Ford F-250 Complaints

11,199 consumer complaints on file.

#10504810March 28, 2013
STEERING, SUSPENSION
DRIVING MY 2007 F250 SD AND HIT A BUMP, FRONT END STARTED TO SHIMMY. SLOWED DOWN AND THE SHIMMY STOPPED. HAD RECEIVED A LETTER FROM FORD MOTOR COMPANY GIVING INFORMATION ABOUT THE FRONT END SHIMMY. SINCE THE FIRST INCIDENT, IT HAS OCCURED NUMEROUS TIMES. MY TRUCK IS CURRENTLY AT 87000 MILES AND THE SHIMMY HAPPENS NUMEROUS TIMES A DAY WHEN I HIT BUMPS/DIPS IN THE ROAD. DIESEL SHOP TELLS ME TO KEEP TIRES INFLATED PROPERLY, ROTATE AND BALANCE TIRES AS WELL AS PROPER ALIGNMENT AND HAVE THE STEERING DAMPNER REPLACED. STEERING DAMPNER IS BRAND NEW (3 MONTHS OLD), TIRES ARE AT PROPER INFLATION AND BALANCED AS WELL AS ALIGNMENT DONE AND THE FRONT END STILL VIBRATES, SOMETIMES VIOLENTLY TO WHERE IT IS TOUGH TO CONTROL UNTIL SPEED DROPS UNDER 40 MPH. STILL WAITING ON A FIX FOR THIS ISSUE AS THE SHIMMY IS DAILY AND IS GETTING WORSE AND I GET THE SAME TEXTBOOK ANSWER FROM FORD EVERYTIME I CALL (TIRES, INFLATION, ALIGNMENT, STEERING DAMPNER). I'M AFRAID THAT THE VIBRATION WILL GET TO THE POINT THAT PARTS WILL START BECOMING LOOSE/BREAK AND CAUSE AN ACCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504659March 27, 2013
STEERING, SUSPENSION
FORD F250 2006 4X4 SUPER DUTY LT. WHEN DRIVING AND HITTING MINOR BUMPS IN THE ROAD THE FRONT END WILL START TO SHAKE VIOLENTLY UNTIL SIGNIFICANT SPEED REDUCTION. HAS HAPPENED MULTIPLE TIMES AND CAN BE REPRODUCED. GOING TO REPLACE THE STEERING DAMPENER AS THAT IS LESS EXPENSIVE THAN TAKING IT TO THE DEALER WHO WILL NOT SAY IF THEY HAVE HEARD OF THE ISSUE. COULD BE A HUGE SAFETY ISSUE ESPECIALLY IF IT HAPPENS UNEXPECTEDLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504525March 26, 2013
SUSPENSION, STEERING
BEGAN IN 2010...DEATH WOBBLE....HITTING A BUMP,,STEERING WHEEL SHAKES VIOLENTLY.....LOSS OF CONFIDENCE IN THE ABILITY OF THE VEHICLE TO PROVIDE SAFE TRANSPORTATION.....DEALERSHIP VISIT WAS NOT HELPFUL...SAID IT WAS TIRE PRESSURE...ADDED A DIFFERENT TRAC BAR IN 2012...HELPED SOME BUT TIL PRODUCES THE WOBBLE AT LOWER SPEEDS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504269March 23, 2013
SEAT BELTS
BOUGHT THE TRUCK 2000 FORD F250 USED IN 2006 AND THE SEAT BELT RETRACTOR WOULD NOT RETRACT THE BELT WHEN NOT IN USE. THE BELT WOULD GET CAUGHT IN THE DOOR WHEN IT WAS CLOSED. I WOULD HAVE TO OPEN THE DOOR TO GET THE SEAT BELT LOOSE SO IT COULD BE USED. THIS PROBLEM MAKES USING THE SEAT BELT A MAJOR PROBLEM EACH TIME I GET INTO THE TRUCK. I BOUGHT A NEW BELT AND RETRACTOR FROM FORD FOR ABOUT $120 AND IT WORKED FOR ABOUT A MONTH AND IT BECAME THE SAME AS THE OLD SEAT BELT. THIS IS A PROBLEM ON ALL 2000 MODEL TRUCKS AND FORD WILL NOT CORRECT THE PROBLEM. THIS PROBLEM CAUSES YOU NOT TO WANT TO USE THE SEAT BELT BECAUSE OF HOW MUCH TROUBLE IT IS TO BE USED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503882March 21, 2013
STRUCTURE:BODY:DOOR, LATCHES/LOCKS/LINKAGES
MY HUSBAND DRIVES A 2006 FORD F250 SUPERCAB PICKUP TRUCK WITH APPROXIMATELY 53,000 MILES (LOW MILEAGE FOR THE YEAR OF THE TRUCK). RECENTLY, THE LATCH CABLES ON THE REAR SUICIDE DOORS BOTH BROKE WITHIN 1 MONTH OF EACH OTHER, RENDERING THE REAR DOORS COMPLETELY INOPERABLE. FROM RESEARCHING BLOGS ONLINE, THIS IS CAUSED BY A DEFECTIVE PLASTIC PART IN THE LATCH MECHANISM AND IS QUITE COMMON ON THIS TYPE FORD TRUCK DOOR. THE PARTS AND LABOR ARE QUITE COSTLY ($400 PER DOOR), AS THE WHOLE MECHANISM MUST BE REPLACED, RATHER THAN JUST THE DEFECTIVE PLASTIC PIECE. THIS IS CERTAINLY A SAFETY CONCERN, AS ANYONE IN THE REAR OF THE VEHICLE IS TRAPPED INSIDE, AS THE DOORS WILL NOT UNLATCH AND OPEN. WE WERE TOLD BY FORD CUSTOMER CARE THAT THEY WILL NOT CORRECT THIS PROBLEM AND MUST REPLACE THE LATCH WITH THE SAME TYPE LATCH CABLE THAT HAS ALREADY BROKEN (CASE # [XXX]). THERE IS NO GUARANTEE WITH THE REPLACEMENT THAT IT WILL NOT HAPPEN AGAIN AND IS QUITE A SAFETY CONCERN, ESPECIALLY IF A CHILD IS IN THE REAR SEAT, AS PASSENGERS MAY NOT BE ABLE TO EXIT DURING AN EMERGENCY. WE FEEL THIS SHOULD BE A RECALL ISSUE AND THE DEFECTIVE PIECE SHOULD BE REPLACED AT NO CHARGE. PERHAPS YOUR AGENCY CAN LOOK INTO THIS MATTER TO SEE IF THIS IS AS COMMON A PROBLEM AS IT APPEARS AND IS NOT ISOLATED TO MODEL AND YEAR OF OUR FORD TRUCK. THESE DOORS ARE COMMON ON MANY FORD TRUCKS. FORD WILL NOT PROVIDE A REMEDY OR RELIEF FOR THIS SITUATION. THANKS FOR YOUR TIME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503732March 20, 2013
EXTERIOR LIGHTING
HEAD LIGHTS ARE NOT BRIGHT DON'T PUT OUT MUCH LIGHT, THEY WERE DIM FROM DAY ONE. I HAVE ABOUT 20,000 MILES NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503543March 19, 2013
STEERING, WHEELS
I WAS DRIVING APPROXIMATELY 45 MPH WHEN I HIT A ROUGH AREA IN THE ASPHALT DURING A SLIGHT LEFT TURN. AFTER HITTING THE ROUGH AREA, THE TRUCK AND STEERING WHEEL BEGAN SHAKING VIOLENTLY. I HAD TO ALMOST STOP BEFORE THE SHAKING WOULD STOP. I PULLED OFF THE ROAD THINKING THAT MAYBE A TIRE WAS FIXING TO FALL OFF BUT EVERYTHING WAS FINE. NOW EVERY TIME I HIT A ROUGH AREA ON THE ROAD I WORRY THAT IT WILL HAPPEN AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503634March 19, 2013
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE STOP SAFELY NOW WARNING MESSAGE FLASHED ON THE INSTRUMENT PANEL. THE CONTACT MOVED OFF THE ROADWAY AND THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED AFTER THIRTY MINUTES. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE DEALER STATED THAT THE EGT EXHAUST TEMPERATURE SENSOR MALFUNCTIONED AND CAUSED THE VEHICLE TO STALL. THE DEALER REPLACED THE EXHAUST TEMPERATURE SENSOR. THE FAILURE MILEAGE WAS 1,600. ...UPDATED 04/25/13 *BF UPDATED 05/22/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503630March 19, 2013
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE WAS RESISTANT TO ACCELERATION ATTEMPTS. ADDITIONALLY, THE VEHICLE WOULD STALL AND LURCH FORWARD INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THREE DIFFERENT DEALERS FOR DIAGNOSIS. NONE OF THE TECHNICIANS WERE ABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 26,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503450March 18, 2013
SERVICE BRAKES, STEERING, SUSPENSION
THIS IS THE FIRST OF FOUR TIMES THAT I HAVE HAD TO HAVE BRAKE WORK DONE ON MY TRUCK. THREE OF THE TIMES I WAS TOLD THAT THE CALIPERS HAD FROZEN AND SO CALIPERS PADS AND (EXCEPT THIS LAST TIME) ROTORS HAD TO BE REPLACED. THIS IS ABSURD FOR A TRUCK WITH LESS THAN 45,000 MILES. UNDERSTAND THIS IS EXPENSIVE!! HAVE NEVER HAD ANYTHING LIKE THIS ON ANY OTHER VEHICLE. ALSO, I HAVE EXPERIENCED THE OFT TALKED ABOUT "DEATH WOBBLE" A FEW TIMES ON THE HIGHWAY. WAS REAR BRAKES IN 2010' FRONTS IN 2011' NOW REARS AGAIN IN 2013. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503487March 18, 2013
FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE
WHILE AT AN INTERSECTION WAITING FOR TRAFFIC TO CLEAR SO I COULD PULL ON TO THE HIGHWAY, I SMELLED GAS. I LOOKED IN MY SIDE MIRROR AND SAW GASOLINE GUSHING OUT OF MY FRONT FUEL TANK. IT WAS OBVIOUSLY UNDER PRESSURE BUT THE FUEL DOOR FORTUNATELY KEPT IT FROM SPRAYING ACROSS THE ROAD. I APPEAR TO HAVE THE SAME PROBLEM THE OTHER TWO COMPLAINT FILERS HAVE HAD AND REFERENCED THE SAME FORD RECALL CAMPAIGN OF 91V146000. IF I AM EVER ABLE TO GET THROUGH TO THE NUMBER FOR THE FORD RECALL (313) 446-4654 I AM SUPPOSED TO REFERENCE RECALL NUMBER 91S39. I AM THE ORIGINAL OWNER OF THIS TRUCK AND HAVE ONLY 22000 TOTAL MILES ON IT SO THE FAILURE CANNOT BE DUE TO MILEAGE. THIS RECALL APPLIED TO QUITE A FEW MODELS OF FORD FOR 1989. THE TWO PRIOR COMPLAINTS HAVE APPARENTLY BEEN IGNORED-------PROBABLY NOT ENOUGH 1989'S AROUND TO REALLY WORRY ABOUT UNLESS SOMEBODY GETS KILLED AT WHICH TIME I HOPE SOMEBODY REMEMBERS THIS WEBSITE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503507March 18, 2013
STEERING, SUSPENSION
TRAVELED OVER A MINOR ROAD IMPERFECTION IMMEDIATELY THE TRUCK BECAME UNCONTROLLABLE IT FELT AS THOUGH ALL FOUR TIRES BLEW. PULLED TO THE SIDE OF THE ROAD AND CHECKED TIRES AND SUSPENSION, NOT FINDING ANYTHING I QUESTIONED MY SANITY AND PROCEEDED UP THE ROAD WITHIN A FEW MINUTES I AGAIN TRAVELED OVER A MINOR ROAD IMPERFECTION ONCE AGAIN THE TRUCK IMMEDIATELY BECAME EXTREMELY DIFFICULT TO CONTROL. I PULLED TO THE SIDE OF THE ROAD AND CALLED FOR A TOW TRUCK. THE FORD DEALER ADVISES ME THAT THE BUSHINGS AND OTHER COMPONENTS RELATED TO THE STEERING STABILIZER NEED TO BE REPLACED AT A COST OF $700. I MADE THE TECHNICIAN AWARE THAT MY PROBLEM IS SIMILAR TO MANY OTHER INTERNET DOCUMENTED INCIDENTS INVOLVING FORD STEERING COMPONENTS AND THAT I RECENTLY RECEIVED A LETTER FROM A LEMON LAW ATTORNEY CITING THIS VERY SAME CONDITION. FORD WILL OFFER NO ASSISTANCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503173March 15, 2013
STEERING
TL* THE CONTACT OWNS A 2006 FORD F250 SUPERDUTY. THE CONTACT STATED THAT WHEN DRIVING BETWEEN 30-60 MPH OR WHEN DRIVING OVER AN UNEVEN ROAD SURFACE, THE VEHICLE WOULD SHAKE UNCONTROLLABLY. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE TIRES WERE REPLACED, BALANCED AND ALIGNED SEVERAL TIMES HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503219March 15, 2013
STEERING, SUSPENSION
WHILE DRIVING 60 MPH, TRUCK HIT IRREGULARITIES IN THE ROAD. VEHICLE STARTED SHAKING VIOLENTLY AND LOST CONTROL OF THE STEERING. VEHICLE HAD TO BE SLOWED TO 10-15 MPH BEFORE THE SHAKING STOPPED. NO ACCIDENT OR INJURY OCCURRED ON THIS INCIDENT. TRUCK WAS TAKEN TO DEALER AND TRACK BAR ASSY / BUSHING WAS REPLACED. THE SECOND SERIOUS INCIDENT WAS @ 48,000 MILES A MERE 11,000 MILES LATER. WHILE TRAVELING 55-60 MPH THROUGH A LEFT HAND CURVE AND CROSSING ANOTHER IRREGULARITY IN THE ROAD (BRIDGE-PAVEMENT JOINT) THE TRUCK AGAIN BEGAN SHAKING VIOLENTLY AND CAUSED THE VEHICLE TO GO INTO THE ONCOMING LANE OF TRAFFIC WHERE A LOG TRUCK WAS TRAVELING. THE LOG TRUCK WAS ABLE TO GET ON THE SHOULDER OF THE ROAD IN TIME TO PREVENT AN ACCIDENT. AGAIN THE TRUCK HAD TO BE SLOWED TO ALMOST A COMPLETE STOP BEFORE THE SHAKING STOPPED. TRUCK WAS TAKEN TO DEALER AGAIN AND THE ONLY THING REPLACED WAS THE TRACK BAR BUSHING. THIS VEHICLE IS NOT SAFE! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502810March 14, 2013
ENGINE
#5 SPARKPLUG SHOT OUT OF THE HEAD WHEN STARTING VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502473March 12, 2013
ENGINE
THE 2011 F250 SUPER DUTY HAS EXPERIENCED THREE INSTANCES OF STALLING OUT AT RANDOM TIMES. THE FIRST INCIDENT ON FEBRUARY 13TH RESULTED IN DAMAGE TO THE TRUCK THROUGH VEHICLE PIPES FROM ANOTHER VEHICLE FLYING LOOSE OFF THE TOP RACK AND HITTING THE VEHICLE. THIS RESULTED IN DAMAGE TO THE VEHICLE. IN THE 30 DAYS SINCE THEN, THERE HAVE BEEN TWO OTHER INSTANCES OF RANDOM STALLS AND ENGINE SHUT DOWN THAT HAVE OCCURRED. IT REQUIRES A RESTART OF THE ENGINE. THE DEALERSHIP HAS HAD THE VEHICLE ON MULTIPLE OCCASIONS BUT HAS NOT BEEN ABLE TO DIAGNOSE THE CAUSE OF THE RANDOM SHUT DOWN. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10502520March 12, 2013
STEERING, SUSPENSION, WHEELS
I WAS DRIVING MY 2009 F-250 TRAVELING ABOUT 40 TO 45 MPH AND AFTER HITTING A ROUGH PATCH OF ROAD THE WHEELS BEGAN TO SHAKE OUT OF CONTROL FOR ABOUT 20 SECONDS. I HAVE HAD MY TRUCK TO THE DEALERSHIP FOR THE SAME PROBLEM ON 6 PLUS TIMES. FORD STATES THAT IT WAS A TIRE PRESSURE ISSUE.......BS!.... BS! EACH TIME FORD HAS MY TRUCK THEY SAY WE HAVE FIXED THE PROBLEM AND IT SHOULD NOT OCCUR AGAIN. THE LAST TIME I LEFT FORD AND SPENT 165.00$ ON A DAMPER ROD TO FIX THIS PROBLEM I DROVE 18 MILES DOWN THE ROAD AND WENT INTO A "DEATH WOBBLE AGAIN. I TURNED THE TRUCK AROUND AND IT IS SITTING AT FORD AS I WRITE THIS POST. AFTER REVIEWING THIS MATTER ON LINE I HAVE NOTICED THAT THERE ARE MORE F-250'S WITH THE SAME ISSUE. A FEDERAL RECALL NEEDS TO BE DONE AND FAST. SEVERAL TIMES THAT THE "DEATH WOBBLE " AS OCCURRED TO ME , I HAVE BEEN LUCKY SO FAR TO DRIVE OUT OF IT WITH OUT A PROBLEM. I MIGHT NOT BE SO LUCKY NEXT TIME. A FEDERAL RECALL NEEDS TO BE DONE FAST!!!!!!!!!!!!!!!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502532March 12, 2013
SUSPENSION, STEERING
EXPERIENCED VIOLENT SHAKING OF FRONT WHEELS AND STEERING AFTER DRIVING OVER A BUMP IN ROAD BECAUSE OF CHANGE IN PAVEMENT ON FLY-OVER PASS. VEHICLE WAS UNCONTROLLABLE AND HAD A TREMENDOUS VIBRATION IN THE FRONT END. HAD TO REDUCE SPEED TO A NEAR STOP ON INTERSTATE HIGHWAY TO GET SHAKING TO STOP AND TO RE-GAIN CONTROL OF VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10501876March 6, 2013
VEHICLE SPEED CONTROL
2011 FORD F250 CREWCAB FX4 6.7L DIESEL ENGINE. SOMETIMES YOU PUSH ON THE GAS AND NOTHING HAPPENS AND IT TAKES A FEW SECONDS AND IT KICKS IN AND GOES. TOWING A FIFTH WHEEL THRU A STOP SIGN WITH A 18 WHEELER BEARIG DOWN ON YOU SUCKS. ALMOST DIDN'T MAKE IT OUT OF THE WAY. THIS HAPPEN TWICE IN ONE DAY. THE DEALER HEARD NOISE FROM MY FUEL PUMP SO THE THEY CHANGED THE FUEL FILTERS AND I HAD A RECALL FOR SOME COMPUTER UPGRADE DATA THINGY. I ONLY HAVE 24K MILES AND THIS HAS HAPPENED A FEW OTHER TIMES WITHOUT A LOAD ON IT (TOWING OR NOT). DID I JUST SPEND $61,000 ON A DEATH TRAP?? AT THE DIESEL STOP.COM WEBSITE, THERE ARE MANY OTHER PEOPLE WITH THIS SAME PROBLEM. I HAVE TAKEN MY VEHICLE IN TO A DEALER AND THEY SAY "CAN NOT DUPLICATE" BUT THIS HAPPENS EVERY NOW AND THEN. ONE PERSON ON THAT FORUM WAS ABLE TO TAKE A FORD MECHANIC DRIVING WITH HIM AND WAS ABLE TO DUPLICATE THE PROBLEM BUT LATER THE MECHANIC SAID NOTHING WAS WRONG. SOUNDS LIKE A COVER UP TO ME. WHAT SHOULD I DO?? JUST KEEP TAKING MY TRUCK IN TO THE DEALER? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10500992March 1, 2013
STEERING
STEERING IS HORRIBLE IN THESE TRUCKS! FORD SHOULD BE ASHAMED. THERE IS PLAY IN THE STEERING. DRIVING STRAIGHT DOWN THE ROAD THE STEERING WHEEL CAN EXHIBIT 1/4 TURN OF PLAY EITHER RIGHT OR LEFT, BUT THE TIRES AND TRUCK ARE STRAIGHT! NOW IF THAT'S NOT UNSAFE, I DON'T KNOW WHAT IS! I HAVE NO LIFT, AND STOCK TIRES. THE ALIGNMENT IS STRAIGHT. I HAVE FOUND NUMEROUS COMPLAINTS ON FORUMS OF STEERING GEAR PROBLEMS. I HAD MY STEERING LOOKED AT AND MECHANICS ARE CLUELESS. THIS IS A FORD TRUCK PROBLEM THAT HAS BEEN AN ISSUE FOR YEARS. STEERING SHOULD BE TIGHT AND PRECISE NOT SLOPPY. I AM BEGGING THE NHTSA TO AT LEAST LOOK INTO THESE, THIS MATTER IS WORTHY OF YOUR TIME AND I AM SURE AN INVESTIGATION WILL REVEAL NUMEROUS COMPLAINTS OF STEERING BOXES THAT GO LOOSE OR WEAR PREMATURELY AND STEERING COMPONENTS THAT BREAK. I AM SURE FORD HAS RECORDS OF THOUSANDS OF COMPLAINTS AND REPAIRS ON THIS BECAUSE ITS BEEN A PROBLEM FOR YEARS AND CONTINUES TO BE A PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250