Ford F-150 Complaints (2022)

583 consumer complaints on file.

#11704613December 11, 2025
POWER TRAIN
CDF drum failed, caused lurching and sporadic speeds on highway while traveling. Transmission was low on fluid from factory and was remedied - possibly led to premature wear on the transmission that ultimately failed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704316December 10, 2025
ENGINE
A few weeks ago, while driving the vehicle, it displayed an engine misfire warning had extreme vibrations, and then the vehicle broke down, left me sitting on the side of the road. After getting the vehicle towed to a Ford dealership, we found the intake valve broke off on the motor and causes catastrophic complete engine failure. This is an active recall in 21 and 2022 F1 50s with the 2.7 eco-boost. Per Ford my Vin is not attached to that recall and they said I had to call or get a hold of the national highway safety administration and get my Vin attached that recall for engine replacement. My vehicle is a 2022 with 100,000 miles on it and now it’s broke down because the engine had catastrophic engine failure due to a problem. Ford knows about this issue and won’t fix it until I get the vehicles then attached to the recall . The current recall number is 24S55 Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703935December 9, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703831December 8, 2025
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM, POWER TRAIN
Hv harness failed (confirmed by dealer/manufacturer) without known reason and without warning, leaving stranded, unable to move vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703715December 8, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. While the contact's son was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The Mobile App indicated a failure related to the power train and to reduce power. The contact's son drove the vehicle to the shoulder of the road and turned off the vehicle. While the contact's son was attempting to start the vehicle, the vehicle started. The vehicle was driven to the intended destination, which was approximately 30 minutes away. The following day, the failure reoccurred. The contact stated that the failure had occurred several times. The contact stated that several days later, the 4WD Low warning light illuminated. The dealer was made aware of the failure and a diagnostic test was scheduled for the following week. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact was informed that the VIN was included in Customer Satisfaction Program: 23S65/NHTSA Campaign Number: 23V896000 (Power Train). In addition, the contact had not received notification of the Customer Satisfaction Program or recall. The failure mileage was approximately 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702969December 4, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train), and the vehicle was taken to the dealer, where an inspection was performed. The contact was then informed that the recall repair needed to be performed; however, the part to do the recall repair was not yet available. The dealer ordered the part. The contact stated that while the vehicle was parked in the garage, the contact noticed that oil had leaked onto the ground underneath the vehicle. The vehicle was driven to the dealer, where it was diagnosed that the rear axle bolts and rear main seal had failed; however, the part to do the recall repair was not yet available. The vehicle was not repaired and had been at the dealer for two weeks. The manufacturer was notified of the failure. The failure mileage was approximately 27,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702768December 3, 2025
FUEL SYSTEM, GASOLINE, POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, there was a loud rattling sound coming from the vehicle. There was no warning light illuminated. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 23V896000 (Power Train); however, parts for the recall repairs were not yet available. The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer informed the contact that the vehicle could not be serviced because parts were still unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702725December 3, 2025
POWER TRAIN, FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 23V896000 (Power Train) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The contact stated that upon starting the vehicle and shifting to drive(D), the vehicle jumped and attempted to accelerate unintendedly. Additionally, the contact stated that upon shifting to reverse(R), the 4WD engaged unintendedly, and the vehicle made an abnormal sound and became difficult to steer. The dealer was contacted, and an appointment was scheduled for the recall repairs; however, upon taking the vehicle to the dealer, the contact was informed that the parts were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was notified of the failure and contacted the dealer on the contact's behalf. The dealer then called the contact and advised that the recall parts were not yet available. The failure mileage was approximately 14,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702703December 3, 2025
ELECTRICAL SYSTEM
My vehicle has continued to have major issues with the radio/audio system. The radio will experience an extremely loud distorted sound when I start the vehicle. It is extremely unsafe since the vehicle can't be operated while this is going on. During the worst situation, I've had to disconnect the battery in order to make the sound stop. I had the first issue happen less than 3 weeks after purchasing the truck in 2022. I had to take it to 3 different dealers in my local area, with NO REPAIR action, before I returned it to the original dealer. The Metter Ford dealer put me in a loaner vehicle while the technical engineer researched the problem. During that first problem, the software was reprogrammed and the APIM module was replaced. However, the problem has continued to this day. The last time it occurred was today, on 12/3/2025. I believe Ford released a recent software update for the BlueCruise 1.4 that possibly addressed a radio problem, but it has NOT FIXED my issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702204December 1, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
The electric motors in the hybrid system intermittently fault and fail completely. I get an error saying there's a powertrain/4wd system failure. There's no clear cause. I've had this in for service numerous times. I've paid for a repair that did not resolve it. They had me pay for a repair for a new alternator-generator unit ($1500). When I get this fault, the truck operates only on gas power and does not use any electric motor power. I go from ~21 mpg highway (which is lower than when new) to ~18 mph highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701670November 26, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated while the vehicle was at the independent mechanic receiving a tire replacement, the contact was informed that the rear passenger's side axle bolt was fractured and had detached. The contact was advised to take the vehicle to the dealer for assistance. The vehicle was taken to the dealer; however, the contact was informed that the part was not available to repair the vehicle. In addition, the dealer kept the bolt. The contact was advised to contact the manufacturer for assistance. The contact stated that the vehicle was taken to the dealer twice for inspection prior to the failure, however the contact was informed that the parts were not available. The contact was unsure of when the failure had occurred between 10/16/2025 and 10/24/2025. The contact stated that because of the failure and the parts not being available, the vehicle was not repaired. In addition, the contact no longer had a vehicle to drive. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part was not available for the recall repair. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the parts were being manufactured. The failure mileage was approximately 40,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700890November 21, 2025
POWER TRAIN
Loss of engine coolant resulted in overheating and need to pull off to side of highway. Issue is described in the SSM - 51485 described below 2021-2023 F-150 - 3.5L PowerBoost - Loss Of Engine Coolant Due To External Coolant Leak At The Heat Exchanger Coolant Spigots Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine may experience a loss of engine coolant with possible engine overheat and/or illuminated malfunction indicator (MIL). This may be due to a crack in the exhaust heat exchanger coolant spigots on the top of the exhaust heat exchanger. The exhaust heat exchanger coolant spigots are now released and should be serviced in pairs. It is no longer necessary to replace the muffler inlet pipe assembly for this type of concern. Workshop Manual, Section 309-00D has been updated to include a new service procedure. For claiming, use causal part 18663 and applicable labor operations in Section 05 of the Service Labor Time Standards (SLTS) Manual. Heat exchanger coolant spigots - NL3Z-18663-A (2 req).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700862November 21, 2025
POWER TRAIN
Since I've purchased the truck in 2023 I've been receiving in the mail notices about a recall for the rear-axel shaft for my 2022 f150. I am a major proponent of safety and maintenance. Year over year I've attempted to get it fixed at authorized ford dealerships but I've been told a handful of times that the parts are not available and I'm not getting the appropriate urgency required for an issue of this stature. I am embarking on a big trip and I'm concerned about my safety and the safety of others on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700427November 19, 2025
AIR BAGS
I was in an accident where I broadsided a vehicle at 45 mph. The accident warning sensors didn’t activate and no airbags deployed. The accident was severe enough that my truck was deemed totaled and the other vehicle flipped upside down
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11700318November 19, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699157November 13, 2025
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2022 Ford F-150. The contact stated that while driving at 55 MPH, the vehicle lost power and stalled on several occasions, but the vehicle was restarted. The check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was taken to the local dealer, who confirmed the parts were on back order. The dealer informed the contact about a diagnostic test. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699089November 13, 2025
UNKNOWN OR OTHER
After entering my 2022 F150 Lariat in a parking lot and starting it, I placed my iPhone on the charger and I backed out of the spot I was in with my hazard lights turned on. I placed the vehicle in drive and turned off the hazard lights. As I pulled forward, a deafening sound came from the back seat of my truck that sounded like some kind of electric static with a popping noise. I reflexively pressed the break, ducked my head and tried to turn the volume knob down which did nothing. I pressed the stop/start button to shut the vehicle off and that did not change the sound coming from the door speakers. I jumped out of the truck because the sound was painful and proceeded to use a pair of pliers from a leatherman that I was carrying to disconnect the positive side of the battery; this too did nothing. At this point, I closed all of doors and searched the web on my phone to see if similar problems existed for other owners and if there was a fix. After about 8-10 minutes, the sound stopped. Based on what I read, this was a widely known issue on Ford F150 models between the years 2021-2024. Apparently, Ford has not responded to this yet. If this we’re to happen while driving, it’s would be shocking enough to cause a reflexive action that could put people in danger of a crash. I have video of this occurrence if needed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697209November 3, 2025
POWER TRAIN
On Acceleration from a stop at approx. 35 miles per hour the rear wheels locked up causing the vehicle to come to an abrupt screeching stop. Almost rear ended by other vehicles causing great concern for safety. According to Ford the codes that kicked off are transmission shift solenoids. This is the second time this happened, fist time was backing out of a driveway, no codes and could not detect. I have fear this could happen at higher speeds and cause great harm.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696770October 31, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE). However, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696649October 30, 2025
EXTERIOR LIGHTING
Day time running lights have burned out which the only way to fix this problem is to replace them at over 2800.00 per light. There are hundreds of forums stating that the Daytime running lights stop working and there is no financially feasible fix without complete headlight replacement. This is a safety issue that should be resolved by ford
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150