Volvo S40 Complaints (2007)

25 consumer complaints on file.

#11360366September 22, 2020
ELECTRICAL SYSTEM, VISIBILITY/WIPER, UNKNOWN OR OTHER
ON OR ABOUT 12/04/2019 DURING A FLASH RAIN STORM LAST WINTER, MY HUSBAND AND I WAS HEADED HOME ON THE 215 FWY NORTHBOUND IN SAN BERNARDINO, CA WHEN THE CENTER DOME AREA AND THE ELECTRIC SUNROOF INSIDE OUR CAR BEGIN POURING IN HUGE AMOUNTS OF VERY COLD RAIN WATER ON US AND ON THE DASHBOARD, STEREO CONSOLE, GEAR SHIFTER, FLOOR AND SEATS. UNTIL IT WAS SAFE TO EXIT THE FREEWAY, MY HUSBAND TRIED TO SOAK UP AS MUCH OF THE LEAKING RAINWATER AS HE COULD WITH HIS COAT BUT THE WATER CONTINUED TO POURING INTO THE CAR. ONCE IT WAS SAFE TO EXIT THE FREEWAY, WE PULLED INTO A GAS STATION AND EXAMINE THE SUNROOF TO MAKE SURE IT WAS SHUT PROPERLY, WHICH IT WAS, NOT UNDERSTANDING WHY THIS WAS HAPPENING, HE AND I USED AS MANY PIECES OF NAPKINS AND CLOTH THAT WE COULD FIND TO SOP UP AS MUCH WATER AS WE COULD AND AS BEST AS WE COULD. WE DROVE ON THE STREETS THE REMAINING FEW MILES TO GET HOME BECAUSE IT WAS MUCH SAFER TO DO SO AT THIS POINT. LATER, WE RESEARCHED AS MUCH AS WE COULD FIND OUT ABOUT THE PROBLEM VIA ONLINE COMPLAINTS AND REVIEWS FROM OTHER VOLVO OWNERS. WE THEN TRIED ONE OF THE FIXES OFFERED: CLEARING POTENTIAL DEBRIS FROM THE SUNROOF DRAIN HOSES. HOWEVER, WHEN WE TOOK THE CAR TO A DRIVE-THRU CARWASH SHORTLY AFTERWARDS, THE EXACT SAME THING HAPPEN. WE ARE LOOKING FORWARD TO SELLING THE VOLVO, BUT DUE TO THE LEAKY CENTER DOME AND SUNROOF, THERE IS NO WAY WE WILL CONSIDER SELLING THE CAR WITHOUT DISCLOSING THIS SAFETY ISSUE TO THE NEXT BUYER, EVEN THOUGH WHEN WE PURCHASED THE CAR IN 2013, THE DEALER WHO SOLD IT TO US DID NOT TELL US ABOUT THE SAFETY DEFECT. UNDOUBTEDLY, IF CAUGHT OFF GUARD WHILE DRIVING (I.E. WITHOUT A PASSENGER'S HELPING HAND), NOT KNOWING ABOUT THE DEFECT MAY RESULT IN A MAJOR ACCIDENT OR FATALITY. PLEASE HELP!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11205749May 6, 2019
STEERING
I WAS DRIVING AND THE ENGINE SHUT OFF CAUSING ME TO LOSE CONTROL OF MY VEHICLE AS THE POWER STEERING SHUT DOWN. I WAS ABLE TO STEER MY VEHICLE WITH DIFFICULTY TO THE SIDE OF THE ROAD WHERE IT STOPPED. ABOUT ONE WEEK LATER THIS HAPPENED AGAIN. THIS TIME I WAS COMING OUT OF A PARKING LOT AND HAD TO AIM MY VEHICLE IN A WAY TO AVOID HITTING OTHER VEHICLES. BOTH TIME, AFTER A FEW MINUTES THE CAR STARTED RIGHT UP AND I WAS ABLE TO DRIVE AGAIN. LAST FRIDAY, MAY 3, I PULLED MY VEHICLE OVER AND WHEN I STOPPED THE VEHICLE SHUT DOWN. THIS TIME IT DID NOT RESTART. THE ERROR MESSAGE DISPLAYED ON THE DASH WAS THAT THE "STEERING WAS LOCKED, TRY AGAIN." AFTER SEVERAL ATTEMPTS INCLUDING JUMP STARTING THE VEHICLE, WHICH WAS UNNECESSARY, THE VEHICLE WOULD NOT START. I HAD MY VEHICLE TOWED TO THE NEAREST VOLVO DEALERSHIP AND WAS TOLD THAT THE "STEERING COLUMN LOCK" HAD FAILED. THE PART NEEDED TO BE REPLACED AT A COST OF OVER $830.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11141465October 19, 2018
SEAT BELTS, AIR BAGS
TL* THE CONTACT OWNED A 2007 VOLVO S40. THE CONTACT CALLED ON BEHALF OF THE DRIVER. THE CONTACT STATED THAT THE VEHICLE WAS STRUCK ON THE FRONT PASSENGER SIDE BY ANOTHER VEHICLE. THE SPEED WAS UNKNOWN. THE AIR BAG FAILED TO DEPLOY AND THE SEAT BELT DETACHED. THE DRIVER SUSTAINED LEG, BACK, AND SHOULDER INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11098954May 31, 2018
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM, UNKNOWN OR OTHER
AFTER PARKING CAR AND TURNING CAR OFF, AIRBAG, BRAKE, AND INFORMATION WARNING LIGHTS STAY ON, AS DOES VENTILATION SYSTEM. PASSENGER SEAT HAS EXCESS WATER UNDERNEATH. NOW CAR WILL NOT START.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10949021February 2, 2017
VEHICLE SPEED CONTROL
VEHICLE LOSES POWER DUE TO ACCELERATOR PEDAL LOW VOLTAGE/SIGNAL. THIS OCCURS IN MULTIPLE SITUATIONS. SAFEST IS SHORTLY AFTER STARTING THE CAR AN ENGINE LIGHT STATING 'ENGINE SYSTEM URGENT' APPEARS. UNSAFE OCCURRENCE INCLUDES POWER LOSS WHILE PEDAL IS DEPRESSES SUCH AS ON THE HIGHWAY WITH CONSTANT PRESSURE OR MOST SEVERE WHEN TURNING LEFT THROUGH AN INTERSECTION POWER IS REDUCED TO IDLE. IF THE VENT OCCURS WITH THE PEDAL REPRESSED, POWER IS REDUCED TO IDLE MOMENTARILY (2-3 SECONDS) AND AFTER 'PUMPING' THE PEDAL SEVERAL TIMES IT RETURNS TO NORMAL. I HAVE BROUGHT THIS VEHICLE SEVERAL TIMES TO REPAIR. DEAL CHANGED PEDAL, CHANGED WIRING CONNECTORS (ALSO CLEANED SEVERAL TIMES) AND ULTIMATELY REPLACED ENGINE COMPUTER. PROBLEM STILL OCCURS AND DEALER DOES NOT KNOW WHAT ELSE TO DO. MOST RECENT OCCURRENCE WAS 27 JAN BUT THIS ISSUES APPEARS ABOUT EVERY TWO MONTHS AFTER REPAIR AND OCCURS DAILY ONCE TO PROBLEM RETURNS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10947597January 25, 2017
ENGINE, VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
SAFETY CONCERN: 2007 VOLVO S40 ELECTRONIC THROTTLE MODULE FAILURE - CAUSING "REDUCED ENGINE PERFORMANCE" MESSAGE AND VEHICLE (2007 VOLVO S40) SUDDENLY SLOWS DOWN WHILE IN MOTION, LIMPS AND CANNOT GO HIGHER SPEED. HAD BARELY EXITED THE FREEWAY ON 1/24/2017 AND THIS HAPPENED AS I WAS ON RAMP. COULD BE EXTREMELY DANGEROUS IF IT HAPPENED 1 MINUTE BEFORE WHEN ON FREEWAY. TURNED VEHICLE IN RIGHT AWAY TO LOCAL VOLVO DEALERSHIP (WHICH WAS LUCKILY WITHIN 15 MINUTES) AND THEY DIAGNOSED IT TO BE FAULTY ELECTRONIC THROTTLE MODULE NEEDING REPLACEMENT. MILEAGE ON CAR 129,000 MILES. WANTED TO REPORT SO THIS ISSUE CAN BE LOOKED INTO FOR SAFETY CONCERN AND IF THE HUGE COST OF REPLACEMENT CAN BE OFFSET SO OWNERS CAN HAVE PEACE OF MIND REPLACING IT TIMELY IF THERE IS A RECOMMENDATION OR BULLETIN (SIMILAR TO TIMING BELTS ETC. - WHICH I DON'T BELIEVE THERE IS CURRENTLY FOR ELECTRONIC THROTTLE MODULE).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10887948July 23, 2016
AIR BAGS
TAKATA RECALL SOMETHING IS WRONG WITH THE AIRBAGS. I T IS SHOWING ME THAT IT NEEDS TO BE REPAIRED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10758733August 24, 2015
ENGINE
TL* THE CONTACT OWNS A 2007 VOLVO S40. WHILE DRIVING, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE PVC VALVE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10745158July 30, 2015
STEERING
MY CAR WOULD NOT START BECAUSE THERE WAS A MESSAGE INDICATING THE STEERING WHEEL WAS LOCKED, BUT, IT WAS NOT LOCKED. I HAD TO TOW THE CAR TO THE SHOP. THEY REPORTED A DEFECTIVE STEERING COLUMN LOCK MODULE. I FOUND THIS IS A COMMON PROBLEM FOR THIS CARS WHICH IS TOTALLY UNSAFE AND UNACCEPTABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662337December 5, 2014
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM, ENGINE AND ENGINE COOLING
THE COOLING SYSTEM AND DEFROST SHUT DOWN AFTER DRIVING FOR A WHILE. TURNS OUT THE CLUTCH WENT BAD ON THE COMPRESSOR. AFTER RESEARCHING FURTHER ONLINE, THERE ARE MANY COMPLAINTS ABOUT THIS FAILURE. UNFORTUNATELY, THIS IS A VERY EXPENSIVE REPAIR THAT I CANNOT AFFORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10648861October 20, 2014
ELECTRICAL SYSTEM, SEATS, STRUCTURE
SUNROOF DRAIN BECAME CLOGGED. THIS CAUSED THE POORLY DESIGNED DRAINS TO LEAK AT A JUNCTION INSIDE THE VEHICLE ALONG THE DOOR PILLAR AND BEHIND THE INSTRUMENT PANEL. THE WATER COLLECTS ON THE REAR PASSENGER FLOORBOARDS AND AROUND THE DRIVERS SEAT. THE CAR OWNER IS UNAWARE OF THE LEAK UNTIL A LARGE AMOUNT OF WATER HAS ACCUMULATED. I AM VERY CONCERNED ABOUT THE POTENTIAL FOR AN ELECTRICAL FAULT OR SHORT CIRCUIT THAT COULD POTENTIALLY RESULT IN A FIRE, MALFUNCTION OR COULD LEAD TO AN ACCIDENT. VOLVO SHOULD MAKE CHECKING THESE DRAINS A REGULAR PART OF IT'S SERVICE PROCEDURES OR CONSIDER A REDESIGN OR RECALL. THIS ISSUE IS WIDESPREAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10648903October 20, 2014
SERVICE BRAKES
TL* THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT STATED THAT THE BRAKE SENSOR ILLUMINATED INDICATING LOW BRAKE FLUID. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN REPLENISHED THE BRAKE FLUID AND RESET THE BRAKE SENSOR. THE CONTACT INDICATED THAT SHORTLY AFTER THE BRAKE SENSOR WAS RESET BY THE DEALER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO WAS NOT ABLE TO REPLICATE OR DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V101000 (BRAKES). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10551644November 9, 2013
TIRES
MICHELIN PRIMACY MXV4 TIRES - DRY ROT ON ALL 4 TIRES AFTER ONLY 20,000 MILES. THE WARRANTY IS FOR 60,000 MILES. THIS DRY ROT IS A HUGE SAFETY CONCERN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10439260December 10, 2011
SERVICE BRAKES, HYDRAULIC
12/9/2011 WHILE ON AN INCLINE DRIVING AT APPROXIMATELY 25 MPH BRAKES FAILED, EVEN AFTER PRESSING PEDAL ALL THE WAY TO THE FLOOR, CAR FAILED TO STOP CAUSING COLLISION WITH VEHICLE IN FRONT DESPITE MORE THAN NECESSARY BRAKING DISTANCE MAINTAINED BETWEEN TWO VEHICLES AND UNDER CLEAR, SUNNY CONDITIONS. NOTE: DEALER HAD COMPLETED 10-POINT INSPECTION DURING OIL CHANGE 14 DAYS BEFORE OCCURRENCE. 8/2011 CAR FLOODED WITH WATER INTERNALLY AND ON FLOOR/CARPET. SECOND OCCURRENCE. SUNROOF DRAIN PIPES REPLACED AND CAR SEATS, CARPETS, FOAM PADDING REMOVED AND DRIED. OWNER REQUIRED TO PAY 50% OF COST OF LABOR AND PARTS, EVEN THOUGH WAS TO HAVE BEEN REPAIRED IN 2/2011.2/2011 FIRST INCIDENT OF CAR FLOOD WITH WATER INTERNALLY AND ON FLOOR/CARPET. SUNROOF REPLACED AND CAR SEATS, CARPETS, FOAM PADDING REMOVED AND DRIED. SUNROOF REPLACED BY VOLVO, OWNER INCURRED LABOR COSTS. WARRANTY EXPIRED 2 MONTHS AND 1 WEEK BEFORE TAKEN IN. CAR HAD UNDERGONE 22500 MILE CHECK WITH NOTHING NOTICED BY VOLVO WHILE UNDER WARRANTY! REGULAR MAINTENANCE WAS DONE AT DEALERS AT RECOMMENDED SCHEDULE AND DEALER PERFORMED STATE-REQUIRED SAFETY AND EMISSION INSPECTIONS. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10437709November 29, 2011
ENGINE AND ENGINE COOLING
I OWN A '07 VOLVO S40 WITH 78,000 MILES. IT BEGAN MAKING A LOUD WHISTLING NOISE COMING FROM THE OIL DIPSTICK. AFTER RESEARCHING ONLINE I FOUND THAT IT WAS A KNOWN PROBLEM BY VOLVO AND THE DEFECTIVE PART IS COVERED UNDER AN EXTENDED WARRANTY, HOWEVER THIS DEFECTIVE PART CAUSES EXCESSIVE DAMAGE TO THE ENGINE THAT IS NOT COVERED BY VOLVO. IT IS NOW UP TO THE CONSUMER TO PAY FOR THE ENGINE DAMAGE OR IT WILL CAUSE THE TIMING BELT TO SNAP AND THE ENGINE TO EXPLODE. AN UNSUSPECTING CONSUMER CAN BE FATALLY INJURED BY THIS PROBLEM AND SOMETHING MUST BE DONE ABOUT IT! *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430628October 18, 2011
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT STATED WHILE DRIVING 30 MPH, SHE APPLIED THE BRAKES AND A BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS LEAKING BRAKE FLUID. BRAKE FLUID WAS ADDED TO THE VEHICLE AS A TEMPORARY REMEDY. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED NHTSA CAMPAIGN ID NUMBER 08V101000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 76,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10381951February 10, 2011
SEAT BELTS:FRONT
2007 VOLVO S-40. CONSUMER WRITES REGARDING A SEAT BELT DEFECT AFTER SUFFERING AN INJURY TO THE EYE DUE TO A REAR END COLLISION *TGW THE CONSUMER STATED HE WAS STRUCK FROM THE REAR WHILE STOPPED YIELDING TO TRAFFIC. THE CONSUMER STATED HE AND HIS WIFE WERE HIT WITH SUCH FORCE THAT THE VEHICLE ROLLED APPROXIMATELY 25 FEET FROM WHERE THEY WERE ORIGINALLY STOPPED. THE DRIVER'S SIDE SEAT BELT DID NOT RETRAIN THE CONSUMERS UPPER BODY WHICH ALLOWED HIS TORSO TO GO FORWARD; CONSEQUENTLY, HIS HEAD STRUCK THE LEFT WINDSHIELD PILLAR. FROM THE IMPACT OF HIS HEAD STRIKING THE WINDSHIELD PILLAR, HIS UPPER EYE LID WAS LACERATED BY THE FRAME OF HIS EYEGLASSES AND SEVERELY BRUISED HIS EYE AS A RESULT. THE CONSUMERS WIFE SUSTAINED WHIPLASH. *JB
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10378807January 26, 2011
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH THE BRAKES FAILED CAUSING HER TO CRASH INTO THE REAR OF A VEHICLE. THE DRIVER SUSTAINED MINOR INJURIES, WHIPLASH AND WAS NOT TRANSPORTED TO THE HOSPITAL. A POLICE REPORT WAS FILED. THE VEHICLE WAS INSPECTED BY AN INSURANCE ADJUSTER WHO CONFIRMED THAT IT WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 63,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10312587February 22, 2010
ELECTRICAL SYSTEM:IGNITION:SWITCH
I PARKED THE 2007 S40 VOLVO AND CAN'T REMOVE THE KEY FROM THE IGNITION SWITCH. THE CAR IS IN PARK, BRAKE ON, ALL NECESSARY CHECKS ARE CHECKED. STILL CAN'T GET THE KEY TO RELEASE, HAD TO TURN IT SEVERAL TIMES (30 MINUTES) RIGHT TO LEFT UNTIL I HEARD A CLICK AND THE KEY CAME OUT. I HAVE SEEM POST ON THE INTERNET ABOUT THIS AND THAT IS HOW I FIGURED OUT HOW TO GET MY KEY AND LOCK THE DOORS. I CALLED VOLVO AND THE RESPONSE WAS GO TO THE DEALER AND YOU ARE OUT OF WARRANTY?! THE KEY WILL NOT GO PAST THE I POSITION. I DON'T MIND PAYING TO GET IT FIXED BUT ACCORDING TO THE VOLVO MAKERS IT IS ISOLATED AND NOT KNOWN HOW TO FIX. I BEG TO DIFFER BASED ON TALKING TO OTHER OWNERS AND THE INFO ON THE WEB. PLEASE ASSIST AS MUCH AS POSSIBLE OR A DIRECTION TO GET RESOLUTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312385February 20, 2010
SERVICE BRAKES, ELECTRIC
I DROVE INTO A HOTEL PARKING GARAGE , CAME INTO MY SPOT AND THE CAR ACCELERATED AND WENT INTO A WALL. I SHUT THE ENGINE OFF TO PREVENT MY WHOLE CAR GOING THRU THE WALL. JUST THE FRONT OF THE CAR WENT INTO THE WALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S40