Volvo S40 Complaints

491 consumer complaints on file.

#10947597January 25, 2017
ENGINE, VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
SAFETY CONCERN: 2007 VOLVO S40 ELECTRONIC THROTTLE MODULE FAILURE - CAUSING "REDUCED ENGINE PERFORMANCE" MESSAGE AND VEHICLE (2007 VOLVO S40) SUDDENLY SLOWS DOWN WHILE IN MOTION, LIMPS AND CANNOT GO HIGHER SPEED. HAD BARELY EXITED THE FREEWAY ON 1/24/2017 AND THIS HAPPENED AS I WAS ON RAMP. COULD BE EXTREMELY DANGEROUS IF IT HAPPENED 1 MINUTE BEFORE WHEN ON FREEWAY. TURNED VEHICLE IN RIGHT AWAY TO LOCAL VOLVO DEALERSHIP (WHICH WAS LUCKILY WITHIN 15 MINUTES) AND THEY DIAGNOSED IT TO BE FAULTY ELECTRONIC THROTTLE MODULE NEEDING REPLACEMENT. MILEAGE ON CAR 129,000 MILES. WANTED TO REPORT SO THIS ISSUE CAN BE LOOKED INTO FOR SAFETY CONCERN AND IF THE HUGE COST OF REPLACEMENT CAN BE OFFSET SO OWNERS CAN HAVE PEACE OF MIND REPLACING IT TIMELY IF THERE IS A RECOMMENDATION OR BULLETIN (SIMILAR TO TIMING BELTS ETC. - WHICH I DON'T BELIEVE THERE IS CURRENTLY FOR ELECTRONIC THROTTLE MODULE).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10944096January 10, 2017
AIR BAGS, SEAT BELTS
[THIS IS A PREVENTATIVE COMPLAINT. NO INJURY SUSTAINED.] THIS CAR HAS A FAILED PASSENGER SEAT SENSOR THAT WHEN DEPRESSED ACTIVATES THE PASSENGER SIDE AIR BAG. THIS VEHICLE ALSO HAS A DRIVER SIDE SEAT BELT THAT CLICKS AND THEN CAN BE PULLED OUT OF THE LOCKING HARNESS. THESE ITEMS ARE NOT RECALLED BY THE MANUFACTURE BUT, IN MY OPINION, SHOULD BE FOR CUSTOMER SAFETY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10940120January 6, 2017
EXTERIOR LIGHTING
THE ISSUE OF NO HEADLIGHTS (LOW-BULB FAILURE) IS DANGEROUS & EXPENSIVE. NOR IS THERE A VIABLE PERMANENT REPAIR AS THE "LOW-BULB FAILURE" ALWAYS RE-OCCURS & HAS BEEN AN ONGOING PROBLEM FOR ME SINCE MY CAR WAS NEW. SUDDENLY HAVING NO HEADLIGHTS CAUSES A SERIOUS & IMMEDIATE SAFETY ISSUE FOR OCCUPANTS OF THE CAR & FOR ONCOMING TRAFFIC WHO CAN'T SEE A CAR WITHOUT HEADLIGHTS. IT CAN BE 1 HEADLIGHT OR BOTH THAT FAIL WITHOUT WARNING; LEAVING NO TIME TO BRING A VEHICLE TO A STOP SAFELY. THE EXPERIENCE IS FRIGHTENING & DANGEROUS IN THOSE TENSE MOMENTS IT TAKES TO STOP A MOVING CAR ON THE ROAD WITHOUT HEADLIGHTS. I HAVE EVEN BEEN ISSUED A VIOLATION TICKET FROM THE POLICE FOR EQUIPMENT FAILURE DESPITE NUMEROUS REPAIR BILLS THAT I KEEP IN THE CAR. AFTER REPEATED ATTEMPTS AT GETTING VOLVO TO FIX THIS ISSUE, I REPORTED THE PROBLEM TO NHTSA SEVERAL YEARS AGO BUT WAS TOLD THERE HAD NOT BEEN ENOUGH COMPLAINTS ABOUT THE HEADLIGHT FAILURE PROBLEM TO DO ANYTHING. NOW, YEARS HAVE GONE BY AND I AM STILL DEALING WITH A CAR THAT IS ESSENTIALLY A DAYTIME ONLY CAR AS IT IS NOT SAFE TO DRIVE AFTER DARK DUE TO THE UNPREDICTABLE LOSS OF HEADLIGHTS. EACH TIME THE HEADLIGHTS FAIL I BRING THE CAR FOR SERVICE AND EVERY TIME THE HEADLIGHT FAILS AGAIN AND AGAIN WITHIN WEEKS OF THE "REPAIR". REPAIR COST ARE IN THE $500 RANGE. THERE IS NO RECOURSE FOR THE REPAIRS OTHER THAN TO TRY SOMETHING NEW. IT HAS BECOME A PROBLEM THAT IS WIDELY KNOWN AT REPAIR SHOPS; AND AFTERMARKET REPAIR KITS ARE NOW COMMON BECAUSE VOLVO HAS IGNORED THE ISSUE STATING THAT THERE IS NOT A PROBLEM TO ME. IT IS EASY TO FIND MANY CAR OWNERS WITH THE SAME ISSUE AND FRUSTRATIONS ON THE INTERNET AS WELL AS SUITS BROUGHT AGAINST OTHER AUTO MANUFACTURERS FOR THE WIDE-SCALE FAILURE OF THESE USELESS, DEFECTIVE HEADLIGHTS. NHTSA SHOULD PROHIBIT THESE HEADLIGHTS AND FORCE ACTION FOR THOSE RESPONSIBLE TO ADDRESS THIS KNOWN SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10925156November 9, 2016
WHEELS
I WAS PROMPTED TO ADD AIR TO MY FRONT TIRE DUE TO THE LOW TIRE PRESSURE LIGHT COMING ON. AFTER I ADDED AIR I ATTEMPTED TO PUT THE TIRE VALVE CAP BACK ON THE WHEEL AND IT BEGAN FORCEFULLY BLOWING OUT AIR. I ATTEMPTED AGAIN TO SECURE THE CAP AND THE VALVE STEM SENSOR CAME OUT OF THE VALVE STEM COMPLETELY. THIS IS A HUGE SAFETY RISK, AND I AM NOW CONCERNED THIS COULD HAPPEN AGAIN. I URGE VOLVO TO HONOR THE REPLACEMENT OF THEIR FAULTY TIRE STEM VALVES IMMEDIATELY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10918442October 24, 2016
TIRES:SIDEWALL
TL* THE CONTACT OWNS A 2008 VOLVO S40 EQUIPPED WITH CONTINENTAL EXTREMECONTACT DWS TIRES, SIZE: 205/50/17 (NA). WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT PASSENGER SIDE TIRE EXPERIENCED A SIDEWALL BLOW OUT AFTER DRIVING OVER GRAVEL IN THE ROAD. DURING THE INCIDENT, THE VEHICLE SUSTAINED DAMAGE TO THE SUSPENSION, BUMPER, AND ROCKER PANEL. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DOT NUMBER, VEHICLE FAILURE MILEAGE, AND VIN WERE NOT AVAILABLE. THE TIRE FAILURE MILEAGE WAS 12,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10918075October 22, 2016
SUSPENSION
BOTH FRONT WHEEL BEARINGS NEEDED TO BE REPLACED WITHIN 1 YEAR OF EACH OTHER. VEHICLE IS NOT DRIVEN OVER ROUGH TERRAIN OR POT HOLES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908871September 23, 2016
SERVICE BRAKES
BRAKE PEDAL IS TOO CLOSE TO ACCELERATOR PEDAL. WHENEVER I OPERATE THE GAS PEDAL, THE SIDE OF MY SHOE ALSO ACTIVATES THE BRAKE. THE PROBLEM IS AGGRAVATED BY THE CENTER TUNNEL CARPET INTRUDING ON THE MINIMAL ACCELERATOR PEDAL SPACE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10903603September 5, 2016
ELECTRICAL SYSTEM
MY VEHICLE DOORS LOCK UP AND CAN'T BE UNLOCKED DUE TO FAULTY LOCKS. NO WAY TO GET DOOR OR DOORS TO UNLOCK. WHICH CAN CAUSE DEATH IF INVOLVED IN A ROLL OVER, SUBMERGED, OR ANY MAJOR ACCIDENTS. IT CAN BE ANY DOOR ON THE VEHICLE. ON MINE IT'S MY REAR PASSENGER DOOR WHICH MY CHILD SITS NEXT TOO IN HER CAR SEAT. I'VE READ MANY OTHER VOLVOS HAVE THIS ISSUE AND VERY COSTLY TO REPAIR. VOLVO SHOULD BE RESPONSIBLE AS I HAVE BEEN TOLD BY A VOLVO DEALER MECHANIC THAT THESE S40 ARE VERY KNOWN TO HAVE THIS ISSUE. FOR MY EXPERIENCE OF THIS HAPPENING IS JUST DRIVING HOME AND PARKING. TRIED TO GET MY DAUGHTER OUT AND IT WOULD NOT UNLOCK. THE KEY FAUBOURG, THE POWER LOCK SWITCH AND TRIED PULLING ON HANDLE AND NOTHING UNLOCKS THIS DOOR. I READ THAT THE LOCK ACTUATORS ARE THE CAUSE OR ITS THE WIRING HARNESS. I ALSO HAVE THIS PROBLEM IN THE TRUNK. ONLY THE KID NAPPED CORD WORKS TO GET THE TRUNK TO OPEN. PLEASE GET VOLVO TO FIX ALL THERE ACTUATORS BEFORE KIDS OR ADULTS GET TRAPPED AND KILLED CAUSE OF THEIR NEGLIGENCE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10893841August 7, 2016
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, EXTERIOR LIGHTING
I'VE CONTACTED VOLVO AND DEMANDED MY MONEY BACK AND THEY REFUSED, THIS IS MY NEXT STEP BEFORE TAKING THEM TO COURT FOR A MEASILY 2,500. THIS CAR HAS CAUSED ME A HEADACHE UNLIKE ANY OTHER, THE ELECTRICAL SYSTEM FAILS IN THIS CAR AND PASSES THROUGH IT MALFUNCTIONING ONE THING AFTER THE NEXT, MY BACK WINDOW WENT UP AND DOWN ON ITS OWN, HEATING AND COOLING SYSTEMS DO WHACKY THINGS WHICH RUINED THE CAR MAKING IT OVERHEAT EVEN AFTER SHOPS REPLACE SENSORS AND RADIATORS, THE MAIN SAFETY CONCERN WHICH VOLVO IS SUPPRESSING IS THAT THE ELECTRICAL GHOST ALSO AFFECTS THE BRAKING SYSTEM AND ACCELERATES, THIS IS A MAIN CONCERN WHEN YOU'RE ON AN EXPRESSWAY ESPECIALLY, IT ACCELERATES AND YOU CANNOT HOLD THE BRAKE DOWN HARD ENOUGH TO SLOW DOWN, AND IT'LL DO IT AT RANDOM, AND I KNOW THIS IS A PROBLEM WITH THIS YEAR VOLVO BECAUSE I HAVE A 1990 WHEN IT WAS VOLVO AND NOT BOUGHT MY AN AMERICAN COMPANY AND THAT CAR IS PERFECT, AND A COP TALKED TO ME FOR ABOUT AN HOUR JUST BEFORE THESE BIGGER ISSUES STARTED HAPPENING, HE'D OWNED A DEALERSHIP AND SAID THIS YEAR VOLVO HAS NOTHING BUT PROBLEMS, AND AT THAT TIME I KNEW HE WAS ONTO SOMETHING BECAUSE THE AIR AND HEAT BUTTONS WERE DOING ALL KINDS OF STRANGE THINGS, I WAS EVEN IN AN ACCIDENT ONCE, A LITTLE FENDER BENDER THANKFULLY JUST ON A SIDE STREET, MY CAR WOULDN'T SLOW DOWN AND IT SKIDDED ALL T HE WAY TO THE LIGHT AND I DENTED SOMEONE'S BUMPER, THEY LET ME SLIDE BECAUSE THEIR CAR WAS A JALOPY, BUT I'VE HAD THIS SAME ELECTRICAL FAILURE HAPPENING ON EXPRESSWAYS AT VARIOUS SPEEDS
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10891923July 31, 2016
STRUCTURE:BODY
MY HUSBAND AND I BOTH OWN 2010 VOLVOS. MINE IS S40, HIS XC60. WE HAVE BOTH HAD LEAKS RELATING TO FAULTY SUNROOF DRAIN. DEALER REPAIRED AND REPLACED FOR MY HUSBAND AT NO COST, BUT FOUGHT WITH ME - BECAUSE I AM A WOMAN - UNTIL MY HUSBAND CAME WITH ME TO DEALERSHIP. EVEN THOUGH THEY ULTIMATELY FIXED THE SUNROOF DRAIN, THERE IS STILL THE STENCH OF MOLD OR MILDEW IN MY CAR. MY HUSBAND ALSO HAD A LEAK DEVELOP IN HIS WINDSHIELD. DEALER TOLD HIM THAT THERE WAS A FAULTY COATING ON WINDSHIELDS THIS MODEL YEAR AND THEY REPLACED HIS WINDSHIELD AT NO COST. JUST NOW, I WAS OUT DRIVING, IT STARTED RAINING, AND WATER STARTED POURING IN THROUGH MY WINDSHIELD. (LUCKILY I WAS JUST ARRIVING AT MY DESTINATION, AND I WAS ABLE TO WAIT UNTIL THE RAIN SUBSIDED BEFORE DRIVING HOME, BECAUSE THERE WERE MULTIPLE STEADY STREAMS OF WATER POURING ON TO ME AND THE STEERING WHEEL WHEN THE RAIN WAS AT ITS PEAK.) APPARENTLY MY WINDSHIELD HAS THE SAME PROBLEM THAT MY HUSBAND'S HAD. I KNOW THERE IS ALREADY A CLASS ACTION LAWSUIT BREWING ABOUT THE LEAKY SUNROOF DRAIN, AND I SEE THAT THERE ARE HUNDREDS OF PEOPLE ONLINE COMPLAINING ABOUT THIS. I ALSO SEE THAT THERE ARE LOTS OF PEOPLE ONLINE COMPLAINING ABOUT THE WINDSHIELD LEAK. THIS IS RIDICULOUS. HOW CAN VOLVO KNOWINGLY LET BUYERS OF ITS CARS DRIVE AROUND KNOWING THAT THEY ARE IN DANGER OF HAVING RAIN POUR IN ON THEM AS THEY ARE DRIVING? OR THAT THE INTERIORS OF THEIR CARS WILL BE SOAKED AND POLLUTED WITH MOLD AND MILDEW? IS NHTSA GOING TO DO SOMETHING ABOUT THIS????
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10887948July 23, 2016
AIR BAGS
TAKATA RECALL SOMETHING IS WRONG WITH THE AIRBAGS. I T IS SHOWING ME THAT IT NEEDS TO BE REPAIRED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10875785June 22, 2016
FUEL/PROPULSION SYSTEM
CAR IS STALLING OUT WHILE DRIVING DOWN THE ROAD ENGINE LIGHT CAME ON WHEN PUT ON MACHINE ERROR GIVEN IS FUEL PRESSURE. THE FUEL PRESSURE WAS CHECKED AND WAS AT CORRECT PRESSURE FOR THE CAR. I HAVE REPLACED FUEL CENSER AND CAR RAN FINE FOR 2 DAYS THEN SAME ISSUE WITH SAME ERROR THE FUEL CONTROLLER HAS A CORRODED PEN I TRIED TO CALL VOLVO THEY ARE TELLING ME THERE IS NOTHING THEY CAN DO WHEN I CAN CLEARLY SEE THE YEAR MAKE AND MODEL HAVE HAD A RECALL FOR THE EXACT ISSUE THAT I AM HAVING WITH THIS CAR. THE RECALL NUMBER IN YOUR SYSTEM IS 08V033000 I NORMALLY WOULD JUST GET THE CAR FIXED BUT THIS IS A MAJOR ISSUE IT SEEMS THE LOCATION OF THE CONTROLLER NEEDS TO BE MOVED TO PREVENT THIS FROM HAPPENING AGAIN. THIS IS A CAR MY 16 YEAR OLD DAUGHTER DRIVES SO YOU CAN UNDERSTAND MY CONCERN WITH VOVLO NOT WANTING TO CORRECT THIS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10861933April 28, 2016
AIR BAGS, ELECTRICAL SYSTEM, SUSPENSION
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE STEERING WHEEL AND ENTIRE VEHICLE BEGAN TO SHAKE AS THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE AIR CONDITIONER, RADIO, HORN AND SUN ROOF FAILED TO FUNCTION WHEN ACTIVATED. THE SRS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ECM, FRONT AXLES AND STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10850393March 18, 2016
ENGINE
EGR OR AKA. OIL TRAP HOUSING, TUBING IS BROKEN AND SUCKING IN AIR. IMPROPER VENTILATION IS TRIPPING OFF EMISSION CODE ON DASH. BRITTLE BLACK PLASTIC HOUSING, DEFECTIVE IN NATURE AND BY DESIGN. POTENTIAL OTHER ISSUES IS THE UNWANTED PRESSURE BUILD UP IN ENGINE WHICH CAN CAUSE PREMATURE FAILURE OF OIL CAM SEALS WHICH I ALSO EXPERIENCED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10837392February 21, 2016
ELECTRICAL SYSTEM
A COLD, WET, WINTERY MORNING; PULLED INTO COFFEE SHOP PARKING LOT, PARKED CAR, TURNED ENGINE OFF, REMOVED KEY, GOT OUT OF THE CAR, LOCKED DOORS, WENT INTO THE COFFEE SHOP. THE CAR WAS STATIONARY, NOTHING LEFT ON IN THE CAR. WHILE WAITING FOR COFFEE GLANCED OUT COFFEE SHOP WINDOW. SAW THAT THE CAR WAS FILLED WITH SMOKE. A PANIC RUSH TO CAR FOUND A FIRE WAS BURNING BEHIND DASH. COFFEE SHOP HAD A FIRE EXTINGUISHER; THE FIRE WAS PUT OUT. THE CAR, INOPERATIVE, WAS TOWED TO A DEALER. AN OPINION IS THAT A MANUFACTURING DEFECT INVOLVING THE CAR'S CEM (CENTRAL ELECTRONIC MODULE) UNDER THE DASH, ON THE PASSENGER'S SIDE, WAS LIKELY THE CAUSE AND SOURCE OF THE FIRE. DEALER REPORT; ENGINE & DASH WIRING, CEM, HEATER HOUSING, AIRBAG, INNER GLOVE BOX TO REPLACE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10823121January 29, 2016
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
THIS HAPPENED YESTERDAY 1/28/16 AND IN APRIL 2015 (THE DEALERSHIP "FIXED IT" BUT IT DIDN'T WORK!!!!) YESTERDAY, WHILE DRIVING HOME FROM WORK, THE CAR DID THE SCARIEST THING I'VE EVER EXPERIENCED WHILE DRIVING. ALL THE LIGHTS ON THE DASH, ALL THE WARNING LIGHTS FLASHED SEVERAL TIMES AND THE CAR CAME TO A COMPLETE STANDSTILL. NO POWER AT ALL. IT DIDN'T SLOW TO A STALL, NO WEIRD SOUNDS...IT JUST LITERALLY STOPPED IN IT'S TRACKS. RIGHT THERE, IN THE ROAD. ALL OF A SUDDEN MY CAR SHUT OFF. WHEN I SAY SHUT OFF I MEAN THE HEADLIGHTS, DOME LIGHTS, ENGINE....ANYTHING THAT WAS ELECTRICAL COMPLETELY SHUT OFF. THIS WOULD INCLUDE THE STEERING WHEEL LOCKING UP. IMAGINE DRIVING ON THE FREEWAY/HIGHWAY IN THE MIDDLE OF THE NIGHT WITH TRAFFIC AROUND YOU AND YOUR LIGHTS GOING OUT, STEERING WHEEL LOCKING AND HAVING NO WAY TO CONTROL THE VEHICLE. THIS COULD HAVE KILLED ME AND MY BABY. LAST NIGHT, I HAS NIGHTMARES ALL NIGHT LONG OF THAT HAPPENING ON THE FREEWAY OR THE TRESTLE WITH MY BABY. WHERE I DRIVE FREQUENTLY. HAD THAT HAVE HAPPENED THERE, I COULD HAVE BEEN KILLED ESPECIALLY IF A SEMI TRUCK WAS BEHIND ME, AS IS OFTEN THE CASE. THEY CAN'T STOP THAT FAST. MOST PEOPLE CAN'T STOP THAT FAST GOING 55-75 MPH. I HAD BEEN ON THE TRESTLE ABOUT 15 MINUTES BEFORE IT HAPPENED. AND I AM PETRIFIED TO THINK WHAT COULD HAVE HAPPENED SINCE I OFTEN HAVE MY BABY IN THE CAR. THE CAR IS AT THE DEALERSHIP IN SERVICE. THEY CANNOT FIND ANYTHING WRONG WITH IT. THE CHECK ENGINE LIGHT DIDN'T COME ON, SO THERE ARE NO CODES. THEY CANNOT GET IT DO IT AGAIN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821737January 22, 2016
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE CONTACT LET THE VEHICLE DECELERATE AND THEN SLOWLY DROVE THE VEHICLE TO THE DEALER. THE DEALER DIAGNOSED THAT THE BRAKE VACUUM PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V474000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10819591January 12, 2016
ENGINE
CAR CAUGHT FIRE WITHOUT WARNING AS I WAS DRIVING IT. CAR HAD 93,000 AND HAD PASSED VA INSPECTION IN AUGUST. I PULLED OVER AND CALLED 911. BY THE TIME THE FIRE DEPARTMENT ARRIVED 3 MINUTES LATER, ENTIRE ENGINE WAS ENGULFED IN LARGE FLAMES. THE TEMPERATURE GAUGE NEVER INDICATED THE ENGINE WAS RUNNING HOT. USAA REMOVED THE VEHICLE, AND I DON'T KNOW WHETHER THEY WILL INSPECT IT FOR CAUSE, BUT I SUSPECT AN ELECTRICAL MALFUNCTION.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10817742January 4, 2016
ELECTRICAL SYSTEM
WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH I NOTICED MY DIM ( DRIVER INFORMATION MODULE) HAD COMPLETELY STOPPED WORKING. I WAS UNABLE TO READ MY SPEEDOMETER, RPM, FUEL LEVEL, AND ENGINE TEMPERATURE WHILE THE CAR WAS STILL RUNNING . AFTER RESEARCHING THIS ONLINE, IT APPEARS THAT THIS SEEMS TO BE A COMMON PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10816978December 30, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S40