Ford F-250 Complaints

11,199 consumer complaints on file.

#10776467September 24, 2015
SUSPENSION
TL* THE CONTACT OWNS A 2012 FORD F-250. WHILE DRIVING APPROXIMATELY 60 MPH, THERE WAS A BUMP IN THE ROAD THAT CAUSED THE VEHICLE TO WOBBLE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE STEERING BOX, STABILIZER, AND DRAG LINK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10775358September 23, 2015
STEERING
TL* THE CONTACT OWNS A 1992 FORD F-250. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STARTED TO SHAKE. WHEN THE SPEED DECREASED TO 20 MPH, THE VEHICLE STOPPED SHAKING. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. UPDATED 02/12/16*LJ *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10775437September 23, 2015
UNKNOWN OR OTHER
WE WERE TRAVELLING THRU NEW MEXICO ON OUR WAY HOME TO ARIZONA WHEN WE FELT A VIBRATION IN THE FRONT END. HAVING EXPERIENCED A SEPARATED CORD IN ONE OF OUR TIRES IN MAY OF 2015 AT 15,000 MILES (SEVERAL MONTHS EARLIER), WE SUSPECTED A TIRE. WE PULLED OFF AT A REST STOP BUT COULD NOT SEE A PROBLEM. WE WENT 50 MILES FURTHER AT A REDUCED RATE OF SPEED TO GET OURSELVES OFF THE ROAD AND NEAR A SERVICE FACILITY. WE PULLED OFF THE ROAD AND CHECKED THE TIRES AGAIN AND DISCOVERED A RAISED AREA IN THE RIGHT FRONT TIRE, SIMILAR TO THE TIRE THAT FAILED AT 15,0000 MILES. THE SECOND TIRE TO SEPARATE HAS ABOUT 23,000 MILES ON IT. I AM BEGINNING TO SERIOUSLY QUESTION THE QUALITY AND SAFETY OF CONTINENTAL TIRES ON OUR F-250. HAD WE NOT BEEN AWARE OF THE POSSIBILITY OF A FAILED TIRE AND HAD NOT PULLED OFF THE ROAD, WE COULD HAVE EXPERIENCED A BLOWOUT AND A SERIOUS ACCIDENT. WHEN THE FIRST TIRE WAS SEPARATED WE ASKED THE DEALER TO REPLACE ALL OF THE TIRES AS WE SUSPECTED THEY WERE ALL MADE IN THE SAME LOT/BATCH. THE DEALER WOULD NOT REPLACE THEM AND SO WE TOOK A CHANCE THAT THE REST WERE OK (THESE ARE ALL TIRES THAT WERE ON THE VEHICLE WHEN WE PURCHASED IT NEW TWO YEARS AGO). SEEMS THERE WAS A SIMILAR FLAW ON THE F-250 TIRES IN 2008/2009 . LAWYERS SAY IT IS THE MANUFACTURER'S FAULT: TIRE DEFECTS ARE DUE TO PERHAPS MOST COMMONLY, INEFFECTIVE ADHESION, USUALLY AS A RESULT OF THE GLUES AGE OR POOR BONDING OF TIRE COMPONENTS DURING THE MANUFACTURING PROCESS. WHEN TIRES ARE BEING MADE, MOISTURE, IMPURITIES, AND OTHER FOREIGN MATERIALS ARE CAPABLE OF ENTERING THE MIX AND GET CURED INTO THE TIRE. TIRE MANUFACTURERS HAVE KNOWN ABOUT THESE TYPES OF PROBLEMS FOR YEARS, BUT HAVE FAILED TO CORRECT THEM, OR TO USE BETTER DESIGNS LESS PRONE TO FAILURE, LIKE IMPROVING SKIN STOCK, WHICH CAN BETTER BOND RUBBER TO THE STEEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10767463September 22, 2015
SEAT BELTS
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT VARIOUS SPEEDS, THE FRONT PASSENGER SIDE SEAT BELT BECAME DETACHED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE HAD ALREADY BEEN THROUGH A RECALL AND THERE WAS NO DEFECT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300,000....UPDATED 01/07/16 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10766371September 21, 2015
FUEL/PROPULSION SYSTEM
FUEL SPILLS FROM REAR TANK WHEN FUELING FRONT TANK. ENGINE SPUTTERS AND QUITS WHILE RUNNING DUE TO FUEL PRESSURE FAILURE..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10765447September 20, 2015
STEERING
DRIVING DOWN THE FREEWAY. HIT A SMALL POTHOLE ON THE HIGHWAY AND LOST CONTROL OF THE VEHICLE DUE TO A "DEATH WOBBLE" THAT FELT LIKE IT WAS FROM THE FRONT END. IT FELT LIKE THE FRONT OF THE TRUCK WAS GOING TO BE RIPPED OFF.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10765160September 18, 2015
UNKNOWN OR OTHER
I AM NOT SURE ABOUT THE SAFETY ISSUE, BUT I WANT THIS ON RECORD. FORD MOTOR COMPANY IS SELLING FORD F-250 WITH SUB PAR AIR CONDITIONING PARTS. I SENT MY TRUCK TO ESTABROOK FORD IN PASCAGOULA MS BECAUSE OF A FOUL SMELL. I WAS TOLD THAT MY "EVAPORATOR INSIDE THE CAB IS LEAKING FREON." THE SERVICE MANAGER TELLS ME THIS HAPPENS ALL OF THE TIME. HE SAID WE HAVE TO TAKE YOUR DASH OUT AND REPLACE IT. "DON'T WORRY ABOUT ANY RATTLES OR ANYTHING LIKE THAT, OUR MECHANIC HAS GOTTEN PRETTY GOOD AT REPLACING THESE. ALL OF THE FIRE DEPT. HAD TO HAVE THEM REPLACED. I HAVE SEEN SOME WITH AS LOW AS 3000 MILES ON THEM GO OUT." I WOULD THINK THAT LEAKING ALL OF THAT FREON IS DANGEROUS TO THE ENVIRONMENT, AND HUMANS INSIDE THE CABS OF THE VEHICLES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10765687September 17, 2015
TIRES
CPSC: I1590170A. 2008 FORD F-250. CONSUMER STATED THAT ON TWO DIFFERENT OCCASIONS THE TIRES FAILED. *LN THE CONSUMER STATED THE PASSENGER SIDE REAR TIRE TREAD SEPARATED AS A PORTION OF THE TREAD BEGAN PEELING OFF WHILE DRIVING. THE NEXT MONTH, THE DRIVER'S SIDE REAR TIRE FAILED WHILE DRIVING ON THE INTERSTATE AND CAUSED NEARLY $3,00 IN DAMAGE TO THE TRUCK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763975September 15, 2015
SERVICE BRAKES
FORD DEALER REVIEWED SQUEALING AND DETERMINED THE BRAKE CALIPERS WERE STICKING. THIS PROBLEM IS NOTED IN A TECH SERVICE BULLETIN FROM FORD FOR MODEL YEAR 2011. DEALER INDICATED THIS PROBLEM HAS BEEN NOTICED ON OTHER F250 MODEL YEAR 2012 BUT NO TSB FROM FORD. DEALER REPLACED CALIPERS ON ALL WHEELS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763419September 13, 2015
SEAT BELTS, SERVICE BRAKES, AIR BAGS
I WAS DRIVING MY FORD 250 ON A SLICK ROAD WHEN A PICK UP STOPPED SHORT IN FRONT OF ME. I WAS UNABLE TO STOP IN TIME HITTING THE REAR END OF THE PICK UP APPROXIMATELY 20-30 MPH. MY AIR BAGS DID NOT DEPLOY AND THE SEAT BELT ALLOWED ME TO SLIDE UNDER THE BELT CAUSING MY KNEES TO HIT THE DASH. OTHER THEN GOOD BRUISES AND MILD SORENESS I WAS FINE. THE OTHER PERSON WAS FINE AS WELL. MY SEAT BELT DID NOT ENGAGE AND I AM WONDERING WHY MY AIRBAGS DID NOT DEPLOY. THE GRILL AND RADIATOR WERE DAMAGED?
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10763067September 11, 2015
SERVICE BRAKES
TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE ATTEMPTING TO STOP THE VEHICLE, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD AND THE VEHICLE FAILED TO STOP. THE CONTACT DISCOVERED BRAKE FLUID WAS LEAKING UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE LINES WERE CORRODED, CAUSING BRAKE FLUID TO LEAK FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763094September 11, 2015
SERVICE BRAKES
TL* THE CONTACT OWNS A 1999 FORD F 250. WHILE DRIVING APPROXIMATELY 5 MPH AND MAKING A LEFT TURN, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO DECELERATE WITHOUT WARNING. THE CONTACT OBSERVED THAT THERE WAS FUEL LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 180,000. UPDATED 11/23/15*LJ *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763175September 11, 2015
STEERING
TL* THE CONTACT OWNS A 2007 FORD F-250. WHILE DRIVING AT 30 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE AND IT VEERED TO THE LEFT AND RIGHT. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE STEERING BOX NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE STEERING BOX NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763265September 11, 2015
TIRES
WE OWN A 2008 FORD F-250 SUPER DUTY TRUCK WITH BF GOODRICH RUGGED TERRAIN T/A TIRES. ON OR ABOUT 7/5/15, THE PASSENGER SIDE REAR TIRE DEVELOPED TREAD FAILURE AS A PORTION OF THE TIRE TREAD BEGAN PEELING OFF WHILE TRAVELING ON I-75. A SPARE TIRE WAS PUT ON AND THE TIRE WAS REPLACED AND A WARRANTY CLAIM WAS SUBMITTED AS IT WAS STILL UNDER THE TREAD WARRANTY. ON OR ABOUT 8/21/15, THE DRIVERS SIDE REAR TIRE EXPERIENCED COMPLETE TIRE FAILURE WHILE TRAVELING ON I-95, WHICH CAUSED NEARLY $3000.00 IN DAMAGES TO THE TRUCK. THERE IS CURRENTLY A RECALL ON THE BF GOODRICH RUGGED TERRAIN T/A TIRES BUT NOT FOR THE 20 INCH TIRES WHICH ARE THE ONES DESCRIBED HERE. WE FEEL THAT THE 20 INCH TIRES NEED TO BE INVESTIGATED FOR POSSIBLE RECALL AS WELL. THESE TIRES ONLY HAD 37,667 MILES ON THEM AND WERE PURCHASED NEW FROM FORD ON 7/23/12. THIS TIRE FAILURE NEARLY CAUSED A SERIOUS ACCIDENT, WHICH COULD OF LED TO DEATH OR SERIOUS INJURY. I HAVE DOCUMENTATION SHOWING THE TIRES HAVE BEEN REGULARLY MAINTAINED/INFLATED AND ROTATED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10762905September 10, 2015
POWER TRAIN, ENGINE
RE: 2015 F250 SOLD TO [XXX] VIN #[XXX] A FEW MONTHS AFTER PURCHASING A NEW 2015 F250 DIESEL, I BEGAN TO EXPERIENCE SOMETHING WRONG. WHEN TRAVELING AT A CONSTANT SPEED, THE ENGINE BEGAN TO KNOCK LOUDLY AND THE ENTIRE TRUCK BEGAN TO VIBRATE. AFTER TAKING MY FOOT OFF THE GAS PEDAL AND COASTING FOR A SHORT PERIOD (THERE IS NO POWER TO ACCELERATE DURING THIS TIME), THE TRUCK SEEMED TO FUNCTION NORMAL AGAIN. THERE WERE NO WARNING LIGHTS OR MESSAGES ON THE DASH. THE PROBLEM IS GETTING WORSE AND MORE FREQUENT; LASTING LONGER AND LOSS OF ABILITY TO ACCELERATE INTERRUPTS FLOW OF TRAFFIC BEHIND ME. I HELD UP TRAFFIC GOING UP MS RIVER BRIDGE, AND THIS PAST INCIDENT LASTED FOR A 15 MILE STRETCH. IT IS EXTREMELY UNSAFE....... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10761990September 7, 2015
UNKNOWN OR OTHER, ENGINE
I HAVE NOTICED ON SEVERAL INSTANCES WHILE TRAVELING ON THE FREEWAY BETWEEN 60-70 MPH WHEN THE TRUCK GOES INTO REGEN MODE I GET A LOUD VALVE CLATTER AND A LOSS OF ENGINE POWER. THIS COULD BE VERY DANGEROUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10761822September 6, 2015
ENGINE, POWER TRAIN
EXHAUST REGENERATION CAUSES ENGINE SHAKE AND LOSS OF POWER. THE LAST INCIDENT OCCURRED WHEN TOWING UPHILL AND A SEMI ALMOST TOOK OUT THE BACK OF MY TRAILER. FORD INDICATES THIS IS NORMAL, HOWEVER, IT DID NOT DO THIS WHEN NEW. IT OCCURRED AFTER APPROXIMATELY 6,000 MILES AND CONTINUES TO HAPPEN. THE DEALER INDICATED THEY HAVE NOT SEEN THIS BEFORE, SO I DON'T BELIEVE "NORMAL" APPLIES HERE. IF THIS IS "NORMAL," THEN FORD ENGINEERS NEED TO GO BACK TO SCHOOL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10761821September 6, 2015
ENGINE, POWER TRAIN
EXHAUST REGION CAUSED EXTREME ROUGH RUNNING ENGINE AND LOSS OF POWER WHEN TOWING UP HILL AND PASSING A SEMI. THIS CAUSED THE SEMI TO ALMOST HIT THE BACK OF MY TRAILER. THIS CONTINUES TO OCCUR WITH EVERY EXHAUST REGENERATION ON THE 6.7 POWERSTROKE DIESEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10759882August 28, 2015
SERVICE BRAKES
LOUD SQUEAL FROM WHEELS WHEN STARTING FROM PARKED LOCATION. SUBSEQUENT INVESTIGATION BY TECHNICIANS AT FORD DEALERSHIP SERVICE SHOWED THAT BRAKE CALIPERS WERE STICKING. THIS PROBLEM IS SAME AS FOUND ON SAME MODEL IN 2011.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10759761August 27, 2015
STEERING, SUSPENSION
PURCHASED 2011 F-250 86000 MILES ON IT. GOING HOME ON THE HIGHWAY RIGHT AFTER I BOUGHT THE TRUCK WE WENT OVER A ROUGH PATCH OF ROAD AND THE TRUCK VIBRATED AND SHOOK SO BAD WE NEARLY LOST CONTROL. HAD TO STOP ON A BUSY HIGHWAY SHOULDER AND LOOK TO SEE IF WE HAD A FLAT TIRE. NOTHING OBVIOUS BUT BROUGHT IT TO OUR MECHANIC ANYWAYS A COUPLE DAYS LATER. EVERY BUMP ON THE ROAD WILL NOW CAUSE THIS REACTION AND AT HIGHWAY SPEEDS COULD BE DEVASTATING. OUR MECHANIC IS GOING TO TRY A NEW STEERING STABILIZER AND FRONT AXLE JOINTS BUT I FEAR THIS TRUCK HAS THE DREADED "DEATH WOBBLE". VERY DANGEROUS ISSUE THAT FORD WILL NOT ADDRESS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250