Chevrolet Cobalt Complaints

7,975 consumer complaints on file.

#11476868August 1, 2022
FUEL/PROPULSION SYSTEM
Fuel line leaking similar to the recall on 2008-10 Cobalts -- gas puddles or drips from leaking fuel lines near the left rear wheel well, near the exhaust pipe and muffler. The leak is caused by corrosion of the metal fuel lines that are secured to the body of the car by plastic blocks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11475860July 26, 2022
FUEL SYSTEM, GASOLINE
The contact owns a 2009 Chevrolet Cobalt. The contact stated that the odor of fuel was present inside and outside of the vehicle. Additionally, the odor was present whether the vehicle was on or turned off. The cause of the failure was not yet determined. The contact stated that no visible fuel leaks were present. The local dealer was contacted regarding the failure and the contact was informed that the vehicle was not included in the NHTSA Campaign Number: 12V459000 (Fuel System, Gasoline). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11475495July 23, 2022
FUEL/PROPULSION SYSTEM
I have to replace my fuel lines due to them rusting out over the left rear wheel well. I noticed a distinct smell of gas for a couple of rides to or from work. After a couple of rides, the smell was very strong and I happened to notice the gas dripping down under the car upon inspection. It was taken to a auto repair shop where I was told that this was a serious hazard and the gas lines would have to be replaced costing me $650. The mechanic said that the lines has rusted causing the leak. He also mentioned that this was a common problem with the 2008 chevy cobalt.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11474445July 18, 2022
STEERING, VEHICLE SPEED CONTROL, POWER TRAIN
Power steering light came on now I have no speedometer and it will not shift right
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472908July 8, 2022
STEERING
The contact owns a 2009 Chevrolet Cobalt. The contact stated while driving approximately 20 MPH, the vehicle lost power steering assist and became difficult to steer. The contact stated no warning light was illuminated. The contact stated that the power steering failure occurred at various speeds. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 10V073000 (Steering). The manufacturer had not been informed of the failure. The failure mileage was approximately 49,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472698July 7, 2022
ELECTRICAL SYSTEM, STEERING, WHEELS
Power steering is locking up while driving. Windows won’t go down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471832June 30, 2022
FUEL SYSTEM, GASOLINE
The contact owns a 2010 Chevrolet Cobalt. The contact stated that while his daughter was driving at an unknown speed, she started to smell an abnormal fuel odor inside the vehicle. The contact stated that the check engine warning light was illuminated. The contact stated while inspecting the vehicle, he noticed a fuel leak on the rear driver’s side of the vehicle. The contact called an unknown local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469994June 19, 2022
STEERING
While parking my 2009 Chevy Cobalt the power steering became difficult. It was like it stopped working at times. Then it began again and then it completely stopped steering and the steering locked. I turned the car off and checked the vehicles power steering fuses. They were all fine. Then turned the car back on to see if the problem still continued and it started working. I rushed home hoping it would work. Once I pulled into my driveway the power steering completely stopped working again. I see that there was a recall in the past but may not be available any longer but seems like they should still correct the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469896June 18, 2022
SEAT BELTS
I wrecked my car and after having it fixed and reset the seat belts are still locked up. this is an extremely common problem in cobalts it seems. i went chevrolet dealership and they are telling me that it isnt fixable, that the seatbelts will just suck back down inside again. my car is fixed but is now rendered not safe to drive because the seat belts dont work, and theres no way to have them fixed according to chevrolet.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11469011June 13, 2022
STEERING:ELECTRIC POWER ASSIST SYSTEM
The contact owns a 2006 Chevrolet Cobalt. The contact stated that after starting the vehicle and attempting to reverse, the steering wheel was very difficult to turn. The check engine warning light was illuminated. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact did not notify the manufacturer of the failure. The failure mileage was approximately 189,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468544June 9, 2022
FUEL/PROPULSION SYSTEM
Leak in fuel line
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468052June 7, 2022
STEERING
The contact owns a 2008 Chevrolet Cobalt. The contact stated that upon starting the vehicle the vehicle experienced power steering failure. The contact drove the vehicle to her destination at approximately 30 MPH without a power steering assist. The contact stated that when she returned and started the vehicle the power steering had regained functionality. The contact stated that the failure had recurred twice in the past three months. The contact stated no warning light was illuminated. The contact had not taken the vehicle to an independent mechanic or dealer. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 91,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467725June 6, 2022
STEERING
The contact owns a 2009 Chevrolet Cobalt. The contact stated while starting the vehicle, the vehicle lost power steering functionality. The power steering assist warning light was illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 67,504.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467808June 6, 2022
STEERING
Power steering assist goes out randomly. Looked up VIN and said does not affect this vehicle, however, it is malfunctioning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467575June 4, 2022
STEERING
My mother owned this 2005 chevrolet cobalt 4D (vin # stated above). The power steering seemed to have quit working, as it was very hard to turn the steering wheel. On Dec.28, 2021 she (& my 2 daughters) were turning left & her car was hit by another car on the right front (passenger side), front 1/4 panel. The car was spun around several times. My mother was temporarily knocked unconscience & then came to. Car was totalled out. (Doctor ignored to perform a head scan instead he scanned her back). My mother bled on her brain for 3 months & died. It was very devastating
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11466566May 29, 2022
STEERING
My power steering seemed very loose. I zig zag across the road.Trying not to hit a telephone pole.Slipped into a ditch. Got back on the road for a few seconds but still no control. Finally car went into the woods hit a tree and was totaled.I don't care if vin says no recalls my steering didn't exist that day.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11466010May 24, 2022
FUEL/PROPULSION SYSTEM
Strong fuel smell and gas on the ground (creating a fire hazard). No warning messages were displayed. Puddling of the fuel is just in front of the left rear tire. Odor was detected first; then one week later the puddle occurred. Car has been repaired by GM service; fuel and EVAP lines replaced (p/n 25999914 and 15934416). Symptom and repair seem identical to HTSA Bulletin 09226C (published July 2015).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465739May 23, 2022
STEERING
The contact owns a 2007 Chevrolet Cobalt. The contact stated while driving approximately 55-60 MPH, the power steering warning light illuminated and the vehicle lost power steering functionality. The contact was able to veer to the side of the road using extra effort to steer the vehicle. The contact turned off and restarted the vehicle and the vehicle regained power steering functionality. The contact stated that the failure had been reoccurring while driving. The dealer was notified of the failure and advised the contact to take the vehicle in for diagnostic testing. The vehicle was not diagnosed or repaired. The contact referenced NHTSA Campaign Number: 10V073000 (Steering). The manufacturer was not notified of the failure. The failure mileage was approximately 143,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465566May 21, 2022
FUEL/PROPULSION SYSTEM
Fuel lines completely rotted out under factory heat shielding. Leaking fuel onto the exhaust near drivers side rear tire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464722May 15, 2022
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Wiring harness is located too close to the human under the driver's seat. Exposes the driver to electrical frequencies that could be avoided if the wire harness was a further distance away from the human. Also, the the fuel line rusted through after 9 years about 9 inches away from the rear axle where the metal tape ends around the fuel line. The metal tape seems to allow more moisture to become trapped around the fuel line; which promotes rust and a leak where the metal tap ends. After the metal tape, the fuel line is in good condition on this specific vehicle. The fuel leak is about 0.5 inches wide and a lot of gasoline drips / leaks after the car is started. The rust particles are located after the fuel filter; which may promote the rust particles to reach the engine via the rusted fuel line. The car has trouble starting (a delay) and needs to have the key turned twice due to the leak. The leak is very close to the muffler, so it seems like it would be at risk of catching on fire if the muffler was hot enough or if it were traveling on a long trip or going up or down a steep hill. The vehicle has been inspected by police. There were no warning lamps or lights.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Cobalt