THE SIDE OF THE HIGHWAY. I HAD IT TOWED TO THE DEALER AND THE RESULT OF THE BREAKDOWN WAS A CPS, (CAM POSITION SENSOR). THIS INCIDENT COST ME RIGHT AT SIX HUNDRED DOLLARS TOTAL BUT SINCE I HAVE LEARNED TO REPLACE IT MYSELF. I AM ON MY 3RD SENSOR AND ONLY HAVE 130K MILES ON MY TRUCK. I BELIEVE FORD KNOWS THIS IS A PROBLEM AND REFUSES TO ADDRESS IT AND WITH THE AMOUNT OF THESE SENSORS GOING OUT THEY ARE RAISING THE COST OF THEM SO THEY CAN PROFIT ON THEIR MISTAKE! MY TRUCK HAS BEGUN THE TYPICAL SYMPTOMS OF ANOTHER CPS FAILURE SO I WILL BE FORCED TO PURCHASE ANOTHER HERE IN THE NEAR FUTURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189173April 28, 2007
SUSPENSION:FRONT
I HAVE A 2003 F250 GAS ENGINE WITH 46,000 MILES AND THE FRONT END WILL SHAKE VIOLENTLY WHEN HITTING MINOR RUFF ROAD AT SPEEDS FROM 60 MPH AND ABOVE. THIS CAUSES ME TO HAVE TO SLOW DOWN VERY FAST WHICH LEAVE DRIVERS BEHIND ME SCRAMBLING TO SAFETY. I HAVE PUT NEW TIRES ON THE FRONT BUT THIS DID NOT FIX THE PROBLEM. I HAVE CHECKED THE FRONT END FOR DAMAGED OR LOOSE PARTS. ALL SEEMS TO BE IN GOOD SHAPE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189088April 27, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
I HAVE REPLACED MY CAM POSITION SENSOR TWO TIMES IN 60K MILES. THE LAST TIME THE TRUCK DIED WHILE TOWING UP AN OFF-RAMP DURING A BLIZZARD. I HAD TO CHANGE THE SENSOR WHILE IMPEDING THE TRAFFIC OF OHTR TRUCKS TRYING TO PASS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188902April 26, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
1ST DAY OF OWNERSHIP OF 2000 F250, ENGINE INEXPLICABLY DIES, RENDERING USELESS POWER STEERING AND POWER BREAKS. TOWED TO DEALER. EXPLAINED PROBLEM TO SERVICE WRITER. WITHOUT EVEN SEEING THE VEHICLE, THE SERVICE WRITER SAYS "CAMSHAFT POSITION SENSOR." AS IT TURNS OUT, HE WAS RIGHT. PROBLEM FIXED FOR NEARLY $500 DOLLARS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188915April 26, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
ENGINE WOULD QUIT WHILE ON THE ROAD OR AT IDLE OUTSIDE TEMP OR ENGINE TEMP DID NOT MAKE ANY DIFFERENCE. REPLACED CAM POSITION SENSOR PROBLEM CORRECTED NEVER OCCURRED AGAIN . WHEN ENGINE QUIT WOULD RESTART. BELIEVE VERY DANGEROUS DUE TO YOU NEVER KNEW WHEN IT MIGHT QUIT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188861April 25, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
CAMSHAFT POSITION SENSOR DIED WHILE ON THE HIGHWAY DOING 55 MPH. THERE WAS NO WARNING OR ANYTHING, JUST CRUISING ALONG AT 55 THEN A DEAD TRUCK WITH NO POWER TO THE BRAKES OR STEERING WHATSOEVER. PULLED OFF THE SIDE OF THE ROAD AND HAD TO DIAGNOSE AND FIX PROBLEM MYSELF ON THE ROAD. NEW CAMSHAFT POSITION SENSOR RESOLVED THE PROBLEMS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188890April 25, 2007
STEERING
SHORTLY AFTER I PURCHASED MY 2005 FORD F-250 SUPER DUTY PICKUP I EXPERIENCED A VIOLENT VIBRATION IN THE STEERING, WHEN TRAVELING OVER 55 MPH, AFTER HITTING A SMALL BUMP IN THE ROAD. WHEN I BROUGHT MY TRUCK IN FOR SERVICE AND MENTIONED THIS EPISODE. THE SERVICE MANAGER ACTED AS THOUGH IT WERE AN ANOMALY, MAYBE THE ROAD CONDITIONS OR SOMETHING ELSE. THIS DIDN'T SEEM TO BE THE TRUTH, SINCE IT HAPPENED SEVERAL TIMES SINCE THEN. WHEN I BROUGHT IT TO THE ATTENTION OF THE LOCAL SERVICE MANAGER, HE SAID THAT THIS IS COMMON AMONGST THESES LARGE PICKUP TRUCKS, AND JUST TAP THE BRAKES UNTIL THE VIBRATIONS SUBSIDE, IT SHOULDN'T LAST LONG. YESTERDAY I WAS TRAVELING AT ABOUT 60 MILES AN HOUR ON THE HIGHWAY, WHEN I WENT OVER A SEWER GRATE IN THE LEFT LANE. THE VIBRATION BECAME SO VIOLENT THAT I HAD NO CONTROL OF THE STEERING AT ALL. I NARROWLY AVOIDED A COLLISION WITH A FUEL TRUCK AND SEVERAL OTHER CARS ON MY WAY OFF THE ROAD AND INTO WOODS CAUSING MULTIPLE TIRE DAMAGE, AND SUFFERING DENTS AND DAMAGE TO THE VEHICLE. I THANK GOD NO ONE WAS HURT, INCLUDING ME. I WAS ABLE TO DRIVE THE TRUCK AWAY AFTER CHANGING THE TIRES AND CLEANING UP THE MESS FROM MY PERSONAL PROPERTY BEING TOSSED AROUND THE CABIN. NOT ONLY DID I LOOSE STEERING BUT, I WAS SURPRISED THAT SUCH A VIOLENT EPISODE DID NOT DEPLOY THE AIR BAGS. I RETURNED TODAY TO THE DEALER WITH MY TRUCK. THE SERVICE MANAGER HAD BEEN REPLACED,WITH A NEW ONE. WHEN I INFORMED HIM OF THE SITUATION HE CHECKED THE COMPUTER FOR MY RECORDS AND MAGICALLY HE WAS ABLE TO FIND EVERY OTHER RECORD OF SERVICE AND REPAIRS, EXCEPT THE STEERING COMPLAINTS. TOMORROW, THE 26TH, I HAVE AN APPOINTMENT WHERE I HOPE TO HAVE THIS CORRECTED. ALTHOUGH THIS SERVICE MANAGER SAYS HE HASN'T HEARD OF ANY PROBLEMS WITH THESE TRUCKS. I WAS SEARCHING THE INTERNET AND FOUND MULTIPLE COMPLAINTS ON DIFFERENT SITES, INCLUDING THE ONE THAT MADE REFERENCE TO YOUR SITE. THROUGH INSURANCE, I HOPE THAT THERE WOULD BE SOME TYPE OF LIABILITY TO THE FORD MOTOR COMPANY. *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10188897April 25, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
MY CMP SENSOR STARTED GOING OUT WHEN ON THE FREEWAY AT 65 MPH AND DIED AND LOST STEERING AND BRAKES. IT WAS A CLOSE CALL AND WENT TO FORD AND THEY WANTED 200.00 FOR A SENSOR SO I CALLED INTERNATIONAL IT WAS 114.00 SAME PART. I AM NOT HAPPY ABOUT FORD AND THERE PRICES. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188896April 25, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
CAM POSITION SENSOR FAILURE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188899April 25, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
I HAVE MY TRUCK AT THE DEALERSHIP TODAY AND AFTER DIAGNOSTIC THEY FIND OUT THAT MY PROBLEM IS CAUSED BY THE CAM SENSOR. MY PROBLEM START ABOUT TWO WEEKS A GO WHEN MY TRUCK JUST WITH NO ALERTS/LIGHTS JUST SHUT OFF ON THE MIDDLE OF THE ROAD BUT ON TUESDAY 24TH OF 2007 I WAS DRIVING ON AN SMALL ROAD I'M PULLING A 6X12 CARGO TRAILER WHEN MY TRUCK DID IT AGAIN BUT THIS TIME BECAUSE MY TRAILER ON THE BACK WAS VERY DIFFICULT TO DRIVE WITH NO POWER STEERING AND NO BRAKES. I DID A SEARCH JUST NOW AND FOUND OUT THAT IS A PROBLEM THAT FORD IS AWARE OFF AND THEY JUST DON'T WANT TO ADMIT PLEASE ADVICE ME TO WHAT I NEED TO DO. DEALER ESTIMATE TO FIX THE PROBLEM IS ABOUT $500.00 LABOR AND PARTS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188692April 24, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
I HAVE HAD TO REPLACE 4 CAM POSITION SENSORS IN MY 2001 FORD F250. ALL OF THE SENSORS FAILED WHILE DRIVING WHICH CREATED A DANGEROUS SITUATION BECAUSE WHEN THEY DIE THE VEHICLE ACTS AS IF THE KEY HAS BEEN TURNED OFF WHICH MEANS YOU LOSE EVERYTHING INCLUDING POWER STEERING AND POWER BRAKES. I FEEL VERY LUCKY THAT NOBODY WAS INJURED AND ALSO LUCKY THAT I WAS NOT PULLING A TRAILER AT THE TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188570April 23, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
THE "CAM POSITION SENSOR" ( CPS ) ON 2001 FORD 7.3L DIESEL FAILED. THIS CAN CAUSE LOSS OF CONTROL AS THE ENGINE DIES THUS LEAVING NO POWER STEERING OR BRAKES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188577April 23, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
1999 FORD SUPER DUTY - 7.3L POWERSTROKE TURBO DIESEL. DRIVING ALONG TOWING A 21' GOOSE NECK STOCK TRAILER AND THE TRUCK SHUT DOWN. NO POWER BRAKES OR STEERING. ENGINE JUST DIED. SAT FOR A WHILE AND RESTARTED - STALLED A COUPLE MORE TIMES GETTING IT HOME. CAMSHAFT POSITION SENSOR FAILED - REPLACED. VERY COMMON AND DANGEROUS PROBLEM ON THESE TRUCKS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188638April 23, 2007
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING 55 MPH IN NORMAL DRIVING CONDITIONS THE DRIVER'S SIDE REAR TIRE BLEW OUT. THE CONTACT PULLED OVER AND REPLACED THE FAILED TIRE WITH A SPARE. THE VEHICLE WAS NOT TAKEN TO THE DEALER , BUT HAD VISIBLE DAMAGE. THE DRIVER'S SIDE REAR PANEL AND WHEEL WELL WERE DAMAGED BY THE TREAD FROM THE TIRE. THE CURRENT MILEAGE IS 85,997 AND FAILURE MILEAGE WAS 78,500. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188657April 23, 2007
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
I RECENTLY BOUGHT A USED 2001 FORD F-250 WITH THE 7.3 DIESEL FROM THE LOCAL FORD DEALER. IT HAD A RECENT COMPUTER REFLASH, SHOULD HAVE TOLD ME SOMETHING. ANYWAY THE CPS WAS BAD IN IT. IT WOULD SHUT DOWN, SOMETIMES STARTING RIGHT BACK, SOMETIMES AFTER A FEW MINUTES. I GOT TIRED OF THE RUN AROUND SO I PUT A NEW CPS IN IT MYSELF. I HAVE HAD NO MORE PROBLEMS, NO THANKS TO FORD. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250