Ford F-150 Complaints

39,812 consumer complaints on file.

#11650331March 24, 2025
POWER TRAIN
When my truck shifts, your be going down the road and then it downshifts and RPM going up, then it goes in between gears..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650333March 24, 2025
ENGINE, POWER TRAIN, ELECTRICAL SYSTEM
During the course of driving on the interstate at 70mph the vehicle decelerated and went to a lower gear. The dash panel of the truck did not show all of the gears available. An emergency stop on the side of the road and turning the vehicle off and back on temporarily resolved the issue. It occurred intermittently and without warning. The truck continued to show problems and was taken to a transmissions shop which checked the transmission, replaced a line for a small leak and said everything seemed to be in order. The cause was not found to be a lack of transmission fluid as the levels were normal. The truck continued to intermittently decelerate. The last time that occurred, the back wheels locked up while on the road. The truck is now sitting due to the safety risk it poses and the locked up transmission on the rear end. It is available for inspection upon request. My safety and that of others was at risk. The problem was not replicated in a service center. The vehicle was inspected beforehand but not after the last issue, (it needs a tow as the back wheels are frozen). There was a warning light for the engine camshaft that came on and the problem was diagnosed at Ford as a camshaft issue though they could not understand the deceleration issue. The truck was taken first to Ford then to an independent transmission shop. Due to the issue the truck is not in use.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650336March 24, 2025
POWER TRAIN, WHEELS
I was driving on [XXX]. In brookefield ohio on [XXX] at approximately [XXX] headed into work. I was driving 60MPH to 65MPH and my 2016 ford f150 went from 6th gear to 1st gear and which locked my rear wheels. I was wearing a seat belt at the time. The date of filling this complaint is 03/24/2025 and has not happened since. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650341March 24, 2025
POWER TRAIN
Component: Vehicle, travelling at 70mph, downshifted to lower gear. Legal speed limit on Hwy 7 Comanche Co, OK. Remained in lower gear and would not upshift. After stopping, stopping engine and re starting, did same, downshifted at 60mph. Took vehicle to Ford dealer service dept. Identified as Lead Frame harness/connector. Safety; driver safety was at risk with sudden downshift jolting vehicle. Other drivers at risk with swerve to adjacent lane. Trailing traffic at risk by sudden slow down & stoppage. Problem; problem confirmed and replacement parts completed by Ford dealership 09/25/2024 at cost of $1,121.80 Vehicle inspection: by Ford dealership service dept technicians Symptoms: NO warning whatsoever. Downshifted at 70mph Made a phone call to Ford Corporate to complain and request Ford cover costs, refund or assistance. Was told NO way. FOX news report 03/24/2025 identified 2015-2017 F150 issues with same conditions. NHTSA, ODI investigating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650342March 24, 2025
POWER TRAIN
Component/System: Automatic transmission. Yes, the failed transmission components are possible but not likely available for inspection upon request contingent on the repair shop not having scrapped them. I’ve had two transmission rebuilds due to repeated failures. Safety Risk: The vehicle unexpectedly downshifted to a lower gear at highway speeds without warning, causing sudden deceleration. Also, at red lights causing jolting or delayed acceleration. This put my safety and others at serious risk of rear-end collisions or loss of vehicle control, especially during high-speed driving, in addition to other things. Confirmed by Service: Yes, the issue was diagnosed and confirmed by two independent repair shops. Each diagnosed severe internal transmission failure consistent with sudden mechanical shock. The failure of the transmission had codes displayed indicating such, and I have a print out from the mechanic prior to the rebuild as I wanted to confirm it was not any other issue before rebuilding. Inspections: The state of New Jersey has not inspected this vehicle. Warning Signs: There were no dashboard warning lights, error messages, or audible alerts prior to the failure that reasonably could have been linked to such event(s). The first rebuild occurred in early 2023, and similar failures repeated despite full rebuilds. No advance indication was ever given before the vehicle downshifted. Second rebuild was in the Fall of 2023. In prior instances to rebuilds, there were wrench light warning alerts indicated on dashboard, however they made no sense and clicking OK dismissed them with no re-alert or info pertaining to such. When this did occur, and since nothing could be linked to it in the average drivers head, it was assumed an accidental notification.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650345March 24, 2025
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
As I was pulling out onto the road it died blocking a 2 lane road at around 5AM so was pitch black luckily cars where paying attention & saw me I was able to roll it back off the road. Had a mechanic look at it after being towed back home he noticed fuse 27 was melted that is fuse for the fuel pump. Currently awaiting how much it will be to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650349March 24, 2025
POWER TRAIN
In May of 2023, the transmission downshifted unexpectantly while going 50 mph from 6th gear to 1st gear for a second, causing the rear tires to lock up for that moment before shifting back to 6th gear. This caused a quick loss of control and reduction of speed while in traffic. Luckily no accident occured during this. If it had not shifted back to 6th gear, the result would have been much different putting myself and others on the road at risk of an accident at high speeds with traffic behind the vehicle and oncoming traffic. Prior to this incident the truck would occassionally not start and the gear selection indicator was not illuminated as normal and the engine light would occasionally come on. Speaking with Ford dealerships they identified it as the molded lead frame connector within the transmission. I'm unsure of the damage this has caused on other parts from the significant shift change at high speeds and I'm concerned of what has been damaged but not shown as of yet. They replaced the molded lead frame connector at a cost to me and the truck has not had that issue since.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650359March 24, 2025
POWER TRAIN
On [XXX] I [XXX] started my truck and left my job at Publix Supermarket in Lake City, Fl. As I turned out of the shopping plaza, My 2020 Ford F-150 felt like it was about to lose power. As I turned into [XXX]. The truck shifted from the first gear, to the second smoothly, as the truck shifted from 2-3 , the truck revved and did not engage into 3rd gear. I let off the gas thinking it was going to catch the next gear and continue to increase speed. but it did not, again it revved and did not engage into 3rd gear. now the traffic was flying past me, i pushed the accelerator to the floor in attempt to avoid an accident. and not get rear ended. After several seconds , the transmission engaged and the truck began to move forward at a slow pace. This is when i received a notification for Ford Pass app, saying the power train malfunction/ reduced power. I was able to get the truck to the closest gas station. where I shut it off. After several minutes, I restarted the truck and drove back to work with no issues. The next day I took it to a local shop, where they indicated that I needed a new transmission. Since then, this vehicle has been in the shop multiple times for the same issue. This will be the 3rd Valve body replaced. Its unsafe to be on the road. Its a safety hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650361March 24, 2025
POWER TRAIN
I was experiencing hard shifting in upper gears like 8, 9 and 10. At 118592 miles the Ford dealer told me the transmission needed to be replaced. I had them install a Ford remanufactured transmission. The dealer told me this reman should have all the upgrades of the latest transmissions. Reman number is JL3Z 7000L. At around 123000 miles I experienced the following. I had the cruise control set at 74mph. On an upgrade I felt a hard shift. I noted the transmission was in 8th gear. Then it shifted to 9th, 10th and then to 1st. The truck was suddenly slowing down for what seemed like 3 to 5 seconds before shifting into 10th. I did not hit the brakes. Cruise control was still engaged. Suddenly it repeated the shifting from 10 to 9 to 8 to 9 to 10 to 1st and then 10th. The wrench warning turn on and 10th gear was locked out. After cycling the engine off and on again I have not experienced this again. I did notice after the incident my vehicle had an oily residue on the exterior. I was traveling on a dry road with few cars around me and good tires. I did not consider it a safety concern until I read about the 6 speed transmissions experiencing this and the their safety concerns. What if someone had been behind me, what if the road had been slick, what if my tires had not been in good condition? I searched ford forums online and was surprised to find others as recently 2023 have reported exactly the same experience on 2018 F150. The fact that my transmission is supposedly what is in the 2025 concerns me. I waiting to get my truck back into Ford Service.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650362March 24, 2025
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
[XXX]: check engine light was on and codes P2196 and P2198 were present. The dealer suspected it was the purge valve, causing the problem so they replaced it and reset the codes. 10/10/24: I brought the truck in to have it looked at due to the check engine light being on again. I was told the lead frame needed to be replaced but was on backorder. The bill to diagnose this was 196.80 and I was told I could still drive it. On [XXX], I had to bring my truck in to be inspected because while I was going about 70 mph it all of a sudden downshifted and jerked me forward like it was going to abruptly stop. The check engine light came on and I had to drive pretty slow to avoid a breakdown on the interstate. Very scary to have this happen in interstate traffic It could have easily caused an accident. At this time, It was brought to my attention that the downshifting could also be related to technical bulletin 1495. Since we couldn’t get a real definitive answer on what was going on and the lead frame was on backorder, I decided to try and have the case connector in the bulletin removed and replaced as well as do a transmission tuneup on 10/23/24. This bill cost me $383.77. All codes were cleared and all appeared to be working correctly. On [XXX], I was driving on the interstate at about 70 mph and my truck seized up again and jerked forward, again scaring me and potentially causing an accident. I drove it very slowly directly to a repair shop. It was there until November 7, 2024 after the lead frame was replaced. That bill cost me $1321.68. I decided to file this complaint after I had seen a news article that this downshifting was being investigated for the same year as my 2015 Ford F150 for a safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650367March 24, 2025
POWER TRAIN, LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Power train failed and truck began to jerk and I lost control of the throttle. I had to throw myself (the truck) on the shoulder to avoid danger. Blinking lights on the dash board occurred. San Leandro Ford diagnosed issue as bad transmission and replaced it in November 2024. Inspected on site by authorized dealer. Told me customer problem must pay to have it replaced!! When I tried contacting national Ford representative and Bill Brandt dealership in Brentwood where purchased in Oct. 2016, no one wanted to take responsibility.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650183March 24, 2025
UNKNOWN OR OTHER
It was the transmission. It downshifted at a high speed going down the highway. Took it to the dealership and they said they could see it downshifted but had no fix for it or did not know why.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650181March 24, 2025
POWER TRAIN
Manufacturer Recall Number23S65 NHTSA Recall Number23V896 Recall StatusRecall Incomplete, remedy not yet available Mine has already failed once last year all the dealer did was put new parts in but said they still are not updated I tow a camper and it is soon time to tow and I am going on a long trip just want to see when the fix will be in
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649953March 23, 2025
POWER TRAIN
The vehicle while driving at all speeds is exhibiting harsh/delayed engagement and/or harsh/delayed shifting. i have completed the recommended service of the software update to the PCM however the vehicle continues to have harsh engagement, delayed engagement, harsh shifting and delayed shifting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649995March 23, 2025
SUSPENSION
Rear left axle snapped in half. Heard hissing noise which turned out to be fluids spraying. Purchased vehicle from Anderson Ford dealership in Kingman in 2022 with 95995 miles on it. I've only put 12,000 miles on it in 3 years. I'm [XXX] and do not drive aggressively. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649856March 22, 2025
POWER TRAIN, ENGINE
I have a 2019 f-150 Platinum . Bought it 4 months ago and I've put about 9,000 miles on it and the transmission is going out from what the dealer told me. I bought it from the same dealer that told me what's wrong with it. It shuts off in the middle of changing gears while driving down the road. It's happened 4 times. It's very unsafe. The service department at the dealership said something's going on with the admissions that could cuase it to vaper-lock shut down. They estimated the job to cost eight thousand dollars, which I don't have. It had139,000 when I bought it frome them
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649880March 22, 2025
POWER TRAIN
While driving on highway the transmission will bang really hard when shifting upshifting and downshifting while vehicle is in motion. This is a safety concern. I seen that there is over a million Ford vehicles recalled over this same problem. I need my vehicle put on this recall list immediately. This is an emergency and I will be keeping copies of all documents I sent and receive for further measures. Thank you for your time and please contact me back as soon as possible.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649891March 22, 2025
POWER TRAIN
All vehicles for maks from 1017to 1024is having transmission issues with the 1080R transmission. I would be driving down the hwy and it would continuously kick in and out of gears. Which is because it has a drum internally which is faulty. Ford knows there's a problem and won't address it. So many people are having to pay for a complete transmission replacement. My vehicle had about 78000 miles only and cost me almost 9000 dollars.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649933March 22, 2025
POWER TRAIN
10 speed has harsh and delayed shifts. The delayed shifts has caused to vehicle to stall in traffic, unable to accelerate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649937March 22, 2025
UNKNOWN OR OTHER
I received a recall on my 2018 F-150 to update / reprogram the PCM. The truck had been running well and had not had any check engine lights on (at least since I have owned it). The recall work was done at a local Ford dealer on 2-17-2025. On [XXX], the check engine light came on. The truck was taken to a local mechanic who scanned the code and said it indicated that one of the catalytic converters needed replaced. The light went out about a week later, but came back on [XXX]. I believe the check engine light coming on is related to / caused by the recall in which the PCM was updated. I contacted the service department where the recall work was performed. He said the dealership could scan the check engine code, but it would cost $200-$300 and I would be responsible for that cost. After reading about many similar cases online in which other people believe the recall work has now caused check engine codes indicating there is a problem with the catalytic converter(s). I contacted FORD customer service and opened a case (case # [XXX] ). I was told by the dealer that the truck could go into limp mode at any point and would be basically undrivable at that point and potentially cause a dangerous situation - especially in traffic or if towing a trailer. I am getting no where with the dealer or FORD customer service. I believe the problem has been caused by the recall in which the PCM was updated. I would greatly appreciate this concern being investigated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150