Dodge Grand Caravan Complaints (1996)

1,157 consumer complaints on file.

#11459290April 1, 2022
ENGINE, FUEL/PROPULSION SYSTEM
Rubber fuel line in main engine bay is leaking fuel and cracked I have seen others that have burned down for this issue. Dodge fiat Chrysler needs to be aware that all 1996 to 2000 dodge caravans and Chrysler town and country’s could burn down if this fuel issue isn’t fixed I have already had to pay out of pocket to fix one vehicle I’m not doing it again.. my phone number if anyone at you’re agency would like to call me my cell is [XXX] thanks PLEASE HELP!! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10846038March 10, 2016
ENGINE
MY 1996 DODGE GRAND CARAVAN HAS THE SERPENTINE BELT ISSUE. IT FALLS OF IF IT RAINS. THIS PROBLEM IS DUE TO A DESIGN FLAW FROM DODGE. THEY USED SMOOTH PULLEYS INSTEAD OF GROVED. IN ADDITION GATES HAD TO MAKE A KIT TO FIX THIS ONE SINGLE ISSUE BECAUSE IT IS SO COMMON. THIS IS A VERY COMMON ISSUE AND CHRYSLER REFUSES TO DO ANYTHING ABOUT IT (LIKE NORMAL). THIS IS A VERY DANGEROUS SITUATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10787512November 1, 2015
VEHICLE SPEED CONTROL
WHEN DRIVING MY 1996 DODGE GRAND CARAVAN THE SPEEDOMETER GOES CRAZY AND THE RPM GAUGE FLUCTUATES A LITTLE AND THE RPMS RAP OUT AROUND 40MPH AND WONT SHIFT ITS LIKE IT HIT SAFETY MODE OR SOMETHING I THINK IT IS MY WHEEL SPEED SENSOR WHAT DO YOU THINK?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10735298July 20, 2015
STRUCTURE:BODY, TIRES:TREAD/BELT
PURCHASED TIRE "AS NEW" FROM GRAVE'S TIRE IN CARTHAGE, TX. COME TO FIND IT WAS 6 YRS OLD WHEN PURCHASED AND DRY ROTTED AS IT BLEW IN 2 MONTHS TIME OF BEING ON THE VEHICLE. TIRE SHOP OWNER (LEO GRAVES) SAYS HE ISN'T HONORING HIS 60,000 MILE/1 YR WARRANTY, THIS HAPPENED TO ANOTHER CUSTOMER OF HIS AND AS FAR AS HE IS CONCERNED, WE BOTH HIT SOMETHING IN THE ROAD. ...UPDATED 10/15/15 *BF UPDATED 11/30/2017*CN
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10691638March 2, 2015
SUSPENSION:REAR, SERVICE BRAKES
TL* THE CONTACT OWNS A 1996 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKES WERE DEPRESSED AND FAILED TO RESPOND. THE CONTACT WAS ABLE TO AVOID A CRASH. THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE BRAKE LINE WAS RUSTED AND FLUID WAS LEAKING. IN ADDITION, THE CONTACT STATED THAT THE REAR AXLE WAS RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. UPDATED 3/31/15*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616919July 28, 2014
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
TL* THE CONTACT OWNS A 1996 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SERPENTINE BELT SEPARATED FROM THE ENGINE WHEN THE VEHICLE WAS DRIVEN IN THE RAIN. THE SERPENTINE BELT WAS REPLACED TWICE, BUT THE FAILURE WAS NOT REMEDIED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 262,747.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10562047January 29, 2014
FUEL SYSTEM, GASOLINE
FUEL LEAKING FROM THE FUEL TANK AND THE INJECTION BASE. START JANUARY 20 ,2014. I AM A NEW OWNER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10472513August 26, 2012
SUSPENSION
NOTHING HAS HAPPENED YET, BUT FEAR OF FRONT END COLLAPSE IS MOUNTING. THE STRUT TOWERS LOOK SEVERELY RUSTED EVEN THOUGH OLDER AND NEWER VEHICLES OF THE SAME MAKE AND MODEL DO NOT DEMONSTRATE THIS POTENTIAL FAILURE. IT SEEMS THAT IF THIS FAILS THAT THE STRUT WOULD PUSH THROUGH THE TOWER CAUSING FRONT WHEEL TO MOVE UP AND BACK RESULTING IN LOSS OF CONTROL, SUDDEN SWERVE, AND POTENTIAL CATASTROPHIC COLLISION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461142June 10, 2012
VISIBILITY/WIPER
THE WINDSHIELD WIPERS WOULD NOT WORK, THEN EVERY ONCE IN A WHILE THEY WILL. I HAD THEM CHECKED AND THE VEHICLE NEEDS A 500 DOLLAR BODY CONTROL MODULE. IT SEEMS THIS IS A VERY COMMON FAILURE, AND IN MY OPINION A DEFECT! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459460May 23, 2012
SUSPENSION, SERVICE BRAKES
TL* THE CONTACT OWNS A 1996 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE BRAKES WERE APPLIED BUT THE VEHICLE DID NOT RESPOND. THE CONTACT ADDED BRAKE FLUID TO THE VEHICLE AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC DISCOVERED THAT THE STRUT TOWER WAS RUSTED AND THE WHEEL CYLINDER HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOTIFIED AND TOLD THE CONTACT TO BRING THE VEHICLE IN FOR REPAIRS AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,852.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415241July 26, 2011
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 1996 DODGE GRAND CARAVAN EQUIPPED WITH TOYO SPECTRUM TIRES SIZE 215/65/R15 (NA). THE DOT NUMBER WAS UNKNOWN. THE CONTACT STATED THAT WHILE DRIVING UNDER 5 MPH, THE STEERING WHEEL WOULD WOBBLE FROM SIDE TO SIDE. THE CONTACT ALSO STATED THAT THE TREAD WAS BEGINNING TO SEPARATE ON ALL FOUR TIRES AND THE REAR PASSENGER SIDE TIRE WAS REPLACED ONCE ALREADY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT REFUSED TO REPLACE THE OTHER THREE TIRES. THE FAILURE MILEAGE OF THE TIRES WAS 12,000. THE FAILURE MILEAGE OF THE VEHICLE WAS 163,462. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410655July 6, 2011
SUSPENSION:FRONT
TL* THE CONTACT OWNS A 1996 DODGE GRAND CARAVAN. WHILE INSPECTING THE VEHICLE THE CONTACT NOTICED THE FRONT DRIVER SIDE STRUT TOWER WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS INFORMED THE CONTACT THAT THERE WAS A KIT THAT COULD BE INSTALLED TO REPAIR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10395315April 8, 2011
STEERING, ENGINE AND ENGINE COOLING
WIFE WAS DRIVING 96 GRAND CARAVAN LE TO COLLEGE IN THE RAIN. WHEN SHE ARRIVED IN THE PARKING LOT STEERING BECAME IMPOSSIBLE TO TURN SO SHE PULLED IT STRAIGHT INTO PARKING SPOT. LOOKED UNDERNEATH AND SAW BELT HAD COME OFF. THIS HAPPENED ONCE BEFORE BUT CAR WAS PARKED IN DRIVEWAY AT HOME. AS SHE STARTED TO REVERSE OUT OF DRIVEWAY STEERING BECAME TOUGH AND CAR WOULD NOT MOVE. IT WAS ALSO RAINING AT THIS TIME. THIS HAPPENED EARLY JANUARY 2011. AROUND MARCH 2010, AGAIN WHILE IT WAS RAINING, AS MY WIFE APPROACHED A STOP SIGN THE CAR BEGAN TO BECOME UNRESPONSIVE AND SHE HAD TO GUIDE IT TO THE SIDE. SINCE IT WAS BLOCKING THE ROAD POLICE DID COME BY AND HELP PUSH IF OFF THE ROAD UNTIL THE TOW TRUCK CAME TO TAKE IT TO THE GARAGE. NEW BELT, IDLER PULLEY AND TENSIONER WAS INSTALLED BY MECHANIC. THE MOST RECENT INCIDENT (APRIL 2011) PULLEY AND TENSIONER WAS REPLACED. DON'T KNOW IF IT WILL SOLVE THE PROBLEM. LUCKILY THE SPEED WAS SLOW IN ALL INSTANCES AND NO INJURY OR DAMAGE WAS DONE...YET. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10372161December 22, 2010
STEERING, POWER TRAIN:DRIVELINE, EQUIPMENT:MECHANICAL, ENGINE AND ENGINE COOLING
I HAVE A 1996 DODGE GRAND CARAVAN LE 3.8. IN THE LAST 2 MONTHS THE SERPENTINE BELT SLIPPED OFF 2 TIMES WHEN IT IS RAINING OUTSIDE OR THE VAN GOES THROUGH A PUDDLE OF WATER. I HAVE ALMOST BEEN KILLED TWICE. I HAVE READ THAT OTHER DODGE OWNERS HAVE ALSO HAD THIS PROBLEM. THE WHEEL CANNOT BE CONTROLLED WHEN THIS HAPPENS, AND MY WIFE IS SCARED TO DRIVE THIS CAR NOW. I THINK THAT DODGE HAS SOME EXPLAINING TO DO AS THEY HAVE BEEN MADE AWARE OF THIS DEFECT, AND ARE NOT TAKING ANY RESPONSIBILITY FOR THIS REPEATED SERIOUS SAFETY FAULT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10368178November 29, 2010
VISIBILITY:WINDSHIELD WIPER/WASHER
FOR SOME TIME NOW MY WIPERS HAD A MIND OF THERE OWN. THEY WORKED WHEN EVER THEY WANTED. NO AS OF 11/29/10 MY WIPERS WILL NOT EVEN COME ON AT ALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10353220August 31, 2010
STEERING
1996 DODGE GRAND CARAVAN - LIFETIME LUBRICATED TIEROD END SEPARATED RESULTING IN A LOSS OF STEERING - THE RUBBER SEAL DETERIORATED THE GREASE WAS GONE AND THE BALL JOINT CORRODED TO THE POINT IT FELL APART - WIFE WAS PARKING THE VAN AT THE TIME - COULD HAVE BEEN MUCH WORSE SHE WAS 150 MILES FROM HOME AT THE TIME LESS THAN A MONTH LATER I SAW ANOTHER DODGE CARAVAN BROKE DOWN ON A HIGHWAY RIGHT FRONT TIRE NOT FACING AS IT SHOULD - I SUSPECT ANOTHER TIE ROD END FAILURE - NOW I KNOW THESE BEARINGS CAN BE MANUFACTURED SO THEY CAN NOT SEPARATE - AIRCRAFT ROD END BEARINGS COME TO MIND - ISN'T A LOSS OF STEERING A GOOD ENOUGH REASON TO MAKE A PART SO IT CANT FAIL? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10276897July 15, 2009
TIRES
ON JAN 2, 2009 I BOUGHT 4 KENDA TIRES (COOPER TIRE) FROM A DEALER IN WATSONVILLE CA. FIRST, I HAD A BLOWOUT ON ONE. IT WAS REPLACED. THEN A SECOND TIRE BLEW OUT ON THE HIGHWAY. CLOSE CALL. HIT TREE, TOTALED VEHICLE, AIRBAGS OFF ETC. I AM HOLDING THE TIRE FOR YOUR INSPECTION IF YOU WISH...I HAVE PHOTOS. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10275319June 30, 2009
SUSPENSION:FRONT, STRUCTURE:BODY
96 GRAND CARAVAN STRUT MOUNT RUST COULDN'T PASS INSPECTION AND THEY SAID MY KIDS COULD HAVE DIED IF I HAD A ACCIDENT. THIS SHOULD BE A MAJOR RECALL. THE GOVERNMENT INVOLVES IN EVERY ASPECT OF OUR LIVES TO KEEP OUR CHILDREN SAFE UNTIL IT MAKES CORPORATION PAY MONEY TO FIX A KNOWN PROBLEM LET SEE WHAT YOU GUYS DO WITH THIS. SORRY IM UPSET JUST SEEMS EXTREMELY DANGEROUS AND AS I READ ON THE INTERNET TONS OF PEOPLE WITH THIS PROBLEM AND CHRYSLER KNOWS ABOUT IT CAUSED I CALLED THE TO AND SAID IF I HAD A ISSUE TO WRITE TO YOU GUYS BUT MOST LIKELY NOTHING WILL BE DONE. THAT IS A QUOTE FROM A CHRYSLER CUSTOMER SERVICE REP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10258712February 15, 2009
SUSPENSION:FRONT
FRONT STRUT TOWERS RUSTED THROUGH. NOTHING HAS BEEN DONE TO CORRECT THE FAILURE YET, BUT IF IT COMPLETELY RUSTS, I'M SURE AN ACCIDENT WILL HAPPEN BECAUSE NOTHING WILL BE SUPPORTING THE FRONT OF THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10240784September 3, 2008
ENGINE AND ENGINE COOLING
WHEN EVER IT RAINS OR SNOWS AND A LIL BIT OF MOISTURE GETS UP IN THE ENGINE THE SERPENTINE BELT COMES OFF AND I LOSE EVERYTHING, POWER STEERING, FAN, YOU NAME IT ITS GONE, AND I HAVE ALMOST WRECKED 5 OUT OF 8 TIMES THIS HAS HAPPENED..2 TIMES I FOUND MYSELF HAVING GOING IN TO A FIELD TO STOP DUE TO STEERING WAS GONE, AND POSSIBLE BURN/ FIRE COULD HAVE RESULTED FROM ENGINE OVER HEATING AND LIQUIDS BOILING/ AND STEAM RISING. LEADING TO BE A VERY DANGEROUS PROBLEM TO ANYONE NEAR THE VEHICLE, I HAVE 3 CHILDREN AND THEY WERE WITH ME 3 OF THE 8 TIMES THE BELT CAME OFF. I SEARCHED ONLINE AND APPARENTLY IM NOT THE ONLY ONE HAVING THIS PROBLEM.. THERE IS ALOT MORE PEOPLE OUT THERE WITH THIS COMPLAINT. I DID HOWEVER REPLACE THE BELT ONCE AGAIN, ALONG WITH PULLEY/ TENSIONER ITS GETTING TO BE QUITE EXPENSIVE FOR ME AS A SINGLE MOM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Grand Caravan