Ford F-250 Complaints

11,199 consumer complaints on file.

#10935413December 15, 2016
FUEL/PROPULSION SYSTEM
THIS VEHICLE WAS TOWED INTO OUR SHOP BECAUSE IT WOULD NOT START. WE INSTALLED A NEW STARTER AND LEFT IT OVER NIGHT IN THE STALL WHEN WE CAME BACK IN THE MORNING IT HAD ATTEMPTED TO START ITS SELF AND HAD DRIVEN THROUGH THE DOOR AND OUT ON TO THE LOT WEDGEING ITSELF IN THE NEW CARS. THIS TRUCK IS A STANDARD TRANSMISSION AND WAS LEFT IN GEAR WITH THE KEYS OUT OF THE IGNITION. IF YOU SET THIS TRUCK AND LEAVE IT IT WILL TRAY TO START IT'S SELF. SOME TIMES IT WILL TAKE A DAY OR AS LITTLE AS 10 MINUTES.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10935359December 14, 2016
WHEELS
I HAVE AMERICAN EAGLE - 20 " EAGLE ALLOY WHEELS. THEY ARE APPROXIMATELY 24 MONTHS OLD. THIS SUMMER A SPOKE CRACKED ALL THE WAY THROUGH ON ONE WHEEL. THE DEALER WOULD NOT WARRANTY IT AND I HAD TO PURCHASE A REPLACEMENT. THIS WEEK I NOTICED ANOTHER OF THE WHEELS CRACKED ALL THE WAY THROUGH. I HAVE NOT HIT ANY MAJOR POT HOLES, CURBS OR ANYTHING ELSE. MY TRUCK IS NOT A WORK TRUCK OR USED FOR MUDDING OR OFF ROAD, IT IS A PAVEMENT PRINCESS DRIVEN BACK AND FORTH TO WORK. I AM WORRIED THERE IS A MANUFACTURER DEFECT AND THAT THE WHEELS ARE NOT SAFE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10934694December 12, 2016
FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
I GOT ON THE HIGHWAY AND WAS DOING A TURNAROUND WHEN I ACCELERATED TO ENTER THE HIGHWAY LANES A WARNING LIGHT THAT SAID REDUCED ENGINE POWER APPEARED ON MY DASH. APPROXIMATELY 200' LATER MY TRUCK DIED ON THE HIGHWAY. MY HIGH PRESSURE FUEL PUMP WENT OUT AND APPARENTLY DISINTEGRATED SENDING ALUMINUM SHAVINGS THROUGHOUT MY ENTIRE FUEL SYSTEM. THE FIX IS TO REPLACE THE ENTIRE FUEL SYSTEM AT A COST OF $11,200. THE FORD COMPANY IS CLAIMING THE FUEL WAS CONTAMINATED AND CAUSED THE PUMP TO RUST AND GO OUT. I HAVE NEVER GOT A WATER IN FUEL WARNING LIGHT ON MY TRUCK AND HAVE HAD ALL THE REQUIRED MAINTENANCE DONE ON THE TRUCK. THE INSURANCE COMPANY HAD A LAB DO A SAMPLE OF THE FUEL IN MY TRUCK AND THE FUEL MET ALL THE ASTM REQUIREMENTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10934147December 9, 2016
ELECTRICAL SYSTEM, ENGINE
TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING, THE "PULL OVER SAFELY NOW" WARNING INDICATOR ILLUMINATED AND THE ENGINE SHUT OFF WITHOUT WARNING. THE CONTACT WAS ABLE TO MANUALLY BYPASS THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE EGT SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10933795December 8, 2016
ENGINE
"FICM & ICP RECALL" RECEIVED A RECALL NOTICE FROM FORD JULY 2005 IN REGARDS TO FAULTY FICM AND ICP. THE FICM WAS REPAIRED AUGUST 2005 BY A FORD DEALERSHIP. NOTE, WE DID NOT HAVE ANY ISSUES WITH THE TRUCK PRIOR TO THE FIX. JANUARY 2006 WE HAD TO TAKE THE TRUCK INTO THE SHOP DUE TO THE ENGINE RUNNING ROUGH WHILE IDLING AND ACCELING; THE FICM WAS REPLACED DUE TO A SHORT; THE ISSUE THAT WAS JUST FIXED ON THE TRUCK. THE TRUCK HAS BEEN IN THE SHOP 5 TIMES SINCE JANUARY 2006 AND HAS COST US OVER $11,000 OUT OF POCKET TO TRY AND RESOLVE THIS ISSUE THAT STARTED AFTER THE INITIAL RECALL FIX. WE HAVE CONTACTED FORD HDQRS AND THEY ADVISED TO TAKE THE TRUCK INTO THE DEALERSHIP WHICH WE DID MULTIPLE TIMES. OVER THE LAST FEW MONTHS THE SURGING HAS BECOME INCREASINGLY WORSE. WHILE TRAVELING IN HEAVY TRAFFIC ON I5 PULLING A 30' 5TH WHEEL TRAILER, THE TRUCK SURGED FORWARD UNEXPECTEDLY JUST MISSING THE CAR IN FRONT OF US. A FEW WEEKS AGO I WAS STOPPED AT AN INTERSECTION, WHEN I BEGAN TO TAKE MY FOOT OFF THE BRAKE TO MOVE FORWARD THE TRUCK SURGED FORWARD 3 FEET. I WAS LUCKY THERE WASN'T ANOTHER CAR CLOSE OR A PERSON IN THE STREET. JUST THE OTHER DAY I WAS PARALLEL PARKING AND WHEN I TOOK MY FOOT OFF THE GAS TO BACK UP A LITTLE THE TRUCK SURGED BACKWARD ALMOST HITTING THE CAR IN BACK OF THE TRUCK. THE TRUCK ALSO STALLS JUST BEFORE COMING TO A COMPLETE STOP OCCASIONALLY. THIS ISSUE HAS BECOME EXTREMELY DANGEROUS IN THAT I DON'T FEEL SAFE DRIVING THE TRUCK. I LOOKED INTO THE CALIFORNIA LEMON LAW AND IT SOUNDS LIKE THE TRUCK MIGHT BE COVERED UNDER THIS. WE NEED TO GET RID OF THIS TRUCK BUT FEEL FORD DOES NOT STANDS BEHIND THEIR PRODUCT. I HAVE ATTACHED THE RECALL NOTICE AND SOME OF THE RECEIPTS FOR THE REPAIRS DONE TO THE TRUCK JUST IN REGARDS TO THIS SURGING ISSUE. I WAS ONLY ABLE TO ATTACH 5 DOCUMENTS BUT HAVE MANY MORE IF NEEDED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10933947December 8, 2016
STEERING, SUSPENSION
VIOLENT SHAKING FROM FRONT STEERING AND SUSPENSION. KNOWN PROBLEM WITH FORD SERVICE TECHNICIANS AND INDEPENDENT TIRE DEALERS. FORD CALLS IT " DEATH WOBBLE". MOST AFFECTED YEAR MODELS ARE 2006 THRU 2012 PER SERVICE WRITER . PROBLEM STARTS APPROXIMATELY 42 MPH IN MY TRUCK ON HIGHWAYS OR CITY STREETS USUALLY AFTER A SMALL BUMP IN ROAD.. SHAKING IN STEERING WHEEL AND BOUNCING IN CAB. I HAD TO COME TO A COMPLETE STOP TO STOP THE SHAKE AND BOUNCE. THE FORD DEALER REPLACED TRACK BAR AND BALL JOINT. THEN REPLACED FOUR TIRES , BALANCED,AND FRONT END ALIGNMENT. TRUCK NOW HAS CONSTANT VIBRATION IN STEERING WHEEL. DEATH WOBBLE HAS OCCURRED TWICE SINCE REPAIR. GOING BACK TO DEALER. THIS PROBLEM HAS BEEN REPORTED AND WELL KNOWN TO FORD. NO SPECIFIC CAUSE OR FIX HAS BEEN OFFERED. SUPPOSEDLY FORD REDESIGNED FRONT STEERING AND SUSPENSION IN 2014 MODELS BECAUSE OF THIS PROBLEM. THE SERVICE WRITER, WENDY, AT SILSBEE FORD IN SILSBEE, TEXAS TOLD ME SHE DID NOT KNOW WHY FORD DOES NOT RECALL THESE TRUCKS IT IS SUCH A BIG PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10933631December 7, 2016
SUSPENSION
AT HIGHWAY SPEEDS WHEN MAKING A SLIGHT LEFT TURN WHEN ENCOUNTERING A BUMP IN THE ROAD THE FRONT SUSPENSION BEGINS SHAKING VIOLENTLY. THIS IS COMMONLY KNOWN AS THE "DEATH WOBBLE" FOR WHICH FORD HAS MANY SERVICE BULLETINS. ONCE VEHICLE SPEED IS REDUCED TO APPROXIMATELY 40 MPH SHAKING STOPS. THE PROCESS OF FIXING IS LONG AND CONSISTS OF TRIAL AND ERROR UNTIL THE MANY POSSIBLE REASONS ARE FINALLY ADDRESSED AND SPECIFIC THING FIXED. FORD SERVICE BULLETIN DISCUSSES SPECIFIC BUILD DATES OF 2011 MODEL YEAR FROM LATE 2010 - MID 2011.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10933678December 7, 2016
STEERING, SUSPENSION
I HAVE HAD THIS TRUCK FOR LESS THAN A MONTH. TWO TIME, WHEN HITTING A ROUGH SPOT IN THE PAVEMENT, THE FRONT END OF THE TRUCK BEGAN TO SHAKE VIOLENTLY FROM SIDE-TO-SIDE, AND THE STEERING WHEEL ALSO TURNS VIOLENTLY FROM SIDE-TO-SIDE LIKE IT IS GOING TO RIP YOUR HANDS OFF. SHAKING DOES NOT END UNTIL YOU DECELERATE SIGNIFICANTLY. THE FIRST TIME WAS AT ABOUT 45 MPH IN THE CITY ON A DECENT STREET. THE SECOND TIME WAS LAST NIGHT AND I WAS GOING ABOUT 70 MPH ON A HIGHWAY. IN BOTH CASES, IT DIDN'T TAKE A SIGNIFICANT BUMP TO CAUSE THE VIOLENT SHUDDER OR SHAKING. MANY, MANY OTHER PEOPLE HAVE BEEN REPORTING THIS ISSUE FOR YEARS. ONE SUGGESTION IS THAT IT IS A PROBLEM WITH THE STEERING DAMPER SHOCK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10930180December 6, 2016
STEERING, SUSPENSION
TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 70 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE. IT TOOK SEVERAL SECONDS FOR THE CONTACT TO REGAIN CONTROL. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUSPENSION SYSTEM FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10930091December 5, 2016
STEERING, SUSPENSION
FORD F250 TRUCK - FRONT END SUSPENSION AND 4 WHEEL DRIVE PROBLEMS. SINCE MARCH OF THIS YEAR 2016, @ 90K MILES, WHILE DRIVING DOWN THE ROAD, TRAVELING AROUND 50 MPH, THE FRONT SUSPENSION ON MY FORD F250 STARTED SHAKING AND WOBBLE UNCONTROLLABLE. THIS HAS HAPPENED PROBABLY 20 TIMES OR SO. THE WOBBLE WAS SO SERIOUS AND SCARY. I WOULD HAVE TO APPLY MY BRAKES AND HOLD ONTO THE STEERING WHEEL WITH A STRONG GRAB, TO KEEP MY TRUCK ON THE ROAD. OTHER VEHICLES AROUND MINE, WOULD SCATTER OUT OF MY WAY. ON OCTOBER 17, 2016, I HAD THE STEERING DAMPER REPLACED AND THE TRACK BAR BALL REPLACED, COSTING $361.71. "DEATH WOBBLE", WAS STILL HAPPENING. LAST MONTH ON NOVEMBER 14, 2016, I TOOK MY TRUCK INTO OUR LOCAL FORD DEALERSHIP FOR REPAIRS ON THE SUSPENSION PROBLEM - "DEATH WOBBLE". REPAIRS INCLUDED, BAR - FRONT SUSPENSION TI, JOINT ASY - BALL, NUT, END ASY - DRAG LINK ROD, ROD, ROD ASY - DRAG LINK, ADJUSTER ASY @ 2, ALL REPLACED WITH NEW PARTS. REPLACE DRAG INK AND END, INSTALL ADJUSTERS FOR CASTOR, FRONT END ALIGNMENT (4 WHEEL DRIVE). THE FORD DEALERSHIP WAS EVEN AWARE OF THIS EXISTING PROBLEM WITH THE FORD F250 SUSPENSION, FROM PREVIOUS COMPLAINS AND REPAIRS. MY REPAIR COST WAS $1205.07. NOW MY 4 WHEEL DRIVE WILL NOT LOCK IN ON THE FRONT END. I HAVE AN APPOINTMENT, TAKING MY TRUCK BACK TO FORD DEALERSHIP TOMORROW MORNING FOR ADDITIONAL REPAIRS. THIS IS A MAJOR SAFETY ISSUE ON THESE VEHICLES AND SOMETHING MUST BE DONE ABOUT IT. A RECALL SHOULD AND MUST BE MANDATORY FOR THE PUBLIC SAFETY. THIS ISSUE WILL END UP KILLING SOMEONE (IF, IT HAS NOT ALREADY) IF, A RECALL IS NOT ORDERED IMMEDIATELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10929658December 2, 2016
SUSPENSION
TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS OVER A BUMP IN THE ROAD, THE FRONT END OF THE VEHICLE WOBBLED VERY VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER ON NUMEROUS OCCASIONS FOR A DIAGNOSTIC TESTING AND REPAIR. THE CONTACT STATED THAT THE BALL JOINTS, SHOCK ABSORBERS, AND OTHER UNKNOWN COMPONENTS WERE REPLACED OR REPAIRED BY THE DEALER, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10928968December 1, 2016
SUSPENSION
TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOBBLED UNCONTROLLABLY. THE BRAKE PEDAL HAD TO BE DEPRESSED AND THE VEHICLE HAD TO ALMOST COME TO A COMPLETE STOP TO KEEP IT FROM WOBBLING. THE DEALER CONFIRMED THAT THERE WAS A WOBBLE IN THE FRONT END OF THE VEHICLE AND THAT A WOBBLE BAR WOULD NEED TO BE PLACED ON THE VEHICLE; HOWEVER, THERE WAS NO GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 01/26/17*LJ UPDATED 7/12/18*JB *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10929410December 1, 2016
ENGINE
I WAS HEADING BACK TO COLLEGE IN BROOKINGS SD, WHEN I WAS STOPPED WAITING FOR A TRAIN TO PASS. AFTER THE TRAIN PASSES I PUT IT FROM PARK INTO DRIVE AND RIGHT WHEN I STARTED MOVING I HEAR A LOUD POP. AFTER I DRIVE ANOTHER BLOCK TO A GAS STATION TO LOOK UNDER THE HOOD I CAME TO THE CONCLUSION THAT I HAD BLOWN A SPARK PLUG. AND IT TOOK OUT THE IGNITION COIL WITH IT AND STRIPED THE THREADS ON THE HEAD. ALONG WITH THAT THERE WAS GAS EVERYWHERE ON THE DRIVERS SIDE OF THE ENGINE BLOCK. THAT'S NOT ONLY SUCKS BECAUSE I HAD TO PAY TO GET IT FIXED, I'M IN COLLEGE I DON'T HAVE MONEY TO PAY FOR THIS. BUT IF THAT GAS WOULD HAVE HIT I SPARK MY TRUCK COULD HAVE BLOWN UP. PLEASE TAKE RESPONSIBILITY FOR UR MISTAKES FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10927085November 20, 2016
TIRES, TIRES:SIDEWALL
DRIVING HIGHWAY SPEED. SIDE WALL FAILURE. BLOW OUT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10926989November 18, 2016
STEERING, SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). WHILE DRIVING AT LOW SPEEDS, THE VEHICLE BECAME DIFFICULT TO STEER AND LOST BRAKING ABILITY. THE FAILURE OCCURRED AT LOW AND HIGH SPEEDS WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10926570November 16, 2016
STEERING, SUSPENSION
WHILE DRIVING AT SPEEDS ABOVE 50 MPH ON BOTH CITY AND HIGHWAY ROADS THE FRONT END AND STEERING WHEEL START TO WOBBLE AND VIBRATE TO A POINT WHERE CONTROL OF THE VEHICLE IS ALMOST LOST. THE ONLY WAY TO REMEDY THE WOBBLE/VIBRATION IS TO HIT THE BRAKES AND SLOW THE VEHICLE DOWN. THIS ONLY OCCURS WHEN DRIVING OVER UNEVEN PAVEMENT, POT HOLES OR WASHBOARD ROADS. MY RESEARCH HAS REVEALED THAT THIS IS A VERY COMMON PROBLEM WITH THE F250S AND IS COMMONLY REFERRED TO AS THE "DEATH WOBBLE". THE 2 DEALERS I BROUGHT IT TO EVEN AGREED THAT IT IS A COMMON PROBLEM THAT THEY HAVE BEEN DEALING WITH. THIS PROBLEMS OCCURS ALMOST EVERY HIGHWAY TRIP I TAKE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10926182November 15, 2016
SUSPENSION
TL* THE CONTACT OWNS A 2012 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SWAYED FROM LEFT TO RIGHT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING; HOWEVER, THE REASON FOR THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10924202November 4, 2016
STEERING
TL* THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING APPROXIMATELY 30 MPH, A LOUD SNAPPING SOUND WAS HEARD FROM THE FRONT END OF THE VEHICLE. THE DRIVER SUDDENLY LOST CONTROL OF THE STEERING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT TIE RODS FRACTURED DUE TO RUST AND CORROSION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. UPDATED 04/06/17LJ UPDATED 09/1/2017 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10924148November 3, 2016
SEAT BELTS
MY DRIVERS SIDE SEATBELT HAS STARTED TO RANDOMLY UNBUCKLE. THERE ISN'T ANYTHING TOUCHING IT, PRESSING IT OR OTHERWISE INTERFERING WITH THE OPERATION. I FIRMLY PRESS THE BUCKLE INTO THE RECEPTACLE, PULL ON IT TO ENSURE IT IS LATCHED AND RANDOMLY IT WILL COME UNDONE. THE DEALERSHIP SAID THERE ISN'T A RECALL OR WARRANTY TO COVER IT SO I HAD TO PURCHASE A NEW RECEPTACLE. THIS HAS HAPPENED GOING AS SLOW AS 5MPH AND AS FAST AS 50MPH AND IS QUITE STARTLING AS THE SEATBELT INSTANTLY STARTS TO REWIND. I DON'T FEEL COMFORTABLE DRIVING MY TRUCK KNOWING THE SEATBELT MIGHT NOT HOLD IF AN ACCIDENT WERE TO HAPPEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10920554November 1, 2016
FUEL SYSTEM, DIESEL, ENGINE
WITHIN 60 SECONDS OF THE MESSAGE "CLEANING EXHAUST FILTER", THE 6.7L ENGINE BEGINS TO LOOSE POWER, VIBRATING, AND MAKING VERY LOUD CLANGING NOISES. ALL WHILE DRIVING AT 60-70 MPH, CAUSING A HUGE DECELERATION, DOWN TO 45 MPH IF GOING UP AN INCLINE, DUE TO LOSE OF POWER. THIS STARTED AT 7,000 MILES AND HAPPENS AT LEAST 1 PER TANK OF FUEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250