Ford F-250 Complaints

11,199 consumer complaints on file.

#10615287July 22, 2014
VEHICLE SPEED CONTROL
AS I PULLED AWAY FROM A STOP SIGN I THROTTLED UP TO REACH THE APPROPRIATE SPEED LIMIT AND MY 2006 FORD F250 6.0 WENT WIDE OPEN THROTTLE OUT OF NOWHERE. I MASHED ON MY BRAKES TO TRY TO SLOW THE TRUCK DOWN, TO NO SUCCESS. I FLASHED MY LIGHTS AND STROBE LIGHTS AT ON COMING TRAFFIC AS WELL AS BLEW THE HORN TO MAKE OTHER DRIVERS AWARE THAT I COULD NOT STOP. LUCK BEING AGAINST ME THIS DAY THE FIRST VEHICLE I APPROACHED WAS A NC STATE TROOPER. I HAD TO TURN OFF MY IGNITION TO STOP THE TRUCK BUT THE ENGINE KEPT RUNNING AT 4500 RPM SO I SLAMMED IT IN PARK. THE STATE TROOPER GAVE ME A TICKET FOR PASSING HIM AT 80MPH IN A 45. KEEP IN MIND THAT MY TRUCK IS EQUIPPED WITH AN SCT LIVEWIRE TUNER, SO WHEN IT OPENED UP IT LAUNCHED LIKE A ROCKET. THIS IS THE SECOND TIME I'VE HAD THE THROTTLE ISSUE, THE FIRST TIME WAS THE SAME CASE EXCEPT I DID NOT HAD A TUNE ON THE VEHICLE. THERE HAS BEEN SEVERAL REPORTED CASES OF THIS HAPPENING, WITH AND WITHOUT TUNERS ON THE VEHICLE. PLEASE SHARE YOUR INSIGHT IF ANY ONE KNOWS THE CAUSE OF THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10615305July 22, 2014
STEERING
THE FRONT STARTED VIBRATING VIOLENTLY, ONLY STOPPED AFTER SLOWING SIGNIFICANTLY. THE PROBLEM WAS FINALLY DIAGNOSED AS STEERING DAMPENER. THE SERVICE DEPARTMENT WAS FAMILIAR WITH THIS PROBLEM AS THE "DEATH WOBBLE". THIS HAS BEEN "REPAIRED" THREE TIMES AND IS NOW RECURRING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10615330July 22, 2014
ENGINE, POWER TRAIN
STOP SAFELY NOW: WHEN THIS HAPPENS THE ENGINE WILL SHUT OFF AND YOU HAVE TO ROLL AS FAR AS YOU CAN TO HOPEFULLY GET OFF THE HIGHWAY. I AM AN EXPERIENCED MECHANIC AND DRIVER OF "NOT SO GREAT RUNNING VEHICLES" AS I HAVE TEST AND TUNE THEM TO SEE WHAT THE ISSUE IS TO REPAIR THEM. E.G. NO BRAKES, NO POWER STEERING, NON WORKING FUEL PUMPS...ETC. WITH THAT SAID, I DO NOT THINK AN INEXPERIENCED DRIVER OF A NON WORKING VEHICLE WOULD DO SO WELL IN THIS SITUATION AND COULD END UP POSSIBLY HARMING OTHERS AS A RESULT. I JUST KNEW FOR SURE THIS WOULD BE ON THE RECALL LIST FOR SAFETY ISSUES AND TO FIND OUT FORD HAS ISSUED A RECALL FOR "EMERGENCY VEHICLES ONLY". MY QUESTION IS... WHO SAYS A PERSONAL VEHICLE IS NOT EVER GOING TO BE AN EMERGENCY VEHICLE FOR YOUR FAMILY, FRIEND OR A COWORKER. COME ON FORD, IF YOUR CUSTOMERS BUY A 65,000 TRUCK SHOULDN'T THEY HAVE THE COMFORT OF TRUSTING THE VEHICLE WILL NOT STRAND THEM DEAD IN THE MIDDLE OF A HIGHWAY OR STOP RUNNING IF THEY ARE TAKING SOMEONE TO THE ER... FORD DID REPAIR MY TRUCK UNDER WARRANTY, BUT, I THINK THIS COULD HAVE ALL BEEN AVOIDED IF THE RECALL WAS OUT FOR ALL VEHICLES WITH THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10614915July 21, 2014
STEERING
TL* THE CONTACT OWNS A 2009 FORD F-250. THE CONTACT STATED WHILE DRIVING OVER A BUMP AT APPROXIMATELY 65 MPH, THE VEHICLE BEGAN SHAKING AND SWERVED INTO ANOTHER LANE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. HOWEVER, ALL FOUR TIRES WERE REPLACED ON FOUR OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10614506July 18, 2014
SUSPENSION, STEERING
THE VEHICLE INVOLVED IS A 2009 F-250XL 4X4 W/8'BOX, EQUIPED FROM FACTORY WITH THE CAMPER SUSPENSION & SNOW PLOW SUSPENSION PACKAGES. NOTE THAT THE TRUCK HAS NEVER CARRIED NOR PULLED A CAMPER NOR HAS IT EVER PUSHED A SNOW PLOW. IT WAS PURCHASED IN 1010 AND CURRENTLY HAS 55XXX MILES ON IT AS A PASSENGER CARRIER. TIRE PRESSURE MONITORING SYSTEM IS FACTORY UNIT. CURRENT TIRE PRESSURE IS AT PROPPER INFLATION. WHILE DRIVING DOWN A ROAD THAT COULD BE CALLED ROUGH THE FRONT END WENT INTO A SEVERE SHIMMY/WOBBLE. CONTROL WAS OBTAINED WITHOUT INCIDENT ONLY DUE TO NO OTHER VEHICLE IN PROXIMITY. THIS OCCURED SEVERAL TIMES SINCE THAT FIRST EPISODE. I HAD MY MECHANIC CHECK THE FRONT END COMPONENTS THAT NORMALLY CAUSE SUCH EVENTS AND ALL WAS TIGHT AND APPEARED O.K., HE DID RECOMMEND THAT I REPLACE MY SHOCKS AND STEERING STABILIZER. THIS WAS DONE BY MY MECHANIC ON 07-07-14 WITH BILSTEIN SHOCKS AND STABILIZER. THE PROBLEM WITH SEVERE SHIMMY/WOBBLE WAS EXPERIENCED 3 TIMES ON THE TRIP HOME ON A ROUGH ROAD. SHIMMY WAS SEVERE ENOUGH TO REQUIRE GREAT EFFORT TO REGAIN CONTROL OF VEHICLE TO PREVENT A RUN OFF THE ROAD INCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10614592July 18, 2014
STEERING, WHEELS
HIT ROUGH PATCH ON HIGHWAY AND TRUCK STARTED SHAKING VIOLENTLY. HAD TO SLOW TO ABOUT 25 MPH BEFORE IT STOPPED. THIS HAS HAPPENED TWICE IN THE LAST 6 MONTHS. THE FORD SERVICE DEPARTMENT SAID THEY COULD FIND NO ISSUES WITH THE TRUCK. NO PARTS WERE REPLACED OR ADJUSTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610938July 16, 2014
AIR BAGS, STRUCTURE:BODY
COLLIED WITH A VEHICLE STOPPING TO MAKE A LEFT HAND TURN. DAMAGES INCLUDE FRAME DAMAGE, SMASHED IN FRONT END. HAD TO KICK THE DRIVER DOOR OPEN TO GET OUT. NO AIRBAGS EVER DEPLOYED. ENDED UP WITH HEAD LACERATIONS. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10610977July 16, 2014
STEERING
LOUD POP NOISE ON DRIVERS SIDE FELT THROUGH FLOORBOARD. STEERING BECAME ERRATIC WITH TRUCK VEERING LEFT TO RIGHT AND VERY DIFFICULT TO KEEP IN LANE. IF IT HAPPENED AT HIGHWAY SPEEDS I WOULD HAVE GONE OFF THE ROAD FOR SURE. TOOK VEHICLE IN FOR ALIGNMENT AND FRONT END INSPECTION AND NOTHING FOUND OUT OF ORDER. DAY AFTER THAT IT DID IT AGAIN. JUST CAME BACK HOME NOW AND IT DID IT AGAIN WITH A POLICE OFFICER BEHIND ME. HE FOLLOWED ME TO MY HOUSE AND THOUGHT I HAD BEEN DRINKING BECAUSE OF THE WAY THE VEHICLE APPEARED TO BE OUT OF CONTROL AT ONLY 20MPH. I'M SCARED TO DRIVE NOW BECAUSE THE FREQUENCIES BETWEEN NORMAL AND NOT ARE SHORTENING.VEHICLE SUSPENSION IS NOT MODIFIED FROM STOCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10611014July 16, 2014
ENGINE, SUSPENSION, EXTERIOR LIGHTING
GOING 55MPH THE TRUCK STARTS SHAKING AND SHIMMING. ALL LIGHTS GO IN AND OUT AND BLOWS WHENEVER ANYTHING IS HOOKED UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610741July 15, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE CAUSED THE FAILURE TO OCCUR AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER:05V26600 (FUEL SYSTEM,GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 105,669. UPDATED 02/12/15*LJ UPDATED 08/24/2017*CT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610443July 14, 2014
SEAT BELTS
DRIVER SIDE SEAT BELTS WILL NOT RETRACT AUTOMATICALLY CAUSING CONCERN BELT WOULD FAIL TO WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610495July 14, 2014
STEERING
TL* THE CONTACT OWNS A 2008 FORD F-250. THE CONTACT STATED THAT THE STEERING WAS SLUGGISH AND, WHILE MAKING A TURN, THE STEERING WHEEL BECAME STUCK IN THE TURN POSITION. AN INDEPENDENT MECHANIC WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609630July 10, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STALLED AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THERE WERE NO WARNING LIGHTS THAT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD WHERE THE CONTACT NOTICED THAT DIESEL FLUID WAS POURING OUT FROM UNDER THE HOOD. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 21,799 AND THE CURRENT MILEAGE WAS 22,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609228July 9, 2014
TIRES, TIRES:TREAD/BELT
KUMHO KL78 245/75R16 LOAD RANGE E TIRE. PURCHASED A SET OF KL78 TIRES IN NOVEMBER 2011 FOR MY 3/4 TRUCK. SINCE THE TIME OF PURCHASE I HAVE PUT LESS THAN 20,000 MILES ON THE TRUCK / TIRES. THREE OF THE TIRES HAVE DEVELOPED LARGE DEFORMATION ACROSS THE TREAD CAP, LIKE A BULGE. THIS IS A MANUFACTURING SAFETY DEFECT CAUSED BY THE SEPARATION OF STEEL BELTS OF THE TIRE ALLOWING THE RUBBER TO DEFORM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10608013July 3, 2014
STEERING, SUSPENSION, WHEELS
NEW 2012 FORD F250, SUPER DUTY, 4X4, CREW CAB TRUCK, PURCHASED 11/2013. APPROX. 1 MONTH PRIOR, THE TRUCK BEGAN HAVING A VIBRATION AT HIGHWAY SPEEDS (75% HIGHWAY DRIVING, 25% CITY). THE VIBRATION GOT WORSE OVER THE COURSE OF A DAY. THE 2ND DAY THE FRONT PASSENGER TIRE EXHIBITED A LARGE BULGE (TREAD SEPARATION) ON THE INSIDE TWO TREAD GROOVES. FORD REPLACED THE TIRE, WITH ANOTHER OF THE SAME BRAND AND MODEL. ON 6/30/2014, THE FRONT DRIVER TIRE, WITH NO WARNING, DEVELOPED THE SAME ISSUE, A LARGE BULGE IN THE INSIDE TREAD GROOVES. THE TIRES ARE CONTINENTAL CONTITRAC LT275/65R18 123/120S TIRES, DOT# A3B9 479B 2511. BOTH TIRES HAD VERY LITTLE TIRE WEAR AND THE WEAR WAS EVEN ACROSS THE TIRE SURFACE, THE TIRES SHOWED NO SIGN OF POTENTIAL FAILURE. I DID GET TO SEE THE INSIDE OF THE SECOND FAILED TIRE, THERE DID NOT APPEAR TO BE ANY DAMAGE EXCEPT THE CORD SEPARATION WHICH WAS NOT VISIBLE FROM EITHER THE INSIDE OR OUTSIDE OF THE TIRE; I DID TAKE PHOTOS. I CONTACTED FORD'S CORPORATE NUMBER AND AWAITING A CALL FROM THE DEALER'S SERVICE MANAGER, AND REGIONAL SERVICE MANAGER IN REFERENCE TO THIS SAFETY CONCERN. FORD DID STATE THEY WOULD CONTACT NHTSA; FORD REFERENCE NUMBER CAS04645143-Z4T8T9. EACH TIME I HAVE TO REPLACE THE CONTINENTAL TIRE UNDER WARRANTY FORD HAS TO LOCATE THE TIRE AND IT IS NOT EASY TO LOCATE. IN ADDITION, EVERY NEW FORD F250 ON THE DEALERS LOT HAS ANOTHER NAME BRAND TIRE, WHICH I BELIEVE INDICATES FORD HAS ISSUE WITH THE CONTINENTAL TIRES. I SEARCHED THE NHTSA DATA BASE AND FOUND ALMOST THE EXACT SAME INCIDENT; NHTSA ID# 10568111. I ALSO FOUND NUMEROUS SIMILAR COMPLAINTS ABOUT THE TIRE MODEL. I ATTEMPTED TO CONTACT CONTINENTAL, CASE #[XXX], THE CALL TAKER READ FROM A SCRIPT AND COULD OFFER NO HELP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10608085July 3, 2014
EQUIPMENT ADAPTIVE/MOBILITY, TRAILER HITCHES
WHEN TOWING A TRAVEL TRAILER SOMETHING SEEMS TO BE BENDING HITCH PINS SLIGHTLY. THIS IS UNNERVING TO SAY THE LEAST. IT APPEARS THIS COULD BE A SAFETY ISSUE IF THE PIN FAILS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10607693July 2, 2014
SUSPENSION, STEERING
TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH ON UNEVEN ROAD PAVEMENT, THE VEHICLE STARTED TO VIBRATE. THE CONTACT ALSO STATED THAT HE REDUCED THE SPEED TO 10 MPH, THE VIBRATION STOPPED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT ALL FOUR TIRES NEEDED TO BE REPLACED AND BALANCED. THE TECHNICIAN ALSO ALIGNED BOTH FRONT DRIVERS AND PASSENGERS SIDE TIRES. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10607347July 1, 2014
SUSPENSION, STEERING
ON MY DAILY COMMUTE TO WORK I EXPERIENCED WHAT I HAVE LATER RESEARCHED TO FIND OUT IS CALLED THE "DEATH WOBBLE". THE FIRST OCCURRENCE HAPPENED WHILE MAINTAINING A SPEED OF APPROXIMATELY 55 MPH WHICH WAS THE SUGGESTED ROAD SPEED LIMIT, AFTER RIDING OVER A SMALL BUMP IN THE ROAD MY FRONT LEFT END INITIATED INTO A VIOLENT SHAKING SENSATION THAT FELT AS THOUGH I HAD JUST BLOWN A TIRE. AFTER REDUCING MY SPEED ABRUPTLY AND NEARLY BEING REAR ENDED THE FRONT END REGAINED ITS CONTROL AND I CONTINUED AND ARRIVED SAFELY TO WORK AFTER REDUCING MY SPEED TO 45 MPH. I LOOKED IN THE WHEEL HUB AND UNDERNEATH BUT DID NOT SEE ANYTHING OUT OF THE ORDINARY FROM PLANE SIGHT. I EXPERIENCED THE VIOLENT SHAKING ON MULTIPLE OCCASIONS, DIFFERENT LOCATIONS AND FOUND MYSELF EXPERIENCING IT MORE AND MORE AT LOWER SPEEDS AND ON SMALLER ROAD BUMPS/POT HOLES. AFTER DAY 2 I SCHEDULED AN APPOINTMENT FOR 6/30/14 WITH FORD SERVICE TO HAVE THE REPAIR & DIAGNOSES. THE NEXT DAY 6/27/14 WE HAD TO EVACUATE OUR JOB SITE IN LOUISIANA DUE TO EXTREME WEATHER CONDITIONS AND POSSIBLE TORNADOS, ON MY COMMUTE HOME, THE SO CALLED DEATH WOBBLE OCCURRED AGAIN AND THIS TIME RESULTED IN LOOSING CONTROL AND CRASHING INTO A SMALL TREE BECAUSE OF THE VIOLENT SHAKING AND NECESSARY BRAKING TO REGAIN CONTROL. I WAS ABLE TO ESCAPE WITH MINOR DAMAGES TO MY FRONT BUMPER. FORD IS HAVING TO REPLACE MY BALL JOINTS, BEARINGS AND TIE BAR THAT WILL COST WELL OVER $600 IN REPAIRS EXCLUDING A NEW FRONT BUMPER THAT I CANNOT AFFORD TO FIX. I'M AFRAID THIS COULD RESULT IN A SERIOUS INJURY/FATALITY IF NOT RECALLED AND FIXED. HAD I GONE INTO INCOMING TRAFFIC IT COULD HAVE BEEN MY LIFE OR THEIRS AND I WOULD THINK FORD WOULD BE FULLY RESPONSIBLE. THERE ARE HUNDREDS OF SIMILAR CASES FROM OLDER MODELS AND EVEN NEWER UP TO 2013, MINE IS A F-250 2008. HTTP://WWW.TOPIX.COM/FORUM/AUTOS/FORD-F-250-SUPER-DUTY/TOHP1M75VBFBFT9IL/P5. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10606370June 26, 2014
STEERING
I WAS DRIVING DOWN A GRAVEL ROAD AT 35 MPH WHEN MY POWER STEERING WENT OUT. I WAS ABLE TO COME TO A STOP BUT HAD TO BE TOWED HOME. UPON INSPECTION OF THE VEHICLE, IT WAS DETERMINED THE GEAR BOX HAS FAILED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10605664June 24, 2014
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 45-50 MPH, THE VEHICLE STALLED AFTER THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND CURRENT WAS 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250