Ford F-250 Complaints

11,199 consumer complaints on file.

#10347082August 3, 2010
EQUIPMENT, WHEELS
DURALAST HUB ASSEMBLY FAILURE FOR 2002 FORD F250. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10346941August 2, 2010
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE
I OWN A 2001 FORD F 250 SUPER DUTY WITH A 6.8 LITER V10 THIS IS THE SECOND TIME NOW THAT IT HAS BLOWN OUT A SPARKPLUG WHILE DRIVING DOWN THE ROAD AT A HIGH SPEED THEY WERE NOT THE SAME PLUG AND THEY ARE ORIGINAL MOTORCRAFT PLUGS . BOTH TIMES YOU SMELL ALOT OF GAS THAT COULD CAUSE A FIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346716August 2, 2010
SUSPENSION:FRONT
2005 FORD F 250 CREWCAB 4X4 FRONT END SHAKES UNCONTROLLABLY AFTER HITTING A BUMP AT HIGHWAY SPEEDS. THE ENTIRE VEHICLE BOUNCES AROUND TO WHERE OTHER VEHICLE ON THE ROADWAY HAVE TO SWERVE TO GET OUT OF THE WAY. ONLY WAY TO STOP IT IS TO SLOW DOWN TO ABOUT 30 MPH. I JUST RECENTLY HAD THE STEERING STABILIZER, DRAG LINK BAR AND SHOCKS ON THE TRUCK REPLACED ALONG WITH TIGHTENING THE STEERING GEAR BOX AND IT STILL CONTINUES TO DO THE SAME THING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346501July 31, 2010
SUSPENSION:FRONT
I RECENTLY PURCHASED A FORD 2005 F250 SUPER DUTY TRUCK. WHILE DRIVING ON THE HIGHWAY AT 70 MPH, I HIT AN UNEVEN SPOT ON THE ROAD THAT CAUSED THE FRONT END TO WOBBLE VIOLENTLY. I FELT I COULD NOT CONTROL THE TRUCK AND HAD TO APPLY THE BRAKES IMMEDIATELY. LUCKILY THERE WERE NO OTHER CARS NEARBY. WHEN THE TRUCK REACHED APPROXIMATELY 30 - 35 MPH, THE WOBBLE CEASED. ON MY WAY BACK HOME, THE WOBBLE OCCURRED AGAIN. THIS TIME I WAS TRAVELING AT 60 - 65 MPH AND HIT ANOTHER ROUGH SPOT ON THE ROAD. THIS IS A MAJOR SAFETY HAZARD THAT NEEDS TO BE RESOLVED BEFORE SOMEONE IS KILLED. I RESEARCHED THE PROBLEM ON THE INTERNET AND DISCOVERED THIS HAS BEEN ONGOING FOR A WHILE. THERE ARE NUMEROUS EXAMPLES FROM OTHER F250 AND F350 OWNERS WITH THE SAME PROBLEM THAT CAN BE FOUND ON THE INTERNET. THE FORD MOTOR COMPANY IS AWARE OF THE PROBLEM AND BLAMES THE WOBBLE ON UNDERFLATED TIRES. THE WOBBLE OCCURS ON PROPERLY INFLATED TIRES ALSO AS DETAILED BY OTHER TRUCK OWNERS. BUT EVEN IF THE TRUCK'S TIRES ARE UNDER INFLATED, A VIOLENT WOBBLE SHOULD NOT OCCUR. MANY OTHER VEHICLES ARE IN USE WITH UNDER INFLATED TIRES, YOU DON'T HEAR OF A VIOLENT WOBBLE AFTER ENCOUNTERING A POT HOLE OR AN UNEVEN ROAD SURFACE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346269July 30, 2010
ELECTRICAL SYSTEM
2006 FORD F250 SUPERDUTY GENERATOR IS FAULTY AS STATED BY FORD TECHNICAL SERVICE BULLITEN DATED SEPTEMBER 19TH 2006. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346192July 29, 2010
STRUCTURE
I HAVE A 2006 F250 DIESEL, SUPERDUTY, SUPERCAB, LONG BED, 4X4. ON THE RIGHT REAR TIRE AREA, THE EMERGENCY BRAKE LINE LOOPS DOWN BELOW THE UNDERCARRIAGE OF THE VEHICLE. ON THE LEFT SIDE IT LOOPS UP. ON ALL FORD TRUCKS THAT I HAVE SEEN, WITH THE EXCEPTION OF THE 2006, BOTH SIDES LOOP UP. THIS IS A 4X4 TRUCK. I BELIEVE THAT IT IS UNSAFE TO HAVE THE EMERGENCY BRAKE LINE LOOP DOWN, AS THE LOWEST POINT ON THE VEHICLE, ON A TRUCK THAT WILL BE USED OFF ROAD. THIS TRUCK IS USED ON A RANCH AND FOR TRAILERING HORSES, SO THE POSSIBILITY OF DRIVING OVER BRANCHES AND ROCKS THAT COULD CATCH ON THE EMERGENCY BRAKE LINE IS HIGH. IN THIS DOWNWARD POSITION, IT IS LIKELY TO BREAK IF IT HITS A ROCK OR BRANCHES. I HAVE REQUESTED THE DEALER AND FORD CORPORATE TO FIX IT, BUT THEY HAVE INFORMED ME THAT THEY CANNOT MODIFY THE VEHICLE DESIGN. I HAVE PHOTOS THAT I CAN SEND, BUT I DO NOT SEE WHERE TO ATTACH ON THIS CONTACT FORM. I BELIEVE THAT THE EMERGENCY BRAKE LINE SHOULD BE ADJUSTED TO LOOP UP TO BE IN A SAFER POSITION AND NOT BE THE LOWEST POINT, HANGING BELOW THE UNDERCARRIAGE OF THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346223July 29, 2010
STEERING
I BOUGHT A 2008 FORD F-250 EXTENDED CAB TRUCK AND WHEN I GO OVER A SMALL BUMP IN THE ROAD THE FRONT END SHAKES REAL BAD TO THE POINT I ALMOST LOST CONTROL GOING DOWN A HIGHWAY AT 55MPH. I CHECKED THE AIR PRESSURE IN THE TIRES AND THEY WERE AT 70PSI IN THE FRONT AND 80PSI IN THE BACK. THE DOOR STICKER SAID THE PRESSURES SHOULD BE 70 IN THE FRONT AND 80 IN THE BACK. I HAVE REPLACED THE SHOCKS AND STEERING STABILIZER SHOCK AND IT DID NOT MAKE A DIFFERENCE. THE OLD SHOCKS APPEARED TO BE IN GOOD SHAPE YET. I THEN REPLACED THE TIRES EVEN THOUGH THEY WERE STILL GOOD AND THEY WERE WORN EVENLY. STILL DID NOT FIX IT. I THEN DROPPED MY AIR PRESSURE IN THE TIRES TO 60PSI FRONT AND BACK TO IF IT MADE A DIFFERENCE. STILL DID NOT FIX IT. I HAD THE DEALERSHIP LOOK AT IT AND THEY SAID THEY COULD NOT FIND ANYTHING WRONG WITH IT. I OWNED A 1999 F-250 AND IT NEVER HAD THIS PROBLEM. I HAD 165,000 MILES ON IT WHEN I TRADED IT IN FOR THIS ONE. I GOOGLED MY PROBLEM AND FOUND A LOT OF PEOPLE WITH THE SAME PROBLEM. FORD NEEDS TO COME UP WITH A REPAIR FOR THIS SOON. I WON'T LET MY WIFE DRIVE THIS TRUCK FOR FEAR OF THIS HAPPENING AND HER ENDING UP IN A WRECK. FORD NEEDS TO THINK ABOUT THE PEOPLE AND CHILDREN THAT RIDE IN THERE VEHICLES AND THE LIVES THAT THEY COULD TAKE. I AM A FORD DRIVER ALL MY VEHICLES ARE FORD AND I'M NOT MAD AT FORD YET BUT THEY NEED TO CURE THIS PROBLEM. THIS PROBLEM IS FOR SURE A DESIGN FLAW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345995July 28, 2010
SUSPENSION:FRONT
TODAY TOOK THE FORD 1999, 250 SD CREW-CAB TO MY MECHANIC, A FUNNY NOISE, LIKE METAL TO METAL IN THE FRONT AREA OF THE SUSPENSION...SOMETIME NOT ALL THE TIME, TECH DOES NOT KNOWS WHAT IT IS, GUESSED IS RELATED TO THE LEAF SPRING WORNOUT BUSHINGS...PLUS SWAY BARS END TIPS...TOLD ME THAT FEW PARTS HAD TO BE CHANGED..AND EVEN SO, HE DID NOT ASSURED ME THAT THE NOISE WILL DISAPPEARED.... IT'S BEEN A VERY GOOD TRUCK, ONLY OIL, BRAKES, BATTERIES, ETC. WHAT A DILEMMA ??? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345224July 26, 2010
ENGINE AND ENGINE COOLING
FORD F-250 WITH THE 6.0L DIESEL MOTOR HAS A RECURRING ISSUE OF A FAILING EGR COOLER. THE FAILURE OF THEIR COOLER CAN RESULT IN COOLANT ENTERING THE ENGINE AND CREATING A MOTOR FAILURE. AT 99,000 MILES I HAD A EGR AND OIL COOLER REPLACED. AT 113,000 MILES I HAVE HAD ANOTHER FAILURE. THE COST TO THE CONSUMER TO REPAIR THIS PROBLEM IS AT A MINIMUM OF $2,500. FORD IS AWARE OF THIS PROBLEM (ASK ANY FORD SERVICE TECHNICIAN) AND REFUSES TO PROVIDE A PERMANENT RESOLUTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345344July 26, 2010
SUSPENSION:FRONT:HUB
TL* THE CONTACT OWNS A 2000 FORD F250 SUPER DUTY. THE CONTACT STATED WHILE DRIVING AT 55 MPH, THERE WAS AN ABNORMAL VIBRATION IN THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE CONTACT WAS INFORMED THAT THE FRONT DRIVER SIDE HUB BEARING WAS DEFECTIVE AND COULD POTENTIALLY CAUSE THE TIRE TO FRACTURE FROM THE VEHICLE. THERE WAS NOT A RECALL FOR THE FAILURE. THE VEHICLE WAS LEFT AT THE REPAIR FACILITY WHERE THE CONTACT WAS AWAITING REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 185,950 AND THE CURRENT MILEAGE WAS APPROXIMATELY 186,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345360July 26, 2010
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2004 FORD F-250 SUPER DUTY EQUIPPED WITH AMERITRACK TR TIRES. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE BEGAN TO SHAKE EXCESSIVELY. THE VEHICLE WAS PULLED OVER AND THE CONTACT NOTICED THE TREAD HAD SEPARATED FROM THE FRONT DRIVERS SIDE TIRE. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT REPAIR CENTER WHERE A FULL SIZED SPARE WAS INSTALLED ON THE FRONT DRIVERS SIDE. SIX DAYS LATER WHILE DRIVING AT APPROXIMATELY 65 MPH; THE FAILURE RECURRED ON THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS PULLED OVER AND THE CONTACT INSTALLED A SPARE TIRE ON THE FRONT PASSENGER SIDE. THE VEHICLE WAS NOT DIAGNOSED FOR THE CAUSE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 43,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345185July 25, 2010
TIRES, TIRES:TREAD/BELT
I WAS DRIVING AT 55-60 MPH ON TWO LANE HIGHWAY (NO SHOULDER) WHEN BELT AND TREAD OF RIGHT REAR TIRE PEELED OFF SUDDENLY WITHOUT WARNING. TIRE DID NOT LOSE PRESSURE IMMEDIATELY SO I WAS ABLE TO DRIVE APPROXIMATELY 50 YARDS TO NEAREST TURN OFF, PULL OFF ROADWAY, AND PUT MY SPARE ON. ON COMING AND FOLLOWING TRAFFIC HAD TO SWERVE (SOME OFF OF ROAD) TO AVOID PIECES OF DISINTEGRATING TIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345187July 25, 2010
TIRES, TIRES:TREAD/BELT
BELT OF TIRE IS SEPARATING (TIRE FEELS OUT OF BALANCE, BULGE IS NOW EVIDENT IN TREAD, 8/32'S OF ORIGINAL 15/32'S OF TREAD REMAIN). THIS IS SECOND TIRE IN SET OF FOUR TO SEPARATE (SEE ODI REPORT # 10345185 FOR FIRST). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345191July 25, 2010
TIRES, TIRES:TREAD/BELT
BELT OF TIRE IS SEPARATING (TIRE FEELS OUT OF BALANCE, BULGE IS NOW EVIDENT IN TREAD, 7/32'S OF ORIGINAL 15/32'S OF TREAD REMAIN). THIS IS THIRD TIRE IN SET OF FOUR TO SEPARATE (SEE ODI REPORTS #10345185 & #10345187 FOR FIRST & SECOND). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345003July 24, 2010
SERVICE BRAKES, HYDRAULIC
I'VE EXPERIENCED A RECURRING PROBLEM WITH THE BRAKE CALIPERS ON MY 05' FORD F-250 SUPER DUTY. IT'S AN INTERMITTENT PROBLEM OF A CALIPER HANGING UP OR NOT RELEASING AFTER BRAKING. THE CALIPER HEATS UP, THE TRUCK SHAKES, SOMETIMES VIOLENTLY AND BRAKING ABILITY IS DIMINISHED. I PURCHASED THE TRUCK BRAND NEW FROM THE DEALERSHIP, AND IT FIRST OCCURRED AT 19,000 MILES ON A FRONT CALIPER. FORD HAS SINCE REPLACED ALL THE CALIPERS AT LEAST ONCE UNDER THE ORIGINAL WARRANTY, BUT NOW REFUSES TO HELP. I'VE REPLACED THE REAR CALIPERS AT MY COST WITH REMANUFACTURED ONES, AND I'M STILL CONTINUING TO HAVE THE SAME PROBLEM. I'VE SPOKEN WITH OTHER OWNERS OF THE SAME VEHICLE WHO HAVE ALSO EXPERIENCED THIS PROBLEM, SO IT DOESN'T APPEAR TO BE AN ISOLATED INCIDENT. I'VE BEEN RELUCTANT TO GET RID OF THIS VEHICLE BECAUSE IT'S PAID FOR IN FULL, AND BECAUSE APART FROM THE OBVIOUS BRAKE DEFECT, IT ISN'T OTHERWISE A BAD TRUCK. I STRONGLY FEEL THE CALIPER DESIGN IS FAULTY AND COULD EASILY CAUSE A PERSON TO LOOSE STEERING CONTROL IF IT OCCURS IN A FRONT CALIPER. I RECEIVED A NOTICE FROM FORD ABOUT A YEAR AGO, DESCRIBING WHAT THEY TERMED A "HANDLING ANOMALY" WHERE THE TRUCK SHIMMIES UNCONTROLLABLY AND FAILS TO STOP SHAKING WITHIN A FEW SECONDS LIKE A "NORMAL SHIMMY". WHILE FORD ATTRIBUTES THIS TO TIRES AND SUSPENSION, I BELIEVE THIS IS THE BRAKE DEFECT THAT'S CAUSING THE SHIMMY. IT'S EASY TO TELL WHICH INDIVIDUAL CALIPER IS STICKING AS IT AND OFTEN EVEN THE WHEEL WILL BE VERY HOT TO THE TOUCH WHILE THE OTHER THREE ARE COOL. IN FACT I'VE HAD VISIBLE SMOKE COMING FROM A SINGLE BRAKE. IT SHOULD BE EASY TO INVESTIGATE THIS PROBLEM-- DRIVE MY STUPID TRUCK FOR A WEEK AND YOU'LL FIND IT. I'LL GLADLY LET YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345098July 24, 2010
STEERING
I OWN A 2005 FORD F-250 4X4. AT SLOW SPEEDS AS TAKING OFF FROM A STOP THE FRONT END SHIFTS FROM LEFT TO RIGHT SO HARD I CANNOT STEER THE TRUCK. I MUST STOP AND MOVE THE STEERING WHEEL LEFT TO RIGHT A FEW TIMES BEFORE STARTING TO MOVE AGAIN. ITS LIKE THE STEERING PUMP IS PUSHING THE STEERING WHEEL LEFT TO RIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10344878July 23, 2010
VEHICLE SPEED CONTROL
OUR BARN AND CONTENTS BURNED DOWN ON JUNE 14, 2010. FIRE INVESTIGATORS BELIEVE THE FIRE STARTED WITH OUR 2002 FORD F-250 TRUCK THAT WAS PARKED INSIDE. FOUND OUT AFTERWARDS THAT THERE IS A RECALL ON THE TRUCK FOR A SENSOR THAT CAN CAUSE FIRE EVEN WHILE VEHICLE IS NOT RUNNING. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10345471July 23, 2010
TIRES
2002 FORD F-250, EXPERIENCED A LEFT FRONT TIRE BLOWOUT THAT CAUSED DAMAGE TO THE LEFT FRONT QUARTER PANEL. *BF ACCORDING TO THE POLICE REPORT, THE TIRE WAS SHREDDED AND DAMAGED. (OHIO TRAFFIC CRASH REPORT # 10-0366-90)*JB UPDATED 08/05/10 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10344986July 23, 2010
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING
FORD 2003 F250 SPARK PLUG EJECTED CYLINDER #7 TRITON 5.4L OCCURRED TWICE. FIRST REPAIR (HELI-COIL INSERT) FAILED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10344678July 22, 2010
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2011 FORD F250 SUPER DUTY. WHILE DRIVING 40 MPH, THE BRAKES WERE APPLIED AND THE VEHICLE PULLED TO THE LEFT. THE VEHICLE WAS TAKEN TO THE DEALER WHO GROUNDED THE FRONT ROTORS, REPLACED THE FRONT CALIPERS AND BRAKE PADS, BUT THE FAILURE WASN'T CORRECTED. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED AND STATED THAT HIS CLAIM WAS ESCALATED AND SOMEONE WOULD CALL HIM. THE FAILURE MILEAGE WAS 5,600 AND THE CURRENT MILEAGE WAS 7500. UPDATED 11/19/10 *CN THE CONSUMER STATED HE IS IN THE PROCESS OF EXCHANGING THE VEHICLE, BECAUSE THE DEALER HAS BEEN UNABLE TO FIX THE PROBLEM. UPDATED 11/23/10
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250