Toyota Tundra Complaints

6,958 consumer complaints on file.

#11424872July 14, 2021
AIR BAGS
I've owned this vehicle for 18 yrs. During that time Air Bags have been replaced on models above and below my year model. Every two or three years, I inquired at Dealerships when this series will be replaced. Always with the same answer, not required because not enough accident reports to warrant replacement. During that time I've only had one small finder bender not affecting the Air Bags to deploy. Curious why this year and model was never required to replace Air Bags?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424586July 13, 2021
ENGINE
2012 Toyota Tundra Cam Carrier seal/cam tower leak on Passenger side. THE CONSUMER STATED ONCE THE OIL PRESSURE BECOMES HIGHER THAN THE BOND HOLDING THE SEAL ELEMENT, IT BEGINS TO LEAK. THE MANUFACTURER WAS NOTIFIED, BUT DID NOT OFFER ANY ASSISTANCE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424437July 12, 2021
STRUCTURE:BODY
The contact owns a 2008 Toyota Tundra. While driving approximately 45 mph, the fuel tank detached from the vehicle. The contact was able to tie the fuel tank to the vehicle with a rope until he was able to get to safety. The dealer was made aware of the failure and confirmed that the subframe needed to be replaced however, the repair was not covered under warranty. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 181,000. THE CONSUMER STATED BOTH FUEL TANK STRAPS CORRODED CAUSING THE FUEL TANK TO DROP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424444July 12, 2021
UNKNOWN OR OTHER
Secondary air intake system has failed- upon researching some years of Toyota Tundra’s had previously recalls for this problem - found one forum where 120 people were complaining this happened to their vehicle also
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424109July 9, 2021
UNKNOWN OR OTHER
2006 Toyota Tundra with under 85,000 miles - dealer that has seen vehicle regularly has it in for routine service tells us it is now unsafe to operate because rust has weakened frame Dealer offered no assistance or suggestions
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11423412July 4, 2021
UNKNOWN OR OTHER
Took the truck to have it checked over and inspection sticker, so I could put it on the road.inspecter said the frame is not safe, he would not put a sticker on it do to the frame. He also said that year was recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11423188July 2, 2021
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
2003 Toyota Tundra. Consumer writes in regards to NHTSA safety recall related to rusted frames.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11423238July 2, 2021
AIR BAGS, SEAT BELTS
The contact owned a 2013 Toyota Tundra. The contact stated that while driving at an undisclosed speed, another vehicle had run a red light and crashed into the front grill assembly of the contact's vehicle then the other vehicle spun and crashed into the driver side of the contact's vehicle. The contact's front driver seat moved inadvertently towards the steering wheel but the seat belt did not prevent the contact's neck, chest, and stomach from slamming into the steering wheel. The contact heard a loud bang and the air bags deployed, filling the inside of the vehicle with a powder substance. The contact and passenger were transported to the hospital by ambulance with injuries sustained. A police report was filed. The vehicle was towed to a towing yard and deemed totaled by the insurance company. The manufacturer was made aware of the failure and a case was opened but the manufacturer informed the contact that there was no recall for the air bags associated with the VIN. The failure mileage was 72,120. Consumer stated driver airbag exploded before it could inflate. Driver was injured.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11423089July 1, 2021
SERVICE BRAKES
I almost hit another vehicle while braking at a stop light. My front brakes gave out. Had new brakes and rotors installed 2 yrs ago and after this incident found that my brakes failed because Toyota refused to fix this problem they knew existed 1 gen Toyota tundra. They changed enlarged the front caliber and pads on 2 gen Toyota because they realized the brakes whe re w to small on the big v8 trucks. I drove aprox 25000 miles on brand new brakes. I should not have to pay for upgrading my front brakes due to a manufacturer defect, How can they get out of recalling these vehicles it is very dangerous and hope they accept responsibility for improper equipment installed on vehicles. I read that they did upgrade some vehicles that where still in warranty why not all?? Vehicles regardless of warranty.???
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422943June 30, 2021
STRUCTURE:BODY, ELECTRICAL SYSTEM
In the course of cleaning my vehicle, I noticed corrosion on edge of door sill (emanating from under inside rubber door seal) of my 2014 Toyota Tundra on June 13, 2021. After removing the plastic scuff plate and rubber door seal, it was apparent that openings from the underside of the vehicle into the cabin are present from the design/manufacturing process - these opening are not sealed. The openings are not a result of corrosion but rather are associated with the geometry of the floor pan at the floor pan to rocker pinch weld - it is not a sealed surface. After removing the rubber seal I was able to look downward into the openings and see daylight from the underside of the cabin. Electrical cabling is immediately adjacent to these openings beneath the plastic scuff plate. It was apparent that the openings permit water and salt infiltration into the cabin, and would appear to be the primary cause of corrosion and build up of salt residues in the cabin and door sill area. My first impression was the condition that I observed was a manufacturing defect. On reflection many questions came to mind including: was the infiltration of water, salt and potentially exhaust through the openings in the floor pan going to have safety consequences - would the deterioration of the body structure as a result of corrosion have consequences in the event of a crash, or would the potential infiltration of exhaust gases affect the safety of cabin occupants? In following up the dealer and manufacturer over the last week, no resolution has been found . Owing to the age I was advised that there was no warranty coverage. The dealer reportedly inspected other Tundras and the design/manufacturing conditions (ie. opening in the floor pan) were the same as I had observed. It was only through my own initiative that I identified a Manufacturer Communication (NHTSA ID 10173991) that shed some light on the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422830June 29, 2021
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
First the gas tank let loose and fell half way off. Result was a new gas tank installed. then part of the frame rusted from the cab. This resulted in having to have it welded. Have had several service repair lights come on that resulted in more fixes. Today just about does it. The spare tire fell to the road because rust ate through what was holding it up. I have all the papers that show the repairs and what it has cost me. I have not done anything yet about spare tire. I have had the truck since 2013 and it has less then 94k miles on it. It had 35 when I bought it and I knew nothing about the rust problem recall. I certainly believe I should have a new frame or some kind of compensation. Over the years I have talked to several dealers that got me no where. I guess this is my last shot.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422674June 28, 2021
STRUCTURE:BODY
The frame on the truck is starting to show holes and I am wondering about the stability of the frame lasting I am in New York state and this is the issue with the climate
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422364June 25, 2021
SUSPENSION
Passenger side front Ball joint failed when driving on interstate. Oil change and service was last done 2/24/21 mileage was 192943. I also sent all the information to Toyota.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11421928June 22, 2021
UNKNOWN OR OTHER
RECENTLY MY MECHANIC BROUGHT TO MY ATTENTION FRAME DAMAGE. I WENT FOR AN INSPECTION FROM A LOCAL FRAME SPECIALIST, WHO TOLD ME MY FRAME WAS COMPLETED RUSTED THROUGH. COST FOR REPLACEMENT MATERIALS AND LABOR TOTAL COST 9227.30. TOYOTA EARLY ON IDENTIFIED KNOWN RUST ISSUES WITH THE TUNDRA WITH A RECALL MANY YEARS AGO. AFTER WAITING OVER A YEAR AFTER THE RECALL MY TRUCK WAS UNDERCOATED WITH A BIG ONE YEAR WARRANTY. APPARENTLY WAS UNAFFECTIVE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11421489June 19, 2021
ENGINE
Perforated exhaust manifolds
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11421393June 18, 2021
UNKNOWN OR OTHER
The frame has rusted so badly that the spare tire fell off into the highway and nearly caused the vehicle behind to almost wreck.Upon arrival at home I looked at the frame and noticed that the u-bolts holding the rear differential are almost rusted off and will need to be replaced. The entire frame is rusted badly. I think something should be done!!! This vehicle has been taken care of and has seldom been off-road. I am a 72 year old man who does not abuse my vehicle. Thank you Jerry Wakeland
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11421005June 15, 2021
STRUCTURE:BODY, SUSPENSION, WHEELS
have noticed rust holes on frame-frame rust is flaking-falling off--rust on brake system and wheel rims
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11420939June 14, 2021
UNKNOWN OR OTHER, STRUCTURE:BODY
I seen that Toyota were recalled for the frame issues on 2004 and up, mine is 2005 tundra with frame issues, like it’s sad, such a nice truck, but frame is horrible. Why is mine not being shown as recalled, but yet I have frame problems? I got my truck from a 1 owner who had it since new, it just hit 100,000 miles on it, it was serviced by Toyota dealership, I’m not sure why they didn’t do nothing with it over the years to help or fix the rust issue on the frame. It’s not just a little rusty, it’s really rusty, and it was garage kept too. Did they forget to include my vin number when they started the recalls? Doesn’t make sense why they would fix some and not all, all around the same years. Thanks Jim
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11420722June 13, 2021
WHEELS, STEERING, SUSPENSION
on June 9th at about 2pm while driving through my neighborhood, my upper an lower ball joints on my 2002 Toyota Tundra separated from my vehicle causing a catastrophic loss of control of truck and tore my hub with tire from vehicle ripping the brake fuel line and shoving entire components up under my Tundra while losing control with no brakes or steering capability. It also destroyed the drivers side front tire. Needless to say if I was say...going 55 to 60 miles per hour on highway...I would not be writing this. Had truck towed to Checkered Flag Toyota and they quoted me a price of over1300$ in repairs... they are fighting me on fixing my truck damages even though said damages were caused by the ball joint recall on the 2002 tundra...recall I D#05v
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11419917June 7, 2021
UNKNOWN OR OTHER
2002 Tundra was recalled for the rusty frame. I had mine inspected at the time of the recall. The dealership sprayed the frame of my truck. Now my frame is severely rusted and unsafe to drive. The balance of my vehicle is in good condition with approximately 200,000 miles. Will I be eligible for repair or replacement? Who should I contact? Thank you Bridgette Gartmann
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra