Ford F-250 Complaints

11,199 consumer complaints on file.

#10313272February 23, 2010
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:ENGINE
2004 FORD F250 SUPERDUTY, 6.0 DIESEL, TOWING A 30FT. 5TH WHEEL RV. WAS TRAVELING SOUTH ON I95 AT 65MPH AND ENGINE CUTS OFF AS IF THE IGNITION WAS TURNED OFF WITH NO WARNING LOOSING POWER STEERING AND BRAKES. TRUCK WAS TOWED TO FORD DEALER AND REPAIRED AT CUSTOMER'S EXPENSE. TWO ENGINE WIRING HARNESSES WAS REPLACED AT A COST OF $1639.00, $104 TOWING, $289.00 RENTAL CAR AND 6 DAYS IN SAVANNAH, GA. UNEXPECTED. THIS HAS BEEN AN ONGOING PROBLEM AS EVIDENCED BY EARLIER SAFETY RECALL FORD #05S34. FORD STILL REFUSES TO DO ANYTHING ABOUT THE PROBLEM BECAUSE THE TRUCK IS 10 MONTHS OUT OF WARRANTY WITH ONLY 51,000 MILES ON THE ODOMETER. SAFETY RECALL APPARENTLY DID NOT SOLVE THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10313365February 23, 2010
SERVICE BRAKES, ELECTRIC, VEHICLE SPEED CONTROL
CRUISE CONTROL WILL NOT DISENGAGE, TRUCK WANTS TO SPEED UP EVEN WITH BRAKE ON, THIS IS AN ONGOING PROBLEM STARTED IN JANUARY OF 2009. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10313382February 23, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
APPROXIMATELY 3 DAYS AGO, AUTOMATIC TRANSMISSION SLIPPED BRIEFLY, OCCURRED AGAIN ON 2/22/10. SELF-CORRECTED BOTH TIMES. VEHICLE WAS HAULING ENCLOSED CARGO TRAILER CONTAINING 3 ATV'S. PARKED VEHICLE AND SHUT OFF IGNITION, VEHICLE WAS IN PARK. APPROXIMATELY 3 MINUTES LATER NOTICED SMOKE FROM UNDER HOOD. FIRE SPREAD TOO RAPIDLY FOR EFFECTIVE USE OF FIRE EXTINGUISHER. ENGINE COMPARTMENT WAS FULLY INVOLVED UPON FIRE DEPT ARRIVAL, WITH RADIANT HEAT AND SMOKE DAMAGE TO THE PASSENGER COMPARTMENT. THE VEHICLE IS CONSIDERED A TOTAL LOSS. UPON INVESTIGATION THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT AND MOST LIKELY WAS DUE TO FAILURE OF THE AUTOMATIC TRANSMISSION OR A COMPONENT OF THE TRANSMISSION. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10312542February 21, 2010
SUSPENSION:FRONT
NEAR COMPLETE LOSS OF CONTROL WHILE DRIVING AT 55-60 MILES AN HOUR ON FLAT FREEWAY. SMALL BUMP SENT TRUCK INTO SHUTTERING WOBBLE. NO STEERING ALMOST NO BRAKES TOOK SEVERAL HUNDRED YARDS TO SLOW DOWN TO ABOUT 10-15 MPH AND REGAIN CONTROL OF VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312330February 20, 2010
VEHICLE SPEED CONTROL
THE FAILURE WAS THE CRUISE CONTROL STARTED A FIRE IN MY 1997 FORD F250 WHILE MY WIFE ,OUR 16 MONTH OLD AND MYSELF WERE SLEEPING. LUCKILY WE GOT OUT BUT EVERYTHING WE HAD IS A TOTAL LOSE. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10312344February 20, 2010
VEHICLE SPEED CONTROL
ON THURSDAY EVENING FEBRUARY 18, 2010 AT APPROXIMATELY 9:45 PM MY WIFE NOTICED WHEN SHE TOOK OUR DOG OUT IN OUR FRONT YARD THAT OUR 1999 FORD F250 LARIET 7.3 LITER DIESEL WAS ON FIRE. I HAD CONNECTED THE FACTORY INSTALLED BLOCK HEATER TO A 120V EXTENSION CORD AT AROUND 9:00 PM THAT SAME EVENING, AS USUALLY DONE IN THE EVENINGS WHEN IT WILL BE DRIVEN THE NEXT DAY. AMBIENT TEMPERATURE WAS APPROXIMATELY 25 DEGREES F. THE TRUCK HAS FACTORY INSTALLED CRUISE CONTROL, AND WAS BROUGHT IN TO A FORD DEALER IN AROUND JULY 2009 AS REQUIRED BY A FORD RECALL NOTICE ABOUT CRUISE CONTROLS. THE SERVICE DEPARTMENT OF THE DEALERSHIP SAID THE CRUISE CONTROL WAS NOT DEFECTIVE. BASED UPON THE FIRE, I BELIEVE FORD'S TEST PROCEDURES TO ASSESS THE SAFE OPERATION OF THE CRUISE CONTROL SWITCH AS TO CORROSION/ELECTRICAL RESISTANCE, AND EXCESSIVE HEAT GENERATION, IS IN ADEQUATE BECAUSE IT PROBABLY DOES NOT MEASURE CONDUCTIVITY, AND SWITCH ASSEMBLY TEMPERATURE. THE BETTENDORF, IOWA FIRE DEPARTMENT RESPONDED, AND EXTINGUISHED THE FIRE WITHIN FIVE MINUTES ONCE THEY HAD THE HOSES, PRY BARS, AND HYDRAULIC JAWS IN PLACE. THE SCOTT COUNTY SHERIFF DEPARTMENT ALSO RESPONDED. OUR INSURANCE COMPANY SAID THE TRUCK IS TOTALED, AND AWAITING MY DECISION REGARDING SALVAGE. I WILL CONTACT AN ATTORNEY (HE WAS IN COURT) MONDAY FEBRUARY 22, 2010 REGARDING WHAT I BELIEVE THAT THE CAUSE OF THE FIRE WAS THE CRUISE CONTROL SWITCH, PROBABLY MANUFACTURED BY TEXAS INSTRUMENTS. THE TRUCK HAS NOT BEEN MOVED AWAITING DIRECTIONS FROM THE ATTORNEY. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10312421February 20, 2010
SERVICE BRAKES, HYDRAULIC
I BOUGHT THE TRUCK USED WITH 138,000 MILES ON IT. I HAVE PUT ABOUT 122,000 MILES ON IT SO IT HAS ABOUT 250,000 MILES ON IT NOW. I HAVE HAD NUMEROUS FRONT BRAKE ISSUES WITH THIS TRUCK. I HAVE HAD 8 BRAKE REPAIRS ON THE TRUCK SINCE I BOUGHT IT. THE TRUCK VIOLENTLY SHAKES WHILE BRAKING. I HAVE TAKEN IT TO MULTIPLE BRAKE SHOPS AND HAD FORD ORIGINAL PARTS PUT BACK ON IT. EVERYTIME THEY CHANGE THE ROTORS AND BRAKE PADS AND EVERY OTHER TIME THE CALIPERS. IT IS JUST A MATTER OF TIME BEFORE I HAVE AN ACCIDENT. I RECENTLY HAD A REPAIR DONE AND I HAVE ONLY WENT 2,100 MILES AND IT IS VIOLENTLY SHAKING AGAIN. I USUALLY GET AROUND 18,000 MILES BETWEEN BRAKE REPAIRS. I HAVE RESEARCHED THE ISSUE AND HAVE FOUND HUNDREDS IF NOT THOUSANDS OF PEOPLE HAVING THE SAME ISSUE WITH THIS TRUCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10311622February 18, 2010
WHEELS
BOTH FRONT WHEELS ON MY 2008 FORD KING RANCH F-250 PICK-UP ARE CRACKING AND NEED TO BE REPLACED. THE CRACKS ARE IN THE WELD AREA ON THE FLAT PART OF THE WHEEL UNDER THE TIRES CAUSING THE TIRES TO NO LONGER HOLD AIR. FORD CUSTOMER SERVICE CLAIMS THE PROBLEM IS MINE SINCE THE TRUCK RECENTLY SURPASSED WARRANTY MILEAGE HOWEVER I AM CERTAIN THIS IS A SERIOUS SAFETY ISSUE. THE WHEELS ARE READY TO COME APART AND COULD HAVE CAUSED A SERIOUS ACCIDENT . IF THE TIRES HAD NOT BEGUN TO LOSE AIR I WOULD HAVE NEVER KNOWN THEY WERE CRACKING. THIS TRUCK HAS HAD THE BEST OF CARE AND HAS NEVER HIT ANYTHING OR BEEN IN ANY KIND OF ACCIDENT. FORD DENIED RESPONSIBILITY WITHOUT EVEN EXAMINING THE CRACKED WHEELS. THE TIRE SHOP BELIEVED THE SITUATION WAS SO UNSAFE THAT THEY RECOMMENDED TOWING INSTEAD OF DRIVING THE TRUCK. THIS CASE # 1526770470 WITH FORD WAS DENIED AND THEY QUOTED OVER 800 DOLLARS PER WHEEL TO REPLACE THE CRACKED WHEELS. ALL AFTER MARKET WHEELS I CHECKED ON WERE AROUND 250 DOLLARS WITH A LIFETIME GUARANTEE. I HAVE WORKED IN CONSTRUCTION FOR OVER 30 YEARS AND HAVE OWNED SEVERAL VEHICLES AND HAVE NEVER ENCOUNTERED ANYTHING LIKE THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10311728February 18, 2010
ENGINE AND ENGINE COOLING:ENGINE, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
I OWN A 2002 F250 V10 WITH APPROX 84,000 MILES. I WAS JUST DRIVING ALONG AND THE SPARK PLUG FROM THE # 8 CYLINDER BLEW OUT. I HAD TO RETAP IT AND PUT A HELICOIL IN IT. THE SPARK PLUGS WERE THE ORIGINAL SPARK PLUGS AND HAVE NEVER BEEN REPLACED. I HAVE SEEN NUMEROUS COMPLAINTS OF THE SAME PROBLEM ON KLINE. IT IS DEFINITELY A MANUFACTURING DEFECT. ALSO I NEED TO REPLACE THE EXHAUST MANIFOLD BOLTS ON THE SAME CYLINDER HEADS. THIS IS ANOTHER PROBLEM I HAVE FOUND NUMEROUS COMPLAINTS ABOUT ONLINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310990February 16, 2010
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 1999 FORD F250 SUPER DUTY. WHEN HE TOOK THE VEHICLE TO INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE HE NOTICED THAT ALL FOUR TIRES WERE BALD AND HAD NOT THREAD. THE TIRES WERE MANUFACTURED BY GENERAL TIRE, LINE GENERAL GRABER AT2, SIZE LT245-75R16 LOAD EASE, DOT P5111UU. HE CONTACTED THE MANUFACTURER. THE MANUFACTURER STATED HE SHOULD FILE A COMPLAINT THEN THEY WILL REPLACED THE TIRE, OR GIVE HIM HIS MONEY BACK. THE VEHICLE CURRENT AND FAILURE MILEAGE WERE 240,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310422February 15, 2010
SUSPENSION, STEERING, SUSPENSION:REAR
I OWN AND DRIVE A FORD F250 SUPER DUTY 4-WHEEL DRIVE TRUCK. I HAVE ON MORE THAN TWENTY (20) OCCASIONS EXPERIENCED A SEVERE SUSPENSION AND STEERING WHEEL VIBRATION, CAUSING ME TO LOSE CONTROL OF MY VEHICLE. THIS OCCURRED DURING THE PERIOD 5/15/2009 THROUGH 1/15/2010. THIS ONLY OCCURS AT SPEEDS OVER 55 MPH ON THE HIGHWAY WHEN I CROSS OVER UNEVEN ROAD SURFACES, LIKE AN OVERPASS OR A CHANGE IN PAVEMENT TYPE. THE VIBRATION IS SO SEVERE THAT THE ONLY WAY TO STOP IT IS TO SLOW DRAMATICALLY TO LESS THAN 30 MPH AND MOVE OUT OF THE TRAFFIC LANES. THE VIBRATION DOES NOT STOP UNLESS I SLOW THE VEHICLE. I HAVE ATTEMPTED TO KEEP THE VEHICLE ON THE ROAD WITHOUT SLOWING DOWN, BUT THE VIBRATION CONTINUED FOR MORE THAN 45 SECONDS. I HAVE ADDRESSED THIS WITH MY LOCAL FORD DEALER. THEY WERE UNABLE TO DUPLICATE THE EVENT. ON ONE OCCASION THEY COULD NOT ADDRESS IT BECAUSE THEY DID NOT HAVE A TRUCK SPECIALIST ON SITE THAT DAY. MY VEHICLE IS AT THE FORD DEALER TODAY TO HAVE THIS ADDRESSED, BUT BASED ON PREVIOUS EXPERIENCE, I DO NOT FEEL THEY WILL ACKNOWLEDGE OR ADDRESS THE PROBLEM. THE PROBLEMS FIRST OCCURRED WHEN THE VEHICLE HAD APPROXIMATELY 28,000 MILES. ALL SERVICE ON MY VEHICLE HAS BEEN PERFORMED AT FORD DEALERS, SO THEY HAVE RECORDS OF MY COMPLAINTS. IT IS MY UNDERSTANDING FROM SPEAKING TO SEVERAL PEOPLE AT MY LOCAL FORD DEALER THAT THE PROBLEM MAY BE RELATED TO A SENSOR IN THE REAR-END WHICH IS ASSOCIATED WITH THE 4-WHEEL DRIVE SYSTEM. ALL OF THESE EVENTS OCCURRED WHILE THE VEHICLE WAS IN 2-WHEEL DRIVE MODE. I AM GREATLY CONCERNED ABOUT MY SAFETY AND THE SAFETY OF OTHER MOTORISTS WHEN DRIVING THIS VEHICLE AT HIGHWAY SPEEDS. IF THE ISSUES CONTINUE, IT IS LIKELY THAT THE VIBRATION WILL CAUSE ME TO LOSE CONTROL OF MY VEHICLE LEADING TO AN ACCIDENT, AND AT HIGHWAY SPEEDS, IT IS LIKELY TO INVOLVE INJURIES OR DEATH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310507February 15, 2010
FUEL SYSTEM, DIESEL
OCT. 20, 2009, TRUCK DIED WHILE PULLING 5TH WHEEL UP STEEP MTN. ROAD TO KENNEDY MEADOWS, CA. BAD SITUATION. AFTER 3 WEEKS IN FORD GARAGE, IN RIDGECREST, CA. SEVERAL PARTS REPLACED ALL RELATED TO THE HIGH PRESSURE OIL SYSTEM USED TO FIRE INJECTORS ON THIS 6.0 POWERSTROKE ENGINE. JAN 26, 2010. AFTER PULLING THE 5TH WHEEL FOR ABOUT 100 MILES THROUGH HEAVY TRAFFIC AND PARKING TRAILER IN MY DRIVEWAY, I CAME BACK LATER AND TRUCK WOULDN'T START. TOWED TO LAKE ELSINORE FORD AND THEY REPLACE THE OIL PRESSURE REGULATOR. THIS IS ALL OVER THE POWERSTROKE SITES ON THE NET. MY NEPHEW HAS HAD THE SAME PROBLEMS. FORD KNOWS THIS TOO. BOTH OF THESE INCIDENTS COULD HAVE RESULTED IN WRECKS, THERE IS NO WARNING, THE ENGINE JUST DIES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310113February 12, 2010
FUEL SYSTEM, DIESEL
EXTREME TURBO LAG WITH LOSS OF POWER WHICH CAUSED VEHICLE NOT TO SHIFT THROUGH THE GEARS, IT IS AN AUTOMATIC, UNABLE TO DRIVE OVER 25MPH AND EMITTING A LARGE CLOUD OF BLACK EXHAUST. INCIDENT OCCURRED AT APPROXIMATELY 100,000 MILES LUCKILY THE TURBO WAS ABLE TO BE DIS-ASSEMBLED AND CLEANED WITH NO INTERNAL DAMAGE AT A RATHER HIGH COST BUT STILL CHEAPER THAN A REPLACEMENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10308318February 10, 2010
SUSPENSION, STEERING
I HAVE A 2006 F250 4X4 WHEN AT 55 MPH OR HITTING A BUMP THE FRONT END SHAKES OUT OF CONTROL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10307928February 9, 2010
SUSPENSION
TL*THE CONTACT OWNS A 2005 FORD F250. WHILE DRIVING THE VEHICLE BEGAN TO SHAKE VIOLENTLY. HE ALSO BEGAN TO EXPERIENCE A VIOLENT FRONT END SHAKING AT HIGHWAY SPEEDS OF OVER 10 MPH WHEN DRIVING OVER MINIMAL BUMPS IN THE ROAD AND UNEVEN SURFACES. THE FORD DEALER WAS CONTACTED AND THEY ADVISED THE CONTACT TO HAVE AN ALIGNMENT PERFORMED AND TO ROTATE HIS TIRES WHICH DID NOT CORRECT THE FAILURE. HE ALSO HAD SHOCKS INSTALLED IN AN ATTEMPT TO CORRECT THE FAILURE; HOWEVER, THE FAILURE PERSISTED. THERE WERE NO ADDITIONAL REPAIRS MADE TO THE VEHICLE IN AN ATTEMPT TO CORRECT THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 85,000. UPDATED 3/10/10 *CN UPDATED 06/04/10*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10306586February 5, 2010
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
THIS IS ABOUT A FUEL TANK DELIVERY AND AIR INDUCTION BULLETIN, CROSS TANK FUEL FLOW PROBLEM MY FORD F250 TRUCK IS HAVING. I HAVE NOTIFIED MY LOCAL DEALERSHIP AND FORD CUSTOMER SERVICE, THEY BOTH SAY THERE IS NO RECALL FOR THIS VEHICLE. BUT I FOUND A NHTSA CAMPAIGN # 93V12500 DESCRIBING EXACTLY WHAT HAS BEEN HAPPENING FOR THE LAST 6 MONTHS. IT NEEDS TO BE FIXED AND IS EXPENSIVE, BUT I CAN'T GET ANY SATISFACTION FROM FORD, I'M HOPING YOU CAN HELP. *TR UPDATED 04/15/10.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10306639February 5, 2010
VISIBILITY
MY HUSBAND WOKE UP AND WENT OUT TO START HIS TRUCK SO IT WOULD BE WARM FOR OUR 1-YR OLD TWIN BABIES TO GET IN THE CAR. WHEN HE WENT TO PUT THE BABIES IN THE BACK SEAT, THE REAR PASSENGER WINDOW WAS BLOWN OUT FROM THE INSIDE OUT; THE GLASS LOOKED BUBBLED. HE IMMEDIATELY TOOK THE CAR TO THE GLASS SHOP AND WAS ADVISED THAT BECAUSE FORD DOESN'T USE THE PROPER SEAL ON IT'S REAR WINDOWS THAT THIS CAN OCCASIONALLY HAPPEN. THE WINDOW BLEW UP FROM THE HEAT INSIDE THE CAR...IT'S 30 DEGREES HERE THIS MORNING. WE THEN TOOK THE VEHICLE THAT IS STILL UNDER WARRANTY TO OUR LOCAL FORD DEALERSHIP AND WE WERE ADVISED THAT IT'S NOT COVERED UNDER WARRANTY. SO I'M LOOKING AT $800 FOR A WHOLE ENTIRE BACK WINDOW THAT HAS TO BE REPLACED. THIS CONCERNS ME AS IF ONE OF MY BABIES WAS IN THE CAR WHEN THIS HAPPENED, WE WOULD HAVE SOME SERIOUS HEALTH ISSUES....THIS IS A HUGE SAFETY CONCERN. BECAUSE OF THEIR FAULTY SEAL, OUR WINDOW EXPLODED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10305776February 4, 2010
ENGINE AND ENGINE COOLING
FORD F-250 2002 ENGINE BLEW OUT A SPARK PLUG. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10305746February 4, 2010
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THE EGR VALVE COOLER RUPTURED AND WAS LEAKING ANTIFREEZE THROUGH THE EXHAUST SYSTEM. THE DEALER WAS AWARE OF THE FAILURE; HOWEVER, THE FORD MANUFACTURER ADVISED THEM TO STOP REPAIRING THE VEHICLE. THE ESTIMATED COST WAS $2600. THERE WERE NO VALID WARRANTIES OR RECALLS. THE FAILURE MILEAGE WAS 51,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10304590February 3, 2010
SUSPENSION:FRONT
TL* THE CONTACT OWNS A 2006 FORD F250 SUPERDUTY. WHILE DRIVING AT APPROXIMATELY 60 MPH THE CONTACT HIT A BUMP ON THE ROAD AND THE VEHICLE STARTED TO SHAKE VIOLENTLY. SHE WAS ABLE TO BRING IT BACK UNDER CONTROL MOVE OVER ON THE SIDE OF THE ROAD TURNED THE VEHICLE OFF. SHE DROVE THE VEHICLE HOME AT A LOW SPEED SHE TOOK THE VEHICLE TO THE DEALER. THE DIAGNOSTIC TEST LOCATED THAT THE STABILIZER BRACKET WAS BROKEN. THE DEALER WILL REPLACE THE STABILIZER BRACKET IN ORDER TO BE ABLE TO TEST DRIVE THE VEHICLE TO RECREATE THE FAILURE. SHE WILL CONTACT THE MANUFACTURER. THE FAILURE AND THE CURRENT MILEAGE WAS 33,481. UPDATED 03/10/10 *BF UPDATED 05/20/10.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250